2015 TOYOTA Sienna

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

6 Recalls for 2015 TOYOTA Sienna

Recall Date Component Summary
2019-07-25 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Vantage Mobility International, LLC (Vantage) is recalling certain 2012-2018 AMS Genesis wheelchair vans, built on a Toyota Sienna vehicles. The rubber brake hoses that attach to the rear wheel assembly may be too short, causing them to rub against the rear axle trailing arm.

Remedy:

Vantage will notify owners, and dealers will install a set of rear brake hoses that will provide the proper clearance, free of charge. The recall began December 16, 2019. Owners may contact Vantage customer service at 1-800-488-9082.

2019-06-04 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Braun Corporation (Braun) is recalling certain 2014-2019 Toyota Sienna mobility van conversions. The brake lines may have incorrect tube nut fittings installed, which may cause a pressure drop within the braking system.

Remedy:

Braun has notified owners, and dealers will install an adaptor to correct the issue, free of charge. The recall began June 25, 2019. Owners may contact Braun customer service at 1-800-488-0359.

2016-11-29 STRUCTURE:BODY:DOOR

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may subsequently open unexpectedly, possibly while the vehicle is moving.

Remedy:

Toyota will notify owners, and dealers will replace the junction block, rear sliding door wire harnesses, and install two sub wire harnesses, free of charge. The recall began on July 28, 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota’s number for this recall is G04.

2015-04-21 STRUCTURE:BODY:ROOF AND PILLARS

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2015 Sienna vehicles manufactured September 1, 2014, to April 13, 2015 and equipped with overhead entertainment accessories installed by SET. During reassembly of the interior after the overhead entertainment system installation, a trim panel securing clip may have been reused instead of being replaced.

Remedy:

SET will notify owners, and dealers will replace the trim panel securing clip, free of charge. The recall began on May 22, 2015. Owners may contact SET customer service at 1-866-405-4226. SET’s number for this recall is SET15B.

2015-04-22 STRUCTURE:BODY:ROOF AND PILLARS

Gulf States Toyota, Inc. (GST) is recalling certain model year 2015 Toyota Sienna vehicles manufactured January 23, 2015, to April 13, 2015, and equipped with non-Toyota-brand overhead entertainment accessories installed by GST. During reassembly of the interior after the overhead entertainment system installation, a trim panel securing clip may have been reused instead of being replaced.

Remedy:

GST will notify owners, and dealers will replace the trim panel securing clip, free of charge. The recall began June 5, 2015. Owners may contact GST customer service at 1-800-444-1074. GST’s number for this recall is 15R1.

2014-11-26 AIR BAGS:SIDE/WINDOW

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Sienna vehicles manufactured September 2, 2014, to November 25, 2014. In the event of a crash that necessitates the deployment of the curtain shield airbag (CSA), the second row overhead assist grips may detach.

Remedy:

Toyota will notify owners, and dealers will modify the headliner near the second row overhead assist grip, free of charge. The recall began on January 15, 2015. Owners may contact Toyota customer service at 1-800-331-4331.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

0 Complaints sent to the Center for Auto Safety for 2015 TOYOTA Sienna

skip to NHTSA complaints

Date Component  

178 Complaints submitted to NHTSA for 2015 TOYOTA Sienna

skip to CAS complaints

Date Component  
2021-04-02 VISIBILITY/WIPER
ODI Number: 11406071
2016-10-26 ENGINE
ODI Number: 10919045
2017-07-10 STRUCTURE:BODY:DOOR
ODI Number: 11004054
2017-07-14 STRUCTURE:BODY
ODI Number: 11005386
2017-07-14 ELECTRICAL SYSTEM
ODI Number: 11005368
2017-07-10 STRUCTURE:BODY
ODI Number: 11004087
2017-07-03 STRUCTURE:BODY
ODI Number: 11002865
2017-06-30 STRUCTURE:BODY
ODI Number: 11002536
2017-07-05 STRUCTURE:BODY
ODI Number: 11003162
2017-06-26 STRUCTURE:BODY
ODI Number: 11001492
2017-06-23 STRUCTURE:BODY
ODI Number: 11000926
2017-06-28 ELECTRICAL SYSTEM
ODI Number: 11001907
2017-06-12 STRUCTURE | STRUCTURE:BODY
ODI Number: 10994459
2017-06-14 STRUCTURE:BODY:DOOR
ODI Number: 10995130
2017-06-09 STRUCTURE:BODY
ODI Number: 10994230
2017-05-29 UNKNOWN OR OTHER
ODI Number: 10992056
2017-05-22 ELECTRICAL SYSTEM | POWER TRAIN | SUSPENSION
ODI Number: 10990866
2017-06-04 STRUCTURE:BODY
ODI Number: 10993072
2017-05-15 STRUCTURE:BODY
ODI Number: 10985791
2017-05-14 STRUCTURE:BODY
ODI Number: 10985620
2017-05-18 SEAT BELTS
ODI Number: 10990496
2017-05-10 ELECTRICAL SYSTEM | STRUCTURE:BODY
ODI Number: 10984625
2017-05-11 STRUCTURE:BODY
ODI Number: 10984960
2017-04-24 STRUCTURE:BODY
ODI Number: 10980094
2017-05-02 AIR BAGS
ODI Number: 10983019
2017-04-26 STRUCTURE:BODY
ODI Number: 10980958
2017-04-24 STRUCTURE:BODY
ODI Number: 10980060
2017-05-01 UNKNOWN OR OTHER
ODI Number: 10981545
2017-04-24 STRUCTURE:BODY:DOOR
ODI Number: 10980146
2017-04-03 UNKNOWN OR OTHER
ODI Number: 10970282
2017-04-04 ELECTRICAL SYSTEM | SEATS
ODI Number: 10970614
2017-04-10 AIR BAGS
ODI Number: 10971583
2017-04-04 STRUCTURE:BODY
ODI Number: 10970572
2017-03-30 POWER TRAIN
ODI Number: 10969454
2017-03-24 STRUCTURE:BODY
ODI Number: 10968303
2017-03-31 ENGINE
ODI Number: 10969725
2017-03-29 STRUCTURE:BODY
ODI Number: 10969349
2017-03-31 STRUCTURE:BODY
ODI Number: 10969685
2017-03-30 STRUCTURE
ODI Number: 10969490
2017-07-25 ELECTRICAL SYSTEM
ODI Number: 11010597
2017-08-01 STRUCTURE:BODY:DOOR
ODI Number: 11012193
2017-08-01 EXTERIOR LIGHTING
ODI Number: 11012156
2017-07-27 ELECTRICAL SYSTEM | STRUCTURE:BODY
ODI Number: 11010986
2016-09-08 ELECTRICAL SYSTEM
ODI Number: 10904844
2016-08-29 SERVICE BRAKES
ODI Number: 10899334
2016-08-25 POWER TRAIN
ODI Number: 10898595
2017-03-10 STRUCTURE:BODY
ODI Number: 10959992
2017-03-15 LATCHES/LOCKS/LINKAGES
ODI Number: 10966062
2017-03-03 ELECTRICAL SYSTEM
ODI Number: 10958421
2017-03-08 AIR BAGS
ODI Number: 10959516
2017-03-10 ELECTRICAL SYSTEM | STRUCTURE:BODY
ODI Number: 10960057
2017-02-17 STRUCTURE:BODY
ODI Number: 10955301
2017-02-23 ELECTRICAL SYSTEM
ODI Number: 10956611
2017-02-10 ELECTRICAL SYSTEM | STRUCTURE:BODY
ODI Number: 10953815
2017-01-19 SEATS
ODI Number: 10946390
2017-01-19 LATCHES/LOCKS/LINKAGES
ODI Number: 10946353
2017-01-17 ELECTRICAL SYSTEM | ENGINE
ODI Number: 10945819
2021-01-26 ELECTRICAL SYSTEM | ENGINE | SERVICE BRAKES
ODI Number: 11390084
2017-01-10 STRUCTURE:BODY
ODI Number: 10944109
2017-01-04 UNKNOWN OR OTHER
ODI Number: 10939776
2017-01-12 SERVICE BRAKES
ODI Number: 10944681
2016-12-26 CHILD SEAT
ODI Number: 10937484
2016-12-26 CHILD SEAT
ODI Number: 10937483
2016-11-23 SEAT BELTS
ODI Number: 10927597
2020-09-12 SEAT BELTS
ODI Number: 11354582
2020-08-28 FUEL/PROPULSION SYSTEM
ODI Number: 11351862
2020-09-08 STRUCTURE:BODY
ODI Number: 11353820
2020-08-12 STRUCTURE:BODY
ODI Number: 11348896
2020-07-03 STRUCTURE:BODY
ODI Number: 11337372
2020-03-22 WHEELS
ODI Number: 11318983
2020-03-05 ENGINE | POWER TRAIN | VEHICLE SPEED CONTROL
ODI Number: 11316319
2020-02-24 STEERING | SUSPENSION
ODI Number: 11311047
2020-02-14 EQUIPMENT | UNKNOWN OR OTHER
ODI Number: 11309288
2020-01-27 ENGINE | FUEL/PROPULSION SYSTEM
ODI Number: 11302373
2020-01-27 ENGINE
ODI Number: 11302322
2020-01-22 AIR BAGS
ODI Number: 11301075
2020-01-02 UNKNOWN OR OTHER
ODI Number: 11296682
2019-12-16 ELECTRICAL SYSTEM | ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 11289262
2019-08-29 STEERING
ODI Number: 11252168
2019-08-26 STRUCTURE:BODY
ODI Number: 11246523
2019-08-15 ELECTRONIC STABILITY CONTROL
ODI Number: 11244310
2019-08-11 STRUCTURE:BODY
ODI Number: 11243071
2019-08-10 ELECTRICAL SYSTEM
ODI Number: 11243008
2019-08-13 SEAT BELTS | STRUCTURE:BODY | UNKNOWN OR OTHER
ODI Number: 11243729
2019-07-23 WHEELS
ODI Number: 11234177
2019-10-08 WHEELS
ODI Number: 11266993
2019-09-16 FUEL/PROPULSION SYSTEM
ODI Number: 11255523
2019-09-11 UNKNOWN OR OTHER
ODI Number: 11254810
2019-05-21 UNKNOWN OR OTHER
ODI Number: 11208883
2019-05-17 ELECTRONIC STABILITY CONTROL
ODI Number: 11208249
2019-05-15 STRUCTURE:BODY
ODI Number: 11207681
2019-05-03 SEAT BELTS
ODI Number: 11205423
2019-04-23 STEERING | SUSPENSION | UNKNOWN OR OTHER
ODI Number: 11203230
2019-03-31 STRUCTURE:BODY
ODI Number: 11192813
2019-04-01 ELECTRICAL SYSTEM | UNKNOWN OR OTHER
ODI Number: 11193033
2019-04-08 UNKNOWN OR OTHER
ODI Number: 11194580
2019-07-09 AIR BAGS
ODI Number: 11230494
2019-07-14 STEERING
ODI Number: 11231675
2019-06-19 SUSPENSION
ODI Number: 11221103
2019-06-25 UNKNOWN OR OTHER
ODI Number: 11222471
2019-06-07 STRUCTURE:BODY
ODI Number: 11218558
2019-02-05 POWER TRAIN
ODI Number: 11174570
2019-01-25 UNKNOWN OR OTHER
ODI Number: 11172122
2019-01-25 UNKNOWN OR OTHER
ODI Number: 11172071
2018-10-02 ELECTRICAL SYSTEM
ODI Number: 11131288
2018-08-30 STRUCTURE:BODY
ODI Number: 11123569
2018-06-07 VISIBILITY:SUN/MOON ROOF ASSEMBLY
ODI Number: 11100338
2018-05-25 ELECTRICAL SYSTEM | STEERING
ODI Number: 11097977
2018-05-11 STEERING
ODI Number: 11093428
2018-04-20 ELECTRICAL SYSTEM:WIRING | ENGINE
ODI Number: 11089088
2019-03-22 WHEELS
ODI Number: 11190647
2019-03-12 UNKNOWN OR OTHER
ODI Number: 11186292
2019-03-10 UNKNOWN OR OTHER
ODI Number: 11185611
2018-03-01 TIRES
ODI Number: 11075749
2018-02-26 STRUCTURE:BODY
ODI Number: 11074894
2018-02-23 ELECTRICAL SYSTEM
ODI Number: 11074549
2018-11-28 SERVICE BRAKES
ODI Number: 11154401
2018-11-27 ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 11154193
2018-11-21 STRUCTURE:BODY
ODI Number: 11153109
2018-11-20 ELECTRICAL SYSTEM | SERVICE BRAKES | UNKNOWN OR OTHER
ODI Number: 11152668
2018-11-01 WHEELS
ODI Number: 11144726
2018-10-28 UNKNOWN OR OTHER
ODI Number: 11143536
2018-10-24 STEERING | SUSPENSION | UNKNOWN OR OTHER
ODI Number: 11142399
2018-10-25 WHEELS
ODI Number: 11142762
2018-08-06 SERVICE BRAKES
ODI Number: 11118098
2018-08-13 FUEL/PROPULSION SYSTEM
ODI Number: 11119526
2018-07-23 UNKNOWN OR OTHER
ODI Number: 11113106
2018-07-09 STRUCTURE:BODY
ODI Number: 11110189
2018-07-17 SERVICE BRAKES
ODI Number: 11111960
2018-07-11 UNKNOWN OR OTHER
ODI Number: 11110822
2018-07-18 VISIBILITY:GLASS, SIDE/REAR
ODI Number: 11112097
2018-06-26 UNKNOWN OR OTHER
ODI Number: 11104116
2018-06-26 VEHICLE SPEED CONTROL:CRUISE CONTROL
ODI Number: 11104018
2018-01-15 CHILD SEAT:SHELL:BOOSTER
ODI Number: 11062797
2017-12-12 ELECTRICAL SYSTEM
ODI Number: 11054102
2017-12-19 UNKNOWN OR OTHER
ODI Number: 11055592
2017-12-08 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
ODI Number: 11053563
2017-11-30 ELECTRICAL SYSTEM | UNKNOWN OR OTHER
ODI Number: 11051452
2017-12-02 ELECTRICAL SYSTEM | STEERING
ODI Number: 11052032
2017-11-23 FUEL/PROPULSION SYSTEM
ODI Number: 11048124
2017-12-05 ELECTRICAL SYSTEM
ODI Number: 11052477
2017-11-13 ELECTRONIC STABILITY CONTROL | STEERING | WHEELS
ODI Number: 11045856
2017-10-12 SERVICE BRAKES
ODI Number: 11033165
2017-10-10 ELECTRICAL SYSTEM | STRUCTURE:BODY
ODI Number: 11032817
2017-10-11 EXTERIOR LIGHTING
ODI Number: 11032970
2017-10-09 WHEELS
ODI Number: 11032609
2017-09-23 UNKNOWN OR OTHER
ODI Number: 11025134
2017-09-18 UNKNOWN OR OTHER
ODI Number: 11023938
2017-09-25 STRUCTURE:BODY
ODI Number: 11025374
2017-09-14 WHEELS
ODI Number: 11023498
2017-11-08 STRUCTURE:BODY:DOOR
ODI Number: 11021973
2017-09-08 SERVICE BRAKES | WHEELS
ODI Number: 11022357
2016-07-28 ELECTRICAL SYSTEM
ODI Number: 10891491
2016-07-20 AIR BAGS
ODI Number: 10886060
2016-06-01 AIR BAGS
ODI Number: 10871836
2016-05-17 STRUCTURE:BODY
ODI Number: 10865527
2016-05-15 UNKNOWN OR OTHER
ODI Number: 10865020
2016-04-29 ELECTRICAL SYSTEM | STRUCTURE:BODY
ODI Number: 10862153
2016-04-01 EXTERIOR LIGHTING:TURN SIGNAL:SWITCH | SERVICE BRAKES, HYDRAULIC
ODI Number: 10852896
2016-03-13 ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 10846305
2016-02-09 EXTERIOR LIGHTING
ODI Number: 10825127
2016-02-16 ELECTRICAL SYSTEM
ODI Number: 10836505
2016-02-01 VISIBILITY/WIPER
ODI Number: 10823570
2015-12-31 ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 10817269
2016-01-06 SEATS
ODI Number: 10818339
2015-11-20 STRUCTURE:BODY
ODI Number: 10795130
2015-11-18 ELECTRICAL SYSTEM
ODI Number: 10794721
2015-10-06 VISIBILITY/WIPER
ODI Number: 10780034
2015-10-03 STRUCTURE:BODY
ODI Number: 10779449
2015-09-05 ENGINE | SERVICE BRAKES
ODI Number: 10761816
2015-08-30 ELECTRICAL SYSTEM
ODI Number: 10760209
2015-08-16 UNKNOWN OR OTHER
ODI Number: 10749014
2015-07-31 SERVICE BRAKES
ODI Number: 10745363
2015-07-20 UNKNOWN OR OTHER
ODI Number: 10735150
2015-04-19 ELECTRICAL SYSTEM | ENGINE
ODI Number: 10706552
2019-04-03 WHEELS
ODI Number: 11193600
2018-02-13 UNKNOWN OR OTHER
ODI Number: 11072700
2018-11-30 SUSPENSION
ODI Number: 11155200
Is the government investigating the safety of your vehicle? Find out here.

0 Investigations for 2015 TOYOTA Sienna

Date Opened Date Closed Component  
Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

411 Service Alerts for 2015 TOYOTA Sienna

Date Description
2022-04-14 350000 EQUIPMENT

Toyota Safety Recall and Service Campaign – Technician Certification Requirements 4.14.2022

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2022-03-17 030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2022-03-17 280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2022-02-01 220000 SEATS

TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2022-01-12 190000 TIRES

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2022-01-12 200000 WHEELS

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2022-01-12 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2022-01-28 114000 ELECTRICAL SYSTEM:WIRING

TSB This Service Bulletin includes guidelines meant to help determine whether to repair or replace a wire harness assembly based on damage type. This Service Bulletin should be used in conjunction with the applicable model and model year El

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-11-23 160000 STRUCTURE

TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-10-04 284300 BACK OVER PREVENTION: SENSING SYSTEM: RADAR

TSB: For proper calibration of the millimeter wave radar sensor, the vehicle and radar target must be on a level surface with a consistent plane. If a level surface with a consistent plane is not available, use the Floor Slope Compensation

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-10-04 264300 FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: RADAR

TSB: For proper calibration of the millimeter wave radar sensor, the vehicle and radar target must be on a level surface with a consistent plane. If a level surface with a consistent plane is not available, use the Floor Slope Compensation

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-07-06 100000 POWER TRAIN

TT: Some 2014-2021 model year vehicles equipped with Dynamic Torque Control AWD system may experience a ?Noise? or ?Abnormal Operation? condition from the rear differential front coupling. In some cases, even an ?AWD System Message? with

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-05-04 132000 VISIBILITY:GLASS, SIDE/REAR

OBSOLETE NOTICE May 04, 2021: This bulletin is now obsolete. Please see T-SB-0004-21.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-05-04 162300 STRUCTURE:BODY:DOOR

OBSOLETE NOTICE May 04, 2021: This bulletin is now obsolete. Please see T-SB-0004-21.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-05-04 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE May 04, 2021: This bulletin is now obsolete. Please see T-SB-0004-21.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-05-04 132000 VISIBILITY:GLASS, SIDE/REAR

TSB: Some 2010 ? 2020 model year Sienna vehicles may exhibit a condition where the front door glass run on either the right-hand or left-hand side comes loose from the door channel during window operation. Follow the Repair Procedure in thi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-05-04 162300 STRUCTURE:BODY:DOOR

TSB: Some 2010 ? 2020 model year Sienna vehicles may exhibit a condition where the front door glass run on either the right-hand or left-hand side comes loose from the door channel during window operation. Follow the Repair Procedure in thi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-05-24 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

UPDATES TO THE 2014-2021 TOYOTA UNIVERSAL FLAT RATE MANUAL

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2001-05-04 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Replacement vin plates.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

1991-01-18 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Product general information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

1989-06-30 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Product general information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

1993-04-09 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Product general information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

1991-01-08 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Product general information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-12-12 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Technician Certification Requirements.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-03-28 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Technician Certification Requirements.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-06-14 114000 ELECTRICAL SYSTEM:WIRING

Oxygen sensor could experience wire degradation inside the oxygen sensor wiring harness.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-06-14 350000 EQUIPMENT

Oxygen sensor could experience wire degradation inside the oxygen sensor wiring harness.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-06-14 356000 EQUIPMENT ADAPTIVE/MOBILITY

Oxygen sensor could experience wire degradation inside the oxygen sensor wiring harness.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-03-17 140000 AIR BAGS

Toyota Safety Recall and Service Campaign – Technician Certification Requirements

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-03-12 030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-03-12 280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-03-18 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0012-21.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-03-08 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0044-16.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-03-05 220000 SEATS

TSB: Some 2010 ? 2021 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water an

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-06-23 110000 ELECTRICAL SYSTEM

Rear Seat Entertainment Overhead DVD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-06-23 160000 STRUCTURE

Rear Seat Entertainment Overhead DVD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-06-23 220000 SEATS

Rear Seat Entertainment Overhead DVD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-02-03 350000 EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-12-14 030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-12-14 280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-01-21 050000 PARKING BRAKE

TSB: Some 2010 ? 2020 model year Sienna vehicles may exhibit a condition where the front door glass run on either the right-hand or left-hand side comes loose from the door channel during window operation. Follow the Repair Procedure in t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2021-01-21 180000 VEHICLE SPEED CONTROL

TSB: Some 2010 ? 2020 model year Sienna vehicles may exhibit a condition where the front door glass run on either the right-hand or left-hand side comes loose from the door channel during window operation. Follow the Repair Procedure in t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-10-21 062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

TT: HVAC drain tube is found to be blocked/clogged.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-11-24 030000 BRAKES (PWS)

TSB: Some 2011 ? 2020 model year Sienna vehicles may exhibit a vibration/pulsation from the front brakes that can be felt in the brake pedal while lightly applying the brake pedal. Follow the Repair Procedure in this bulletin to address thi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-12-14 030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-03-26 350000 EQUIPMENT

TT: For proper calibration of the millimeter wave radar sensor, the vehicle must be on a level surface. If a level surface is not available, this tech tip should be used in conjunction with the repair manual to set the angle of the front mi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-03-26 280000 BACK OVER PREVENTION

TT: For proper calibration of the millimeter wave radar sensor, the vehicle must be on a level surface. If a level surface is not available, this tech tip should be used in conjunction with the repair manual to set the angle of the front mi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-07-30 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

TT: HVAC drain tube is found to be blocked/clogged.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-04-07 350000 EQUIPMENT

TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-04-06 350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-01-23 350000 EQUIPMENT

TT: In certain cases of leaking air conditioning systems, the root cause of the leak is inadvertently overlooked, causing a repeat repair. To improve customer satisfaction and repair A/C system leaks in one dealer visit, Toyota has develope

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-02-06 350000 EQUIPMENT

TSB: Some 2004 ? 2017 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bull

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-10-23 350000 EQUIPMENT

Region Letter: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following infor

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-10-23 350000 EQUIPMENT

Region Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-10-23 350000 EQUIPMENT

Dealer Package: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following info

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-10-23 350000 EQUIPMENT

Dealer Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-02-12 350000 EQUIPMENT

OBSOLETE NOTICE February 12, 2020: This bulletin is now obsolete. Please see T-SB-0010-20.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2020-01-27 350000 EQUIPMENT

TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-09-18 110000 ELECTRICAL SYSTEM

TT: Some customers may experience poor outgoing Bluetooth sound quality, this can occur for various reasons. Current multimedia systems are designed with the ability to adjust Bluetooth sound quality to compensate for echo or excessive back

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-09-18 350000 EQUIPMENT

TT: Some customers may experience poor outgoing Bluetooth sound quality, this can occur for various reasons. Current multimedia systems are designed with the ability to adjust Bluetooth sound quality to compensate for echo or excessive back

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-07-09 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: OBSOLETE NOTICE July 9, 2019: This bulletin is now obsolete. Please see T-SB-0080-19.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-07-09 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-07-09 356000 EQUIPMENT ADAPTIVE/MOBILITY

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-07-03 200000 WHEELS

TSB: Some 2009 ? 2019 model year Toyota vehicles with super chrome wheel finishes may become discolored and/or damaged when aftermarket cleaners, polishes, or brake dust removal products are used on wheels with super chrome finishes. Wheel

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-07-03 350000 EQUIPMENT

TSB: Some 2009 ? 2019 model year Toyota vehicles with super chrome wheel finishes may become discolored and/or damaged when aftermarket cleaners, polishes, or brake dust removal products are used on wheels with super chrome finishes. Wheel

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-07-01 100000 POWER TRAIN

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-07-01 110000 ELECTRICAL SYSTEM

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-07-01 060000 ENGINE (PWS)

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-08-09 162300 STRUCTURE:BODY:DOOR

Dealer Package: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2018 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right pow

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-08-01 162300 STRUCTURE:BODY:DOOR

Dealer Package: This Customer Confidence Program is a component of a class action settlement that includes 3 elements of coverage, including prospective coverage for repairs to certain sliding door parts but only those repairs that relate t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-08-01 022000 SUSPENSION:REAR

TSB: Some AWD 2014 – 2017 model year Sienna and 2016 – 2018 model year RAV4 customers may experience an abnormal noise from rear coupling unit while driving. This condition can be caused by utilizing an improper towing method when transport

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-04-30 353000 EQUIPMENT:ELECTRICAL

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. In some in

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-04-30 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. In some in

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-04-30 356000 EQUIPMENT ADAPTIVE/MOBILITY

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. In some in

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-03-01 162300 STRUCTURE:BODY:DOOR

Dealer Daily Message: Sienna Sliding Door Certain 2011 ? 2018 Model Year Sienna Vehicles ? A court has preliminarily approved a proposed settlement regarding sliding doors on certain 2011-2018 model year Sienna vehicles. ? The proposed sett

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Dealer Package: Certain 2011 ? 2018 Model Year Sienna Vehicles Coverage for the Power Sliding Door Cable Sub-Assembly (Vehicles equipped with power sliding doors ONLY). In our continuing efforts to ensure the best in customer satisfaction,

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Dealer Package: Certain 2011 ? 2018 Model Year Sienna Vehicles Coverage for the Power Sliding Door Cable Sub-Assembly (Vehicles equipped with power sliding doors ONLY). In our continuing efforts to ensure the best in customer satisfaction,

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 350000 EQUIPMENT

Dealer Package: Certain 2011 ? 2018 Model Year Sienna Vehicles Coverage for the Power Sliding Door Cable Sub-Assembly (Vehicles equipped with power sliding doors ONLY). In our continuing efforts to ensure the best in customer satisfaction,

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 350000 EQUIPMENT

Customer Support Program: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the fuel filler doo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 074000 FUEL/PROPULSION SYSTEM (PWS)

Customer Support Program: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the fuel filler doo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Dealer Package: Certain 2011 ? 2018 Model Year Sienna Vehicles Coverage for the Fuel Filler Door Hinge and Pin. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a class action settlement, Toyota is anno

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 350000 EQUIPMENT

Dealer Package: Certain 2011 ? 2018 Model Year Sienna Vehicles Coverage for the Fuel Filler Door Hinge and Pin. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a class action settlement, Toyota is anno

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Dealer Package: Certain 2011 ? 2018 Model Year Sienna Vehicles Coverage for the Sliding Door Center Hinge Assembly. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a class action settlement, Toyota is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Dealer Package: Certain 2011 ? 2018 Model Year Sienna Vehicles Coverage for the Sliding Door Center Hinge Assembly. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a class action settlement, Toyota is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Dealer Package: Certain 2011 ? 2018 Model Year Sienna Vehicles Coverage for the Sliding Door Center Hinge Assembly. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a class action settlement, Toyota is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162000 STRUCTURE:BODY

Dealer Package: Certain 2011 ? 2018 Model Year Sienna Vehicles Coverage for the Sliding Door Center Hinge Assembly. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a class action settlement, Toyota is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Dealer Package: Certain 2011 – 2018 Model Year Sienna Vehicles Sienna Sliding Door Functional Inspection. This Sienna Sliding Door Functional Inspection is one of multiple elements involved in a class action settlement. Refer to Customer Co

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Dealer Package: Certain 2011 – 2018 Model Year Sienna Vehicles Sienna Sliding Door Functional Inspection. This Sienna Sliding Door Functional Inspection is one of multiple elements involved in a class action settlement. Refer to Customer Co

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Dealer Package: Certain 2011 – 2018 Model Year Sienna Vehicles Coverage for Internal Functional Concerns of Certain Sliding Door Parts. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a Sienna sliding

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Dealer Package: Certain 2011 – 2018 Model Year Sienna Vehicles Coverage for Internal Functional Concerns of Certain Sliding Door Parts. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a Sienna sliding

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Dealer Package: Certain 2011 – 2018 Model Year Sienna Vehicles Coverage for Internal Functional Concerns of Certain Sliding Door Parts. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a Sienna sliding

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Dealer Package: Certain 2011 – 2018 Model Year Sienna Vehicles Coverage for Internal Functional Concerns of Certain Sliding Door Parts. In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a Sienna sliding

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Region Letter: Certain 2011 – 2018 Model Year Sienna Vehicles Coverage for Certain Internal Functional Concerns of Certain Sliding Door Parts. Specific information for Region support is provided below. In our continuing efforts to ensure th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Region Letter: Certain 2011 – 2018 Model Year Sienna Vehicles Coverage for Certain Internal Functional Concerns of Certain Sliding Door Parts. Specific information for Region support is provided below. In our continuing efforts to ensure th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Dealer Email: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a Sienna sliding door class action settlement, Toyota is announcing a Customer Confidence Program. The following information is provided to

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Dealer Email: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a Sienna sliding door class action settlement, Toyota is announcing a Customer Confidence Program. The following information is provided to

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Region Email: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a Sienna sliding door class action settlement, Toyota is announcing a Customer Confidence Program. The following information is provided to

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Region Email: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a Sienna sliding door class action settlement, Toyota is announcing a Customer Confidence Program. The following information is provided to

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

TSB: REVISION NOTICE June 19, 2019 Rev1: ? The Parts Information section has been updated. Any previous printed versions of this bulletin should be discarded. Some 2011 ? 2018 model year Sienna vehicles may exhibit a condition where the pow

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

TSB: REVISION NOTICE June 19, 2019 Rev1: ? The Parts Information section has been updated. Any previous printed versions of this bulletin should be discarded. Some 2011 ? 2018 model year Sienna vehicles may exhibit a condition where the pow

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

TSB: Some 2011 ? 2018 model year Sienna customers may express concern about their vehicle?s slide door performance. Upon customer request, the Inspection Procedure in this bulletin may be performed for a functional check of the slide door s

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 350000 EQUIPMENT

TSB: Some 2011 ? 2018 model year Sienna vehicles may exhibit a condition where the fuel lid door is loose or not flush against the vehicle body, which may prevent the driver side slide door from opening. This condition may be caused by a br

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 074000 FUEL/PROPULSION SYSTEM (PWS)

TSB: Some 2011 ? 2018 model year Sienna vehicles may exhibit a condition where the fuel lid door is loose or not flush against the vehicle body, which may prevent the driver side slide door from opening. This condition may be caused by a br

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

TSB: Some 2011 ? 2018 model year Sienna vehicles equipped with power slide doors may exhibit a condition where the slide door center hinge has corroded, causing the power slide door to not fully open or close during operation. Follow the In

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

TSB: Some 2011 ? 2018 model year Sienna vehicles equipped with power slide doors may exhibit a condition where the slide door center hinge has corroded, causing the power slide door to not fully open or close during operation. Follow the In

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

TSB: Some 2011 ? 2018 model year Sienna vehicles equipped with manual doors may exhibit a condition where the slide door center hinge has corroded, causing the slide door to become difficult to operate while opening or closing. Follow the I

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

TSB: Some 2011 ? 2018 model year Sienna vehicles equipped with manual doors may exhibit a condition where the slide door center hinge has corroded, causing the slide door to become difficult to operate while opening or closing. Follow the I

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 170000 LATCHES/LOCKS/LINKAGES

Customer Support Program: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011?2018 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 170000 LATCHES/LOCKS/LINKAGES

Dealer Package: June 19, 2019 Information about a proposed class action settlement has been added. ? Toyota has expanded the covered vehicle population. ? Toyota has extended the coverage period by one additional year. In our continuing eff

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 170000 LATCHES/LOCKS/LINKAGES

Customer Support Program: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011?2018 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sli

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 170000 LATCHES/LOCKS/LINKAGES

Dealer Package: June 19, 2019 Information about a proposed class action settlement has been added. ? Toyota has expanded the covered vehicle population. ? Toyota has extended the coverage period by one additional year. In our continuing eff

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-20 160000 STRUCTURE

Customer Support Program: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011?2018 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-20 162300 STRUCTURE:BODY:DOOR

Customer Support Program: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011?2018 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-20 170000 LATCHES/LOCKS/LINKAGES

Customer Support Program: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011?2018 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-20 160000 STRUCTURE

Customer Support Program: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the sliding door ce

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-20 162300 STRUCTURE:BODY:DOOR

Customer Support Program: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the sliding door ce

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-20 350000 EQUIPMENT

Customer Support Program: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the sliding door ce

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Customer Support Program: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the sliding door ce

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Customer Support Program: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the sliding door ce

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 350000 EQUIPMENT

Customer Support Program: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the sliding door ce

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 160000 STRUCTURE

Customer Program Support: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the power sliding d

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 162300 STRUCTURE:BODY:DOOR

Customer Program Support: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the power sliding d

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-06-19 350000 EQUIPMENT

Customer Program Support: In our continuing efforts to ensure the best in customer satisfaction, and pursuant to a proposed class action settlement, Toyota is announcing a Customer Support Program to provide coverage for the power sliding d

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2019-02-25 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TT: HVAC drain tube is found to be blocked/clogged.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-09-14 110000 ELECTRICAL SYSTEM

TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-12-07 350000 EQUIPMENT

TT: For customer concerns of no or poor outgoing sound from the Bluetooth systems there are diagnostics in the repair manual which can be performed to diagnose the condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-12-07 170000 LATCHES/LOCKS/LINKAGES

TT: Sliding Door will not latch in the closed position due to either front and/or rear lock malfunctioning. Please see link references of video for example condition and diagnosis instruction.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-12-01 350000 EQUIPMENT

TT: Some customers may experience poor outgoing Bluetooth sound quality, this can occur for various reasons. Current multimedia systems are designed with the ability to adjust Bluetooth sound quality to compensate for Echo or excessive back

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-12-01 350000 EQUIPMENT

TT: Since MY 2011, several different update or upgrade USB SST’s have been issued for Toyota audio and navigation system. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabili

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-12-02 220000 SEATS

TSB: December 2, 2015: This bulletin is now obsolete. Please see T-SB-0118-15.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-12-02 220000 SEATS

TSB: Some 2011 ? 2015 model year Sienna vehicles may exhibit a condition where the driver side 2nd row seat with the tip-up style lower seat cushion has excessive up and down movement. While some seat movement is a normal characteristic of

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-01-06 110000 ELECTRICAL SYSTEM

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-01-06 110000 ELECTRICAL SYSTEM

TSB: Some 2015 ? 2016 model year Sienna vehicles may exhibit a MIL ?ON? condition with Diagnostic Trouble Code (DTC) P2610 (ECM/PCM Engine Off Timer Performance) present. The Engine Control Module (ECM) logic has been modified to reduce the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-11-14 170000 LATCHES/LOCKS/LINKAGES

TSB: REVISION NOTICE November 14, 2018 Rev1: ? The Diagnosis Procedure and Repair Procedure sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2011 ? 2018 model year Sienna vehicles may exh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-09-14 060000 ENGINE (PWS)

TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-11-26 162300 STRUCTURE:BODY:DOOR

TSB: Some 2011 ? 2018 model year Sienna vehicles may exhibit a condition where the power sliding door cable becomes separated, causing the power sliding door to become inoperative. Follow the Repair Procedure in this bulletin to reduce this

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-07-06 350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0043-14. ? Applicability has been updated to include 2017 ? 2018 model year Toyota vehicles. Service Bulletin No. T-SB-0043-14 is obso

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-05-10 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The trail period of service is provided upon the vehicle purchase. Once the subscription has expired the DCM (Telematics Transceiver) will

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-05-10 030000 BRAKES (PWS)

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0045-14. * Applicability has been updated to include 2018 model year Sienna vehicles. * The entire bulletin has been updated. Service B

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-05-14 220000 SEATS

TT: Some vehicles may experience a condition in which the 2nd row seat, with center seat, exhibits a chirp/squeak noise from the rear seat latches (floor area). This condition is present while driving over rough or bumpy roads. Upon further

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-26 110000 ELECTRICAL SYSTEM

TSB: Some 2015 ? 2016 model year Avalon, Camry, Sienna, and Tundra vehicles equipped with Blind Spot Monitor may exhibit a Blind Spot Monitor Warning message with Diagnostic Trouble Code (DTC) C1AB2 Short to Ground in Outer Mirror Indicato

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-26 350000 EQUIPMENT

TSB: Some 2015 ? 2016 model year Avalon, Camry, Sienna, and Tundra vehicles equipped with Blind Spot Monitor may exhibit a Blind Spot Monitor Warning message with Diagnostic Trouble Code (DTC) C1AB2 Short to Ground in Outer Mirror Indicato

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-04 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: Some customers may experience Bluetooth connection issues after updating the Android Operating System to 5.x.x (Lollipop) or later.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-04 110000 ELECTRICAL SYSTEM

TSB: Some 2014 – 2016 Sienna vehicles may exhibit an intermittent cruise control stalk illumination flicker condition. Please follow the Repair Procedure in this bulletin to address this condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-04 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

TSB: Some 2014 – 2016 Sienna vehicles may exhibit an intermittent cruise control stalk illumination flicker condition. Please follow the Repair Procedure in this bulletin to address this condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-06-06 030000 BRAKES (PWS)

TSB: OBSOLETE NOTICE May 10, 2018: This bulletin is now obsolete. Please see T-SB-0033-18.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-19 160000 STRUCTURE

TSB: On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard?

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-19 356000 EQUIPMENT ADAPTIVE/MOBILITY

TSB: On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard?

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-09-05 220000 SEATS

Service Bulletin sent to all dealers to inspect L-track bolts for correct torque and to incorporate torque check as part of regular maintenance

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-07-21 350000 EQUIPMENT

Update on Technician Certification Requirements.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-07-21 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Update on Technician Certification Requirements.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-08-31 350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-08-31 355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-08-31 350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-08-31 355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-26 110000 ELECTRICAL SYSTEM

TSB: Some 2015 ? 2016 model year Avalon, Camry, Sienna, and Tundra vehicles equipped with Blind Spot Monitor may exhibit a Blind Spot Monitor Warning message with Diagnostic Trouble Code (DTC) C1AB2 Short to Ground in Outer Mirror Indicato

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-26 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: Some 2015 ? 2016 model year Avalon, Camry, Sienna, and Tundra vehicles equipped with Blind Spot Monitor may exhibit a Blind Spot Monitor Warning message with Diagnostic Trouble Code (DTC) C1AB2 Short to Ground in Outer Mirror Indicato

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-26 273000 LANE DEPARTURE: BLIND SPOT DETECTION

TSB: Some 2015 ? 2016 model year Avalon, Camry, Sienna, and Tundra vehicles equipped with Blind Spot Monitor may exhibit a Blind Spot Monitor Warning message with Diagnostic Trouble Code (DTC) C1AB2 Short to Ground in Outer Mirror Indicato

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-19 162000 STRUCTURE:BODY

TSB: On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard?

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-11 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TSB: Some 2014 model year applicable vehicles equipped with Entune? Audio (version 010169) / Entune? Audio Plus (version 010171) / Entune? Premium Audio (version 010185) may exhibit one or more of the following conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-11 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TSB: Some 2014 model year applicable vehicles equipped with Entune? Audio (version 010169) / Entune? Audio Plus (version 010171) / Entune? Premium Audio (version 010185) may exhibit one or more of the following conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-04-19 110000 ELECTRICAL SYSTEM

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has expired the DCM (Telematics Transceiver) wi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-04-19 350000 EQUIPMENT

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has expired the DCM (Telematics Transceiver) wi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-04-19 353000 EQUIPMENT:ELECTRICAL

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has expired the DCM (Telematics Transceiver) wi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-04-10 220000 SEATS

TSB: Some North American produced RAV4, Highlander, Highlander HV, and Sienna vehicles equipped with manual front seats may exhibit an inoperative forward/rearward adjustment function. Upon closer inspection it may be noticed that the Seat

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-04-10 350000 EQUIPMENT

TSB: Some North American produced RAV4, Highlander, Highlander HV, and Sienna vehicles equipped with manual front seats may exhibit an inoperative forward/rearward adjustment function. Upon closer inspection it may be noticed that the Seat

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-04-10 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TSB: Some 2011 ? 2016 model year Sienna vehicles may exhibit Sliding Door Front and Rear Latches simultaneously NOT latching due to the PSD 25 Amp fuse becoming open. APPLICABLE WARRANTY: This repair is covered under the Toyota Basic Warran

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-06-20 110000 ELECTRICAL SYSTEM

Warranty Policy Bulletin: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011?2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-06-20 170000 LATCHES/LOCKS/LINKAGES

Warranty Policy Bulletin: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011?2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-06-20 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Warranty Policy Bulletin: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011?2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sli

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-06 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-06 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-06 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-11-28 356000 EQUIPMENT ADAPTIVE/MOBILITY

TT: Some customers may experience poor outgoing Bluetooth sound quality, this can occur for various reasons. Current multimedia systems are designed with the ability to adjust Bluetooth sound quality to compensate for Echo or excessive back

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-11-28 350000 EQUIPMENT

TT: For customer concerns of no or poor outgoing sound from the Bluetooth systems there are diagnostics in the repair manual which can be performed to diagnose the condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-11-28 353000 EQUIPMENT:ELECTRICAL

TT: For customer concerns of no or poor outgoing sound from the Bluetooth systems there are diagnostics in the repair manual which can be performed to diagnose the condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-08-31 118000 ELECTRICAL SYSTEM:SOFTWARE

TechTip: Condition: Customers may experience connectivity issues when the following conditions are met: The customer?s iPhone is operating on iOS9 firmware The customer?s iPhone is connected to the vehicle via Bluetooth. If the veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-08-19 356000 EQUIPMENT ADAPTIVE/MOBILITY

TSB: 2015 ? 2016 model year vehicles are equipped with driver?s side floor mat retaining clips to secure the floor mat in the correct position. In addition, some models may utilize retaining clips for passenger side and rear seat floor ma

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-08-19 353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

TSB: Some 2015 – 2016 model year vehicles are equipped with a Smart Key system, which allows the customer to enter and start the vehicle without using a mechanical key. To ensure the system is operating properly, the Smart Key functions (Sm

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-22 110000 ELECTRICAL SYSTEM

TT: Some vehicles may exhibit an error message when trying to perform a radio software update: ?Unable to update the software. Please try again later.? If the following screen is seen; follow the directions below.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-22 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-06-23 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Publication discusses how to find the diagnostic information and component exchange information for the Southeast Toyota accessory overhead DVD player.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-08 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-06 110000 ELECTRICAL SYSTEM

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has lapsed the DCM will be in an inactive state

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-03-23 350000 EQUIPMENT

TSB: REVISION NOTICE March 23, 2017 Rev1: ? Applicability has been updated to include 2016 – 2017 model year Mirai vehicles. G1855ware Version Information charts and the Introduction have been updated. SUPERSESSION NOTICE: The informa

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-10-04 350000 EQUIPMENT

TT: Previously, an error message was received when performing DCM activation initiated by Techstream. This condition has been remedied, and DCM activation utilizing Techstream can now be resumed.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-03-04 222000 SEATS:MID/REAR ASSEMBLY

TSB: OBSOLETE NOTICE December 2, 2015: This bulletin is now obsolete. Please see T-SB-0118-15.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-10-25 203000 WHEELS:LUGS/NUTS/BOLTS

TT: Front Brake Vibration Key Points: * Issue can occur at any time if improper torque is applied on lug nuts * Over time, even one lug nut over or under torqued, can cause a vibration issue * When lug nuts are over torqued, this causes

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-10-03 110000 ELECTRICAL SYSTEM

TT: Some customers may experience Bluetooth disconnections or loss of SMS text message functionality on the navigation/audio system with Android phones running OS 4.4 or later. Condition tends to occur to customers who have many previous t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-08 353000 EQUIPMENT:ELECTRICAL

TT: An error message is received when performing DCM activation initiated by Techstream. This is a known condition and will be remedied in the near future. Please discontinue DCM activations utilizing Techstream until further notice.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Dealer Daily Message: Extension of Warranty Coverage for the Power Sliding Door Rear Lock Assemblies. The Dealer Letter for Warranty Enhancement Program ZH5 is now available on TIS.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Warranty Policy Bulletin: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/o

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Warranty Policy Bulletin: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/o

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Dealer Letter: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right pow

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Dealer Letter: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right pow

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Dealer Email: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right powe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Dealer Email: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right powe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Region Letter: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right pow

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Region Letter: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right pow

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Region Email: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right powe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Region Email: Toyota has received a number of reports regarding the power sliding door rear lock assemblies on certain 2011 ? 2015 model year Sienna vehicles. In these reports, corrosion on the position sensor of the left and/or right powe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Dealer Daily Message: Extension of Warranty Coverage for the Sliding Door Front Lock Assemblies. The Dealer Letter for Warranty Enhancement Program ZH4 is now available on TIS.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Dealer Daily Message: Extension of Warranty Coverage for the Sliding Door Front Lock Assemblies. The Dealer Letter for Warranty Enhancement Program ZH4 is now available on TIS.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Warranty Policy Bulletin: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Warranty Policy Bulletin: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Dealer Letter: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sliding do

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Dealer Letter: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sliding do

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Dealer Email: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sliding doo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Dealer Email: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sliding doo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Region Letter: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sliding do

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-03 162300 STRUCTURE:BODY:DOOR

Region Email: Toyota has received a number of reports regarding sliding door front lock assemblies on certain 2011 ? 2016 model year Sienna vehicles. In these reports, during the closing operation of the left and/or right side sliding doo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-02 162300 STRUCTURE:BODY:DOOR

TSB: Some 2011 ? 2016 model year Sienna vehicles may exhibit power or manual sliding door front and rear latches simultaneously NOT latching due to corrosion on the latch lever pin of the front lock assembly. Additionally, some 2011 ? 2015

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-08-02 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TSB: Some 2011 ? 2016 model year Sienna vehicles may exhibit power or manual sliding door front and rear latches simultaneously NOT latching due to corrosion on the latch lever pin of the front lock assembly. Additionally, some 2011 ? 2015

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-04-26 353000 EQUIPMENT:ELECTRICAL

TT: Some customers may experience Bluetooth connection issues after updating the Android Operating System to 5.x.x (Lollipop) or later.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-01-11 118000 ELECTRICAL SYSTEM:SOFTWARE

Tech Tip: Some customers may experience difficulty programming HomeLink.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-04-13 100000 POWER TRAIN

TSB: This bulletin includes basic procedures for inspecting and adjusting World Standard (WS) Automatic Transmission Fluid (ATF) level at normal vehicle operating temperature. Note: The following adjustment procedures are for U660E/F and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-15 118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-15 060000 ENGINE (PWS)

TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2012-09-20 222000 SEATS:MID/REAR ASSEMBLY

TSB: OBSOLETE NOTICE December 2, 2015: This bulletin is now obsolete. Please see T-SB-0118-15.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-01-12 110000 ELECTRICAL SYSTEM

Service Bulletin sent to all dealers to update the firmware in the affected vehicles VMI computer. This allows for more amperage to draw the Powerkneel up allowing the up-limit switch to be tripped consistently. If the up limit switch is no

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-11-22 110000 ELECTRICAL SYSTEM

TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-07-08 060000 ENGINE (PWS)

Tech Tip: Starting with the 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. There are multiple benefits of this oil including: Reduced friction and wear on engine surfaces, Improved fuel

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-03-08 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: REVISION NOTICE March 08, 2017 Rev1: ? Applicability has been updated to include 2015 – 2017 model year Toyota vehicles. ? The Parts Information section has been updated. Some vehicles in particular geographic areas may exhibit a c

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-03-07 162000 STRUCTURE:BODY

TSB: REVISION NOTICE March 07, 2017 Rev1: ? Applicability has been updated to include 2017 model year Toyota vehicles. On some vehicles, when Rapgard? is removed the paint may have a stained appearance. These stains appear to be under the c

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-07-25 353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-07-07 353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-07-29 110000 ELECTRICAL SYSTEM

Tech Tip: Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-07-29 130000 VISIBILITY

Tech Tip: Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-03-16 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Some vehicles may exhibit an error message when trying to perform a radio software update: “Unable to update the software. Please try again later.” If the following screen is seen, follow the directions below.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-03-16 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: Some vehicles may exhibit an error message when trying to perform a radio software update: “Unable to update the software. Please try again later.” If the following screen is seen, follow the directions below.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-07-07 135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

TSB: Some 2015 ? 2016 model year Avalon, Camry, Sienna, and Tundra vehicles equipped with Blind Spot Monitor may exhibit a Blind Spot Monitor Warning message with Diagnostic Trouble Code (DTC) C1AB2 Short to Ground in Outer Mirror Indicato

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-03-08 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicab

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-03-08 110000 ELECTRICAL SYSTEM

TT: Some customers may encounter Bluetooth connectivity concerns such as: ? Difficulty pairing the phone. ? Intermittent Bluetooth failure to connect when first turning on the vehicle. ? Various Bluetooth Audio functions are no lon

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-03-30 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

TSB: Some 2014 ? 2016 model year Sienna vehicles may exhibit an intermittent cruise control stalk illumination flicker condition. Please follow the Repair Procedure in this bulletin to address the condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-03-25 106200 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

TSB: Some 2015 ? 2016 model year Sienna vehicles may exhibit a grease leak where grease is coming through the boot clamp area on the big end of the outboard front axle shaft joint. Follow the Repair Procedure in this bulletin to address the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-02-25 118000 ELECTRICAL SYSTEM:SOFTWARE

Tech Tip: This Tech Tip is being provided to bring attention to the new location of the Entune/NAV/Map Update and Upgrade USB Directory. Click on the TIS tab, Diagnostics tab, Telematics tab, and the document is now located under the refer

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-06-12 118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bullet

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-08 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-06 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has lapsed the DCM will be in an inactive state

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-05-01 060000 ENGINE (PWS)

Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-05-01 280000 BACK OVER PREVENTION

Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-22 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Some vehicles may exhibit an error message when trying to perform a radio software update: ?Unable to update the software. Please try again later.? If the following screen is seen; follow the directions below.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-22 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: Some vehicles may exhibit an error message when trying to perform a radio software update: ?Unable to update the software. Please try again later.? If the following screen is seen; follow the directions below.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-22 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-11-10 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Some 2004 ? 2017 model year Toyota vehicles may exhibit odor

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-11-09 130000 VISIBILITY

TT: Some 2015-2017MY Sienna owners may have a concern with the inability of customizing their outer mirrors when shifting the vehicle to Reverse (?R? position). The owner?s manual describes the ability to customize the outer mirror positio

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-11-09 350000 EQUIPMENT

TT: Some 2015-2017MY Sienna owners may have a concern with the inability of customizing their outer mirrors when shifting the vehicle to Reverse (?R? position). The owner?s manual describes the ability to customize the outer mirror positio

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-10-24 353000 EQUIPMENT:ELECTRICAL

TT: Some vehicles may exhibit an error message when trying to perform a radio software update: “Unable to update the software. Please try again later.” If the following screen is seen; follow the directions below.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-10-24 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Some vehicles may exhibit an error message when trying to perform a radio software update: “Unable to update the software. Please try again later.” If the following screen is seen; follow the directions below.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-15 110000 ELECTRICAL SYSTEM

TT: iPhone text messages do not appear on multimedia dis[play.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-15 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: iPhone text messages do not appear on multimedia dis[play.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-13 110000 ELECTRICAL SYSTEM

Technical Instructions: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicl

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-13 060000 ENGINE (PWS)

Technical Instructions: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicl

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-14 110000 ELECTRICAL SYSTEM

Dealer Letter: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicle will il

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-14 060000 ENGINE (PWS)

Dealer Letter: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicle will il

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-14 110000 ELECTRICAL SYSTEM

Dealer email: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicle will ill

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-14 060000 ENGINE (PWS)

Dealer email: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicle will ill

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-13 110000 ELECTRICAL SYSTEM

Region Letter: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicle will il

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-13 060000 ENGINE (PWS)

Region Letter: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicle will il

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-13 110000 ELECTRICAL SYSTEM

Region email: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicle will ill

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-13 060000 ENGINE (PWS)

Region email: The subject vehicles are equipped with an Oxygen Sensor which could experience wire degradation inside the Oxygen Sensor wiring harness caused by vehicle vibration during normal operation. If this occurs, the vehicle will ill

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-21 353000 EQUIPMENT:ELECTRICAL

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-14 110000 ELECTRICAL SYSTEM

TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-14 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-09 110000 ELECTRICAL SYSTEM

TT: Multimedia systems reset procedure should be performed when the multimedia system no longer responds or reboots itself.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-11 118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: OBSOLETE NOTICE: This bulletin is now obsolete. Please see T-SB-0035-16.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-11-29 118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-02-02 350000 EQUIPMENT

TSB: The purpose of this Service Bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in Toyota vehicles. As an additional resource, if the vehicle is equipped with factory leather seats, the ve

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-02 162300 STRUCTURE:BODY:DOOR

TT: Sliding Door will not latch manually in the closed position due to either the front and or/rear lock malfunctioning. Please see link references of video for example condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-02 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

TT: Sliding Door will not latch manually in the closed position due to either the front and or/rear lock malfunctioning. Please see link references of video for example condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-04-17 356000 EQUIPMENT ADAPTIVE/MOBILITY

2015 model year vehicles are equipped with driver?s side floor mat retaining clips to secure the floor mat in the correct position. In addition, some models may utilize retaining clips for passenger side and rear seat floor mats as well. Fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-04-16 350000 EQUIPMENT

Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage condition

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-04-16 200000 WHEELS

During the manufacturing process tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires remain

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-04-15 116000 ELECTRICAL SYSTEM:IGNITION

Some 2015 model year vehicles are equipped with a Smart Key system, which allows the customer to enter and start the vehicle without using a mechanical key. To ensure the system is operating properly, the Smart Key functions (Smart Entry a

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-04-11 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

The radio antenna pole on some models is designed with a hex-cut base and requires installation using an 8 mm wrench. When performing PDS or installing the antenna pole for any other reason, inspect the antenna base for a hex-cut to determi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-02-28 353000 EQUIPMENT:ELECTRICAL

TT: Some customers may experience greyed out buttons or inactive screens (lockouts) while driving. This is to promote safe driving practices and reduce the amount of distractions while driving. These lockouts can?t be deactivated or defeat

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-02-12 190000 TIRES

TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-02-21 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: This bulletin is regarding best practices when handling navigation systems that use Hard Disc Drive or Micro SD Card memory.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-02-12 190000 TIRES

TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-01-11 350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-22 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: Some 2015 model year Sienna vehicles equipped with Dual Front Air Conditioning Systems may exhibit an intermittent buzzing noise condition coming from the center of the instrument panel during HVAC operation. The noise occurs during t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2018-01-12 110000 ELECTRICAL SYSTEM

Service Bulletin sent to all dealers to update the firmware in the affected vehicles VMI computer. This allows for more amperage to draw the Powerkneel up allowing the up-limit switch to be tripped consistently. If the up limit switch is no

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-11-01 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TT: Rev1_Some 2015-2017MY Sienna owners may have a concern with the inability of customizing their outer mirrors when shifting the vehicle to Reverse (?R? position). The owner?s manual describes the ability to customize the outer mirror pos

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-10-30 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-07-03 162300 STRUCTURE:BODY:DOOR

TSB: Some 2014 – 2017 model year Highlander/Highlander HV and 2011 – 2017 model year Sienna vehicles equipped with a Power Back Door (PBD) may exhibit a condition in which the back door latch does not release and the PBD cannot be opened fr

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-07-03 162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

TSB: Some 2014 – 2017 model year Highlander/Highlander HV and 2011 – 2017 model year Sienna vehicles equipped with a Power Back Door (PBD) may exhibit a condition in which the back door latch does not release and the PBD cannot be opened fr

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-10-27 162300 STRUCTURE:BODY:DOOR

TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-07-23 353000 EQUIPMENT:ELECTRICAL

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-25 020000 SUSPENSION

Dealer Letter: It has come to our attention that your dealership recently received ’15 Model Year Sienna (s) that may not have had the passenger seat Occupant Classification Sensors (OCS) properly calibrated during the assembly process. It

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-25 021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Dealer Letter: It has come to our attention that your dealership recently received ’15 Model Year Sienna (s) that may not have had the passenger seat Occupant Classification Sensors (OCS) properly calibrated during the assembly process. It

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-07-23 353000 EQUIPMENT:ELECTRICAL

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2017-09-18 220000 SEATS

TT: Some 2015-2017 Sienna vehicles with power or manual 3rd row seats, may experience a condition where the front leg/legs, may not latch correctly after being returned from the stowed position. The front leg/legs may be misaligned with the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-30 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-30 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-30 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-17 353000 EQUIPMENT:ELECTRICAL

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-17 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-17 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-07 353000 EQUIPMENT:ELECTRICAL

TT: Clock becomes inoperative, has dashes displayed, or cannot be adjusted.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-07 060000 ENGINE AND ENGINE COOLING

TT: Starting with 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil. Due to the them improved performance and durability of 0w-20 synthetic oil, To

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-13 353000 EQUIPMENT:ELECTRICAL

TSB: Entune Audio Head Unit Update

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-13 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TSB: Entune Audio Head Unit Update

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-10 110000 ELECTRICAL SYSTEM

TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-09 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-09 110000 ELECTRICAL SYSTEM

TT: MULTIMEDIA SYSTEMS RESET PROCEDURE SHOULD BE PERFORMED WHEN THE MULTIMEDIA SYSTEM NO LONGER RESPONDS OR REBOOTS ITSELF.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-09 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: MULTIMEDIA SYSTEMS RESET PROCEDURE SHOULD BE PERFORMED WHEN THE MULTIMEDIA SYSTEM NO LONGER RESPONDS OR REBOOTS ITSELF.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-19 110000 ELECTRICAL SYSTEM

TSB: While a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. Batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-19 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: While a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. Batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-13 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-15 200000 WHEELS

TSB: During the manufacturing process tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-15 210000 TRAILER HITCHES

TSB: During the manufacturing process tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-15 354000 EQUIPMENT:MECHANICAL

TSB: During the manufacturing process tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. If the wheels are replaced or refinished before vehicle delivery, it is important that the tires

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-02 353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-02 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-10 162000 STRUCTURE:BODY

TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-06 353000 EQUIPMENT:ELECTRICAL

TSB: Some 2015 model year Sienna vehicles equipped with the Intuitive Parking Assist system may exhibit a condition where the Parking Assist customizable settings cannot be changed through the radio display. An updated Clearance Warning Com

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-06 280000 BACK OVER PREVENTION

TSB: Some 2015 model year Sienna vehicles equipped with the Intuitive Parking Assist system may exhibit a condition where the Parking Assist customizable settings cannot be changed through the radio display. An updated Clearance Warning Com

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-12 353000 EQUIPMENT:ELECTRICAL

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-12 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-12 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-15 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Tech Tip: Some customers may experience Bluetooth disconnections or loss of SMS Text Message Functionality on the navigation/audio system with Android phones running OS 4.4 or later. Condition tends to occur to customers who have many previ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-15 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Tech Tip: Some customers may experience Bluetooth disconnections or loss of SMS Text Message Functionality on the navigation/audio system with Android phones running OS 4.4 or later. Condition tends to occur to customers who have many previ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-15 118000 ELECTRICAL SYSTEM:SOFTWARE

Tech Tip: Some customers may experience Bluetooth disconnections or loss of SMS Text Message Functionality on the navigation/audio system with Android phones running OS 4.4 or later. Condition tends to occur to customers who have many previ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-13 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-13 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-13 118000 ELECTRICAL SYSTEM:SOFTWARE

Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-13 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TSB: Entune Audio Head Unit Update

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-10 110000 ELECTRICAL SYSTEM

TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-10 353000 EQUIPMENT:ELECTRICAL

TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-09 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-19 110000 ELECTRICAL SYSTEM

TSB: While a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. Batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-19 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: While a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. Batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-05-13 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-30 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-30 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-30 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-17 353000 EQUIPMENT:ELECTRICAL

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-17 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-17 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-07 353000 EQUIPMENT:ELECTRICAL

TT: Clock becomes inoperative, has dashes displayed, or cannot be adjusted.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-02 353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-02 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-02 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-12 353000 EQUIPMENT:ELECTRICAL

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-12 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-12 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-12 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-10 162000 STRUCTURE:BODY

TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-06 353000 EQUIPMENT:ELECTRICAL

TSB: Some 2015 model year Sienna vehicles equipped with the Intuitive Parking Assist system may exhibit a condition where the Parking Assist customizable settings cannot be changed through the radio display. An updated Clearance Warning Com

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-06 118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: Some 2015 model year Sienna vehicles equipped with the Intuitive Parking Assist system may exhibit a condition where the Parking Assist customizable settings cannot be changed through the radio display. An updated Clearance Warning Com

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-16 100000 POWER TRAIN

TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-16 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-16 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-16 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-16 103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-04-07 060000 ENGINE AND ENGINE COOLING

TT: Starting with 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil. Due to the them improved performance and durability of 0w-20 synthetic oil, To

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-08-28 220000 SEATS

TSB: The 2015 model year Sienna may be optionally equipped with an Auto Access Seat that can be rotated, raised, and lowered to help the occupant easily enter and exit the vehicle. To ensure that the Auto Access Seat system is operating pro

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-03 110000 ELECTRICAL SYSTEM

TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-03 160000 STRUCTURE

TSB: Pre-Delivery Service (PDS) is a critical step in satisfying our new car customers. Customer feedback indicates the following areas deserve special attention when performing PDS: ? Careful inspection for paint chips/scratches and body

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-03 350000 EQUIPMENT

TSB: Sienna 2015 Pre-Delivery Check Sheet

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-03 010000 STEERING

TSB: As a result of the removal of the Short Pin, the power source to the steering angle sensor is cut off. When the Short Pin is reinstalled, the Parking Assist Monitor System will be operative, but it cannot display guidelines to assist p

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-03 353000 EQUIPMENT:ELECTRICAL

TSB: As a result of the removal of the Short Pin, the power source to the steering angle sensor is cut off. When the Short Pin is reinstalled, the Parking Assist Monitor System will be operative, but it cannot display guidelines to assist p

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-06-17 353000 EQUIPMENT:ELECTRICAL

TT: iPhone text messages do not appear on multimedia display.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-06-17 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: iPhone text messages do not appear on multimedia display.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-10-13 353000 EQUIPMENT:ELECTRICAL

TT: Some customers may experience Bluetooth disconnections or loss of SMS Text Message Functionality on the navigation/audio system with Android phones running OS 4.4 or later. Condition tends to occur to customers who have many previous te

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-10-13 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Some customers may experience Bluetooth disconnections or loss of SMS Text Message Functionality on the navigation/audio system with Android phones running OS 4.4 or later. Condition tends to occur to customers who have many previous te

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-10-13 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Some customers may experience Bluetooth disconnections or loss of SMS Text Message Functionality on the navigation/audio system with Android phones running OS 4.4 or later. Condition tends to occur to customers who have many previous te

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-10-15 350000 EQUIPMENT

TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. The following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage co

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-06-17 353000 EQUIPMENT:ELECTRICAL

TT: iPhone text messages do not appear on multimedia display.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-06-17 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: iPhone text messages do not appear on multimedia display.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-06-17 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: iPhone text messages do not appear on multimedia display.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-30 350000 EQUIPMENT

THIS SB NOTIFIES THE TECHNICIANS OF THE AVAILABILITY OF AN UPGRADED DOOR OPEN LIMIT SWITCH. IT’S MORE ROBUST DESIGN MAKES IT EASIER TO ADJUST AND HOLDS THE ADJUSTMENT IN PLACE REDUCING OR ELIMINATING INCORRECT SIGNALLING TO THE VMI AND OEM

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-04-11 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-22 060000 ENGINE AND ENGINE COOLING

TSB: SOME 2015 MODEL YEAR SIENNA VEHICLES EQUIPPED WITH DUAL FRONT AIR CONDITIONING SYSTEMS MAY EXHIBIT AN INTERMITTENT BUZZING NOISE CONDITION COMING FROM THE CENTER OF THE INSTRUMENT PANEL DURING HVAC OPERATION. THE NOISE OCCURS DURING T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-22 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: SOME 2015 MODEL YEAR SIENNA VEHICLES EQUIPPED WITH DUAL FRONT AIR CONDITIONING SYSTEMS MAY EXHIBIT AN INTERMITTENT BUZZING NOISE CONDITION COMING FROM THE CENTER OF THE INSTRUMENT PANEL DURING HVAC OPERATION. THE NOISE OCCURS DURING T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-15 350000 EQUIPMENT

TT: IPHONE TEXT MESSAGES DO NOT APPEAR ON MULTIMEDIA DIS[PLAY.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-02-25 350000 EQUIPMENT

TECH TIP: THIS TECH TIP IS BEING PROVIDED TO BRING ATTENTION TO THE NEW LOCATION OF THE ENTUNE/NAV/MAP UPDATE AND UPGRADE USB DIRECTORY. CLICK ON THE TIS TAB, DIAGNOSTICS TAB, TELEMATICS TAB, AND THE DOCUMENT IS NOW LOCATED UNDER THE REFE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-03-16 350000 EQUIPMENT

TT: SOME VEHICLES MAY EXHIBIT AN ERROR MESSAGE WHEN TRYING TO PERFORM A RADIO SOFTWARE UPDATE: “UNABLE TO UPDATE THE SOFTWARE. PLEASE TRY AGAIN LATER.” IF THE FOLLOWING SCREEN IS SEEN, FOLLOW THE DIRECTIONS BELOW.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-03-16 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: SOME VEHICLES MAY EXHIBIT AN ERROR MESSAGE WHEN TRYING TO PERFORM A RADIO SOFTWARE UPDATE: “UNABLE TO UPDATE THE SOFTWARE. PLEASE TRY AGAIN LATER.” IF THE FOLLOWING SCREEN IS SEEN, FOLLOW THE DIRECTIONS BELOW.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-03-08 350000 EQUIPMENT

TT: SINCE MY 2011, SEVERAL DIFFERENT UPDATE OR UPGRADE USB SSTS HAVE BEEN ISSUED FOR TOYOTA AUDIO AND NAVIGATION SYSTEMS. REFER TO THE CHART BELOW FOR A COMPREHENSIVE LIST OF ALL CURRENT AND PREVIOUSLY ISSUED USB SSTS AND THEIR APPLICA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-30 100000 POWER TRAIN

TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-30 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-08 020000 SUSPENSION

TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Flat towing or towing where only the front or rear wheels are supported may damage the all-whee

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-10-08 200000 WHEELS

TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Flat towing or towing where only the front or rear wheels are supported may damage the all-whee

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-01 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-03 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-09-03 350000 EQUIPMENT

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-08-28 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-02 162300 STRUCTURE:BODY:DOOR

TT: SLIDING DOOR WILL NOT LATCH MANUALLY IN THE CLOSED POSITION DUE TO EITHER THE FRONT AND OR/REAR LOCK MALFUNCTIONING. PLEASE SEE LINK REFERENCES OF VIDEO FOR EXAMPLE CONDITION.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-02 170000 LATCHES/LOCKS/LINKAGES

TT: SLIDING DOOR WILL NOT LATCH MANUALLY IN THE CLOSED POSITION DUE TO EITHER THE FRONT AND OR/REAR LOCK MALFUNCTIONING. PLEASE SEE LINK REFERENCES OF VIDEO FOR EXAMPLE CONDITION.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2014-11-26 350000 EQUIPMENT

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-06 118000 ELECTRICAL SYSTEM:SOFTWARE

TOYOTA SIENNA 2015: INFORMATION REGARDING PARKING ASSIST CUSTOMIZABLE SETTINGS NOT CHANGING THROUGH RADIO DISPLAY. *LJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-07-20 350000 EQUIPMENT

TECHNICAL INSTRUCTIONS: THE SUBJECT VEHICLES ARE EQUIPPED WITH AN OXYGEN SENSOR WHICH COULD EXPERIENCE WIRE DEGRADATION INSIDE THE OXYGEN SENSOR WIRING HARNESS CAUSED BY VEHICLE VIBRATION DURING NORMAL OPERATION. IF THIS OCCURS, THE VEHICL

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-02-06 350000 EQUIPMENT

TOYOTA: SOME VEHICLES NEED UPDATED CLEARANCE WARNING COMPUTER TO RESOLVE PARKING ASSIST CUSTOMIZE SETTINGS THAT WILL NOT BE CHANGED THROUGH DISPLAY OF RADIO. MODEL 2015 SIENNA. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-12-01 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: SINCE MY 2011, SEVERAL DIFFERENT UPDATE OR UPGRADE USB SST’S HAVE BEEN ISSUED FOR TOYOTA AUDIO AND NAVIGATION SYSTEM. REFER TO THE CHART BELOW FOR A COMPREHENSIVE LIST OF ALL CURRENT AND PREVIOUSLY ISSUED USB SSTS AND THEIR APPLICABIL

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-12-02 222000 SEATS:MID/REAR ASSEMBLY

TSB: DECEMBER 2, 2015: THIS BULLETIN IS NOW OBSOLETE. PLEASE SEE T-SB-0118-15.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-04 180000 VEHICLE SPEED CONTROL

TSB: SOME 2014 – 2016 SIENNA VEHICLES MAY EXHIBIT AN INTERMITTENT CRUISE CONTROL STALK ILLUMINATION FLICKER CONDITION. PLEASE FOLLOW THE REPAIR PROCEDURE IN THIS BULLETIN TO ADDRESS THIS CONDITION.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-04 350000 EQUIPMENT

TSB: SOME 2014 – 2016 SIENNA VEHICLES MAY EXHIBIT AN INTERMITTENT CRUISE CONTROL STALK ILLUMINATION FLICKER CONDITION. PLEASE FOLLOW THE REPAIR PROCEDURE IN THIS BULLETIN TO ADDRESS THIS CONDITION.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-14 350000 EQUIPMENT

TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-14 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-13 060000 ENGINE (PWS)

TECHNICAL INSTRUCTIONS: THE SUBJECT VEHICLES ARE EQUIPPED WITH AN OXYGEN SENSOR WHICH COULD EXPERIENCE WIRE DEGRADATION INSIDE THE OXYGEN SENSOR WIRING HARNESS CAUSED BY VEHICLE VIBRATION DURING NORMAL OPERATION. IF THIS OCCURS, THE VEHICL

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-11 110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE: THIS BULLETIN IS NOW OBSOLETE. PLEASE SEE T-SB-0035-16.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-05-11 350000 EQUIPMENT

TSB: OBSOLETE NOTICE: THIS BULLETIN IS NOW OBSOLETE. PLEASE SEE T-SB-0035-16.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-01-11 350000 EQUIPMENT

TECH TIP: SOME CUSTOMERS MAY EXPERIENCE DIFFICULTY PROGRAMMING HOMELINK.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-21 350000 EQUIPMENT

TT: SINCE MY 2011, SEVERAL DIFFERENT UPDATE OR UPGRADE USB SSTS HAVE BEEN ISSUED FOR TOYOTA AUDIO AND NAVIGATION SYSTEMS. REFER TO THE CHART BELOW FOR A COMPREHENSIVE LIST OF ALL CURRENT AND PREVIOUSLY ISSUED USB SSTS AND THEIR APPLICABILIT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-21 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: SINCE MY 2011, SEVERAL DIFFERENT UPDATE OR UPGRADE USB SSTS HAVE BEEN ISSUED FOR TOYOTA AUDIO AND NAVIGATION SYSTEMS. REFER TO THE CHART BELOW FOR A COMPREHENSIVE LIST OF ALL CURRENT AND PREVIOUSLY ISSUED USB SSTS AND THEIR APPLICABILIT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-07-20 110000 ELECTRICAL SYSTEM

TECHNICAL INSTRUCTIONS: THE SUBJECT VEHICLES ARE EQUIPPED WITH AN OXYGEN SENSOR WHICH COULD EXPERIENCE WIRE DEGRADATION INSIDE THE OXYGEN SENSOR WIRING HARNESS CAUSED BY VEHICLE VIBRATION DURING NORMAL OPERATION. IF THIS OCCURS, THE VEHICL

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-07-20 060000 ENGINE (PWS)

TECHNICAL INSTRUCTIONS: THE SUBJECT VEHICLES ARE EQUIPPED WITH AN OXYGEN SENSOR WHICH COULD EXPERIENCE WIRE DEGRADATION INSIDE THE OXYGEN SENSOR WIRING HARNESS CAUSED BY VEHICLE VIBRATION DURING NORMAL OPERATION. IF THIS OCCURS, THE VEHICL

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-01-15 060000 ENGINE (PWS)

TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. THIS BUL

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2016-06-30 162300 STRUCTURE:BODY:DOOR

THIS SB NOTIFIES THE TECHNICIANS OF THE AVAILABILITY OF AN UPGRADED DOOR OPEN LIMIT SWITCH. IT’S MORE ROBUST DESIGN MAKES IT EASIER TO ADJUST AND HOLDS THE ADJUSTMENT IN PLACE REDUCING OR ELIMINATING INCORRECT SIGNALLING TO THE VMI AND OEM

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015-09-15 190000 TIRES

TSB: DURING THE MANUFACTURING PROCESS TIRES ARE MOUNTED ON THE VEHICLE AS MATCHED SETS TO HELP REDUCE CONDITIONS SUCH AS PULLING OR DRIFTING. IF THE WHEELS ARE REPLACED OR REFINISHED BEFORE VEHICLE DELIVERY, IT IS IMPORTANT THAT THE TIRE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2015 TOYOTA Sienna

search for another vehicle