2018 VOLVO XC60
5 Recalls for 2018 VOLVO XC60
Recall Date | Component | Summary |
---|---|---|
1970-01-01 | VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES | Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Remedy:
Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car’s number for this recall is R10044. |
2019-03-20 | SEATS | Volvo Car USA LLC (Volvo) is recalling certain 2018-2019 XC60 and S90 vehicles. The driver and passenger front seat rail rear flange nuts may not have been installed during assembly.
Remedy:
Volvo will notify owners, and dealers will inspect the front seat rails for missing flange nuts, installing them as necessary, free of charge. The recall began May 7, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo’s number for this recall is R19931. |
2019-01-18 | STRUCTURE:BODY:TAILGATE | Volvo Car USA LLC (Volvo) is recalling certain 2018-2019 Volvo XC60 vehicles. Under certain conditions and cold temperatures, the tailgate lifting arms may freeze which may cause the lifting arms to separate from the vehicle.
Remedy:
Volvo has notified owners, and dealers will replace the tailgate lift arms with an improved designed, free of charge. The recall began May 14, 2019. Owners may contact Volvo customer service at 1-800-458-1552. Volvo’s number for this recall is R89910. |
2018-11-13 | ELECTRICAL SYSTEM:SOFTWARE | Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Remedy:
Volvo will notify owners, and dealers will correct the software, free of charge. The recall began December 26, 2018. Owners may contact Volvo customer service at 1-800-458-1552. Volvo’s number for this recall is R39917. |
2020-08-25 | VISIBILITY/WIPER | VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES | Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
Remedy:
Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car’s number for this recall is R10044. |
0 Complaints sent to the Center for Auto Safety for 2018 VOLVO XC60
Date | Component |
---|
16 Complaints submitted to NHTSA for 2018 VOLVO XC60
Date | Component | |||
---|---|---|---|---|
2020-09-02 |
SERVICE BRAKES
ODI Number: 11352727 |
|||
2020-07-12 |
SERVICE BRAKES
ODI Number: 11338864 |
|||
2020-02-11 |
SERVICE BRAKES
ODI Number: 11308508 |
|||
2020-02-05 |
SERVICE BRAKES | STRUCTURE:BODY:DOOR
ODI Number: 11307312 |
|||
2020-01-14 |
ELECTRICAL SYSTEM
ODI Number: 11299270 |
|||
2019-12-20 |
ELECTRICAL SYSTEM
ODI Number: 11290340 |
|||
2019-12-03 |
WHEELS
ODI Number: 11286684 |
|||
2019-10-08 |
LANE DEPARTURE: LANE KEEP: AUTOMATIC STEERING
ODI Number: 11266969 |
|||
2019-05-14 |
ELECTRICAL SYSTEM | ELECTRONIC STABILITY CONTROL | STRUCTURE:BODY
ODI Number: 11207490 |
|||
2019-04-08 |
STRUCTURE:BODY
ODI Number: 11194622 |
|||
2018-09-29 |
UNKNOWN OR OTHER
ODI Number: 11132304 |
|||
2019-02-23 |
ELECTRICAL SYSTEM | ENGINE | SERVICE BRAKES
ODI Number: 11182168 |
|||
2019-02-26 |
LANE DEPARTURE: BLIND SPOT DETECTION
ODI Number: 11175670 |
|||
2018-02-28 |
SEAT BELTS
ODI Number: 11075545 |
|||
2018-03-06 |
ELECTRONIC STABILITY CONTROL | STEERING | VEHICLE SPEED CONTROL
ODI Number: 11076417 |
|||
2018-06-28 |
ELECTRICAL SYSTEM | ENGINE
ODI Number: 11104618 |
1 Investigations for 2018 VOLVO XC60
Date Opened | Date Closed | Component | |
---|---|---|---|
2023-01-27 | 2023-08-07 | ELECTRICAL SYSTEM:PROPULSION SYSTEM |
591 Service Alerts for 2018 VOLVO XC60
Date | Description |
---|---|
2025-03-18 | ELECTRICAL SYSTEM
This is a Technical Journal: Improved 12V battery test in VIDA. Service: Don´t charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2025-03-11 | FORWARD COLLISION AVOIDANCE: WARNINGS
This is a Technical Journal: Alleged issues with Intellisafe functionality. Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe. The owner’s manual is a good source of info Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2025-02-28 | EXTERIOR LIGHTING
This is a Technical Journal: Changed front fog/cornering lights behavior. This logic of the cornering lights is now changed in the cars with software version 3.3.16 or later Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2025-02-27 | VISIBILITY/WIPER
This is a Technical Journal: Replacement of Wiper Blades. Follow steps 1-7 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2025-02-21 | UNKNOWN OR OTHER
Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing i Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2025-02-13 | UNKNOWN OR OTHER
Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing i Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2025-01-30 | UNKNOWN OR OTHER
This is a Technical Journal: Climate system heating performance (HVCH). Replace HVCH. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2025-01-16 | UNKNOWN OR OTHER
This is a Technical Journal: Vehicle/Connectivity report checklist. To provide timely and high-quality feedback to the appropriate department or factory Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2025-01-16 | EXTERIOR LIGHTING
This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session: •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-04-29 | 200000 WHEELS
Center wheel caps, removal instruction Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-05-06 | 353000 EQUIPMENT:ELECTRICAL
ICUP/Google Built-In Diagnostic Operations Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-05-06 | 980000 UNKNOWN OR OTHER
ICUP/Google Built-In Diagnostic Operations Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-06-23 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Battery Charger/maintainer requirement Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-06-23 | 980000 UNKNOWN OR OTHER
Battery Charger/maintainer requirement Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-05-12 | 980000 UNKNOWN OR OTHER
The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-04-14 | 357500 EQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS
No bass from sound system. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-02-07 | 134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY
Panoramic sunroof, sealing strip has a gap Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-02-07 | 350000 EQUIPMENT
Panoramic sunroof, sealing strip has a gap Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-02-03 | 110000 ELECTRICAL SYSTEM
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-02-03 | 350000 EQUIPMENT
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-02-09 | 350000 EQUIPMENT
VIDA QR Scanner Mobile App Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-04-22 | 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
No bass from sound system. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-02-28 | 110000 ELECTRICAL SYSTEM
The corrective action is to update the VCM software. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2022-02-28 | 110000 ELECTRICAL SYSTEM
Product, Safety and Compliance. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-16 | 280000 BACK OVER PREVENTION
arts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-27 | 190000 TIRES
Tires/Vibration/out of round. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-12-21 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-64 and P240F-00 In Different Combinations, Occurrences, And Time Stamps (Two To Four Codes), Possible Vehicle Derate – US17+OBD16, US17+OBD18 Emissions, Common Model Years 2018 And 20 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2016-03-30 | 354000 EQUIPMENT:MECHANICAL
News Letter 70 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-09-01 | 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Emission Warranty Update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-11-04 | 060000 ENGINE AND ENGINE COOLING
Trucks Equipped With A Cummins Engine – Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater) Operation – Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-26 | 221700 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-26 | 350000 EQUIPMENT
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-29 | 350000 EQUIPMENT
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-29 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-29 | 061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-26 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM “Car key not found” or if functions such as lock/unlock are not working, please follow advice for detecting key Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-26 | 350000 EQUIPMENT
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM “Car key not found” or if functions such as lock/unlock are not working, please follow advice for detecting key Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-10-18 | 120000 EXTERIOR LIGHTING
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-10-18 | 121000 EXTERIOR LIGHTING:HEADLIGHTS
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-10-18 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-07-13 | 110000 ELECTRICAL SYSTEM
If the check engine lamp may appear in the DIM (Driver Information Module) and the listed DTC is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-07-07 | 060000 ENGINE AND ENGINE COOLING
If the check engine lamp may appear in the DIM (Driver Information Module) and the listed DTC is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-07-21 | 130000 VISIBILITY
Outer rear view mirror glass incorrect position after reversing. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-07-19 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Perform a software upgrade in accordance with TJ 31543. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-06-25 | 353000 EQUIPMENT:ELECTRICAL
New Software Products (SP) have been developed to convert a Care Key to a standard key. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-12 | 350000 EQUIPMENT
This is a Technical Journal: Creaking noise from Steering Wheel Module Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-12 | 010200 STEERING:STEERING CONTROL MODULE
This is a Technical Journal: Creaking noise from Steering Wheel Module Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-05-25 | 110000 ELECTRICAL SYSTEM
This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-05-21 | 120000 EXTERIOR LIGHTING
This is a Service Journal: Head Lamp Washer pump not available. Modify connector on replacement pump. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-05-21 | 130000 VISIBILITY
This is a Service Journal: Head Lamp Washer pump not available. Modify connector on replacement pump. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-04-20 | 190000 TIRES
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Tire balancing should be checked and corrected as needed but is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-04-20 | 200000 WHEELS
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Tire balancing should be checked and corrected as needed but is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-04-14 | 020000 SUSPENSION
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Seri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-04-14 | 110000 ELECTRICAL SYSTEM
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Seri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-04-14 | 350000 EQUIPMENT
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Seri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-04-14 | 020000 SUSPENSION
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Seri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-04-14 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Seri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-04-14 | 350000 EQUIPMENT
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Seri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-03-23 | 120000 EXTERIOR LIGHTING
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is water ingress into rear park assist sensors and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-03-12 | 020000 SUSPENSION
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Seri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-03-12 | 251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Seri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-03-31 | 350000 EQUIPMENT
This is a Technical Journal: AC evaporator repair, additional parts needed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-03-11 | 284100 BACK OVER PREVENTION:DISPLAY FUNCTION
This is a Technical Journal: Connectivity services activation – PSIM issues Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-03-01 | 350000 EQUIPMENT
Create PB with attached word doc. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-03-05 | 150000 SEAT BELTS
This is to inform you that we have procured Rebuilders Automotive Supply (RAS) to handle the returns of the recalled Front Seat Belt Fastener Pretensioner for Recall R10029. RAS has created instructions for the pretensioner shipping procedu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-03-05 | 150000 SEAT BELTS
This is to inform you that we have procured Rebuilders Automotive Supply (RAS) to handle the returns of the recalled Front Seat Belt Fastener Pretensioner for Recall R10029. RAS has created instructions for the pretensioner shipping procedu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-03-04 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-02-27 | 020000 SUSPENSION
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Seri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-02-27 | 130000 VISIBILITY
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-02-25 | 130000 VISIBILITY
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-02-25 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-02-19 | 350000 EQUIPMENT
Volvo?s Warranty Department tracks Retailer warranty spending by utilizing the Warranty Retailer Counseling Process (WRCP). The WRCP is used to gauge individual retailer performance on objective measures over time. By setting clear performa Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-02-09 | 010000 STEERING
This is a Technical Journal: Noise when turning steering wheel. Check rubber gromet in firewall Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-26 | 110110 ELECTRICAL SYSTEM:SEAT HEATER:MAT
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-12 | 010000 STEERING
This is a Technical Journal: Creaking noise from Steering Wheel Module Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-12 | 200000 WHEELS
This is a Technical Journal: Creaking noise from Steering Wheel Module Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-12 | 280000 BACK OVER PREVENTION
This is a Technical Journal: Creaking noise from Steering Wheel Module Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-29 | 010000 STEERING
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-29 | 030000 BRAKES (PWS)
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-26 | 120000 EXTERIOR LIGHTING
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM “Car key not found” or if functions such as lock/unlock are not working, please follow advice for detecting key Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-10 | 199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a “spinning wheel”, while calibration is ongoing. The calibration function its Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-10 | 350000 EQUIPMENT
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a “spinning wheel”, while calibration is ongoing. The calibration function its Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-10 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Sensus Connect, Internet browser limitations. Do not attempt to repair. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-10 | 353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT
This is a Technical Journal: Sensus Connect, Internet browser limitations. Do not attempt to repair. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-12-04 | 190000 TIRES
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-08 | 060000 ENGINE (PWS)
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under “Service”. Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Remove the left engine pad and split Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-29 | 350000 EQUIPMENT
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-29 | 071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2021-01-29 | 071420 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:HOSES/VALVES/SENSORS
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-01 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-12-02 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Check engine lamp and DTC – ECM P227000 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-12-02 | 060000 ENGINE (PWS)
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under “Service”. Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Remove the left engine pad and split Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-11-25 | 150000 SEAT BELTS
This is a Technical Journal: Seat belt front, may not retract fully Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-11-25 | 350000 EQUIPMENT
This is a Technical Journal: Seat belt front, may not retract fully Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-11-10 | 140000 AIR BAGS
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-21 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-16 | 350000 EQUIPMENT
This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-10 | 200000 WHEELS
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a “spinning wheel”, while calibration is ongoing. The calibration function its Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-10 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a “spinning wheel”, while calibration is ongoing. The calibration function its Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-08 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under “Service”. Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Remove the left engine pad and split Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-10 | 280100 BACK OVER PREVENTION:SOFTWARE
This is a Technical Journal: Sensus Connect, Internet browser limitations. Do not attempt to repair. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-09-18 | 350000 EQUIPMENT
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-09-18 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-03-31 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-12-11 | 350000 EQUIPMENT
This is a Technical Journal: PAC 360 side camera, intermittent no image Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-12-11 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: PAC 360 side camera, intermittent no image Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-12-11 | 275100 LANE DEPARTURE: SENSING SYSTEM: CAMERA
This is a Technical Journal: PAC 360 side camera, intermittent no image Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-08-28 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-08-28 | 350000 EQUIPMENT
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-08-05 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-07-17 | 151000 SEAT BELTS:FRONT
This is a Technical Journal: Seat belt front, may not retract fully Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-07-14 | 134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY
This is a Technical Journal: Panoramic sunroof, roller blind hanging loose Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-04-25 | 060000 ENGINE (PWS)
This is a Technical Journal: Ping noise from exhaust when cooling down Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-04-25 | 130000 VISIBILITY
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-04-03 | 162700 STRUCTURE:BODY:TRUNK LID
This is a Technical Journal: Trunk lid, water intrusion. Add Part number sealing 32282741. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-27 | 130000 VISIBILITY
This is a Technical Journal: Panoramic sunroof, roller blind hanging loose Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-27 | 100000 POWER TRAIN
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under “Service”. Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Remove the left engine pad and split Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-10-23 | 020000 SUSPENSION
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-06-20 | 135000 VISIBILITY:REARVIEW MIRRORS/DEVICES
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-06-17 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: Prior Approval for VCM Replacement Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-11-06 | 350000 EQUIPMENT
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. At PDS and when attempting to diagnose a customer concern regarding voice controls not working or responding properly, make Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-11-06 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-03-24 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Replacing CEM or Recommunicating with a ‘sleeping’ vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-11-19 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other co Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-11-14 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other co Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-11-09 | 110000 ELECTRICAL SYSTEM
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-01-09 | 130000 VISIBILITY
This is a Service Manager Bulletin: Windshield Cleaning Operation Service Interval Change. Will only be performed at 20k Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-01-09 | 131000 VISIBILITY:WINDSHIELD
This is a Service Manager Bulletin: Windshield Cleaning Operation Service Interval Change. Will only be performed at 20k Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-01-08 | 220000 SEATS
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-01-08 | 221700 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-01-03 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-01-03 | 060000 ENGINE (PWS)
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-01-28 | 060000 ENGINE (PWS)
This is a Technical Journal: 4 Cylinder VEP engine: Castrol Edge Professional V 0W-20 Synthetic oil. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-01-30 | 350000 EQUIPMENT
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-10-16 | 060000 ENGINE AND ENGINE COOLING
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-10-16 | 060000 ENGINE AND ENGINE COOLING
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). The sound may come from the balance shaft which is fitted in the oil sump area where the noise is most concentrat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-04-21 | 350000 EQUIPMENT
Please return stock of part number 31664288 Decal Set to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-04-13 | 350000 EQUIPMENT
Please return stock of 31430070 service kit to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-04-13 | 110000 ELECTRICAL SYSTEM
This is a Service Product Journal: VIDA will not support Windows 8.1 after June 30th 2017 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-04-13 | 350000 EQUIPMENT
This is a Service Product Journal: VIDA will not support Windows 8.1 after June 30th 2017 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-02-14 | 100000 POWER TRAIN
This is a Technical Journal: Rough shifts, 5-4, Neutral Control, N-D TF80SC/SD Due to internal tolerance deviation in automatic gearbox, (TF80SC/SD) the customer may experience rough shift from 5:th to 4:th gear, or/and shift shock after st Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-02-25 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: DTC CEM-U030141 with no customer symptom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-03-22 | 070000 FUEL SYSTEM, GASOLINE
This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA 201 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-02-08 | 350000 EQUIPMENT
Volvo Complimentary Factory Scheduled Maintenance ‘FSM330’ MY2013 and later. Factory Scheduled Maintenance up to the first 3 years or 36,000 miles (whichever comes first) as recommended in the Volvo Warranty and Maintenance Information book Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-02-06 | 160000 STRUCTURE
This is a Technical Journal: Info request, loose door sealing strips. replace if needed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-02-06 | 162300 STRUCTURE:BODY:DOOR
This is a Technical Journal: Info request, loose door sealing strips. replace if needed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-02-01 | 060000 ENGINE AND ENGINE COOLING
This is a Service Journal: Coolant Filling Equipment Tool Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2020-02-01 | 350000 EQUIPMENT
This is a Service Journal: Coolant Filling Equipment Tool Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-12-11 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Check engine lamp and DTC – ECM P050B00 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-12-11 | 060000 ENGINE (PWS)
This is a Technical Journal: Check engine lamp and DTC – ECM P050B00 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-12-07 | 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
This is a Technical Journal: Removal of “SiriusXM Subscription has Expired” Message Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-05-11 | 110000 ELECTRICAL SYSTEM
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-05-11 | 350000 EQUIPMENT
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-12-07 | 350000 EQUIPMENT
This is a Technical Journal: Infotainment System Reboots while driving (blank screen). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-12-07 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Infotainment System Reboots while driving (blank screen). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-05-05 | 350000 EQUIPMENT
Please return stock of part number 31460615 tooth belt kit to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-03-18 | 010000 STEERING
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo C Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-03-17 | 350000 EQUIPMENT
This is a Service Manager Bulletin: Retailer Car Delivery Process. All vehicles must have a pre-delivery service and a proper customer delivery. Perform all required maintenance, repairs and updates prior to delivery to customer. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-03-29 | 350000 EQUIPMENT
This is a Service Manager Bulletin: Factory Scheduled Maintenance menu. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-03-24 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Replacing CEM or Recommunicating with a ‘sleeping’ vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-02-28 | 110000 ELECTRICAL SYSTEM
MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-02-28 | 350000 EQUIPMENT
Please produce a Special Tool Bulletin using the attached draft copy. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-11-22 | 350000 EQUIPMENT
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. At PDS and when attempting to diagnose a customer concern regarding voice controls not working or responding properly, make Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-10-22 | 030000 SERVICE BRAKES, HYDRAULIC
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-10-17 | 350000 EQUIPMENT
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-08-23 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Service Manager Bulletin: Technician Skillset Requirments Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-09-27 | 350000 EQUIPMENT
This is a Technical Journal: Climate system, unusual noise from dashboard area. replace the heater core according to the attached instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-09-27 | 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
This is a Technical Journal: Climate system, unusual noise from dashboard area. replace the heater core according to the attached instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-06-11 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: DTC SRS-B15381B High Voltage battery loop control. The resistance of the circuit can be monitored using the SRS parameter “High voltage battery power supply disconnect” Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-06-05 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Service Managers Bulletin: Volvo Cars is constantly developing the in-car systems and the services offered to customers, so that their cars give them the best experience possible . As of May 13th, 2019, when the software in your c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-06-05 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Service Product Journal: Information Notice. We process the personal data that you provide in connection with the creation of your VIDA account. The purpose of our processing is to administer your VIDA account (from registration t Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-08-31 | 110000 ELECTRICAL SYSTEM
The customer may report that the infotainment system in the vehicle re-starts or reboots intermittently while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-08-31 | 350000 EQUIPMENT
The customer may report that the infotainment system in the vehicle re-starts or reboots intermittently while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-08-31 | 353000 EQUIPMENT:ELECTRICAL
The customer may report that the infotainment system in the vehicle re-starts or reboots intermittently while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-09 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM “Car key not found” or if functions such as lock/unlock are not working, please follow advice for detecting key Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-09 | 350000 EQUIPMENT
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM “Car key not found” or if functions such as lock/unlock are not working, please follow advice for detecting key Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-09 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM “Car key not found” or if functions such as lock/unlock are not working, please follow advice for detecting key Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-08 | 011000 STEERING: STEERING WHEEL/HANDLE BAR
This is a Technical Journal: T8 Seat/Steering Wheel Heat Inop using Remote Parking Climate w/VOC app Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-08 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: T8 Seat/Steering Wheel Heat Inop using Remote Parking Climate w/VOC app Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-08 | 220000 SEATS
This is a Technical Journal: T8 Seat/Steering Wheel Heat Inop using Remote Parking Climate w/VOC app Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-08 | 221700 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
This is a Technical Journal: T8 Seat/Steering Wheel Heat Inop using Remote Parking Climate w/VOC app Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 162500 STRUCTURE:BODY:TAILGATE
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 162510 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 350000 EQUIPMENT
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 162500 STRUCTURE:BODY:TAILGATE
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 162510 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 350000 EQUIPMENT
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-05 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: No VIDA communication with vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-05 | 350000 EQUIPMENT
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-05 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-08-28 | 350000 EQUIPMENT
This is a Technical Journal: Gear shift lever inoperable Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-08-28 | 220000 SEATS
This is a Technical Journal: Front passenger seat, noise when turning. Install plastic clips p/n 9475400 according to the repair instructions. Plastic clip might have some interference with the seat rail cover. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-08-28 | 160000 STRUCTURE
This is a Service Product Journal: Template Bumperskin Towbar Hitch, a template needs to be used to make the cut. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-31 | 106000 POWER TRAIN:AXLE ASSEMBLY
This is a Technical Journal: If the rear axle causes judder/sound at parking maneuvres. (full turn and acceleration), then follow advice under service. Download Total Upgrade software Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-22 | 106000 POWER TRAIN:AXLE ASSEMBLY
This is a Technical Journal: Replacement of ERAD components. Follow instruction for the replacement of the ERAD. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-08-12 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-08-03 | 131000 VISIBILITY:WINDSHIELD
This is a Service Manager Bulletin: Windshield replacement products. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 030000 SERVICE BRAKES, HYDRAULIC
This is a Technical Journal: Squealing noise from rear brakes at low speed. If squealing noise occur from rear brakes 17″ at low speed, follow advice under service. If symptom is confirmed, follow advice in VIDA regarding greasing method wh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 040000 SERVICE BRAKES, AIR
This is a Technical Journal: Squealing noise from rear brakes at low speed. If squealing noise occur from rear brakes 17″ at low speed, follow advice under service. If symptom is confirmed, follow advice in VIDA regarding greasing method wh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 060000 ENGINE (PWS)
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Check engine lamp and DTC – ECM P050B00 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 060000 ENGINE (PWS)
This is a Technical Journal: Check engine lamp and DTC – ECM P050B00 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 130000 VISIBILITY
This is a Technical Journal: Rear wiper cover scratching rear window. Modify the rear wiper cover Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Rear wiper cover scratching rear window. Modify the rear wiper cover Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 220000 SEATS
This is a Technical Journal: The factory is looking for seat upholstery information and we are in need of pictures and description of affected seat covers before removal. Seat upholsteries are not to be replaced without contacting Volvo Tec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: The factory is looking for seat upholstery information and we are in need of pictures and description of affected seat covers before removal. Seat upholsteries are not to be replaced without contacting Volvo Tec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 353000 EQUIPMENT:ELECTRICAL
This is a Technical Journal: DTC IHU-B156C8F sets incorrectly. For the cars in the header this DTC can be ignored as it doesn’t affect any of the functions in the car. Do not perform any fault tracing or component replacement due to this DT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: DTC IHU-B156C8F sets incorrectly. For the cars in the header this DTC can be ignored as it doesn’t affect any of the functions in the car. Do not perform any fault tracing or component replacement due to this DT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: DTC IHU-B156C8F sets incorrectly. For the cars in the header this DTC can be ignored as it doesn’t affect any of the functions in the car. Do not perform any fault tracing or component replacement due to this DT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-06-27 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Check engine lamp and DTC – ECM P050B00 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 021230 SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 350000 EQUIPMENT
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-07 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-07 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 350000 EQUIPMENT
This is a Service Product Journal: Software Purchase Failed – General error occured – VDS / SPA / CMA cars. Download software fix Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Service Product Journal: Software Purchase Failed – General error occured – VDS / SPA / CMA cars. Download software fix Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-02 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: High Voltage Battery repairs Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-02 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This is a Technical Journal: High Voltage Battery repairs Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-09-15 | 070000 FUEL SYSTEM, GASOLINE
Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Action S29843 on certain model year 2017 – 2018 XC90, V90, and model year 2018 XC60 vehicles equipped with the T8 engine Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-09-15 | 060000 ENGINE AND ENGINE COOLING
This is a Quality Bulletin. Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Action S29843 on certain model year 2017 – 2018 XC90, V90 and model year 2018 XC60 vehicles Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-09-07 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Service Manager Bulletin: Claiming for Map Upgrades is not a matter for warranty. Claims submitted for map upgrades will be debited Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-16 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: The factory is looking for seat upholstery information and we are in need of pictures and description of affected seat covers before removal. Seat upholsteries are not to be replaced without contacting Volvo Tec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-16 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: The factory is looking for seat upholstery information and we are in need of pictures and description of affected seat covers before removal. Seat upholsteries are not to be replaced without contacting Volvo Tec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-08 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Infotainment System Reboots while driving (blank screen). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-08 | 350000 EQUIPMENT
This is a Technical Journal: Infotainment System Reboots while driving (blank screen). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-08 | 353000 EQUIPMENT:ELECTRICAL
This is a Technical Journal: Infotainment System Reboots while driving (blank screen). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-08 | 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This is a Technical Journal: Rear Window Defrost will not Stay Activated. Total Upgrade should be used if there are any upgrades available. – Perform an IHU Reload Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-08 | 114300 ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-08 | 162500 STRUCTURE:BODY:TAILGATE
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-21 | 220000 SEATS
This is a Recall Quality Bulletin: Recall R19931 Front Seat Rail Flange Nuts Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-19 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Vehicles with Bowers & Wilkins (B&W) Premium Sound may exhibit a crackling sound from the front door midrange speaker. Please remove the front door midrange loudspeaker in accordance with VIDA instructions. The Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-19 | 350000 EQUIPMENT
This is a Technical Journal: Vehicles with Bowers & Wilkins (B&W) Premium Sound may exhibit a crackling sound from the front door midrange speaker. Please remove the front door midrange loudspeaker in accordance with VIDA instructions. The Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-19 | 353000 EQUIPMENT:ELECTRICAL
This is a Technical Journal: Vehicles with Bowers & Wilkins (B&W) Premium Sound may exhibit a crackling sound from the front door midrange speaker. Please remove the front door midrange loudspeaker in accordance with VIDA instructions. The Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-07 | 350000 EQUIPMENT
This is a Special Tool Bulletin: Newsletter 83 Mandatory Tools Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-07 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: No VIDA communication with vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-07 | 350000 EQUIPMENT
This is a Technical Journal: No VIDA communication with vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-04 | 350000 EQUIPMENT
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. At PDS and when attempting to diagnose a customer concern regarding voice controls not working or responding properly, make Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 350000 EQUIPMENT
This is a Technical Journal: No Internet Connection With Car Modem/”SIM Card Not Inserted” message. In order to restore the connectivity functions, the “Roaming” function must be activated in the vehicle menus. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: No Internet Connection With Car Modem/”SIM Card Not Inserted” message. In order to restore the connectivity functions, the “Roaming” function must be activated in the vehicle menus. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: No Internet Connection With Car Modem/”SIM Card Not Inserted” message. In order to restore the connectivity functions, the “Roaming” function must be activated in the vehicle menus. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 021230 SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-06-27 | 350000 EQUIPMENT
This is a Technical Journal: SPA Condensation water drops in around pedals area Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-06-21 | 060000 ENGINE AND ENGINE COOLING
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-06-20 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Damaged throttle body due to showroom device. To protect the throttle housing when using Volvo Car Showmode kit in the specified cars, always remove the connector from the throttle housing (see picture 34206.jpg Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-24 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-24 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-23 | 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
This is a Technical Journal: Climate unit, not sufficient airflow from vents. Perform action according to instructions for different car variants. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-23 | 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
This is a Technical Journal: Climate unit, not sufficient airflow from vents. Perform action according to instructions for different car variants. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-23 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Climate unit, not sufficient airflow from vents. Perform action according to instructions for different car variants. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-22 | 353000 EQUIPMENT:ELECTRICAL
This is a Technical Journal: SiriusXM Travel Link service cannot be activated Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-22 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: SiriusXM Travel Link service cannot be activated Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-20 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-22 | 350000 EQUIPMENT
This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it’s dealer or any shop maintaining or repairing Volvo’s. The equipment can be provided by Volvo’s equipment supplier Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-22 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it’s dealer or any shop maintaining or repairing Volvo’s. The equipment can be provided by Volvo’s equipment supplier Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Parts Bulletin: Hazmat Return Transportation Documentation and requirements Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-18 | 200000 WHEELS
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-18 | 350000 EQUIPMENT
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-18 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 200000 WHEELS
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 350000 EQUIPMENT
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-08 | 220000 SEATS
This is a Technical Journal: Lumbar support, inflates when opening door Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-04 | 350000 EQUIPMENT
This is a Technical Journal: Vehicle Key Not Found Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-04 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Vehicle Key Not Found Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 180000 VEHICLE SPEED CONTROL
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 030000 BRAKES (PWS)
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-07 | 190000 TIRES
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Tire balancing should be checked and corrected as needed but is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-07 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Tire balancing should be checked and corrected as needed but is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-07 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This is a Parts Bulletin: 12 Volt support batteries, part number 30659531 must be maintained 9 months from the month of manufacture and every 9 months thereafter.To maintain the battery, connect the battery to an appropriate 12V battery cha Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-07 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Parts Bulletin: 12 Volt support batteries, part number 30659531 must be maintained 9 months from the month of manufacture and every 9 months thereafter.To maintain the battery, connect the battery to an appropriate 12V battery cha Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 103300 POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
This is a Technical Journal: Gear shift lever inoperable Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 350000 EQUIPMENT
This is a Technical Journal: Gear shift lever inoperable Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Gear shift lever inoperable Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: SPA Brake noise Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 030000 BRAKES (PWS)
This is a Technical Journal: SPA Brake noise Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 021230 SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 114400 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 350000 EQUIPMENT
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 130000 VISIBILITY
This is a Technical Journal: Rear wiper cover scratching rear window. Modify the rear wiper cover Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Rear wiper cover scratching rear window. Modify the rear wiper cover Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-13 | 350000 EQUIPMENT
This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-13 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-15 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Battery Energy Control Module (BECM), Cell balancing DTCs If Check engine light is on and balancing Diagnostic Trouble Code (DTC) is set in the BECM, follow advice under “Service”. Service: Revised BECM SW has b Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-15 | 023000 SUSPENSION:MULTIPLE AXLE
This is a Technical Journal: ERAD Clutch DTCs, Signal Compare Failure DTCs and/or Watchdog Revised IEM software has been released. Perform an upgrade of the software according to TJ 31543. Test the car and check if any of the above DTCs ret Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-15 | 104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
This is a Technical Journal: ERAD Clutch DTCs, Signal Compare Failure DTCs and/or Watchdog Revised IEM software has been released. Perform an upgrade of the software according to TJ 31543. Test the car and check if any of the above DTCs ret Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-15 | 060000 ENGINE (PWS)
This is a Technical Journal: ERAD Clutch DTCs, Signal Compare Failure DTCs and/or Watchdog Revised IEM software has been released. Perform an upgrade of the software according to TJ 31543. Test the car and check if any of the above DTCs ret Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-11 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-11 | 060000 ENGINE (PWS)
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-09 | 062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-09 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-09 | 060000 ENGINE (PWS)
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-08 | 020000 SUSPENSION
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Rear air suspension – air spring dust cover comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30517 Technical Service PARTNER : ISSUE DATE : 3 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-08 | 022000 SUSPENSION:REAR
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Rear air suspension – air spring dust cover comes loose REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30517 Technical Service PARTNER : ISSUE DATE : 3 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 200000 WHEELS
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 110000 ELECTRICAL SYSTEM
This is a Service Product Journal. High Voltage Gloves. Proper use and handling when working on hybrid vehicles Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 350000 EQUIPMENT
This is a Service Product Journal. High Voltage Gloves. Proper use and handling when working on hybrid vehicles Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Service Product Journal. High Voltage Gloves. Proper use and handling when working on hybrid vehicles Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Service Product Journal. High Voltage Gloves. Proper use and handling when working on hybrid vehicles Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-20 | 130000 VISIBILITY
This is a Technical Journal: If the vehicle shows the symptom of the outer rear view mirror not folding correctly, Follow advise under service. Perform a total software upgrade according to TJ 31543. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-20 | 350000 EQUIPMENT
This is a Technical Journal: If the vehicle shows the symptom of the outer rear view mirror not folding correctly, Follow advise under service. Perform a total software upgrade according to TJ 31543. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-20 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: If the vehicle shows the symptom of the outer rear view mirror not folding correctly, Follow advise under service. Perform a total software upgrade according to TJ 31543. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-18 | 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
This is a Technical Journal: SPA P044200 EVAP Troubleshooting Guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-18 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: SPA P044200 EVAP Troubleshooting Guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-17 | 020000 SUSPENSION
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Knocking noise from rear suspension , loose spring aid in upper spring seat REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 23844 Technical Service PARTN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-17 | 220000 SEATS
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Knocking noise from rear suspension , loose spring aid in upper spring seat REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 23844 Technical Service PARTN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-17 | 350000 EQUIPMENT
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Knocking noise from rear suspension , loose spring aid in upper spring seat REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 23844 Technical Service PARTN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-17 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Knocking noise from rear suspension , loose spring aid in upper spring seat REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 23844 Technical Service PARTN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-16 | 350000 EQUIPMENT
This is a Technical Journal: Rear floor mats, fixation Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-16 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: Rear floor mats, fixation Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-16 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Rear floor mats, fixation Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 350000 EQUIPMENT
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 350000 EQUIPMENT
Please return stock of 31457428, 31457431 washer pumps to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Please return stock of 31457428, 31457431 washer pumps to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Please return stock of 31457428, 31457431 washer pumps to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-24 | 151400 SEAT BELTS:FRONT:BUCKLE ASSEMBLY
This is a Technical Journal: If the front seat belt catch makes noise when moving against the seat upholstery, follow instruction under Service. Add adhesive tape. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-24 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: If the front seat belt catch makes noise when moving against the seat upholstery, follow instruction under Service. Add adhesive tape. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: No Internet Connection With Car Modem/”SIM Card Not Inserted” message. In order to restore the connectivity functions, the “Roaming” function must be activated in the vehicle menus. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 021230 SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-16 | 350000 EQUIPMENT
This is a Service Product Journal: VIDA VOC Access and Functionality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-16 | 350000 EQUIPMENT
This is a Service Product Journal: VIDA VOC Access Functionality and Instruction Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 110000 ELECTRICAL SYSTEM
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-24 | 110000 ELECTRICAL SYSTEM
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-24 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-16 | 110000 ELECTRICAL SYSTEM
This is a Service Product Journal: Unable to set SPA/CMA vehicle into programming mode – P2P Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-16 | 350000 EQUIPMENT
This is a Service Product Journal: Unable to set SPA/CMA vehicle into programming mode – P2P Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-14 | 350000 EQUIPMENT
This is a Technical Journal: Volvo On Call Service Required, VCM Back-up battery DTC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-14 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: It may happen that after a software download, the TPMS light is flashing and DTC VDDM-U24004A, “ECU Software. System internal failures” is set. This is due to that the I-TPMS function in VDDM has not been initia Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-14 | 190000 TIRES
This is a Technical Journal: It may happen that after a software download, the TPMS light is flashing and DTC VDDM-U24004A, “ECU Software. System internal failures” is set. This is due to that the I-TPMS function in VDDM has not been initia Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-14 | 199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
This is a Technical Journal: It may happen that after a software download, the TPMS light is flashing and DTC VDDM-U24004A, “ECU Software. System internal failures” is set. This is due to that the I-TPMS function in VDDM has not been initia Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-10 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Changing DIM trip computer value Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 110000 ELECTRICAL SYSTEM
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-14 | 150000 SEAT BELTS
This bulletin is a service manager bulletin. Seat Belt Extender. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-14 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This bulletin is a service manager bulletin. Seat Belt Extender. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 030000 SERVICE BRAKES, HYDRAULIC
This is a Technical Journal: Squealing noise from rear brakes at low speed. If squealing noise occur from rear brakes 17″ at low speed, follow advice under service. If symptom is confirmed, follow advice in VIDA regarding greasing method wh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 060000 ENGINE AND ENGINE COOLING
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Check engine lamp and DTC – ECM P050B00 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 060000 ENGINE (PWS)
This is a Technical Journal: Check engine lamp and DTC – ECM P050B00 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 130000 VISIBILITY
This is a Technical Journal: Rear wiper cover scratching rear window. Modify the rear wiper cover Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 220000 SEATS
This is a Technical Journal: The factory is looking for seat upholstery information and we are in need of pictures and description of affected seat covers before removal. Seat upholsteries are not to be replaced without contacting Volvo Tec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: The factory is looking for seat upholstery information and we are in need of pictures and description of affected seat covers before removal. Seat upholsteries are not to be replaced without contacting Volvo Tec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-13 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: DTC IHU-B156C8F sets incorrectly. For the cars in the header this DTC can be ignored as it doesn’t affect any of the functions in the car. Do not perform any fault tracing or component replacement due to this DT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 021230 SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-09 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-07 | 110000 ELECTRICAL SYSTEM
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-07 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-07 | 110000 ELECTRICAL SYSTEM
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-07 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-03-20 | 020000 SUSPENSION
Quality letter that relates to the return of strut products that did not meet quality specifications. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 110000 ELECTRICAL SYSTEM
This is a Service Product Journal: Software Purchase Failed – General error occured – VDS / SPA / CMA cars. Download software fix Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Service Product Journal: Software Purchase Failed – General error occured – VDS / SPA / CMA cars. Download software fix Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 100000 POWER TRAIN
This is a Technical Journal: Gear shift lever inoperable Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 350000 EQUIPMENT
This is a Technical Journal: Gear shift lever inoperable Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-02 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Gear shift lever inoperable Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 030000 BRAKES (PWS)
This is a Technical Journal: SPA Brake noise For the purpose of correct fault tracing of the brake noise, the attached guideline has been developed, as an overview of the brake noise and indicates possible faults/solutions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 020000 SUSPENSION
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 114400 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-31 | 060000 ENGINE AND ENGINE COOLING
This is a Technical Journal: Ping noise from exhaust when cooling down Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-31 | 060000 ENGINE (PWS)
This is a Technical Journal: Ping noise from exhaust when cooling down Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-30 | 190000 TIRES
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a “spinning wheel”, while calibration is ongoing. The calibration function its Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-30 | 199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a “spinning wheel”, while calibration is ongoing. The calibration function its Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-07 | 200000 WHEELS
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 200000 WHEELS
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-29 | 350000 EQUIPMENT
This is a Service Product Journal. High Voltage Gloves. Proper use and handling when working on hybrid vehicles Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 110000 ELECTRICAL SYSTEM
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-27 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-29 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-29 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Updates to the customer’s software, May 2019 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-21 | 110000 ELECTRICAL SYSTEM
This is a Service Managers Bulletin: Volvo Cars is constantly developing the in-car systems and the services offered to customers, so that their cars give them the best experience possible . As of May 13th, 2019, when the software in your c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-21 | 160000 STRUCTURE
This is a Technical Journal: Headliner, squeak/rattle noise Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-05-21 | 350000 EQUIPMENT
This is a Technical Journal: Headliner, squeak/rattle noise Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-24 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: SPA Hybrid Irregular electrical distance to empty after software upgrade Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-24 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Vehicle key does not work Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-24 | 350000 EQUIPMENT
This is a Technical Journal: Vehicle key does not work Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-23 | 350000 EQUIPMENT
This is a Technical Journal: Rear tow hook cover, comes loose Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-18 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: DTC BECM-P0C4200 and possible Check Engine Lamp Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-11-03 | 060000 ENGINE AND ENGINE COOLING
This is a Technical Journal: T8 P0EA773 Auxiliary Cooling System Performance Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-27 | 350000 EQUIPMENT
This is a Service Manager Bulletin: Vehicle Transport Handling Procedures and Policy Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-23 | 110000 ELECTRICAL SYSTEM
This is Technical Journal: Intermittent low performance + triple ECM DTC. Do not replace any parts for these cases. A new software for the ECM (engine control module) is under development and is planned to be released Q4-2018 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-09-28 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Configuration Test Software Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-05 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Vehicle key does not work Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-05 | 350000 EQUIPMENT
This is a Technical Journal: Vehicle key does not work Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-05 | 353000 EQUIPMENT:ELECTRICAL
This is a Technical Journal: Vehicle key does not work Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-03 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This is a Technical Journal: 12V battery message and DTC CEM-B129F96 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 110000 ELECTRICAL SYSTEM
This is a Quality Bulletin. Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R39917 on certain model year 2017 ? 2019 XC90, S90, V60CC, V90, XC40, V60, XC60, V90CC vehicles. Volvo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 350000 EQUIPMENT
This is a Quality Bulletin. Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R39917 on certain model year 2017 ? 2019 XC90, S90, V60CC, V90, XC40, V60, XC60, V90CC vehicles. Volvo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 110000 ELECTRICAL SYSTEM
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R39917 on certain model year 2017 ? 2019 XC90, S90, V60CC, V90, XC40, V60, XC60, V90CC vehicles. Volvo has identified that the Tel Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 350000 EQUIPMENT
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R39917 on certain model year 2017 ? 2019 XC90, S90, V60CC, V90, XC40, V60, XC60, V90CC vehicles. Volvo has identified that the Tel Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 350000 EQUIPMENT
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-14 | 150000 SEAT BELTS
This bulletin is a service manager bulletin. Seat Belt Extender. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-14 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This bulletin is a service manager bulletin. Seat Belt Extender. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: SPA Brake noise Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 030000 BRAKES (PWS)
This is a Technical Journal: SPA Brake noise Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 021230 SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-21 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-14 | 150000 SEAT BELTS
This bulletin is a service manager bulletin. Seat Belt Extender. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-14 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin is a service manager bulletin. Seat Belt Extender. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-14 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This bulletin is a service manager bulletin. Seat Belt Extender. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-18 | 190000 TIRES
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-18 | 200000 WHEELS
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-18 | 350000 EQUIPMENT
Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-20 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-20 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Software Installation Policy changes – Canada Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 350000 EQUIPMENT
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Please return stock of Heaters 32206448, 32206450 to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 350000 EQUIPMENT
Please return stock of 31457428, 31457431 washer pumps to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-30 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Please return stock of 31457428, 31457431 washer pumps to your servicing distribution center. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-24 | 151100 SEAT BELTS:FRONT:ANCHORAGE
This is a Technical Journal: If the front seat belt catch makes noise when moving against the seat upholstery, follow instruction under Service. Add adhesive tape. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-24 | 151400 SEAT BELTS:FRONT:BUCKLE ASSEMBLY
This is a Technical Journal: If the front seat belt catch makes noise when moving against the seat upholstery, follow instruction under Service. Add adhesive tape. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-07 | 190000 TIRES
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Tire balancing should be checked and corrected as needed but is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-07 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
This is a Parts Bulletin: 12 Volt support batteries, part number 30659531 must be maintained 9 months from the month of manufacture and every 9 months thereafter.To maintain the battery, connect the battery to an appropriate 12V battery cha Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-04 | 350000 EQUIPMENT
This is a Technical Journal: Vehicle Key Not Found Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-04 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Vehicle Key Not Found Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-16 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: The factory is looking for seat upholstery information and we are in need of pictures and description of affected seat covers before removal. Seat upholsteries are not to be replaced without contacting Volvo Tec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-14 | 162300 STRUCTURE:BODY:DOOR
This is a Technical Journal: Noise from deco door panel when playing music Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-14 | 350000 EQUIPMENT
This is a Technical Journal: Noise from deco door panel when playing music Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-14 | 350000 EQUIPMENT
This is a special tool bulletin: Kits 33300309, 33300310 and 33300311 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-14 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a special tool bulletin: Kits 33300309, 33300310 and 33300311 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-14 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a special tool bulletin: Kits 33300309, 33300310 and 33300311 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-16 | 350000 EQUIPMENT
This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-16 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-16 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-19 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-19 | 350000 EQUIPMENT
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-19 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-16 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the advic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-16 | 160000 STRUCTURE
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the advic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-19 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-19 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-18 | 353000 EQUIPMENT:ELECTRICAL
This is a Technical Journal: DTC BECM-P0C4200 and possible Check Engine Lamp Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-17 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: SPA Hybrid Irregular electrical distance to empty after software upgrade Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-17 | 121000 EXTERIOR LIGHTING:HEADLIGHTS
Technical Journal TITLE : Headlamp , Leak Test REF NO : ISSUING DEPARTMENT : CAR MARKET : United States TJ 17076 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North America YEAR MONTH DAY 2012 10 11 FUNC GROUP : FUNC DESC : Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-16 | 042100 SERVICE BRAKES, AIR:SUPPLY:COMPRESSOR
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-16 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-10 | 100000 POWER TRAIN
This is a Technical Journal: Replacement of ERAD components. Follow instruction for the replacement of the ERAD. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-10 | 350000 EQUIPMENT
This is a Technical Journal: Replacement of ERAD components. Follow instruction for the replacement of the ERAD. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-26 | 162500 STRUCTURE:BODY:TAILGATE
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-26 | 162510 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-26 | 162500 STRUCTURE:BODY:TAILGATE
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-26 | 162510 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-24 | 020000 SUSPENSION
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-24 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Blown fuse, compressor – air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-05 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Ghost DTC set, VCM-B15F855, CEM-B158151 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-01-05 | 350000 EQUIPMENT
This is a Technical Journal: Ghost DTC set, VCM-B15F855, CEM-B158151 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-19 | 350000 EQUIPMENT
This is a Technical Journal: T8 P0EA773 Auxiliary Cooling System Performance Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Parts Bulletin: Hazmat Return Transportation Documentation and requirements Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-16 | 350000 EQUIPMENT
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the advic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-16 | 353000 EQUIPMENT:ELECTRICAL
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the advic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-16 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: If the preconditioning timer function in the Volvo on call app does not work, but setting the calendar function in the car and direct start of the climate settings from the app does work, please follow the advic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-16 | 350000 EQUIPMENT
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-16 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-08 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Battery Energy Control Module (BECM), Cell balancing DTCs If Check engine light is on and balancing Diagnostic Trouble Code (DTC) is set in the BECM, follow advice under “Service”. Service: Revised BECM SW has b Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-08 | 060000 ENGINE (PWS)
This is a Technical Journal: Battery Energy Control Module (BECM), Cell balancing DTCs If Check engine light is on and balancing Diagnostic Trouble Code (DTC) is set in the BECM, follow advice under “Service”. Service: Revised BECM SW has b Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-08 | 100000 POWER TRAIN
This is a Technical Journal: ERAD Clutch DTCs, Signal Compare Failure DTCs and/or Watchdog Revised IEM software has been released. Perform an upgrade of the software according to TJ 31543. Test the car and check if any of the above DTCs ret Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-08 | 350000 EQUIPMENT
This is a Technical Journal: ERAD Clutch DTCs, Signal Compare Failure DTCs and/or Watchdog Revised IEM software has been released. Perform an upgrade of the software according to TJ 31543. Test the car and check if any of the above DTCs ret Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-08 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: ERAD Clutch DTCs, Signal Compare Failure DTCs and/or Watchdog Revised IEM software has been released. Perform an upgrade of the software according to TJ 31543. Test the car and check if any of the above DTCs ret Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-10 | 060000 ENGINE (PWS)
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 200000 WHEELS
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-11-30 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Damaged throttle body due to showroom device. To protect the throttle housing when using Volvo Car Showmode kit in the specified cars, always remove the connector from the throttle housing (see picture 34206.jpg Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-11-30 | 060000 ENGINE (PWS)
This is a Technical Journal: Damaged throttle body due to showroom device. To protect the throttle housing when using Volvo Car Showmode kit in the specified cars, always remove the connector from the throttle housing (see picture 34206.jpg Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-14 | 130000 VISIBILITY
This is a Technical Journal: Rear wiper cover scratching rear window. Modify the rear wiper cover Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-13 | 350000 EQUIPMENT
This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-13 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-09 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM “Car key not found” or if functions such as lock/unlock are not working, please follow advice for detecting key Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-08 | 011000 STEERING: STEERING WHEEL/HANDLE BAR
This is a Technical Journal: T8 Seat/Steering Wheel Heat Inop using Remote Parking Climate w/VOC app Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-08 | 221700 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
This is a Technical Journal: T8 Seat/Steering Wheel Heat Inop using Remote Parking Climate w/VOC app Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 162500 STRUCTURE:BODY:TAILGATE
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 162510 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 162500 STRUCTURE:BODY:TAILGATE
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-06 | 162510 STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R89910 on certain model year 2018 ? 2019 XC60 vehicles equipped with a Power Operated Tailgate (POT). Volvo has identified that th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-20 | 130000 VISIBILITY
This is a Technical Journal: If the vehicle shows the symptom of the outer rear view mirror not folding correctly, Follow advise under service. Perform a total software upgrade according to TJ 31543. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-20 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: If the vehicle shows the symptom of the outer rear view mirror not folding correctly, Follow advise under service. Perform a total software upgrade according to TJ 31543. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-18 | 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
This is a Technical Journal: SPA P044200 EVAP Troubleshooting Guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-18 | 350000 EQUIPMENT
This is a Technical Journal: SPA P044200 EVAP Troubleshooting Guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-17 | 020000 SUSPENSION
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Knocking noise from rear suspension , loose spring aid in upper spring seat REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 23844 Technical Service PARTN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-17 | 350000 EQUIPMENT
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Knocking noise from rear suspension , loose spring aid in upper spring seat REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 23844 Technical Service PARTN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-16 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Rear floor mats, fixation Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-03-23 | 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
This is a Technical Journal: Climate unit, not sufficient airflow from vents. Perform action according to instructions for different car variants. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-22 | 350000 EQUIPMENT
This is a Technical Journal: SiriusXM Travel Link service cannot be activated Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-22 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: SiriusXM Travel Link service cannot be activated Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2019-02-09 | 060000 ENGINE AND ENGINE COOLING
This is a Technical Journal: Oil in cooling system. New cleaning method developed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-05 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: No VIDA communication with vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-05 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-05 | 060000 ENGINE (PWS)
This is a Technical Journal: Petrol engine & misfire codes. Do NOT replace any parts for this issue. A revised software solution for the ECM (Engine Control Module) is under development for this issue. This TJ will be updated as soon as sol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 110000 ELECTRICAL SYSTEM
This is a Quality Bulletin. Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R39917 on certain model year 2017 ? 2019 XC90, S90, V60CC, V90, XC40, V60, XC60, V90CC vehicles. Volvo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 110000 ELECTRICAL SYSTEM
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Group, has decided to launch Recall R39917 on certain model year 2017 ? 2019 XC90, S90, V60CC, V90, XC40, V60, XC60, V90CC vehicles. Volvo has identified that the Tel Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 350000 EQUIPMENT
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-12-04 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-08-22 | 350000 EQUIPMENT
This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it’s dealer or any shop maintaining or repairing Volvo’s. The equipment can be provided by Volvo’s equipment supplier Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-05-17 | 150000 SEAT BELTS
This bulletin is a service manager bulletin. Seat Belt Extender. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-30 | 350000 EQUIPMENT
Please return stock of 31359465 towing hook to your servicing distribution center for inspection. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-30 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
Please return stock of 31359465 towing hook to your servicing distribution center for inspection. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-23 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
This is a Technical Journal: Gear shift lever inoperable Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-22 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: Engine remote start is intermittently not working. Corrected software for this issue will be released in Total Upgrade, Service 2.0, and PDS software packages during Q4 2017 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-22 | 116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
This is a Technical Journal: Engine remote start is intermittently not working. Corrected software for this issue will be released in Total Upgrade, Service 2.0, and PDS software packages during Q4 2017 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-07-28 | 350000 EQUIPMENT
This is a Technical Journal: New XC60; Initial quality reporting Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-07-28 | 100000 POWER TRAIN
This is a Special Tool Bulletin: The OTC Powertrain Lift table is designed to safely aid the technician in removal and installation of electric vehicle and PHEV battery assemblies. The table fits conveniently between the 2 lift columns and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-07-28 | 350000 EQUIPMENT
This is a Special Tool Bulletin: The OTC Powertrain Lift table is designed to safely aid the technician in removal and installation of electric vehicle and PHEV battery assemblies. The table fits conveniently between the 2 lift columns and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-01 | 980000 UNKNOWN OR OTHER
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. At PDS and when attempting to diagnose a customer concern regarding voice controls not working or responding properly, make Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-01 | 350000 EQUIPMENT
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo C Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-04-30 | 200000 WHEELS
This is a Technical Journal: If vibrations occur due to issues with tires or wheels, follow the advice under Service and Vehicle Report. Service: In case of vibrations, please follow TJ 20803 to establish the if the vibrations are coming fr Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-04 | 350000 EQUIPMENT
MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-03 | 110000 ELECTRICAL SYSTEM
This is a Service Product Journal: Windows 7: Unable to open Wiring diagrams Windows 10: VIDA will crash when trying to open wiring diagram Final Solution: The only solution that we are aware of is to uninstall Adobe SVG viewer. Instruction Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-03 | 350000 EQUIPMENT
This is a Service Product Journal: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-01 | 350000 EQUIPMENT
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. At PDS and when attempting to diagnose a customer concern regarding voice controls not working or responding properly, make Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-01 | 353000 EQUIPMENT:ELECTRICAL
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. At PDS and when attempting to diagnose a customer concern regarding voice controls not working or responding properly, make Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-01 | 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. At PDS and when attempting to diagnose a customer concern regarding voice controls not working or responding properly, make Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-01 | 160000 STRUCTURE
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo C Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-05-01 | 350000 EQUIPMENT
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo C Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-20 | 130000 VISIBILITY
This is a Technical Journal: If the vehicle shows the symptom of the outer rear view mirror not folding correctly, Follow advise under service. Perform a total software upgrade according to TJ 31543. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-18 | 350000 EQUIPMENT
This is a Technical Journal: SPA P044200 EVAP Troubleshooting Guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-17 | 020000 SUSPENSION
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Knocking noise from rear suspension , loose spring aid in upper spring seat REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 23844 Technical Service PARTN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-04-30 | 190000 TIRES
This is a Technical Journal: If vibrations occur due to issues with tires or wheels, follow the advice under Service and Vehicle Report. Service: In case of vibrations, please follow TJ 20803 to establish the if the vibrations are coming fr Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-04-30 | 200000 WHEELS
This is a Technical Journal: If vibrations occur due to issues with tires or wheels, follow the advice under Service and Vehicle Report. Service: In case of vibrations, please follow TJ 20803 to establish the if the vibrations are coming fr Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-10-10 | 060000 ENGINE (PWS)
Volvo Chassis – HVAC Recirculation Door Whistle – US17+OBD2016 Emissions, Model Year 2018 (Common Rail Fuel System ONLY) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-08 | 350000 EQUIPMENT
This is a Technical Journal: This TJ is released to highlight the importance of not storing the remote control key close to objects that may shield radio communication between the remote control key and the car or could cause interference w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-22 | 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
This is a Technical Journal: Infotainment system switches to FM radio source at random Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-16 | 162300 STRUCTURE:BODY:DOOR
This is a Technical Journal: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-15 | 350000 EQUIPMENT
This is a Service Manager Bulletin: Retailer Car Delivery Process. All vehicles must have a pre-delivery service and a proper customer delivery. Perform all required maintenance, repairs and updates prior to delivery to customer. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-08 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: This TJ is released to highlight the importance of not storing the remote control key close to objects that may shield radio communication between the remote control key and the car or could cause interference w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-08 | 116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE
This is a Technical Journal: This TJ is released to highlight the importance of not storing the remote control key close to objects that may shield radio communication between the remote control key and the car or could cause interference w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-08 | 350000 EQUIPMENT
This is a Technical Journal: This TJ is released to highlight the importance of not storing the remote control key close to objects that may shield radio communication between the remote control key and the car or could cause interference w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-04 | 110000 ELECTRICAL SYSTEM
MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-03 | 110000 ELECTRICAL SYSTEM
This is a Service Product Journal: Windows 7: Unable to open Wiring diagrams Windows 10: VIDA will crash when trying to open wiring diagram Final Solution: The only solution that we are aware of is to uninstall Adobe SVG viewer. Instruction Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-03 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Service Product Journal: Windows 7: Unable to open Wiring diagrams Windows 10: VIDA will crash when trying to open wiring diagram Final Solution: The only solution that we are aware of is to uninstall Adobe SVG viewer. Instruction Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-03 | 350000 EQUIPMENT
This is a Service Product Journal: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-03 | 353000 EQUIPMENT:ELECTRICAL
This is a Service Product Journal: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-07-17 | 200000 WHEELS
This is a Technical Journal: Vibrations due to wheels and tire uniformity/force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-07-13 | 220000 SEATS
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-07-13 | 221700 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-07-13 | 190000 TIRES
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-07-13 | 200000 WHEELS
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-07-12 | 350000 EQUIPMENT
This is a Special Tool Bulletin: Kits 33300313 and 33300315 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018-07-12 | 354000 EQUIPMENT:MECHANICAL
This is a Special Tool Bulletin: Kits 33300313 and 33300315 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-16 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Rear floor mats, fixation Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-20 | 130000 VISIBILITY
This is a Technical Journal: If the vehicle shows the symptom of the outer rear view mirror not folding correctly, Follow advise under service. Perform a total software upgrade according to TJ 31543. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-18 | 350000 EQUIPMENT
This is a Technical Journal: SPA P044200 EVAP Troubleshooting Guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-17 | 020000 SUSPENSION
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Knocking noise from rear suspension , loose spring aid in upper spring seat REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 23844 Technical Service PARTN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-16 | 356000 EQUIPMENT ADAPTIVE/MOBILITY
This is a Technical Journal: Rear floor mats, fixation Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-16 | 350000 EQUIPMENT
This is a Technical Journal: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-11-15 | 350000 EQUIPMENT
This is a Service Manager Bulletin: Retailer Car Delivery Process. All vehicles must have a pre-delivery service and a proper customer delivery. Perform all required maintenance, repairs and updates prior to delivery to customer. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-06-09 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
The Warranty Retailer Counseling Process (WRCP) is used to gauge individual retailer performance on objective measures over time. By setting clear performance expectations and parameters and assisting retailers in focusing on individual pro Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-21 | 070000 FUEL SYSTEM, GASOLINE
This is a Technical Journal: If the fuel low pressure sensor (LPS) needs replacement, see updated information under service. This TJ is released to inform that a method is changed in VIDA regarding replacement of fuel low pressure sensor (L Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-21 | 110000 ELECTRICAL SYSTEM
This is a Technical Journal: The check engine light (CEL) may be illuminated without any other customer symptoms or the code BECM-P0CE100 is read out with VIDA. Please follow the advice under Service. BECM = Battery Electronic Control Modul Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-21 | 060000 ENGINE (PWS)
This is a Technical Journal: The check engine light (CEL) may be illuminated without any other customer symptoms or the code BECM-P0CE100 is read out with VIDA. Please follow the advice under Service. BECM = Battery Electronic Control Modul Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-19 | 190000 TIRES
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-19 | 200000 WHEELS
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-10 | 110000 ELECTRICAL SYSTEM
the infotainment system in the vehicle restarts or reboots repeatedly while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-21 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: If the fuel low pressure sensor (LPS) needs replacement, see updated information under service. This TJ is released to inform that a method is changed in VIDA regarding replacement of fuel low pressure sensor (L Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-19 | 200000 WHEELS
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-12-04 | 354000 EQUIPMENT:MECHANICAL
This is a Technical Journal: Brake vibrations due to lockable wheel screws Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-12-04 | 030000 BRAKES (PWS)
This is a Technical Journal: Brake vibrations due to lockable wheel screws Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-12-04 | 200000 WHEELS
This is a Technical Journal: Vibrations due to wheels and tire uniformity / force variation. Before carrying out this TJ, always start with TJ 20803 to sort out if the problem is related to driveline or wheels. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-10 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: DTC BECM-P060A00 may appear when performing VIDA read out. If the DTC is present please follow step under Service. Reported symptoms are: – Error message in DIM BECM = Battery Energy Control Module DIM = Driver Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-03 | 354000 EQUIPMENT:MECHANICAL
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). The sound may come from the balance shaft which is fitted in the oil sump area where the noise is most concentrat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-03 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). The sound may come from the balance shaft which is fitted in the oil sump area where the noise is most concentrat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-10-03 | 118000 ELECTRICAL SYSTEM:SOFTWARE
This is a Technical Journal: If the rear axle causes judder/sound at parking maneuvres. (full turn and acceleration), then follow advice under service. Download Total Upgrade software Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2017-06-28 | 200000 WHEELS
This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2018 VOLVO XC60
search for another vehicle