2009 VOLKSWAGEN Golf Recalls, Complaints and Investigations

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

0 Recalls for 2009 VOLKSWAGEN Golf

Recall Date	Component	Summary

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

0 Complaints sent to the Center for Auto Safety for 2009 VOLKSWAGEN Golf

skip to NHTSA complaints

Date			Component

3 Complaints submitted to NHTSA for 2009 VOLKSWAGEN Golf

skip to CAS complaints

Date			Component
2017-05-05			SERVICE BRAKES ODI Number: 10983768
2018-08-03			ELECTRICAL SYSTEM \| ENGINE ODI Number: 11115555
2016-07-01			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES ODI Number: 10882059

Is the government investigating the safety of your vehicle? Find out here.

1 Investigations for 2009 VOLKSWAGEN Golf

By letter dated october 3, 2011, volkswagen group of america, inc. (vw) notified the national highway traffic safety administration (nhtsa) that it will conduct a safety recall to address a defect in approximately 168,275 model year (my) 2009-2012 volkswagen jetta, jetta sportwagen, golf, and audi a3 vehicles equipped with the 2.0l tdi common rail clean diesel engine (nhtsa recall no. 11v-490).the recalled jetta and jetta sportwagen vehicles were built from may 2008 through september 2011, the golf vehicles were built from may 2009 through september 2011, and the audi a3 vehicles were built from september 2009 through september 2011.according to volkswagen, in u.s. applications of the above cited tdi vehicles including engine codes cjaa and cbea, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and rpm conditions.this resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.as a contributing factor, vw indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.lines manufactured in these periods were installed in vehicles produced in the following 10 months:december 2008, january-february 2009, october 2009, march-april 2010 and september-december 2010.injector lines using this material exhibit a significantly higher failure rate.dealers will replace injector line #2 in all vehicles built in these months.in addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.analysis of nhtsa complaints, vw complaints, vw field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.the leaking line was not identified in 62 of the vehicles.for the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by vw, which accounted for approximately one-quarter of the recalled vehicles.the failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (iptv).the failure rate for injector line #2 in other production months of recalled vehicles is 0.8 iptv.the leak/repair rates for the other injector lines are all well under 1 iptv.the action taken by volkswagen is sufficient to resolve the issues raised by this investigation. the agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. accordingly, this investigation is closed.

Date Opened	Date Closed	Component
2011-08-02	2011-12-02	FUEL SYSTEM, DIESEL

Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

604 Service Alerts for 2009 VOLKSWAGEN Golf

Date	Description
2022-06-28	060000 ENGINE AND ENGINE COOLING Engine Oil Quality Standards updated to include model year 2023 and the latest Engine Oil attachments. (excludes Routan & ID.4) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-28	060000 ENGINE AND ENGINE COOLING Engine oil consumption measurement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-15	070000 FUEL SYSTEM, GASOLINE Gasoline quality. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-08	980000 UNKNOWN OR OTHER Battery Testing and Charging using VAS6161 and or GRX3000VAS Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-08	119100 ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY Battery Testing and Charging using VAS6161 and or GRX3000VAS Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-15	060000 ENGINE AND ENGINE COOLING Engine misfire diagnostic aid. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL VW engine oil specifications. Update to model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-15	980000 UNKNOWN OR OTHER VW engine oil specifications. Update to model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-14	060000 ENGINE AND ENGINE COOLING Recommended fuel additive to avoid engine misfires. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-14	100000 POWER TRAIN Auto Trans fluid requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-25	160000 STRUCTURE Technical Bulletins. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-25	350000 EQUIPMENT Technical Bulletins. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-15	350000 EQUIPMENT This special notice is to inform dealers to return the parts listed if it meets the criteria provided. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-06	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL VW engine oil specifications. Update to attachments. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-06	980000 UNKNOWN OR OTHER VW engine oil specifications. Update to attachments. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-22	980000 UNKNOWN OR OTHER Software Version Management (SVM) instruction. Update to require 70amp minimum battery charger during procedure. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-06-22	119111 ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM):SOFTWARE Software Version Management (SVM) instruction. Update to require 70amp minimum battery charger during procedure. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-22	140000 AIR BAGS Airbag Issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-05-26	060000 ENGINE AND ENGINE COOLING Engine oil pressure priming. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-05-26	060000 ENGINE (PWS) Engine oil pressure priming. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-19	200000 WHEELS Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-05-18	138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and cost of cleaning solution in warranty table. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-05-16	110000 ELECTRICAL SYSTEM Battery Testing and Charging using recommended VW test equipment. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-05-12	110000 ELECTRICAL SYSTEM Battery Tester VAS 6161 introduction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-15	350000 EQUIPMENT Part ordering Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-26	060000 ENGINE AND ENGINE COOLING Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-14	060000 ENGINE AND ENGINE COOLING Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blind spot monitoring error in MFI Customer states blower stays on Cu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-14	353000 EQUIPMENT:ELECTRICAL Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blind spot monitoring error in MFI Customer states blower stays on Cu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-14	030000 BRAKES (PWS) Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blind spot monitoring error in MFI Customer states blower stays on Cu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-14	118420 ELECTRICAL SYSTEM:ADAS:BLINDSPOT:SENSORS Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blind spot monitoring error in MFI Customer states blower stays on Cu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-12	060000 ENGINE AND ENGINE COOLING Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blind spot monitoring error in MFI Customer states blower stays on Cu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-12	220000 SEATS Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blind spot monitoring error in MFI Customer states blower stays on Cu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-12	030000 BRAKES (PWS) Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blind spot monitoring error in MFI Customer states blower stays on Cu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-12	118420 ELECTRICAL SYSTEM:ADAS:BLINDSPOT:SENSORS Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blind spot monitoring error in MFI Customer states blower stays on Cu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-07	060000 ENGINE AND ENGINE COOLING Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blower stays on Customer states cannot set seat memory Customer state Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-07	120000 EXTERIOR LIGHTING Exterior Lights, Moisture Accumulation. Update model year applicability to include 2022. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-05	350000 EQUIPMENT This special notice is to inform dealers to return the parts listed if it meets the criteria provided. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-03	060000 ENGINE (PWS) Rattling noises from engine compartmen area or exhaust system. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-03	060000 ENGINE AND ENGINE COOLING Customer states rattle noise from the underbody heat shields Oil level sensor leaking Customer states front brake noise Customer states blower stays on Customer states cannot set seat memory Customer states cannot set seat memory Any Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-03	220000 SEATS Customer states rattle noise from the underbody heat shields Oil level sensor leaking Customer states front brake noise Customer states blower stays on Customer states cannot set seat memory Customer states cannot set seat memory Any Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-03	030000 BRAKES (PWS) Customer states rattle noise from the underbody heat shields Oil level sensor leaking Customer states front brake noise Customer states blower stays on Customer states cannot set seat memory Customer states cannot set seat memory Any Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-02	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY Discharged Battery, Diagnosis for excessive current draw. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-10	060000 ENGINE AND ENGINE COOLING Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blower stays on Customer states cannot set seat memory Customer state Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-10	220000 SEATS Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blower stays on Customer states cannot set seat memory Customer state Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-10	030000 BRAKES (PWS) Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states front brake noise Customer states blower stays on Customer states cannot set seat memory Customer state Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-14	060000 ENGINE AND ENGINE COOLING Engine oil consumption measurement. Update procedure and work sheet. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-22	060000 ENGINE AND ENGINE COOLING Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-29	060000 ENGINE AND ENGINE COOLING Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states MIL-on, fault P2422 stored in ECM Customer states front brake noise Customer states blower stays on Cus Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-29	100000 POWER TRAIN Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states MIL-on, fault P2422 stored in ECM Customer states front brake noise Customer states blower stays on Cus Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-29	110000 ELECTRICAL SYSTEM Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states MIL-on, fault P2422 stored in ECM Customer states front brake noise Customer states blower stays on Cus Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-29	160000 STRUCTURE Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states MIL-on, fault P2422 stored in ECM Customer states front brake noise Customer states blower stays on Cus Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-29	220000 SEATS Customer states rattle noise from the underbody heat shields Customer states coolant leak Oil level sensor leaking Customer states MIL-on, fault P2422 stored in ECM Customer states front brake noise Customer states blower stays on Cus Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-09-28	350000 EQUIPMENT Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-03-12	100000 POWER TRAIN DTC P2711 Implausible transmission shift sequence. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-02	103000 POWER TRAIN:AUTOMATIC TRANSMISSION On-Car Analysis List. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-02	060000 ENGINE (PWS) On-Car Analysis List. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-23	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM VW Elsa Newsletter. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-02-24	060000 ENGINE AND ENGINE COOLING Update model and model year applicability, introduce new coolant G12Evo. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-02-22	020000 SUSPENSION Customer states rattle noise from the underbody heat shields Oil level sensor leaking Customer states noise from front suspension Customer states blower stays on Customer states cannot set seat memory Customer states cannot set seat me Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-02-22	220000 SEATS Customer states rattle noise from the underbody heat shields Oil level sensor leaking Customer states noise from front suspension Customer states blower stays on Customer states cannot set seat memory Customer states cannot set seat me Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-02-22	061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION Customer states rattle noise from the underbody heat shields Oil level sensor leaking Customer states noise from front suspension Customer states blower stays on Customer states cannot set seat memory Customer states cannot set seat me Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-02-21	060000 ENGINE (PWS) Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-31	021000 SUSPENSION:FRONT Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-31	161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-31	980000 UNKNOWN OR OTHER Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-26	021000 SUSPENSION:FRONT Customer states MIL-on with P0087 P053F in the ECM Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-26	161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS Customer states MIL-on with P0087 P053F in the ECM Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-26	980000 UNKNOWN OR OTHER Customer states MIL-on with P0087 P053F in the ECM Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-26	061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM) Customer states MIL-on with P0087 P053F in the ECM Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-24	021000 SUSPENSION:FRONT Customer states MIL-on with P0087 P053F in the ECM Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-24	090000 FUEL SYSTEM, OTHER Customer states MIL-on with P0087 P053F in the ECM Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-24	161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS Customer states MIL-on with P0087 P053F in the ECM Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-24	980000 UNKNOWN OR OTHER Customer states MIL-on with P0087 P053F in the ECM Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states blower stays on Any TDI within the vehicle/MY range Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-18	110000 ELECTRICAL SYSTEM Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	110000 ELECTRICAL SYSTEM Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-21	060000 ENGINE AND ENGINE COOLING Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-21	350000 EQUIPMENT Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-21	060000 ENGINE (PWS) Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-10	110000 ELECTRICAL SYSTEM Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-03	110000 ELECTRICAL SYSTEM Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-15	020000 SUSPENSION Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-15	110000 ELECTRICAL SYSTEM Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-15	140000 AIR BAGS Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-15	061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM) Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-13	020000 SUSPENSION Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-13	110000 ELECTRICAL SYSTEM Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-13	140000 AIR BAGS Customer states MIL-on with P0087 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301, P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer stat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-06	110000 ELECTRICAL SYSTEM Battery testing using VW special tools, updated to include additional model year applicability and include I.D.4. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-13	060000 ENGINE AND ENGINE COOLING Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-01	060000 ENGINE AND ENGINE COOLING Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-15	118000 ELECTRICAL SYSTEM:SOFTWARE This bulletin contains general instructions for software updates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-12-03	353000 EQUIPMENT:ELECTRICAL Explanation of error message received from scan tool when erasing diagnostic trouble codes (DTCs) in Control Module -623- after repair. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-11-08	110000 ELECTRICAL SYSTEM Update to model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-01-14	350000 EQUIPMENT Body surfaces (engine compartment and underside of hood) are not directly visible (exposed) therefore do not match exterior paint finish. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-01-14	350000 EQUIPMENT Battery testing. Updated to include additional model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-10-28	060000 ENGINE (PWS) Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-11-17	162300 STRUCTURE:BODY:DOOR Update to include additional components in parts table. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-10-26	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Additional safety related Inquiry and Reporting instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-09-28	060000 ENGINE AND ENGINE COOLING Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-09-02	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update to model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-08-04	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER A/C Compressor replacement requirements, updated to include additional model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-07-28	350000 EQUIPMENT Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-07-28	061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-22	350000 EQUIPMENT Engine Misfire Diagnostic Aid. Updated to include additional model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-21	090000 FUEL SYSTEM, OTHER VW approved gasoline fuel additive, update to include additional models and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-21	060000 ENGINE (PWS) VW approved gasoline fuel additive, update to include additional models and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-22	070000 FUEL SYSTEM, GASOLINE Fuel Additive to Help Prevent Sporadic Misfire Faults Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-22	060000 ENGINE (PWS) Fuel Additive to Help Prevent Sporadic Misfire Faults Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-29	061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-21	118000 ELECTRICAL SYSTEM:SOFTWARE Software Version Management (SVM) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-22	061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION Engine oil consumption measurement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-03	061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-06-22	060000 ENGINE AND ENGINE COOLING Engine Misfire Diagnostic Aid. Updated to include additional model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-05-11	060000 ENGINE AND ENGINE COOLING Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-05-18	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Removing musty odor from A/C system. Updated to include additional model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-04-05	350000 EQUIPMENT Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-04-05	060000 ENGINE (PWS) Update engine oil quality standard lists (attachments) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-04-09	350000 EQUIPMENT Parts ordering information Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-04-30	350000 EQUIPMENT Elsa2Go campaign information is now 100% aligned with ElsaPro. This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-02	120000 EXTERIOR LIGHTING Exterior lighting moisture in lens updated to exclude LED lighting. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-01	070000 FUEL SYSTEM, GASOLINE VW approved gasoline fuel additive, update to include additional models and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-18	350000 EQUIPMENT Updated key ordering protocol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-18	356000 EQUIPMENT ADAPTIVE/MOBILITY Updated key ordering protocol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-02-22	350000 EQUIPMENT Update to brochure purchase url Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-02-19	350000 EQUIPMENT Update regeneration test plan instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-02-22	060000 ENGINE AND ENGINE COOLING Update to top tier brochure purchasing url. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-02-01	060000 ENGINE AND ENGINE COOLING Updated to include update recommended engine oil attachments. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-02-08	110000 ELECTRICAL SYSTEM Software Version Management (SVM) instruction updated to include model year 2021 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-11-05	060000 ENGINE AND ENGINE COOLING Oil consumption test updated to include additional models and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-11-04	162300 STRUCTURE:BODY:DOOR Update to model and model year applicability and remove WISE claiming information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-11-04	171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH Update to model and model year applicability and remove WISE claiming information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-11-05	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Oil consumption test updated to include additional models and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-11-04	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update to model and model year applicability and remove WISE claiming information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-18	110000 ELECTRICAL SYSTEM Updated key ordering protocol Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-18	350000 EQUIPMENT This special notice is to inform dealers to return the part numbers listed (State of California only). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-01-14	160000 STRUCTURE Body surfaces (engine compartment and underside of hood) are not directly visible (exposed) therefore do not match exterior paint finish. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-01-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Updated to include an additional model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-01-29	280100 BACK OVER PREVENTION:SOFTWARE Data link diagnostics and tips Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-01-26	042100 SERVICE BRAKES, AIR:SUPPLY:COMPRESSOR A/C requirements, update to title. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-01-14	110000 ELECTRICAL SYSTEM Battery testing. Updated to include additional model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-11-17	350000 EQUIPMENT Update to include additional components in parts table. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-10	355100 EQUIPMENT:OTHER:LABELS Recall Reminder Part Labels Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-01	060000 ENGINE AND ENGINE COOLING Cam screen damage. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-01	350000 EQUIPMENT Cam screen damage. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-25	110000 ELECTRICAL SYSTEM This document outlines updates to the ODIS diagnostic software. Updates include corrected diagnostic test plans for the stated vehicles. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-12	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Tool number added to table. Removal of Behr Flush Kit. VAS 6337/1A Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-15	070000 FUEL SYSTEM, GASOLINE Update brochure part number and recording URL. Update model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-02	350000 EQUIPMENT Update to include 2020-2021 model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-02	356000 EQUIPMENT ADAPTIVE/MOBILITY Update to include 2020-2021 model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-11	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Metadata update (add MY 2014 Eos (missing). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-21	353000 EQUIPMENT:ELECTRICAL Updated to include additional models and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-02	010000 STEERING Mandatory fastener. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-02	030000 BRAKES (PWS) Mandatory fastener. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-02	060000 ENGINE (PWS) Mandatory fastener. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-02	060000 ENGINE AND ENGINE COOLING Update to Volkswagen engine oil specification attachments. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-04	046000 SERVICE BRAKES, AIR:ANTILOCK Antilock brake function test direction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-04	350000 EQUIPMENT Antilock brake function test direction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-24	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Statement referring to TB 2043893 removed. To include additional models and model year applicability. A.C. Compressor Replacement, GFF Required Regardless of Concern and Flush Requirement Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-07	060000 ENGINE AND ENGINE COOLING Oil pressure priming after engine replacement or internal repair. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-06	350000 EQUIPMENT Tire Chain Information (for California dealers only) All Model Years. Information only for all other dealers. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-31	250000 ELECTRONIC STABILITY CONTROL Electronic Stabilization Program (ESP) function test may not end on its own causing DTC. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-25	350000 EQUIPMENT Antilock brake function test direction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-25	030000 BRAKES (PWS) Antilock brake function test direction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-13	060000 ENGINE (PWS) Update to regeneration instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-01-08	060000 ENGINE AND ENGINE COOLING Update to Volkswagen Identifying and mixing of coolant. Introducing new coolant type. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-01-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update to Volkswagen Identifying and mixing of coolant. Introducing new coolant type. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-05	110000 ELECTRICAL SYSTEM Update model applicability to MY 2020. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-05	350000 EQUIPMENT Update model applicability to MY 2020. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-11-15	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM Diganostic direction to locate exhaust leak Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-11-01	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM Nox regeneration information. Updated to correct the tech tip number in the title. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-29	350000 EQUIPMENT Update to Volkswagen engine oil standards. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-29	060000 ENGINE (PWS) Update to Volkswagen engine oil standards. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-22	980000 UNKNOWN OR OTHER The part number listed in the document is to be returned. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-11-04	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Update to mode; and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-11-08	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM Catalytic Converter Regeneration Scan Tool instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-03-10	350000 EQUIPMENT Volkswagen After Sales Weekly Communication – March 10, 2020 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-11-07	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Include new special tool adapter and 2018 model year Jetta only Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-11-25	060000 ENGINE AND ENGINE COOLING Update to Volkswagen engine oil standards. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-01-21	060000 ENGINE AND ENGINE COOLING Update to Volkswagen engine oil specification attachments. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-02-21	110000 ELECTRICAL SYSTEM ERP fault information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-31	980000 UNKNOWN OR OTHER The part number listed in the document is to be returned if it meets the criteria provided. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-01-09	060000 ENGINE AND ENGINE COOLING Update to Volkswagen Identifying and mixing of coolant. Introducing new coolant type. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-01-09	350000 EQUIPMENT Update to Volkswagen Identifying and mixing of coolant. Introducing new coolant type. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-19	060000 ENGINE (PWS) Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-09-10	350000 EQUIPMENT Include additional photo’s of water ingress. Also includes 2018-2020 Tiguan LWB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-13	350000 EQUIPMENT Remote Key Battery Replacement Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-13	353000 EQUIPMENT:ELECTRICAL Remote Key Battery Replacement Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-09-24	060000 ENGINE (PWS) Update to Volkswagen engine oil standards. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-28	350000 EQUIPMENT This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-20	100000 POWER TRAIN On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-20	110000 ELECTRICAL SYSTEM On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-03	100000 POWER TRAIN On-car analysis list from customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-03	110000 ELECTRICAL SYSTEM On-car analysis list from customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-19	110000 ELECTRICAL SYSTEM Update vehicle metadata for 2009 pull ahead. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-15	073100 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL Update vehicle metadata for 2009 pull ahead. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-15	092100 FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP Update vehicle metadata for 2009 pull ahead. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-04-24	060000 ENGINE AND ENGINE COOLING Update to labor operation numbers per Saga updates. Also applies to the 2006-2007 Beetle Convertible. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-04-24	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM Update to labor operation numbers per Saga updates. Also applies to the 2006-2007 Beetle Convertible. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-18	120000 EXTERIOR LIGHTING Condensation and or water droplets visible on inside of exterior light lenses. TB updated to include model year 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-12	070000 FUEL SYSTEM, GASOLINE Service Action Campaign (TDI Clean Diesel Engine Install Misfueling Guard): As diesel engine passenger vehicles become more popular, auto manufacturers have seen an increase in the number of misfueling cases where diesel engine vehicles a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-12	080000 FUEL SYSTEM, DIESEL Service Action Campaign (TDI Clean Diesel Engine Install Misfueling Guard): As diesel engine passenger vehicles become more popular, auto manufacturers have seen an increase in the number of misfueling cases where diesel engine vehicles a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-04-29	350000 EQUIPMENT Adhesive circular. Note: also includes 2004 Golf, Jetta, Passat, Touareg, GTI, Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-23	350000 EQUIPMENT TT 001202……..Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Update vehicle metadata. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	356000 EQUIPMENT ADAPTIVE/MOBILITY Update vehicle metadata. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Additional Safety Inquiry and Reporting instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	356000 EQUIPMENT ADAPTIVE/MOBILITY Additional Safety Inquiry and Reporting instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-15	350000 EQUIPMENT REMOVED all 12 hour wait period before starting references. ADDED EFB to “Select correct battery type” in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-21	350000 EQUIPMENT Quick Reference Update Guide. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	350000 EQUIPMENT Engine oils which meet Volkswagen oil quality standards. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	356000 EQUIPMENT ADAPTIVE/MOBILITY Engine oils which meet Volkswagen oil quality standards. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	060000 ENGINE (PWS) Engine oils which meet Volkswagen oil quality standards. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-11-03	100000 POWER TRAIN Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-19	110000 ELECTRICAL SYSTEM Battery Testing and Charging instruction. Updated to include model year 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update to TB to include model year 2018 & 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	356000 EQUIPMENT ADAPTIVE/MOBILITY Update to TB to include model year 2018 & 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	060000 ENGINE (PWS) Update to TB to include model year 2018 & 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-11-03	100000 POWER TRAIN Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-27	060000 ENGINE AND ENGINE COOLING Gasoline Engine Misfire Diagnosis document Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-22	350000 EQUIPMENT VAS 6154 Replacement Part Setup Guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-15	110000 ELECTRICAL SYSTEM Instrument cluster production mode solution, updated to include additional model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-11-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Update vehicle metadata. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-15	117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL Instrument cluster production mode solution, updated to include additional model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-11-29	350000 EQUIPMENT Update to TB to include model year 2018 & 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-11-29	356000 EQUIPMENT ADAPTIVE/MOBILITY Update to TB to include model year 2018 & 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-11-29	060000 ENGINE (PWS) Update to TB to include model year 2018 & 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY High Pressure Fuel Pump Diagnosis. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-11-13	060000 ENGINE (PWS) Engine oils which meet Volkswagen oil quality standards. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-22	110000 ELECTRICAL SYSTEM Alternative method for radio code retrieval. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-22	350000 EQUIPMENT Alternative method for radio code retrieval. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-11-26	140000 AIR BAGS Additional Safety Inquiry and Reporting instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-29	120000 EXTERIOR LIGHTING Adaptive front lighting descriptive Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-11-21	140000 AIR BAGS Additional Safety Inquiry and Reporting instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-03	350000 EQUIPMENT This document outlines updates to the diagnostic software (ODIS). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-03	118000 ELECTRICAL SYSTEM:SOFTWARE This document outlines updates to the diagnostic software (ODIS). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-11	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-11	356000 EQUIPMENT ADAPTIVE/MOBILITY Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-11	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-11	356000 EQUIPMENT ADAPTIVE/MOBILITY Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-27	350000 EQUIPMENT The part number listed in the document is to be returned if it meets the criteria provided. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-20	080000 FUEL SYSTEM, DIESEL This document informs dealers of a revision to the Extended Emissions Warranty Limited Warranty Extension for 2.0L TDI Gen 1 vehicles. Added clarification on totaled vehicles and loaners Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-15	073100 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL Update vehicle metadata for 2009 pull ahead. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-02	070000 FUEL SYSTEM, GASOLINE Updated to include an additional warranty claiming statement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-16	060000 ENGINE (PWS) Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-11-13	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Thei Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-29	110000 ELECTRICAL SYSTEM Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Additional Safety Inquiry and Reporting instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-06-12	356000 EQUIPMENT ADAPTIVE/MOBILITY Additional Safety Inquiry and Reporting instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-05-06	350000 EQUIPMENT Campaign Reminder Communication. Also includes: 1998-2004 Beetle, 2003-2004 Beetle Convertible, 2019 Beetle Convertible, 1994-2004 Eurovan, 1994-2004 Golf, 1994-2004 Jetta, 2001-2004 Jetta Wagon, 2018-2019 Tiguan LWB, 1994-2004 Passat, 1994 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-18	120000 EXTERIOR LIGHTING Condensation and/or water droplets visible on inside of exterior light lenses. TB updated to include model year 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-18	350000 EQUIPMENT Condensation and/or water droplets visible on inside of exterior light lenses. TB updated to include model year 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-31	060000 ENGINE AND ENGINE COOLING Valve spring diagnosis. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-31	350000 EQUIPMENT Valve spring diagnosis. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-31	356000 EQUIPMENT ADAPTIVE/MOBILITY Valve spring diagnosis. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-12	060000 ENGINE (PWS) Engine Oils Which Meet Volkswagen Oil Quality Standards Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-09	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-09	110000 ELECTRICAL SYSTEM On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-07	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-07	110000 ELECTRICAL SYSTEM On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-04	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-04	110000 ELECTRICAL SYSTEM On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-25	060000 ENGINE (PWS) Update brochure part number, literature ordering websie address and include an additional model year applicability Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-03	060000 ENGINE (PWS) Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-18	120000 EXTERIOR LIGHTING Condensation and or water droplets visible on inside of exterior light lenses. TB updated to include model year 2019 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-24	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-24	356000 EQUIPMENT ADAPTIVE/MOBILITY Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-25	356000 EQUIPMENT ADAPTIVE/MOBILITY Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-11	350000 EQUIPMENT VOLKSWAGEN DEALERSHIP COMMUNICATION (Revision to Service Action 20T8 ? Owner Supplements Install Misfueling Guard): This document informs the work procedure for Service Action 20T8 has been revised to include an owner supplement that must Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-15	350000 EQUIPMENT Tech Tips (All Models 2000-2014 – Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Spec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-14	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Updated to include model year 2014 thru 2018 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-15	100000 POWER TRAIN Update to model year applicability and existing tip for Dual clutch basic settings procedure. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-25	060000 ENGINE AND ENGINE COOLING Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-25	080000 FUEL SYSTEM, DIESEL Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-25	060000 ENGINE AND ENGINE COOLING Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the observations that need to be taken to service a water pump replacement Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-01	110000 ELECTRICAL SYSTEM Updates (RVU): This document informs of the reflashs that took place at specific updated software levels to address the complaints of various cars. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-17	110000 ELECTRICAL SYSTEM Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-17	060000 ENGINE (PWS) Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-26	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-22	060000 ENGINE AND ENGINE COOLING Update procedure to reset oxygen sensor adaptations, as a result of erratic test plan function. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-22	350000 EQUIPMENT Updated to address additional model years. Tip to reinforce dealer scan tool update importance in regards to 23Q3/24CV/23U3 campaign Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-22	356000 EQUIPMENT ADAPTIVE/MOBILITY Updated to address additional model years. Tip to reinforce dealer scan tool update importance in regards to 23Q3/24CV/23U3 campaign Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-29	355100 EQUIPMENT:OTHER:LABELS Tip demonstrating label information for clarity Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-29	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Tip demonstrating label information for clarity Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-15	100000 POWER TRAIN Update model year applicability and existing tip for transmission basic settings direction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-14	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY Updated to include model year 2014 thru 2018 applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-02	100000 POWER TRAIN On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-18	100000 POWER TRAIN Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/o Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-18	101000 POWER TRAIN:CLUTCH ASSEMBLY Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/o Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-18	103000 POWER TRAIN:AUTOMATIC TRANSMISSION Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/o Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-15	103000 POWER TRAIN:AUTOMATIC TRANSMISSION Update to model year applicability and existing tip for Dual clutch basic settings procedure. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-15	100000 POWER TRAIN Update model year applicability and existing tip for transmission basic settings direction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update model year applicability and existing tip for transmission basic settings direction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-22	060000 ENGINE (PWS) Update procedure to reset oxygen sensor adaptations, as a result of erratic test plan function. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-22	350000 EQUIPMENT Updated to address additional model years. Tip to reinforce dealer scan tool update importance in regards to 23Q3/24CV/23U3 campaign Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-08	110000 ELECTRICAL SYSTEM Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-08	350000 EQUIPMENT Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-02	103000 POWER TRAIN:AUTOMATIC TRANSMISSION On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-26	103000 POWER TRAIN:AUTOMATIC TRANSMISSION On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-16	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-10	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-09	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-24	160000 STRUCTURE Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-24	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-12-07	350000 EQUIPMENT Balance shaft direction for debris issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-12-07	060000 ENGINE (PWS) Balance shaft direction for debris issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update vehicle metadata for 2009 pull ahead. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-15	118000 ELECTRICAL SYSTEM:SOFTWARE Update vehicle metadata for 2009 pull ahead. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-07	103000 POWER TRAIN:AUTOMATIC TRANSMISSION On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-04	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-15	110000 ELECTRICAL SYSTEM Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-25	160000 STRUCTURE Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-25	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the observations that need to be taken to service a water pump replacement Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	110000 ELECTRICAL SYSTEM On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-16	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-16	110000 ELECTRICAL SYSTEM On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-10	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-10	110000 ELECTRICAL SYSTEM On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-29	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-18	100000 POWER TRAIN Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): Debris in the clutch assembly causing too much drag torque from the multiple clutch. DTC as described may cause shifting concerns and/o Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-03	060000 ENGINE AND ENGINE COOLING Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-29	355100 EQUIPMENT:OTHER:LABELS Tip demonstrating label information for clarity Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-29	100000 POWER TRAIN Technical Bulletin (Slave Cylinder – Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-29	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin (Slave Cylinder – Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-07	353000 EQUIPMENT:ELECTRICAL Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor operations Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-20	100000 POWER TRAIN On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-20	110000 ELECTRICAL SYSTEM On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-20	350000 EQUIPMENT On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-03	100000 POWER TRAIN On-car analysis list from customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-03	110000 ELECTRICAL SYSTEM On-car analysis list from customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-03	350000 EQUIPMENT On-car analysis list from customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-12	080000 FUEL SYSTEM, DIESEL Service Action Campaign (TDI Clean Diesel Engine Install Misfueling Guard): As diesel engine passenger vehicles become more popular, auto manufacturers have seen an increase in the number of misfueling cases where diesel engine vehicles a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-01	110000 ELECTRICAL SYSTEM Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-11-02	350000 EQUIPMENT Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-11-02	130000 VISIBILITY/WIPER (PWS) Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-11-13	350000 EQUIPMENT Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Thei Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-15	350000 EQUIPMENT Tech Tips (All Models 2000-2014 – Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Spec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-10	060000 ENGINE AND ENGINE COOLING Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition i Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-03	060000 ENGINE AND ENGINE COOLING Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Instrument cluster production mode solution, updated to include additional model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-15	117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL Instrument cluster production mode solution, updated to include additional model and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-25	350000 EQUIPMENT Update information regarding Top Tier brochure part number andVW literature ordering address Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-13	350000 EQUIPMENT Iinclude additional model year applicability and tool information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-13	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Iinclude additional model year applicability and tool information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-03	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-07	350000 EQUIPMENT Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor operations Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-11-02	136000 VISIBILITY:WINDSHIELD WIPER/WASHER Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence and factory defect. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-19	070000 FUEL SYSTEM, GASOLINE Update vehicle metadata for 2009 pull ahead. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-06-19	080000 FUEL SYSTEM, DIESEL Update vehicle metadata for 2009 pull ahead. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-29	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-25	080000 FUEL SYSTEM, DIESEL Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-25	060000 ENGINE (PWS) Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update brochure part number, literature ordering websie address and include an additional model year applicability Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-25	063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE Update information regarding Top Tier brochure part number andVW literature ordering address Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-09-13	350000 EQUIPMENT Iinclude additional model year applicability and tool information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-10	060000 ENGINE AND ENGINE COOLING Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition i Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-09-28	350000 EQUIPMENT Scan tool tip to address no identification of AW77 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-09-28	356000 EQUIPMENT ADAPTIVE/MOBILITY Scan tool tip to address no identification of AW77 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-09-28	061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER Incorrect removal of Turbocharger oil feed line may cause engine damage Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-09-28	061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER Incorrect removal of Turbocharger oil feed line may cause engine damage Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-09-28	072200 FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS Incorrect removal of Turbocharger oil feed line may cause engine damage Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-10-19	350000 EQUIPMENT Vacuum line inspection for specific DTCS. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-09-14	110000 ELECTRICAL SYSTEM Comfort/BCM Replacement direction, updated to include additional model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-13	118000 ELECTRICAL SYSTEM:SOFTWARE Update content and include additional models and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-01-11	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. Alternative method for radio code retrieval. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-09	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-24	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-29	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM On-car analysis list of Customer Complaints: Transmission Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-29	116000 ELECTRICAL SYSTEM:IGNITION On-car analysis list of Customer Complaints: Transmission Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-29	162300 STRUCTURE:BODY:DOOR On-car analysis list of Customer Complaints: Transmission Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-01	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Updates (RVU): This document informs of the reflashs that took place at specific updated software levels to address the complaints of various cars. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-01	118000 ELECTRICAL SYSTEM:SOFTWARE Updates (RVU): This document informs of the reflashs that took place at specific updated software levels to address the complaints of various cars. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-17	110000 ELECTRICAL SYSTEM Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-17	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-17	060000 ENGINE (PWS) Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-01	110000 ELECTRICAL SYSTEM Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-01	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-29	101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE) Technical Bulletin (Slave Cylinder – Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-29	356000 EQUIPMENT ADAPTIVE/MOBILITY Technical Bulletin (Slave Cylinder – Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-08	110000 ELECTRICAL SYSTEM Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-08	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-08	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-11	350000 EQUIPMENT VOLKSWAGEN DEALERSHIP COMMUNICATION (Revision to Service Action 20T8 ? Owner Supplements Install Misfueling Guard): This document informs the work procedure for Service Action 20T8 has been revised to include an owner supplement that must Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-03	100000 POWER TRAIN On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-15	100000 POWER TRAIN On-car analysis list of Customer Complaint: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-18	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM This special notice is to inform dealers to return all part numbers listed in the document. Only superseded part numbers to be ordered going forward. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-02	100000 POWER TRAIN On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-12	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-25	063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR This special notice is to inform dealers to return all part numbers listed in the document. Only superseded part numbers to be ordered going forward. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-16	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-14	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-22	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns(including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-06-06	110000 ELECTRICAL SYSTEM This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-13	118000 ELECTRICAL SYSTEM:SOFTWARE Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-05	060000 ENGINE AND ENGINE COOLING 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-10-31	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update model year applicability to include 2017. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-11-17	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Updated to include additional models and model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-11-10	118000 ELECTRICAL SYSTEM:SOFTWARE Tip for Scan tool concerns that may occur duing a test plan Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-05	092100 FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP UPDATED TECHNICAL BULLETIN TO ADD INJECTOR SEAL PLATE TO PARTS TABLE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-05	060000 ENGINE (PWS) UPDATED TECHNICAL BULLETIN TO ADD INJECTOR SEAL PLATE TO PARTS TABLE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-22	110000 ELECTRICAL SYSTEM Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-20	118000 ELECTRICAL SYSTEM:SOFTWARE Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-03	080000 FUEL SYSTEM, DIESEL VOLKSWAGEN DEALERSHIP COMMUNICATION: This document announced a warranty Volkswagen extension program to cover the High Pressure Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-03	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL VOLKSWAGEN DEALERSHIP COMMUNICATION: This document announced a warranty Volkswagen extension program to cover the High Pressure Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-02-01	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-27	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-14	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-12	118000 ELECTRICAL SYSTEM:SOFTWARE Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-07	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) Technical Bulletin (Implausible Transmission Shift Sequence Stored in the Transmission Control Module): This document informs of debris in the clutch assembly causing too much drag torque from the multiple clutch. The production solution Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-29	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-04-18	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-06	121000 EXTERIOR LIGHTING:HEADLIGHTS Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Updated to include additional model year and required documentation instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-10-20	060000 ENGINE (PWS) Updated to include additional model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-10-20	060000 ENGINE (PWS) Update to include additional model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-23	110000 ELECTRICAL SYSTEM Tech Tips (Engine Control Module Fault P130A ?Hide Cylinder?): This document informs that DTC P130A ?Hide Cylinder? indicates that excessive misfiring has occurred. As a result, the ECM has turned off a fuel injector to prevent catalyst da Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-10-20	110000 ELECTRICAL SYSTEM Update model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-06-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL To update claim processing statement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-04-04	118000 ELECTRICAL SYSTEM:SOFTWARE Tech Tips (MDI Functions with iPhone 5 Variants (5, 5c, 5s and iPad fourth generation, iPod Nano seventh generation)): The Apple iPhone 5, iPhone 5c, and iPhone 5s, as well as the iPad 4th generation and iPod Nano 7th generation use a prop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-04-10	350000 EQUIPMENT Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-04-29	118000 ELECTRICAL SYSTEM:SOFTWARE Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-23	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-01	060000 ENGINE AND ENGINE COOLING Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrica Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-18	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM Technical Bulletin Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis): Completing the GFF function test and performing a vacuum check on the Canister Purge Valve -N80- are essential to diagnose prop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-18	070000 FUEL SYSTEM, GASOLINE Update to expand fuel testing for lean DTCS. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-21	118000 ELECTRICAL SYSTEM:SOFTWARE Precautionary steps to Error Code ERP0203E when performing campaign 23U3. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update to existing tip for fuel quality checking. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-07	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update information regarding Top Tier brochure. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Tip to reinforce dealer scan tool update importance in regards to 24CV campaign. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-04	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM Tips to address specific DTCs that can result from an exhaust leak. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-10-28	350000 EQUIPMENT Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-16	160000 STRUCTURE Technical Bulletin (Damage on External Chrome or Aluminum Surfaces) The surfaces of chrome parts can get damaged in the production process or by external influences. This document discusses options for repairs covered under warranty, and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-30	110000 ELECTRICAL SYSTEM Technical Bulletin (Ignition Switch Faults Stored – Various Malfunctioning Comfort Functions): This document informs High resistance in the “S-contact” circuit of the ignition switch. The product solution to this issue was an Improved S Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-30	116000 ELECTRICAL SYSTEM:IGNITION Technical Bulletin (Ignition Switch Faults Stored – Various Malfunctioning Comfort Functions): This document informs High resistance in the “S-contact” circuit of the ignition switch. The product solution to this issue was an Improved S Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-31	110000 ELECTRICAL SYSTEM Technical Bulletin (Ignition Switch Faults Stored – Various Malfunctioning Comfort Functions): This document informs of High resistance in “S-contact circuit” of the ignition switch. The product solution for this issue was Improved S con Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-31	116000 ELECTRICAL SYSTEM:IGNITION Technical Bulletin (Ignition Switch Faults Stored – Various Malfunctioning Comfort Functions): This document informs of High resistance in “S-contact circuit” of the ignition switch. The product solution for this issue was Improved S con Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-22	350000 EQUIPMENT This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-22	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-04-13	080000 FUEL SYSTEM, DIESEL Update fuel sampling requirement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-21	060000 ENGINE (PWS) Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage. This document informs on the procedure to remove the engine cover. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-10-24	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Update to model year applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-06-15	131000 VISIBILITY:WINDSHIELD explaination of cross car distorion when looking through the windshield and how the “effect” in normal. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-07	136000 VISIBILITY:WINDSHIELD WIPER/WASHER Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence or a factory issue. This document informs what is under coverage for wiper blade issues. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-26	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM Tech Tips (Equipped with 2.0L TDI Engine – Engine Control Module Fault P2413 “Exhaust Gas Recirculation System Performance” Diagnosis Tip): When diagnosing ECM fault P2413 “Exhaust Gas Recirculation System Performance”, pressure test tur Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-22	118000 ELECTRICAL SYSTEM:SOFTWARE Technical Bulletin (Factory Installed Media-In (MDI), Updated Programming for Various iPod Concerns): The update programming procedure in this document addresses the following concerns: ? Music skips at beginning of track. This document Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-06-09	162800 STRUCTURE:BODY:HOOD Corrosion may be found on the folded edge of the hood. Supersedes TB V551603 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-17	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Golf Perfect Delivery Inspection (PDI) – Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purch Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-15	110000 ELECTRICAL SYSTEM Technical Bulletin (Bluetooth System Identification): This document informs how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Updated to include additional model year and required documentation instruction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-08-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Updated to include an additional diagnostic trouble code (P04F0) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-28	061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Thi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-14	070000 FUEL SYSTEM, GASOLINE Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document informs how to perform the di Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-02-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This technical bulletin was updated per powertain team and warranty team. Info from this bulletin is combined with TB 2031075 (V241208) and 2038161 (V241506) due to warranty extension claiming/processing confusion. (Basically 3 technical Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-02-17	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Instruction on what to do “if” a DTC remains or returns after campaign 45F2 is performed on the vehicle. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-02-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update Technical bulletin to include model year 2016 and 2017 models. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-13	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Golf Perfect Delivery Inspection (PDI) – Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purcha Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-03	080000 FUEL SYSTEM, DIESEL VOLKSWAGEN DEALERSHIP COMMUNICATION: Volkswagen announced a warranty extension program to cover the High Pressure Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-03	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL VOLKSWAGEN DEALERSHIP COMMUNICATION: Volkswagen announced a warranty extension program to cover the High Pressure Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-18	118000 ELECTRICAL SYSTEM:SOFTWARE Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-26	060000 ENGINE (PWS) Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-22	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-01	117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This in Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-22	060000 ENGINE (PWS) Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubricati Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-03-04	110000 ELECTRICAL SYSTEM Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-28	101000 POWER TRAIN:CLUTCH ASSEMBLY Technical Bulletin (Slave Cylinder – Clutch Pedal Operation Diagnosis): Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to prev Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-21	160000 STRUCTURE Technical Bulletin: Rear Quarter Panel Corrosion issues. This document has the Warranty documentation to inquire about coverage. It also has examples of instances calculating the services performed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-21	350000 EQUIPMENT Technical Bulletin: Rear Quarter Panel Corrosion issues. This document has the Warranty documentation to inquire about coverage. It also has examples of instances calculating the services performed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-27	118000 ELECTRICAL SYSTEM:SOFTWARE Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-07	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Tech Tips (Oxygen Sensor Reset Procedures): This document informs of the procedure to rest oxygen sensors -For 2009-2014 vehicles with engine codes CJAA or CBEA: -For 2012-2015 vehicles with engine codes CKRA, CVCA or CRUA: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-08-25	080000 FUEL SYSTEM, DIESEL Technical Bulletin (Fuel Rail/System Pressure, and Pressure Sensor issues): When diagnosing the Fuel Rail/System Pressure, and Pressure Sensor issue condition on a common rail diesel vehicle, if no root cause is found after checking all ot Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-24	080000 FUEL SYSTEM, DIESEL Technical Bulletin (No Start, or Rough Running issues): When diagnosing the condition(No Start, or Rough Running) on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-24	110000 ELECTRICAL SYSTEM Technical Bulletin (No Start, or Rough Running issues): When diagnosing the condition(No Start, or Rough Running) on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-20	061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS Tech Tips: Generator Charging Concern Diagnosis Tip – One Way Clutch Pulley Testing Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-08	110000 ELECTRICAL SYSTEM Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-08	132000 VISIBILITY:GLASS, SIDE/REAR Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-08	133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-06	110000 ELECTRICAL SYSTEM Tech Tips: Vehicles with Immobilizer with Download/Discharge? New Key Will Not Program Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-06	356000 EQUIPMENT ADAPTIVE/MOBILITY Tech Tips: Vehicles with Immobilizer with Download/Discharge? New Key Will Not Program Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-03-12	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-26	134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY Technical Bulletin (Sunroof or Power Sunshade, Does Not Open/Close or Automatic Operation Does Not Function). This document contains Warranty information for coverage, and informs of methods to to service the issue Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-03-11	356000 EQUIPMENT ADAPTIVE/MOBILITY Technical Bulletin: Diagnosing with Damage on External Chrome or Aluminum Surfaces Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-03-27	120000 EXTERIOR LIGHTING Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-03-27	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-03-02	162300 STRUCTURE:BODY:DOOR Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-28	200000 WHEELS Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel speed sensor complaints Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-29	160000 STRUCTURE Technical Bulletin: Rear Quarter Panel Corrosion issues. This document discusses causes, fault codes for servicing, and example claim forms for the servicing of the vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-29	350000 EQUIPMENT Technical Bulletin: Rear Quarter Panel Corrosion issues. This document discusses causes, fault codes for servicing, and example claim forms for the servicing of the vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-20	132000 VISIBILITY:GLASS, SIDE/REAR Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. This document contains the fault codes, Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-10	117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-28	070000 FUEL SYSTEM, GASOLINE Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document contains the procedure to update Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-28	110000 ELECTRICAL SYSTEM Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document contains the procedure to update Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-28	060000 ENGINE (PWS) Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document contains the procedure to update Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-28	060000 ENGINE AND ENGINE COOLING Technical Bulletin (Intake manifold runner position sensor issues): This document informs what repairs are needed to fix the issue. This document contains the fault codes necessary to check the warranty coverage for servicing this issue. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-07	060000 ENGINE AND ENGINE COOLING Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-07	350000 EQUIPMENT Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-22	130000 VISIBILITY Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-07	060000 ENGINE AND ENGINE COOLING Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-07	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-10	060000 ENGINE (PWS) Tech Tips (Common Rail TDI ? Fuel Filter Replacement and Prime/Bleed Procedure): This document informs when replacing fuel system components on the Common Rail TDI engine (including the fuel filter), the fuel system must be primed. The p Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-16	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-05	073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-05	070000 FUEL SYSTEM, GASOLINE Technical tips on what to do if improper gasoline has been added to the vehicle. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-20	070000 FUEL SYSTEM, GASOLINE Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-19	060000 ENGINE AND ENGINE COOLING Tech Tips (Coolant Leak or Repeat Coolant Leak from the Water Pump Area): The document informs to inspect for issues, and why issues may happen. It also notes how to fix the issue, and other issues that could happen while repairing the iss Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-23	110000 ELECTRICAL SYSTEM Technical Bulletin (P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory ): Document discusses diagnosis Codes necessary to diagnosis, and potential remedy of issue. The diagnosis codes for checking warranty coverage for servic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-22	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-26	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin (Rocker Panel – Front Fender ? Corrosion ): Document discusses diagnosis, and potential remedy of issue. The document also has example claim forms for repears. The diagnosis codes for checking warranty coverage for servi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-28	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technical Bulletin (Corrosion Hood Edge ): Document discusses diagnosis, and potential remedy of issue. The document also has example claim forms for repears. The diagnosis codes for checking warranty coverage for servicing the vehicle are Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-25	200000 WHEELS Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-10	060000 ENGINE (PWS) Technical Bulletin (Camshaft Adjustment Valve 1 -N205- Diagnosis): Completing the GFF function test and performing basic settings on the camshaft adjustment valve are essential to diagnose proper operation and to avoid unnecessary replac Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-22	060000 ENGINE AND ENGINE COOLING Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-22	110000 ELECTRICAL SYSTEM Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-21	118000 ELECTRICAL SYSTEM:SOFTWARE To update software version management (SVM) reflasg code. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-06	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update Parts Table. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-06	060000 ENGINE AND ENGINE COOLING Remove engine coolant from parts table. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-05	060000 ENGINE AND ENGINE COOLING Tech Bullentin concerning Electric Coolant Fans that Continue to Run after Ignition is Switched OFF Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-05	110000 ELECTRICAL SYSTEM Tech Bullentin concerning Electric Coolant Fans that Continue to Run after Ignition is Switched OFF Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-19	162000 STRUCTURE:BODY Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-19	200000 WHEELS Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-12-10	080000 FUEL SYSTEM, DIESEL Technical Bulletin (Fuel Rail/System Pressure issues): When diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedures have been performed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-15	061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-24	138200 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose t Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-11	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-11	103000 POWER TRAIN:AUTOMATIC TRANSMISSION On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-11	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Golf/GTI Perfect Delivery Inspection (PDI) – Technician and Detailer Inspections: Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-24	070000 FUEL SYSTEM, GASOLINE Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-24	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-13	100000 POWER TRAIN On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-19	061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER Tech Tips: The document discusses the conditions of when turbo can to be fixed or replaced Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-19	100000 POWER TRAIN Tech Tips: The document discusses the conditions of when turbo can to be fixed or replaced Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-29	118000 ELECTRICAL SYSTEM:SOFTWARE Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-26	010000 STEERING Tech Tips (2009-2015 Jetta, Eos, Rabbit, Golf, GTI, Passat, CC, and Tiguan Equipped with Electromechanical Power Steering ? G85 Location Identification Tip): Ths document informs of the location of the G85 steering sensor. The sensors expe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-26	100000 POWER TRAIN Tech Tips (2009-2015 Jetta, Eos, Rabbit, Golf, GTI, Passat, CC, and Tiguan Equipped with Electromechanical Power Steering ? G85 Location Identification Tip): Ths document informs of the location of the G85 steering sensor. The sensors expe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-04	063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE Technical Bulletin (Intake Manifold issues): This document informs of a failure of Intake manifold causing fault codes to be stored in the ECM. The fault codes are written in the document. The product solution for this issue an Improved in Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-08	063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE Technical Bulletin (Intake Manifold Fault issues): This document informs of Intake Manifold issues that are recognized in the ECM fault memory. The Production Solution to this issue was an improved intake manifold design. This document dis Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-22	063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE Technical Bulletin (Intake Manifold Faults Stored in ECM Fault Memory issues): This document informs of a failure of Intake manifold causing fault codes to be stored in the ECM. The production solution improved intake manifold design. Th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-02	060000 ENGINE (PWS) Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-24	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-19	110000 ELECTRICAL SYSTEM Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selec Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-11	070000 FUEL SYSTEM, GASOLINE Tech Tips (2009-2014 All TDI (2.0L, 3.0L) Common Rail models Passat, Golf, Jetta, Jetta SportWagen, Touareg Adapting Injector Quantity adjustment correction values (IMA/IVA)): This document informs When replacing or adapting fuel injectors Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-11	070000 FUEL SYSTEM, GASOLINE Tech Tips (Fuel line connections): Be aware that fuel lines are color coded on vehicles with return fuel pressure lines. The black line is for fuel pressure supply and the blue line is for fuel pressure return. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-04	103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installat Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-04	120000 EXTERIOR LIGHTING Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-04	350000 EQUIPMENT Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-06	190000 TIRES Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products wil Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-06	200000 WHEELS Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products wil Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-20	070000 FUEL SYSTEM, GASOLINE Tech Tips (Adapting Injector Quantity adjustment correction values (IMA/IVA)): When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize this documents procedure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-20	073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM Tech Tips (Adapting Injector Quantity adjustment correction values (IMA/IVA)): When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize this documents procedure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-02	021300 SUSPENSION:FRONT:SHOCK ABSORBER Technical Bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak. Document contains examples of Strut or Shock Absorber Leak Assessments Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-02	022400 SUSPENSION:REAR:SHOCK ABSORBER Technical Bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak. Document contains examples of Strut or Shock Absorber Leak Assessments Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-03	162000 STRUCTURE:BODY Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. It gives examples on where to check for repair coverage from warranties, fixing possible issues, and how to docu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-03	200000 WHEELS Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. It gives examples on where to check for repair coverage from warranties, fixing possible issues, and how to docu Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-01	162200 STRUCTURE:BODY:BUMPERS The document refers to Corrosion being found where the rear bumper cover meets the quarter panel. It discusses how it can happen, and where to find warranty coverage to service the parts Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-17	356000 EQUIPMENT ADAPTIVE/MOBILITY Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. It discusses where to find what appl Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-24	100000 POWER TRAIN Tech Tips (Lean Fuel Trim Readings): This document informs to recheck the crankcase vacuum at idle. If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Erase the faults and road test 10 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-17	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-17	062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-10	091200 FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM Tech Tips (ECM Fault P1250 “Fuel Level Too Low” Will Not Clear): This document informs to clear static ECM fault P1250 “Fuel Level Too Low”, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without co Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-10	353000 EQUIPMENT:ELECTRICAL Tech Tips (ECM Fault P1250 “Fuel Level Too Low” Will Not Clear): This document informs to clear static ECM fault P1250 “Fuel Level Too Low”, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without co Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-10	200000 WHEELS Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel speed sensor complaints. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-03-28	162000 STRUCTURE:BODY Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to fi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-12-07	110000 ELECTRICAL SYSTEM Technical Bulletin (Engine, Misfire Diagnostic Aid): This document informs that Multiple components SHOULD NOT be replaced for 1 misfiring cylinder. Repeat repairs must be carefully addressed to identify the root cause of the concern. If m Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-17	060000 ENGINE (PWS) Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-25	162000 STRUCTURE:BODY Technical Bulletin (Rocker Panel – Front Fender ? Corrosion): This document informs of Corrosion on contact surfaces of the front fender to rocker panel (side member). This document discusses the “Fault Codes” necessary to diagnosis, and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-03	010000 STEERING VOLKSWAGEN: STEERING RACK. AFTER REPLACING THE STEERING RACK THE FAULT CODE 01309 008 IS SET IN ABS/ESP MODULE. ALSO INCLUDED MODEL GTI MY 2013, MODEL TIGUAN MY 2005-2007, MODEL RABBIT MY 2005/2011-2013, MODEL EOS MY 2005/2013, MODEL CC MY Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-08	062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN VOLKSWAGEN: IT IS A NORMAL OCCURRENCE FOR THE ELECTRIC COOLANT FANS TO CONTINUE TO RUN AFTER THE IGNITION IS SWITCHED OFF. *JS Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-07-23	060000 ENGINE (PWS) VOLKSWAGEN: ALL MODELS EXPERIENCE THE TIMING CHAIN SLIPPING, RATTLING NOISES OF THE ENGINE AFTER STARTING, AND ENGINE FAILS TO START. 2008-13 ALL MODELS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-06-07	162200 STRUCTURE:BODY:BUMPERS TO UPDATE CLAIM PROCESSING STATEMENT. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-09-16	073100 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL VOLKSWAGEN: MIL ON; DTC P0087 AND/OR P0192 STORED IN ECM FAULT MEMORY. ONE OR MORE OF THE FOLLOWING CODES MAY BE STORED IN THE ECM FAULT MEMORY-LOW FUEL RAIL PRESSURE DETECTED; FUEL RAIL PRESSURE SENSOR CIRCUIT LOW. ASSISTANCE TO PROPERL Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-09-30	581000 CHILD SEAT:LATCH CONNECTOR/CLIP VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-09-30	583000 CHILD SEAT:LATCH STRAP VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-08-09	110000 ELECTRICAL SYSTEM VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE F Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-08-09	114000 ELECTRICAL SYSTEM:WIRING VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE F Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-08-09	121000 EXTERIOR LIGHTING:HEADLIGHTS VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE F Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-12-03	063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS. REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-27	162000 STRUCTURE:BODY BETTER DEFINE CORROSION DAMAGE AND LOCATION COVERED BY THIS TECHNICAL BULLETIN. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-08-16	114400 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS VOLKSWAGEN: HVAC BLOWER ONLY OPERATES ON HIGH SPEED (US ONLY). FRESH AIR BLOWER RUNS ONLY AT HIGHEST LEVEL. BECAUSE OF PERMANENT FROST AND SNOWFALL FINE SNOW CAN GET INTO THE FRESH AIR BLOWER VIA THE AIR INTAKE. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-08-16	980000 UNKNOWN OR OTHER VOLKSWAGEN: HVAC BLOWER ONLY OPERATES ON HIGH SPEED (US ONLY). FRESH AIR BLOWER RUNS ONLY AT HIGHEST LEVEL. BECAUSE OF PERMANENT FROST AND SNOWFALL FINE SNOW CAN GET INTO THE FRESH AIR BLOWER VIA THE AIR INTAKE. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-06-06	013000 STEERING:GEAR BOX (OTHER THAN RACK AND PINION) VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-06-06	103000 POWER TRAIN:AUTOMATIC TRANSMISSION VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-03-23	050000 PARKING BRAKE VOLKSWAGEN: WHEN THE WARNING LIGHTS ARE USED FOR AN EXTENDED TIME THERE MAY BE MULTIPLE PROBLEMS DUE TO A SOFTWARE CONCERN: WARNING LIGHT SYMBOL STAYS ON AFTER THEY ARE TURNED OFF. OPEN DOOR AND HATCH SYMBOLS ARE SHOWN EVEN THOUGH THEY ARE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-02-14	061000 ENGINE AND ENGINE COOLING:ENGINE VOLKSWAGEN: MALFUNCTION LIGHT IS ON AND THERE IS NOISE WITH THE ENGINE RUNNING ROUGH. MULTIPLE TROUBLE CODES POSSIBLY STORED. ALL MODELS 2008-2012. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-22	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL INJE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-22	980000 UNKNOWN OR OTHER VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL INJE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-24	072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP VOLKSWAGEN: VEHICLE IS ROUGH RUNNING, FAILS TO START AND MALFUNCTION INDICATOR LAMP (MIL) BE ON AND AFTER CHECKING COMPONENTS AND NO ROOT CAUSE IS FOUND, NEED TO CHECK HIGH PRESSURE FUEL PUMP FOR METALLIC PARTICLES. MODEL 2009-12 GOLF JET Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-06-24	073100 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL VOLKSWAGEN: VEHICLE IS ROUGH RUNNING, FAILS TO START AND MALFUNCTION INDICATOR LAMP (MIL) BE ON AND AFTER CHECKING COMPONENTS AND NO ROOT CAUSE IS FOUND, NEED TO CHECK HIGH PRESSURE FUEL PUMP FOR METALLIC PARTICLES. MODEL 2009-12 GOLF JET Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-12-01	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-18	118000 ELECTRICAL SYSTEM:SOFTWARE SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-12-21	060000 ENGINE (PWS) VOLKSWAGEN: CAMSHAFT ADJUSTMENT VALVE 1-N205-DIAGNOSIS. ONE OR MORE SPECIFIC FAULT CODES MAY BE STORED IN THE ECM FAULT MEMORY. *JS Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-08-01	101000 POWER TRAIN:CLUTCH ASSEMBLY VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. IN SOME VEHICLES IT IS POSSIBLE THAT A BUSHING INSIDE THE MECHATRONIC UNIT HAS THE POTENTIAL TO WEAR OUT PREMATURELY, CAUSING THE CLUTCHES INSIDE THE TRANSMISSION Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-06	100000 POWER TRAIN VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE AN IMPLAUSIBLE TRANSMISSION SHIFT SEQUENCE STORED IN THE TRANSMISSION CONTROL MODULE. THERE MAY BE A LACK OF MOBILITY UPON START UP AND SHIFTING COMPLICATIONS. STORED DTC P2711. ALSO INCLUDED JETTA Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-02-24	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) VOLKSWAGEN: THE TRANSMISSION CONTROL MODULE HAS AN IMPLAUSIBLE TRANSMISSION SHIFT SEQUENCE DUE TO THE CLUTCH ASSEMBLY HAVING DEBRIS IN IT. 8PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-12-22	061000 ENGINE AND ENGINE COOLING:ENGINE VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES ARE EXPERIENCING ENGINE NOT STARTING, MAKING A RATTLING NOISE WHEN ENGINE HAS STARTED, TIMING CHAIN KEEPS SLIPPING AND EXHAUST LIGHT COMES ON. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-13	162000 STRUCTURE:BODY TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-18	060000 ENGINE (PWS) VOLKSWAGEN: ACTIVATED CHARCOAL FILTER SYSTEM, SOLENOID VALVE AND PERFORMING GFF FUNCTION TEST A VACUUM CHECK ON CANISTER PURGE VALVE N80 ARE ESSENTIAL TO DIAGNOSE PROPER OPERATION. MODEL 2009-14 ALL BUT ROUTAN. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-08-25	073100 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-08-25	091130 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-09	060000 ENGINE (PWS) VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE A MISFIRE AND/OR REDUCED ENGINE PERFORMANCE. *JS Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-11-24	063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL VOLKSWAGEN: THERE IS A WARRANTY EXTENSION ON HARD START CONDITIONS FOR CUSTOMERS WHO HAD AN EARLIER CAMPAIGN ADDRESSED ON THEIR VEHICLES. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-11-24	118000 ELECTRICAL SYSTEM:SOFTWARE VOLKSWAGEN: THERE IS A WARRANTY EXTENSION ON HARD START CONDITIONS FOR CUSTOMERS WHO HAD AN EARLIER CAMPAIGN ADDRESSED ON THEIR VEHICLES. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2009 VOLKSWAGEN Golf

0 Recalls for 2009 VOLKSWAGEN Golf

0 Complaints sent to the Center for Auto Safety for 2009 VOLKSWAGEN Golf

3 Complaints submitted to NHTSA for 2009 VOLKSWAGEN Golf

1 Investigations for 2009 VOLKSWAGEN Golf

604 Service Alerts for 2009 VOLKSWAGEN Golf