2006 FORD Expedition Recalls, Complaints and Investigations

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

6 Recalls for 2006 FORD Expedition

Recall Date	Component	Summary
2009-04-07	EXTERIOR LIGHTING	SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, “LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.” THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS. Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
2006-07-17	EXTERIOR LIGHTING	CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT. Remedy: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
2006-06-13	FUEL SYSTEM, GASOLINE	CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED. Remedy: UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
2006-03-13	EXTERIOR LIGHTING:HEADLIGHTS	CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, “LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.” Remedy: ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
2005-11-09	VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR	ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR. Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
2005-07-06	TIRES:TREAD/BELT	ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT AND REAR TIRES ON THE DRIVER’S SIDE OF AFFECTED VEHICLES MAY HAVE BEEN DAMAGED AT THE CENTER TREAD DURING PRODUCTION. Remedy: DEALERS WILL INSPECT ALL FOUR TIRES (TO ENSURE INSPECTION OF THE LEFT HAND SIDE TIRES THAT MAY HAVE BEEN ROTATED TO THE OTHER SIDE OF THE VEHICLE) FOR TIRE TREAD DAMAGE AND, IF NECESSARY, REPLACE THE DAMAGED TIRE. THE RECALL BEGAN ON JULY 13, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

7 Complaints sent to the Center for Auto Safety for 2006 FORD Expedition

skip to NHTSA complaints

Date			Component
2017-08-06
2016-08-04			paint
2015-10-09			paint
2011-05-12			engine
2011-05-12			paint
2011-05-12			paint
2011-05-12			paint

294 Complaints submitted to NHTSA for 2006 FORD Expedition

skip to CAS complaints

Date			Component
2016-11-07			ENGINE ODI Number: 10924646
2016-10-18			AIR BAGS ODI Number: 10916742
2016-10-25			ENGINE ODI Number: 10918834
2016-10-17			POWER TRAIN ODI Number: 10916436
2016-10-17			ENGINE ODI Number: 10916527
2017-07-11			UNKNOWN OR OTHER ODI Number: 11004328
2017-07-13			UNKNOWN OR OTHER ODI Number: 11005204
2017-06-07			ENGINE ODI Number: 10993713
2017-06-13			AIR BAGS ODI Number: 10994910
2017-04-11			ELECTRICAL SYSTEM \| ENGINE ODI Number: 10971943
2017-08-05			POWER TRAIN \| STRUCTURE:BODY ODI Number: 11013028
2017-08-05			ENGINE ODI Number: 11012978
2017-01-18			ENGINE ODI Number: 10945943
2017-01-13			ENGINE ODI Number: 10944979
2020-01-20			ENGINE ODI Number: 11300564
2019-07-15			ELECTRICAL SYSTEM \| ENGINE ODI Number: 11232007
2019-05-15			SERVICE BRAKES ODI Number: 11207898
2019-04-23			VISIBILITY/WIPER ODI Number: 11203186
2018-05-25			SERVICE BRAKES \| STEERING \| UNKNOWN OR OTHER ODI Number: 11097889
2018-02-27			FUEL/PROPULSION SYSTEM \| POWER TRAIN ODI Number: 11075280
2018-11-21			UNKNOWN OR OTHER ODI Number: 11153128
2018-11-07			FUEL/PROPULSION SYSTEM ODI Number: 11149843
2018-07-16			ENGINE \| VEHICLE SPEED CONTROL ODI Number: 11111689
2018-01-12			ELECTRICAL SYSTEM \| ENGINE \| VEHICLE SPEED CONTROL ODI Number: 11062497
2018-01-17			STRUCTURE:BODY ODI Number: 11063199
2017-09-11			FUEL/PROPULSION SYSTEM ODI Number: 11022588
2017-09-08			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 11022322
2016-07-09			STEERING \| UNKNOWN OR OTHER ODI Number: 10883751
2016-06-29			ELECTRICAL SYSTEM \| ENGINE ODI Number: 10881519
2016-06-06			ENGINE \| POWER TRAIN \| STEERING ODI Number: 10872668
2016-06-02			ENGINE ODI Number: 10872106
2016-05-06			STRUCTURE:BODY ODI Number: 10863557
2016-05-06			FUEL/PROPULSION SYSTEM ODI Number: 10863554
2016-03-09			ENGINE ODI Number: 10845751
2016-03-07			UNKNOWN OR OTHER ODI Number: 10840393
2016-01-12			ENGINE ODI Number: 10819673
2016-01-11			ENGINE ODI Number: 10819422
2015-12-28			ENGINE ODI Number: 10816393
2015-11-16			ELECTRICAL SYSTEM \| ENGINE \| STEERING ODI Number: 10790557
2015-10-28			ENGINE ODI Number: 10786860
2015-11-05			ENGINE ODI Number: 10788701
2015-10-29			ENGINE ODI Number: 10787029
2015-10-20			POWER TRAIN ODI Number: 10783799
2015-10-23			ENGINE \| POWER TRAIN ODI Number: 10785496
2015-10-05			FUEL/PROPULSION SYSTEM ODI Number: 10779940
2015-10-09			STRUCTURE:BODY ODI Number: 10781060
2015-10-08			ENGINE ODI Number: 10780878
2015-09-29			ELECTRICAL SYSTEM \| STEERING \| VEHICLE SPEED CONTROL ODI Number: 10778348
2015-08-14			UNKNOWN OR OTHER ODI Number: 10748723
2015-07-31			ENGINE ODI Number: 10745352
2015-07-09			ENGINE ODI Number: 10733064
2015-07-01			ENGINE ODI Number: 10731606
2015-05-01			ENGINE ODI Number: 10714059
2015-05-01			ELECTRICAL SYSTEM \| ENGINE ODI Number: 10714028
2015-03-24			ENGINE \| STEERING \| VEHICLE SPEED CONTROL ODI Number: 10701287
2015-03-24			ENGINE ODI Number: 10701390
2015-02-24			ENGINE \| STEERING ODI Number: 10690292
2015-01-28			AIR BAGS \| VISIBILITY/WIPER ODI Number: 10679376
2015-01-15			ELECTRICAL SYSTEM ODI Number: 10672818
2015-01-20			ENGINE ODI Number: 10676673
2015-01-09			ENGINE ODI Number: 10671241
2014-12-31			ELECTRICAL SYSTEM \| ENGINE ODI Number: 10669324
2014-12-19			ENGINE \| POWER TRAIN ODI Number: 10667242
2014-10-11			ENGINE \| VEHICLE SPEED CONTROL ODI Number: 10644023
2014-09-10			ELECTRICAL SYSTEM \| ENGINE ODI Number: 10632045
2014-08-26			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10628480
2014-08-09			AIR BAGS \| FUEL SYSTEM, GASOLINE \| VEHICLE SPEED CONTROL ODI Number: 10621042
2014-08-07			ENGINE \| FUEL/PROPULSION SYSTEM ODI Number: 10620711
2014-07-29			ELECTRONIC STABILITY CONTROL \| ENGINE \| VEHICLE SPEED CONTROL ODI Number: 10617085
2014-07-04			ENGINE \| STEERING ODI Number: 10608197
2014-05-22			FUEL SYSTEM, GASOLINE ODI Number: 10593339
2014-05-27			ENGINE ODI Number: 10594383
2014-05-16			ENGINE ODI Number: 10588814
2014-04-23			ENGINE \| FUEL SYSTEM, GASOLINE \| POWER TRAIN \| STRUCTURE ODI Number: 10584466
2014-04-23			ELECTRICAL SYSTEM \| ENGINE ODI Number: 10584459
2014-04-25			ENGINE ODI Number: 10584816
2014-04-17			POWER TRAIN ODI Number: 10583376
2014-04-21			ENGINE ODI Number: 10583919
2014-04-03			ENGINE \| STEERING ODI Number: 10577260
2014-03-20			STRUCTURE ODI Number: 10573806
2014-03-27			ENGINE \| STEERING \| VEHICLE SPEED CONTROL ODI Number: 10575089
2014-03-03			FUEL/PROPULSION SYSTEM ODI Number: 10566784
2014-02-28			ENGINE \| STEERING \| VEHICLE SPEED CONTROL ODI Number: 10566562
2014-02-07			VEHICLE SPEED CONTROL ODI Number: 10563369
2014-01-03			ENGINE ODI Number: 10558303
2013-12-02			ENGINE ODI Number: 10554452
2013-11-07			ENGINE ODI Number: 10551251
2013-11-21			ENGINE ODI Number: 10553237
2013-10-21			ENGINE ODI Number: 10548694
2013-10-15			ELECTRICAL SYSTEM \| ENGINE \| VEHICLE SPEED CONTROL ODI Number: 10547909
2013-08-06			ELECTRICAL SYSTEM \| ELECTRONIC STABILITY CONTROL \| ENGINE ODI Number: 10533790
2013-07-03			ENGINE AND ENGINE COOLING ODI Number: 10523121
2013-06-17			ENGINE ODI Number: 10520096
2013-06-05			ENGINE ODI Number: 10515349
2013-06-07			ENGINE ODI Number: 10515622
2013-05-17			SERVICE BRAKES ODI Number: 10512575
2013-04-24			ENGINE ODI Number: 10509385
2013-04-24			ENGINE ODI Number: 10509382
2013-04-09			ENGINE ODI Number: 10505626
2013-04-12			POWER TRAIN ODI Number: 10506064
2013-04-04			VEHICLE SPEED CONTROL ODI Number: 10507117
2013-03-27			ENGINE ODI Number: 10504652
2013-03-20			ENGINE ODI Number: 10503750
2013-03-11			ENGINE ODI Number: 10502343
2013-03-22			VEHICLE SPEED CONTROL ODI Number: 10504098
2013-02-27			ELECTRICAL SYSTEM \| ENGINE ODI Number: 10500639
2013-03-06			POWER TRAIN ODI Number: 10501850
2013-02-25			ENGINE ODI Number: 10499913
2013-01-18			ENGINE ODI Number: 10493471
2012-12-19			ENGINE ODI Number: 10489233
2012-12-28			VEHICLE SPEED CONTROL ODI Number: 10490327
2012-12-27			ENGINE \| SERVICE BRAKES \| STEERING ODI Number: 10490170
2013-01-02			ENGINE ODI Number: 10490748
2012-11-05			ENGINE AND ENGINE COOLING ODI Number: 10483436
2012-11-01			ENGINE ODI Number: 10482857
2012-10-11			ENGINE ODI Number: 10479803
2012-09-30			ENGINE ODI Number: 10478010
2012-09-27			ENGINE ODI Number: 10477285
2012-10-04			AIR BAGS \| ENGINE \| STRUCTURE:BODY \| WHEELS ODI Number: 10478584
2012-09-26			VEHICLE SPEED CONTROL ODI Number: 10477178
2012-08-28			ENGINE ODI Number: 10472812
2012-08-08			ENGINE ODI Number: 10469718
2012-07-19			ENGINE AND ENGINE COOLING \| FUEL/PROPULSION SYSTEM ODI Number: 10466586
2012-07-13			ENGINE ODI Number: 10465518
2012-07-16			ENGINE ODI Number: 10465762
2012-07-23			ELECTRICAL SYSTEM ODI Number: 10467077
2012-07-16			LATCHES/LOCKS/LINKAGES:DOORS:LATCH ODI Number: 10465837
2012-07-18			ENGINE \| POWER TRAIN ODI Number: 10466460
2012-07-03			ENGINE ODI Number: 10464083
2012-05-02			ENGINE AND ENGINE COOLING ODI Number: 10457105
2012-04-30			ENGINE AND ENGINE COOLING ODI Number: 10456870
2012-04-28			FUEL SYSTEM, GASOLINE ODI Number: 10456764
2012-04-25			ENGINE AND ENGINE COOLING ODI Number: 10456443
2012-04-20			LATCHES/LOCKS/LINKAGES:DOORS:LATCH \| POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL \| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS \| STRUCTURE:FRAME AND MEMBERS \| VISIBILITY:POWER WINDOW DEVICES AND CONTROLS ODI Number: 10456236
2012-02-28			VEHICLE SPEED CONTROL ODI Number: 10449526
2012-02-11			ENGINE AND ENGINE COOLING ODI Number: 10447516
2012-02-13			ENGINE AND ENGINE COOLING ODI Number: 10447835
2012-02-14			ELECTRICAL SYSTEM ODI Number: 10447969
2012-02-06			ENGINE AND ENGINE COOLING ODI Number: 10446777
2012-01-23			TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS ODI Number: 10444963
2012-01-19			ENGINE AND ENGINE COOLING ODI Number: 10444512
2011-12-23			ENGINE AND ENGINE COOLING ODI Number: 10441128
2012-01-06			ENGINE AND ENGINE COOLING \| VEHICLE SPEED CONTROL ODI Number: 10442650
2011-12-15			ENGINE AND ENGINE COOLING ODI Number: 10440029
2011-12-14			VEHICLE SPEED CONTROL ODI Number: 10439941
2011-11-28			ENGINE AND ENGINE COOLING ODI Number: 10437574
2011-11-23			ENGINE AND ENGINE COOLING ODI Number: 10436883
2011-11-14			ENGINE AND ENGINE COOLING ODI Number: 10435469
2011-11-17			ENGINE AND ENGINE COOLING ODI Number: 10437008
2011-11-14			SEAT BELTS ODI Number: 10435518
2011-11-27			ELECTRICAL SYSTEM \| ENGINE AND ENGINE COOLING \| VEHICLE SPEED CONTROL ODI Number: 10437417
2011-11-02			ENGINE AND ENGINE COOLING ODI Number: 10433992
2011-10-12			ENGINE AND ENGINE COOLING ODI Number: 10429638
2011-10-06			ENGINE AND ENGINE COOLING ODI Number: 10428961
2011-09-29			ENGINE AND ENGINE COOLING ODI Number: 10427845
2011-09-09			POWER TRAIN ODI Number: 10424423
2011-08-18			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10420044
2011-08-22			ENGINE AND ENGINE COOLING ODI Number: 10421011
2011-08-23			ENGINE AND ENGINE COOLING ODI Number: 10421151
2011-08-08			TIRES ODI Number: 10417910
2011-07-15			ENGINE AND ENGINE COOLING ODI Number: 10412447
2011-07-24			TIRES ODI Number: 10414913
2011-07-21			ENGINE AND ENGINE COOLING ODI Number: 10413913
2011-06-15			AIR BAGS:FRONTAL ODI Number: 10406971
2011-06-08			FUEL SYSTEM, GASOLINE ODI Number: 10405638
2011-06-09			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10405777
2011-06-17			ENGINE AND ENGINE COOLING ODI Number: 10407257
2011-06-10			UNKNOWN OR OTHER ODI Number: 10406490
2011-05-28			AIR BAGS:FRONTAL ODI Number: 10403653
2011-05-25			ENGINE AND ENGINE COOLING ODI Number: 10402720
2011-05-10			ENGINE AND ENGINE COOLING:COOLING SYSTEM ODI Number: 10399803
2011-04-17			ELECTRICAL SYSTEM \| ENGINE AND ENGINE COOLING ODI Number: 10396558
2011-04-24			ENGINE AND ENGINE COOLING \| ENGINE AND ENGINE COOLING \| FUEL SYSTEM, GASOLINE ODI Number: 10397771
2011-04-27			FUEL SYSTEM, GASOLINE ODI Number: 10397988
2011-03-25			VEHICLE SPEED CONTROL ODI Number: 10392883
2011-04-06			SEAT BELTS ODI Number: 10394497
2011-03-18			VEHICLE SPEED CONTROL ODI Number: 10392175
2011-04-04			ENGINE AND ENGINE COOLING \| POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10394140
2011-03-28			ENGINE AND ENGINE COOLING ODI Number: 10393496
2011-03-10			ELECTRICAL SYSTEM \| ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10389188
2011-03-01			ELECTRICAL SYSTEM ODI Number: 10384861
2011-02-24			ENGINE AND ENGINE COOLING ODI Number: 10384296
2011-02-03			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10380086
2011-01-13			AIR BAGS:FRONTAL ODI Number: 10376575
2011-01-11			ELECTRICAL SYSTEM ODI Number: 10376233
2011-01-06			ELECTRICAL SYSTEM \| FUEL SYSTEM, GASOLINE ODI Number: 10374970
2011-01-16			UNKNOWN OR OTHER ODI Number: 10376844
2010-12-20			ENGINE AND ENGINE COOLING \| ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10371851
2011-01-04			ENGINE AND ENGINE COOLING ODI Number: 10374056
2010-12-29			UNKNOWN OR OTHER ODI Number: 10373209
2010-10-28			AIR BAGS ODI Number: 10363330
2010-09-22			SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS ODI Number: 10356959
2010-09-15			ENGINE AND ENGINE COOLING ODI Number: 10355690
2010-09-09			ELECTRICAL SYSTEM ODI Number: 10354633
2010-09-10			VEHICLE SPEED CONTROL ODI Number: 10354878
2010-09-16			ENGINE AND ENGINE COOLING:COOLING SYSTEM ODI Number: 10356053
2010-08-16			ENGINE AND ENGINE COOLING ODI Number: 10349685
2010-08-02			SEAT BELTS ODI Number: 10346710
2010-07-29			VEHICLE SPEED CONTROL ODI Number: 10346046
2010-08-05			ENGINE AND ENGINE COOLING ODI Number: 10347550
2010-07-15			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10343453
2010-06-28			VEHICLE SPEED CONTROL ODI Number: 10340416
2010-07-07			SERVICE BRAKES, HYDRAULIC ODI Number: 10341811
2010-06-15			ENGINE AND ENGINE COOLING:ENGINE \| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR \| FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS ODI Number: 10336418
2010-06-24			ELECTRICAL SYSTEM \| ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10339814
2010-06-07			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10335094
2010-05-13			ELECTRONIC STABILITY CONTROL \| ENGINE AND ENGINE COOLING ODI Number: 10330326
2010-05-14			FUEL SYSTEM, GASOLINE ODI Number: 10330441
2010-04-28			STRUCTURE ODI Number: 10327913
2010-05-03			ENGINE AND ENGINE COOLING \| VEHICLE SPEED CONTROL ODI Number: 10328713
2010-04-09			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10324757
2010-04-19			WHEELS ODI Number: 10326438
2010-03-19			ENGINE AND ENGINE COOLING ODI Number: 10320956
2010-03-14			ELECTRICAL SYSTEM \| ENGINE AND ENGINE COOLING ODI Number: 10319602
2010-02-24			ENGINE AND ENGINE COOLING ODI Number: 10313559
2010-02-21			STRUCTURE:BODY ODI Number: 10312482
2010-02-17			WHEELS ODI Number: 10311415
2010-02-18			ELECTRICAL SYSTEM \| FUEL SYSTEM, GASOLINE ODI Number: 10311621
2010-02-08			WHEELS ODI Number: 10307412
2010-02-01			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10303599
2010-01-03			FUEL SYSTEM, GASOLINE ODI Number: 10297912
2009-12-21			WHEELS:RIM ODI Number: 10296524
2009-12-01			FUEL SYSTEM, GASOLINE ODI Number: 10294125
2009-12-08			FUEL SYSTEM, GASOLINE ODI Number: 10294852
2009-12-04			ENGINE AND ENGINE COOLING ODI Number: 10294525
2009-11-05			STRUCTURE:FRAME AND MEMBERS ODI Number: 10291144
2009-11-17			ENGINE AND ENGINE COOLING ODI Number: 10292617
2009-10-05			WHEELS ODI Number: 10286279
2009-08-08			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10279744
2009-08-17			EQUIPMENT ODI Number: 10280628
2009-07-15			ENGINE AND ENGINE COOLING ODI Number: 10276889
2009-07-20			TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS ODI Number: 10277518
2009-07-13			STRUCTURE:BODY ODI Number: 10276504
2009-07-29			STRUCTURE:BODY ODI Number: 10278623
2009-06-19			ENGINE AND ENGINE COOLING ODI Number: 10274331
2009-04-07			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10264389
2009-03-13			ENGINE AND ENGINE COOLING ODI Number: 10261722
2009-03-05			ENGINE AND ENGINE COOLING ODI Number: 10260814
2009-03-12			WHEELS ODI Number: 10261663
2009-02-19			STRUCTURE ODI Number: 10259382
2009-02-23			ENGINE AND ENGINE COOLING ODI Number: 10259622
2008-12-18			ENGINE AND ENGINE COOLING ODI Number: 10252165
2008-11-25			AIR BAGS:FRONTAL ODI Number: 10249887
2008-12-15			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10251821
2008-11-17			UNKNOWN OR OTHER ODI Number: 10248992
2008-10-30			WHEELS ODI Number: 10247221
2008-10-23			AIR BAGS:SIDE/WINDOW ODI Number: 10246492
2008-09-15			VISIBILITY:POWER WINDOW DEVICES AND CONTROLS ODI Number: 10242310
2008-08-27			ENGINE AND ENGINE COOLING \| SERVICE BRAKES, HYDRAULIC ODI Number: 10240001
2008-08-18			ENGINE AND ENGINE COOLING \| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR ODI Number: 10238652
2008-08-14			WHEELS ODI Number: 10238153
2008-07-14			ELECTRICAL SYSTEM ODI Number: 10234170
2008-06-30			STRUCTURE:BODY ODI Number: 10232716
2008-06-06			ENGINE AND ENGINE COOLING \| STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS \| SUSPENSION ODI Number: 10230648
2008-06-24			ENGINE AND ENGINE COOLING ODI Number: 10232177
2008-04-07			ENGINE AND ENGINE COOLING ODI Number: 10223551
2008-03-05			WHEELS:RIM ODI Number: 10220133
2008-01-07			TIRES:TREAD/BELT ODI Number: 10214028
2007-12-13			UNKNOWN OR OTHER ODI Number: 10211839
2007-12-15			ENGINE AND ENGINE COOLING ODI Number: 10211999
2007-12-06			ELECTRONIC STABILITY CONTROL \| POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) \| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP ODI Number: 10211048
2007-10-16			SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER ODI Number: 10205885
2007-09-05			AIR BAGS:FRONTAL \| ENGINE AND ENGINE COOLING:COOLING SYSTEM \| ENGINE AND ENGINE COOLING:ENGINE:GASOLINE \| EQUIPMENT ODI Number: 10201895
2007-07-09			POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) ODI Number: 10195689
2007-05-24			STRUCTURE:BODY:DOOR ODI Number: 10191636
2007-06-11			SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP ODI Number: 10192941
2007-04-14			AIR BAGS:FRONTAL ODI Number: 10187866
2007-04-17			AIR BAGS ODI Number: 10188135
2007-03-19			SERVICE BRAKES, HYDRAULIC ODI Number: 10185594
2007-03-11			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10184734
2007-03-12			STEERING:RACK AND PINION:RACK ODI Number: 10184818
2007-01-28			SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE ODI Number: 10180943
2007-01-26			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10180802
2006-12-13			UNKNOWN OR OTHER ODI Number: 10176009
2006-10-30			ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH ODI Number: 10172196
2006-10-04			STEERING:LINKAGES:TIE ROD ASSEMBLY ODI Number: 10169925
2006-09-12			EQUIPMENT:APPLIANCE:AIR CONDITIONER ODI Number: 10168096
2006-07-28			AIR BAGS ODI Number: 10163822
2006-08-10			ENGINE AND ENGINE COOLING \| EQUIPMENT:APPLIANCE:AIR CONDITIONER ODI Number: 10165109
2006-08-11			ELECTRICAL SYSTEM ODI Number: 10165260
2006-04-25			EQUIPMENT ODI Number: 10156067
2006-05-10			ENGINE AND ENGINE COOLING \| POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10157176
2006-04-25			SEATS \| UNKNOWN OR OTHER \| VISIBILITY ODI Number: 10156104
2006-03-28			ELECTRICAL SYSTEM:HORN ODI Number: 10154144
2006-03-20			ELECTRICAL SYSTEM:HORN ODI Number: 10154085
2006-03-10			SERVICE BRAKES, HYDRAULIC ODI Number: 10152411
2006-02-11			TIRES:BEAD ODI Number: 10150040
2005-12-17			ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC) \| SERVICE BRAKES, HYDRAULIC ODI Number: 10145519
2014-09-24			ENGINE ODI Number: 10638800
2010-05-20			ENGINE AND ENGINE COOLING ODI Number: 10331400
2012-02-06			VEHICLE SPEED CONTROL ODI Number: 10446900
2009-05-03			STRUCTURE ODI Number: 10267600
2008-12-18			STRUCTURE ODI Number: 10252200
2012-01-18			ENGINE AND ENGINE COOLING ODI Number: 10444400

Is the government investigating the safety of your vehicle? Find out here.

2 Investigations for 2006 FORD Expedition

Ford "special service vehicle" (ssv) expeditions use a steel full face wheel design similar to that investigated in pe03009, rq04007, ea04034 (crown victoria police interceptor) and pe03026 (gm pickups and suvs).a total of 8,251 ssvs (2.2% of total production) were produced within model years 2004-2006 and sold primarily for use by state, federal, and municipal law enforcement (le) agencies.ford stipulates that the subject vehicles are not suitable for high speed or pursuit operations and also identified a 2004 national institute for justice vehicle evaluation report which also acknowledges this limitation. the full face wheel is fabricated from two pieces: a stamped outer wheel disc and a formed rim.the two pieces, which together comprise the outer bead seat, are joined together with a circumferential weld.a cyclic bending moment occurs in the outer bead seat area as the wheel rotates, resulting in fatigue stresses in the weld's heat affected zone that can lead to fracturing (cracking) of the rim material.because the failure occurs under the outboard tire bead, air leakage may not readily occur when the rim cracks, dependent on how well the bead seals on the rim.if multiple cracks grow undetected and suddenly join into a single large crack, the wheel's structure can become compromised leading to rapid air loss.a rapid air loss, especially at higher speed, may lead to a crash. ford responded to odi's january 5, 2009 information request (ir) on february 24.ford's response acknowledges a number of wheel fractures on the ssvs.however, based on its assessment of the pertinent factors, it concludes that the condition does not represent an unreasonable risk to safety.the lack of reports of rapid air loss, no alleged crashes, and their assessment that a cracked wheel can be detected through slow, repeated air loss or vibration, were the bases for ford's conclusion.ford discusses the results of a study it performed on wheels returned from le field use, design revisions it made to the subject wheel, and the outcome of durability testing it conducted on the old and new wheel designs. the counts shown above include a duplicate odi and ford report; the ford counts are unique vehicles alleging wheel fracture(s).some warranty claims involved more than one wheel replacement.although the subject vehicles have been in service for a longer period of time than vehicles investigated in the previous investigations of two-piece wheel fracture, odi did not identify any allegations of crashes, rapid air loss events due to wheel fractures or allegations of effects on vehicle control or stability, as were the cases in past investigations where safety recalls were conducted to replace affected wheels.the agency agrees that the ssv is not suitable for pursuit or high speed usage, reducing the potential for crashes or loss of control incidents to be caused by the alleged defect. ford implemented a 'shot peening' process in june 2006 which reduced the wheel's surface stress and significantly improved its durability, and odi is unaware of any failures of shot peened wheels (service part number 7l1z-1015-b).ford's testing showed a slightly reduced durability for the non-shot peened wheels when 'lt' instead of ford approved 'p' metric type tires are used. a safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that a safety-related defect does not exist.the agency will take further action if warranted by further circumstances.

Date Opened	Date Closed	Component
2008-12-09	2009-04-15	WHEELS:RIM
2008-12-09	2009-04-15	WHEELS

Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

55 Service Alerts for 2006 FORD Expedition

Date	Description
2022-06-21	100000 POWER TRAIN Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-13	160000 STRUCTURE This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint wi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-16	110000 ELECTRICAL SYSTEM Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends ( Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-16	200000 WHEELS Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends ( Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-16	350000 EQUIPMENT Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends ( Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-07	160000 STRUCTURE Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-07	350000 EQUIPMENT Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-07	160000 STRUCTURE Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Fo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-06-01	350000 EQUIPMENT Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-06-01	060000 ENGINE (PWS) Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only cam Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-01-01	190000 TIRES VIBRATION DIAGNOSIS – TIRE/WHEEL RUNOUT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-01-01	200000 WHEELS VIBRATION DIAGNOSIS – TIRE/WHEEL RUNOUT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-08-01	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-08-01	060000 ENGINE (PWS) FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	060000 ENGINE AND ENGINE COOLING The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	061000 ENGINE AND ENGINE COOLING:ENGINE The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV) The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE) The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-21	060000 ENGINE (PWS) The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-04-24	110000 ELECTRICAL SYSTEM When ordering a 2005 to 2008 remanufactured 5.4L 3v or 6.8L 3v engine, spark plug boots may be provided in the packaging. Replace all black spark plug boots from the original engine with the ‘brown’ spark plug boots, as provided. The update Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2006-01-01	110000 ELECTRICAL SYSTEM VARIOUS ELECTRICAL CONCERNS – 3 BLOCK AUXILIARY RELAY BOX 1 CHAFING – SERVICE TIP. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-11-14	060000 ENGINE AND ENGINE COOLING WDS COP KIT DIAGNOSTIC TIP – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-01-01	033000 SERVICE BRAKES, HYDRAULIC:POWER ASSIST UNINTENDED BRAKE ASSIST. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2006-01-01	190000 TIRES LOW TIRE INDICATOR ON – TPMS SYSTEM SENSOR WAKE UP. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-05-01	106200 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-05-01	106220 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL FORD: SOME VEHICLES MAY EXHIBIT OIL SEPARATION FROM THE INTERNAL LUBE FOUND IN THE UNITIZED CARTRIDGE SEAL. OIL SEPARATION APPEARS TO BE AND IS OFTEN MISDIAGNOSED, AS AN AXLE LUBE LEAK. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-04-01	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) FORD: SOME HYBRID VEHICLES MAY EXHIBIT AN INTERMITTENT RED TRIANGLE ON AND STOP SAFELY NOW MESSAGE DISPLAYED ON THE MESSAGE CENTER, ACCOMPANIED BY A SUDDEN RPM LOSS/NO START WITH A DIAGNOSTIC TROUBLE CODE (DTC) P1A0C. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2006-01-01	030000 SERVICE BRAKES, HYDRAULIC BRAKE SHUDDER. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-01-01	061000 ENGINE AND ENGINE COOLING:ENGINE DIAGNOSTIC TROUBLE CODE (DTC) P0340 AND OR P0344-5.4 3V ENGINE. *SC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
	221700 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER CLIMATE CONTROLLED SEAT SYSTEM DTC B272D AND OR B272D. *SC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-06-07	151300 SEAT BELTS:FRONT:RETRACTOR SAFETY BELT RETRACTION SPEED. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-07-01	100000 POWER TRAIN A CLUNK/THUMP NOISE FROM THE REAR WHEN THE TRANSMISSION IS ENGAGED OR SHIFTED, DURING A CHANGE IN VEHICLE DIRECTION OR ON ACCELERATION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
	061000 ENGINE AND ENGINE COOLING:ENGINE DIAGNOSTIC TROUBLE CODES (DTC) P0340, P0344, P0345, P0349. ARE FOUND. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-01-01	061000 ENGINE AND ENGINE COOLING:ENGINE 5.4L 3V WITH P030X AND/OR P0316 ACCOMPANIED BY SPARK KNOCK. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
	103000 POWER TRAIN:AUTOMATIC TRANSMISSION UN-COMMANDED TCC APPLY ON THE 1-2 SHIFT CAUSING PERCEPTION OF HESITATION AND/OR LACK OF POWER DURING SHIFT. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-30	060000 ENGINE (PWS) LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2006-01-01	030000 SERVICE BRAKES, HYDRAULIC BRAKE SHUDDER (ROTOR THICKNESS VARIATION) DUE TO THE NEW LOW DUST FRONT BRAKE LINING USED IN PRODUCTION, OR NEW LININGS THAT WERE INSTALLED PER TSB 04-05-02. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2006-01-01	110000 ELECTRICAL SYSTEM DIAGNOSTIC TROUBLE CODES P0340/P0344/P0345/P0349 – 4.6L 3V AND 5.4L 3V. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-06-07	100000 POWER TRAIN CLUNK/GRIND/THUMP NOISE FROM REAR OF VEHICLE WHEN TRANSMISSION IS SHIFTED – VEHICLES BUILT BEFORE 6/13/2005. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-06-07	161000 STRUCTURE:FRAME AND MEMBERS CLUNK/GRIND/THUMP NOISE – FRAME REPAIR PROCEDURE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-06-01	114000 ELECTRICAL SYSTEM:WIRING SERVICE WIRING HARNESS REPLACEMENT GUIDELINES – SERVICE TIPS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
	021230 SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM AIR SUSPENSION PERFORMANCE – HEIGHT SENSOR LINKAGE ARM DISENGAGING. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2006 FORD Expedition

6 Recalls for 2006 FORD Expedition

7 Complaints sent to the Center for Auto Safety for 2006 FORD Expedition

294 Complaints submitted to NHTSA for 2006 FORD Expedition

2 Investigations for 2006 FORD Expedition

55 Service Alerts for 2006 FORD Expedition