2004 TOYOTA Highlander Recalls, Complaints and Investigations

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

5 Recalls for 2004 TOYOTA Highlander

Recall Date	Component	Summary
2011-11-09	ENGINE AND ENGINE COOLING	TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT. Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
2011-02-24	VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM. Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
2010-10-21	SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER	TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER. Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
2006-07-13	VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER’S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD. Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
2004-04-15	LATCHES/LOCKS/LINKAGES:DOORS:LATCH	CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION. Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

5 Complaints sent to the Center for Auto Safety for 2004 TOYOTA Highlander

skip to NHTSA complaints

Date			Component
2011-07-12
2011-05-12			transmission
2011-05-12			accelerator/throttle
2011-05-12			transmission
2011-05-12			engine

282 Complaints submitted to NHTSA for 2004 TOYOTA Highlander

skip to CAS complaints

Date			Component
2017-07-11			UNKNOWN OR OTHER ODI Number: 11004382
2017-04-07			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES \| TRACTION CONTROL SYSTEM ODI Number: 10971175
2016-09-13			ENGINE ODI Number: 10906228
2017-02-12			ENGINE ODI Number: 10954090
2021-01-04			SERVICE BRAKES ODI Number: 11386458
2020-09-14			ELECTRONIC STABILITY CONTROL \| STEERING \| VEHICLE SPEED CONTROL ODI Number: 11355039
2018-11-26			VEHICLE SPEED CONTROL ODI Number: 11153718
2017-09-08			SEAT BELTS ODI Number: 11022298
2016-07-13			ELECTRICAL SYSTEM ODI Number: 10884668
2016-07-07			STEERING ODI Number: 10883405
2016-06-02			AIR BAGS ODI Number: 10872252
2016-04-25			VEHICLE SPEED CONTROL ODI Number: 10861258
2016-04-10			ELECTRONIC STABILITY CONTROL ODI Number: 10854642
2016-03-29			ELECTRONIC STABILITY CONTROL ODI Number: 10852145
2016-01-21			AIR BAGS ODI Number: 10821589
2015-12-04			VISIBILITY/WIPER ODI Number: 10808336
2015-11-08			ELECTRONIC STABILITY CONTROL ODI Number: 10789080
2015-09-26			ENGINE ODI Number: 10777806
2015-09-15			TIRES:TREAD/BELT ODI Number: 10763812
2015-08-11			SEATS ODI Number: 10748001
2015-05-27			STRUCTURE:BODY \| UNKNOWN OR OTHER \| VISIBILITY/WIPER ODI Number: 10721835
2015-05-05			ENGINE ODI Number: 10714728
2015-05-05			ELECTRICAL SYSTEM ODI Number: 10714718
2015-02-04			ENGINE ODI Number: 10681355
2015-01-05			ELECTRICAL SYSTEM \| STEERING ODI Number: 10670096
2014-12-04			ENGINE ODI Number: 10662293
2014-11-20			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES ODI Number: 10659890
2014-12-02			SEAT BELTS ODI Number: 10661801
2014-11-06			AIR BAGS \| VISIBILITY/WIPER ODI Number: 10653201
2014-09-23			SERVICE BRAKES ODI Number: 10638580
2014-08-18			VISIBILITY/WIPER ODI Number: 10626190
2014-08-01			POWER TRAIN ODI Number: 10618236
2014-07-14			ELECTRICAL SYSTEM \| EXTERIOR LIGHTING ODI Number: 10610270
2014-05-12			VEHICLE SPEED CONTROL ODI Number: 10587923
2014-04-14			TIRES ODI Number: 10579640
2014-04-08			ENGINE ODI Number: 10578324
2014-01-07			SEAT BELTS ODI Number: 10558769
2013-11-27			VISIBILITY/WIPER ODI Number: 10554039
2013-12-07			VISIBILITY ODI Number: 10555197
2013-11-18			VISIBILITY/WIPER ODI Number: 10552733
2013-09-13			VEHICLE SPEED CONTROL ODI Number: 10543458
2013-07-15			FUEL SYSTEM, GASOLINE \| VEHICLE SPEED CONTROL ODI Number: 10525448
2013-05-06			EXTERIOR LIGHTING:HEADLIGHTS ODI Number: 10510792
2013-04-06			ENGINE \| POWER TRAIN ODI Number: 10507360
2013-03-14			ENGINE ODI Number: 10503016
2013-03-27			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10504763
2013-03-03			STRUCTURE:BODY ODI Number: 10501099
2013-02-20			ENGINE ODI Number: 10499444
2013-02-11			ENGINE ODI Number: 10497711
2013-02-05			ENGINE ODI Number: 10496546
2012-11-02			ENGINE ODI Number: 10482953
2012-10-29			EXTERIOR LIGHTING \| VISIBILITY/WIPER ODI Number: 10482596
2012-10-11			STEERING ODI Number: 10479785
2012-10-11			ELECTRICAL SYSTEM \| VISIBILITY:POWER WINDOW DEVICES AND CONTROLS ODI Number: 10479722
2012-10-04			VISIBILITY/WIPER ODI Number: 10478597
2012-10-03			VISIBILITY ODI Number: 10478554
2012-08-30			ENGINE ODI Number: 10473054
2012-08-27			ENGINE AND ENGINE COOLING ODI Number: 10472601
2012-07-26			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10467769
2012-07-17			ENGINE ODI Number: 10465951
2012-06-19			POWER TRAIN ODI Number: 10462268
2012-07-03			POWER TRAIN:AUTOMATIC TRANSMISSION \| POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) ODI Number: 10464064
2012-07-05			SEAT BELTS ODI Number: 10464343
2012-05-15			EQUIPMENT:APPLIANCE:AIR CONDITIONER ODI Number: 10458512
2012-04-02			POWER TRAIN ODI Number: 10453819
2012-03-02			ENGINE AND ENGINE COOLING ODI Number: 10450090
2012-02-05			ENGINE AND ENGINE COOLING ODI Number: 10446744
2012-02-01			SERVICE BRAKES, HYDRAULIC ODI Number: 10446209
2011-11-18			SERVICE BRAKES, HYDRAULIC \| VEHICLE SPEED CONTROL ODI Number: 10436406
2011-11-07			STEERING ODI Number: 10434744
2011-08-01			ENGINE AND ENGINE COOLING:ENGINE \| SERVICE BRAKES, HYDRAULIC \| TRACTION CONTROL SYSTEM \| VEHICLE SPEED CONTROL ODI Number: 10416607
2011-08-02			ELECTRICAL SYSTEM ODI Number: 10416627
2011-07-21			ELECTRICAL SYSTEM \| EQUIPMENT:APPLIANCE:AIR CONDITIONER ODI Number: 10413917
2011-06-23			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10408702
2011-06-20			VISIBILITY ODI Number: 10407470
2011-06-11			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10405945
2011-05-17			EQUIPMENT:APPLIANCE:AIR CONDITIONER ODI Number: 10401234
2011-04-19			EXTERIOR LIGHTING:BRAKE LIGHTS ODI Number: 10396837
2011-04-19			VISIBILITY ODI Number: 10396828
2011-04-13			EXTERIOR LIGHTING ODI Number: 10395715
2011-03-21			VEHICLE SPEED CONTROL ODI Number: 10392355
2011-03-28			STEERING ODI Number: 10393110
2011-02-10			ENGINE AND ENGINE COOLING ODI Number: 10381449
2011-02-15			EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) ODI Number: 10382783
2011-02-17			ENGINE AND ENGINE COOLING:COOLING SYSTEM ODI Number: 10383048
2011-02-08			EQUIPMENT:APPLIANCE:AIR CONDITIONER ODI Number: 10381108
2011-01-11			ENGINE AND ENGINE COOLING ODI Number: 10375547
2011-01-10			EQUIPMENT \| VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM ODI Number: 10375478
2010-12-28			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10372729
2010-12-20			ENGINE AND ENGINE COOLING ODI Number: 10371259
2011-01-04			ENGINE AND ENGINE COOLING ODI Number: 10374440
2010-12-11			VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM ODI Number: 10369990
2010-12-14			ENGINE AND ENGINE COOLING ODI Number: 10370659
2010-11-12			EXTERIOR LIGHTING ODI Number: 10366129
2010-11-02			SERVICE BRAKES, HYDRAULIC ODI Number: 10363659
2010-11-05			ELECTRONIC STABILITY CONTROL ODI Number: 10364915
2010-10-04			ELECTRICAL SYSTEM ODI Number: 10359091
2010-10-05			ELECTRICAL SYSTEM \| EXTERIOR LIGHTING ODI Number: 10359218
2010-08-14			VEHICLE SPEED CONTROL ODI Number: 10349373
2010-08-10			STEERING ODI Number: 10348382
2010-07-09			VEHICLE SPEED CONTROL ODI Number: 10342202
2010-06-11			VEHICLE SPEED CONTROL ODI Number: 10335791
2010-06-01			STRUCTURE:BODY:BUMPERS ODI Number: 10334006
2010-06-04			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10334610
2010-06-08			VISIBILITY:POWER WINDOW DEVICES AND CONTROLS ODI Number: 10335310
2010-05-25			EXTERIOR LIGHTING:HEADLIGHTS ODI Number: 10332158
2010-05-20			SERVICE BRAKES, HYDRAULIC ODI Number: 10331424
2010-05-22			VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM ODI Number: 10331796
2010-04-24			VISIBILITY ODI Number: 10327252
2010-04-28			ELECTRONIC STABILITY CONTROL ODI Number: 10327919
2010-04-20			STEERING ODI Number: 10326584
2010-04-05			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10323747
2010-03-18			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10320874
2010-03-05			VEHICLE SPEED CONTROL ODI Number: 10316983
2010-03-09			VEHICLE SPEED CONTROL ODI Number: 10318157
2010-03-03			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10315985
2010-02-24			STEERING ODI Number: 10313920
2010-02-24			VEHICLE SPEED CONTROL ODI Number: 10313910
2010-02-23			STEERING ODI Number: 10313128
2010-02-15			VEHICLE SPEED CONTROL ODI Number: 10310631
2010-02-17			AIR BAGS ODI Number: 10311339
2010-02-06			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10307026
2010-02-09			SERVICE BRAKES, ELECTRIC ODI Number: 10307884
2010-02-07			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10307262
2010-02-01			VEHICLE SPEED CONTROL ODI Number: 10303528
2010-02-02			VEHICLE SPEED CONTROL ODI Number: 10304074
2010-01-22			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10301891
2009-12-06			ENGINE AND ENGINE COOLING ODI Number: 10294646
2009-12-09			VEHICLE SPEED CONTROL ODI Number: 10295149
2009-11-16			ELECTRICAL SYSTEM \| EXTERIOR LIGHTING ODI Number: 10292292
2009-10-07			EXTERIOR LIGHTING ODI Number: 10286617
2009-08-25			STEERING ODI Number: 10281722
2009-06-08			ELECTRICAL SYSTEM \| POWER TRAIN:AUTOMATIC TRANSMISSION \| STEERING \| WHEELS ODI Number: 10273069
2009-05-19			STEERING ODI Number: 10269450
2009-04-23			ELECTRONIC STABILITY CONTROL ODI Number: 10266458
2009-02-16			VISIBILITY ODI Number: 10258777
2009-02-16			VISIBILITY ODI Number: 10258743
2009-02-16			ELECTRICAL SYSTEM ODI Number: 10258737
2009-02-25			ELECTRONIC STABILITY CONTROL \| STEERING ODI Number: 10259942
2009-01-19			VISIBILITY:POWER WINDOW DEVICES AND CONTROLS ODI Number: 10255594
2009-01-22			EQUIPMENT:APPLIANCE:AIR CONDITIONER ODI Number: 10255968
2009-01-19			AIR BAGS ODI Number: 10255541
2009-01-13			VISIBILITY ODI Number: 10254926
2009-01-06			ELECTRONIC STABILITY CONTROL ODI Number: 10254022
2008-12-18			VISIBILITY ODI Number: 10252173
2008-12-24			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES, HYDRAULIC ODI Number: 10252755
2009-01-07			SERVICE BRAKES, ELECTRIC ODI Number: 10254194
2008-11-27			STEERING ODI Number: 10250016
2008-11-27			ELECTRICAL SYSTEM ODI Number: 10250015
2008-12-14			ELECTRICAL SYSTEM ODI Number: 10251753
2008-11-04			STEERING ODI Number: 10247652
2008-10-31			STEERING ODI Number: 10247404
2008-10-06			EQUIPMENT ODI Number: 10244466
2008-07-07			POWER TRAIN:DRIVELINE ODI Number: 10233330
2008-06-16			STRUCTURE ODI Number: 10231110
2008-06-08			ENGINE AND ENGINE COOLING:EXHAUST SYSTEM ODI Number: 10230280
2008-04-09			EXTERIOR LIGHTING:FOG LIGHTS \| EXTERIOR LIGHTING:HEADLIGHTS ODI Number: 10223780
2008-03-18			POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT ODI Number: 10221554
2008-03-06			STEERING:RACK AND PINION:RACK ODI Number: 10220323
2008-02-27			STEERING:COLUMN ODI Number: 10219261
2008-03-12			EXTERIOR LIGHTING:HEADLIGHTS ODI Number: 10220964
2008-03-13			ELECTRONIC STABILITY CONTROL \| VEHICLE SPEED CONTROL ODI Number: 10221087
2008-01-07			ELECTRONIC STABILITY CONTROL ODI Number: 10214029
2008-01-18			FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP ODI Number: 10215399
2008-01-18			SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER ODI Number: 10215385
2007-12-30			STEERING:RACK AND PINION:PINION SHAFT ODI Number: 10213223
2007-12-06			EXTERIOR LIGHTING ODI Number: 10211695
2007-12-24			STEERING:COLUMN ODI Number: 10212641
2007-11-09			ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC) \| VISIBILITY:WINDSHIELD WIPER/WASHER ODI Number: 10208507
2007-10-21			TIRES:TREAD/BELT ODI Number: 10206425
2007-10-30			SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP \| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT ODI Number: 10207457
2007-10-08			STEERING: STEERING WHEEL/HANDLE BAR ODI Number: 10205189
2007-09-13			STEERING ODI Number: 10203753
2007-08-02			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10198279
2007-07-30			SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES ODI Number: 10197846
2007-07-30			POWER TRAIN:MANUAL TRANSMISSION ODI Number: 10197844
2007-07-30			VISIBILITY:SUN/MOON ROOF ASSEMBLY ODI Number: 10197842
2007-06-22			SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP ODI Number: 10193972
2007-06-15			VEHICLE SPEED CONTROL ODI Number: 10193437
2007-06-20			STEERING:GEAR BOX:SHAFT SECTOR ODI Number: 10193839
2007-05-16			SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP ODI Number: 10190922
2007-05-08			STEERING:COLUMN ODI Number: 10190213
2007-04-26			STEERING:GEAR BOX:SHAFT SECTOR \| STEERING:RACK AND PINION:RACK ODI Number: 10188944
2007-03-21			STEERING:COLUMN ODI Number: 10185765
2007-03-04			STEERING ODI Number: 10184188
2006-12-30			STEERING ODI Number: 10177404
2006-12-01			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10174949
2006-11-22			POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT ODI Number: 10174054
2006-12-09			TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS ODI Number: 10175675
2006-11-13			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10173375
2006-09-15			UNKNOWN OR OTHER ODI Number: 10168408
2006-08-22			TIRES:TREAD/BELT ODI Number: 10166227
2006-09-01			SERVICE BRAKES, HYDRAULIC ODI Number: 10167210
2006-08-17			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10165742
2006-07-27			TIRES:SIDEWALL ODI Number: 10163632
2006-07-31			FUEL SYSTEM, GASOLINE \| VEHICLE SPEED CONTROL ODI Number: 10164775
2006-06-29			POWER TRAIN:AUTOMATIC TRANSMISSION \| VEHICLE SPEED CONTROL ODI Number: 10161055
2006-07-13			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10162279
2006-07-18			ELECTRICAL SYSTEM ODI Number: 10162736
2006-06-09			SERVICE BRAKES, HYDRAULIC ODI Number: 10159371
2006-06-08			VEHICLE SPEED CONTROL ODI Number: 10159337
2006-04-29			STEERING ODI Number: 10156443
2006-05-08			ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR ODI Number: 10157016
2006-03-09			EQUIPMENT:MECHANICAL:ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT \| WHEELS:LUGS/NUTS/BOLTS ODI Number: 10152350
2006-03-18			STEERING:LINKAGES:ROD:RELAY:CONNECTING ODI Number: 10153101
2006-01-25			ELECTRICAL SYSTEM \| POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10148539
2006-02-06			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10149501
2006-01-27			TIRES ODI Number: 10148854
2005-12-16			ELECTRICAL SYSTEM \| STEERING ODI Number: 10145437
2005-12-06			FUEL SYSTEM, GASOLINE:DELIVERY \| POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10144572
2006-01-02			ELECTRICAL SYSTEM \| FUEL SYSTEM, GASOLINE \| STEERING ODI Number: 10146704
2005-11-06			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10141879
2005-11-21			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10143398
2005-11-14			ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL \| VEHICLE SPEED CONTROL ODI Number: 10142635
2005-12-01			VEHICLE SPEED CONTROL ODI Number: 10144140
2005-10-15			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10139796
2005-08-23			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10134521
2005-08-12			VISIBILITY:REARVIEW MIRRORS/DEVICES ODI Number: 10133437
2005-07-15			POWER TRAIN:AUTOMATIC TRANSMISSION \| POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) ODI Number: 10128904
2005-07-13			ENGINE AND ENGINE COOLING \| TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS ODI Number: 10128624
2005-06-04			TIRES:TREAD/BELT ODI Number: 10124188
2005-06-22			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10126228
2005-06-22			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10126222
2005-05-16			VEHICLE SPEED CONTROL ODI Number: 10120992
2005-05-17			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10121231
2005-05-09			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10120348
2005-05-27			SERVICE BRAKES, HYDRAULIC:POWER ASSIST ODI Number: 10122365
2005-05-03			VISIBILITY ODI Number: 10119413
2005-05-02			FUEL SYSTEM, OTHER ODI Number: 10119373
2005-03-23			ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC) ODI Number: 10114548
2005-02-18			STRUCTURE:BODY ODI Number: 10111786
2005-02-16			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10111632
2005-02-20			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10111830
2005-02-14			POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) ODI Number: 10110539
2005-02-01			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10108342
2005-01-24			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10107842
2005-02-12			LATCHES/LOCKS/LINKAGES:DOORS:LATCH ODI Number: 10110411
2005-02-16			SEAT BELTS:FRONT ODI Number: 10108274
2005-01-11			STEERING:HYDRAULIC POWER ASSIST SYSTEM ODI Number: 10107233
2005-01-03			AIR BAGS:SIDE/WINDOW ODI Number: 10105672
2004-12-23			POWER TRAIN:AUTOMATIC TRANSMISSION \| VEHICLE SPEED CONTROL ODI Number: 10104409
2004-12-21			SERVICE BRAKES, HYDRAULIC ODI Number: 10101828
2004-12-21			LATCHES/LOCKS/LINKAGES ODI Number: 10104267
2004-11-09			POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL) ODI Number: 10101457
2004-11-19			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10100216
2004-12-07			VISIBILITY:GLASS, SIDE/REAR ODI Number: 10099140
2004-11-22			FUEL SYSTEM, GASOLINE:DELIVERY ODI Number: 10100327
2004-10-29			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10097988
2004-10-16			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10095883
2004-10-24			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10096327
2004-10-19			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10096006
2004-10-15			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10095823
2004-10-20			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10096134
2004-10-14			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10095798
2004-10-12			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10095601
2004-10-25			POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) ODI Number: 10096372
2004-09-18			VEHICLE SPEED CONTROL ODI Number: 10091231
2004-10-05			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10093622
2004-09-09			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10090696
2004-09-16			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10091128
2004-09-28			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10093251
2004-09-14			POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER ODI Number: 10090951
2004-09-14			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10090943
2004-09-30			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10093384
2004-09-10			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10090804
2004-09-30			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10093383
2004-08-22			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10088361
2004-08-20			SEATS:FRONT ASSEMBLY:HEAD RESTRAINT ODI Number: 10089354
2004-08-29			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10088769
2004-08-23			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10088430
2005-03-07			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10086822
2004-08-20			SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP ODI Number: 10083782
2004-07-29			EXTERIOR LIGHTING:HEADLIGHTS ODI Number: 10082925
2004-08-02			STRUCTURE:BODY ODI Number: 10083154
2004-06-27			EQUIPMENT:MECHANICAL:ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT ODI Number: 10078895
2004-04-13			VEHICLE SPEED CONTROL ODI Number: 10066047
2004-03-19			AIR BAGS:FRONTAL ODI Number: 10062599
2004-03-15			STRUCTURE:BODY ODI Number: 10062206
2010-08-18			ENGINE AND ENGINE COOLING:COOLING SYSTEM \| VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT ODI Number: 10350400
2010-05-04			ELECTRONIC STABILITY CONTROL \| TRACTION CONTROL SYSTEM ODI Number: 10328900
2010-02-16			VEHICLE SPEED CONTROL ODI Number: 10310900
2004-09-19			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10091300

Is the government investigating the safety of your vehicle? Find out here.

2 Investigations for 2004 TOYOTA Highlander

On february 16, 2010, nhtsa's office of defects investigation (odi) opened rq10-003 to determine whether the scope of prior toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, toyota recalls 07e-082, 09v-388, 10v-017, and 10v-023.nhtsa also requested information regarding potential electronic causes of unintended acceleration in toyota and lexus vehicles.i. pedal interference from floor mats, carpet covers and plastic pads in carpets.during the rq10-003 investigation, odi reviewed a large volume of documents to assess whether additional vehicles should be recalled.following the agency's analysis, nhtsa requested that toyota recall additional vehicles.toyota complied with the agency's request.the details of these recalls are set forth more fully in toyota's reports to nhtsa pursuant to 49 cfr part 573.these recalls are as follows:recall 11v-112: (1) model year (my) 2004-2006 toyota highlander and highlander hybrid; and, (2) my 2004-2007 lexus rx330,rx350, and rx400h (hybrid model). the total estimated population under this recall is 769,379 vehicles.this recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). recall 11v-113: (1) my 2003-2009 through 2009 toyota 4runner; (2) my 2006-2010 toyota rav4; and, (3) my 2008-2011 lexus lx570.the total estimated population under this recall is 1,381,000 vehicles.this recall supplements recall 09v-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.recall 11v-115: (1) my 2006-2007 lexus gs300 (all wheel drive vehicles); and, (2) my 2006-2007 lexus gs350 (all wheel drive vehicles). the total estimated population under this recall is 19,647 vehicles.this recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.ii. potential electronic causes of unintended acceleration.after nhtsa opened rq10-003, nhtsa launched a ten-month study of potential electronic causes of unintended acceleration in toyota vehicles.nhtsa launched the study in the spring of 2010 in light of concerns aired in congressional hearings.nhtsa enlisted engineers at the national aeronautics and space administration (nasa) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in toyota vehicles.that study has concluded.two reports are associated with the study and are available on nhtsa's website.nasa's report is entitled "technical support to the national highway traffic safety administration (nhtsa) on the reported toyota motor corporation (tmc) unintended acceleration (ua) investigation," nesc assessment no. ti-10-00618 (jan. 18, 2011).nhtsa's report is entitled "technical assessment of toyota electronic throttle control (etc) systems" (feb. 2011).both reports should be read in conjunction with each other. as stated in its report, nasa did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. nhtsa did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by toyota's recalls. this rq is closed.

Date Opened	Date Closed	Component
2010-02-16	2011-03-01	VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
2010-02-16	2011-03-01	ELECTRICAL SYSTEM:SOFTWARE

Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

160 Service Alerts for 2004 TOYOTA Highlander

Date	Description
2022-04-14	350000 EQUIPMENT Toyota Safety Recall and Service Campaign – Technician Certification Requirements 4.14.2022 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-17	030000 SERVICE BRAKES, HYDRAULIC TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-17	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-09	050000 PARKING BRAKE TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the Repair Procedure in this bulletin to replace the loose or damaged carpet floor retai Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	190000 TIRES POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	200000 WHEELS POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2001-05-04	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Replacement vin plates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1991-01-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1989-06-30	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1993-04-09	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1991-01-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-17	140000 AIR BAGS Toyota Safety Recall and Service Campaign – Technician Certification Requirements Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-12	030000 BRAKES (PWS) TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-12	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-02-03	350000 EQUIPMENT TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	030000 BRAKES (PWS) TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	030000 SERVICE BRAKES, HYDRAULIC TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-23	020000 SUSPENSION TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see T-SB-0063-20. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-23	200000 WHEELS TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-07	350000 EQUIPMENT TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-06	350000 EQUIPMENT TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-02-12	350000 EQUIPMENT OBSOLETE NOTICE February 12, 2020: This bulletin is now obsolete. Please see T-SB-0010-20. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-01-27	350000 EQUIPMENT TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	100000 POWER TRAIN TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	110000 ELECTRICAL SYSTEM TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	060000 ENGINE (PWS) TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-14	060000 ENGINE (PWS) TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-14	110000 ELECTRICAL SYSTEM TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-01-06	110000 ELECTRICAL SYSTEM TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-21	350000 EQUIPMENT Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-21	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-07-31	350000 EQUIPMENT TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	350000 EQUIPMENT Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	355100 EQUIPMENT:OTHER:LABELS Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	350000 EQUIPMENT Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	355100 EQUIPMENT:OTHER:LABELS Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-08-24	100000 POWER TRAIN TechTip: Condition – The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	110000 ELECTRICAL SYSTEM Some customers may complain that the Rear Seat Entertainment (RSE) system is inoperative if they have misplaced the parental passcode for the system. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	220000 SEATS Some customers may complain that the Rear Seat Entertainment (RSE) system is inoperative if they have misplaced the parental passcode for the system. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	355100 EQUIPMENT:OTHER:LABELS This bulletin is now obsolete. Please see T-SB-0054-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	350000 EQUIPMENT California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-04	280000 BACK OVER PREVENTION If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-04	358100 EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-20	140000 AIR BAGS TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-20	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-01	100000 POWER TRAIN The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-19	130000 VISIBILITY/WIPER (PWS) This bulletin is now obsolete. Please see T-SB-0185-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-19	130000 VISIBILITY The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-23	132000 VISIBILITY:GLASS, SIDE/REAR The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	110000 ELECTRICAL SYSTEM These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	353000 EQUIPMENT:ELECTRICAL These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	140000 AIR BAGS Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	220000 SEATS Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	350000 EQUIPMENT Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-21	140000 AIR BAGS Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-12	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	050000 PARKING BRAKE A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	350000 EQUIPMENT A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-11	118000 ELECTRICAL SYSTEM:SOFTWARE Tech Tip: Some customers may experience difficulty programming HomeLink. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	060000 ENGINE (PWS) TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-14	140000 AIR BAGS Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-11-21	350000 EQUIPMENT TSB: OBSOLETE NOTICE November 21, 2017: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-23	190000 TIRES Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-28	350000 EQUIPMENT Customer complains of Bluetooth connectivity concerns such as: Difficulty to pair phone, Intermittent Bluetooth failure to connect to the vehicle when first turning on the vehicle. These concerns can be caused by changes made on the custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-05	030000 SERVICE BRAKES, HYDRAULIC A key part to maintain the proper function and safe operation of the vehicle’s braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-05	350000 EQUIPMENT A key part to maintain the proper function and safe operation of the vehicle’s braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-27	110000 ELECTRICAL SYSTEM The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-20	100000 POWER TRAIN This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-11-22	110000 ELECTRICAL SYSTEM TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-07	980000 UNKNOWN OR OTHER TSB: OBSOLETE NOTICE: July 7, 2014: This bulletin is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-07	353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-12	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-25	353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-03-08	110000 ELECTRICAL SYSTEM TT: Some customers may encounter Bluetooth connectivity concerns such as: ? Difficulty pairing the phone. ? Intermittent Bluetooth failure to connect when first turning on the vehicle. ? Various Bluetooth Audio functions are no lon Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-07	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-01	060000 ENGINE (PWS) Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-01	280000 BACK OVER PREVENTION Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-03	110000 ELECTRICAL SYSTEM Some customers may complain that the Rear Seat Entertainment (RSE) system is inoperative if the have misplaced the parental passcode for the system. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-11-10	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Some 2004 ? 2017 model year Toyota vehicles may exhibit odor Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-11-29	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	060000 ENGINE (PWS) TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-04	162000 STRUCTURE:BODY Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-02-12	190000 TIRES TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-02-12	190000 TIRES TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-01-11	350000 EQUIPMENT TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-11	350000 EQUIPMENT TECH TIP: SOME CUSTOMERS MAY EXPERIENCE DIFFICULTY PROGRAMMING HOMELINK. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This bulletin is now obsolete. Please see T-SB-0012-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	118000 ELECTRICAL SYSTEM:SOFTWARE Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-02	118000 ELECTRICAL SYSTEM:SOFTWARE Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Toyota will be sending Safety Recall Follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Toyota will be sending Safety Recall Follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-03	140000 AIR BAGS Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-10-30	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-10-27	162300 STRUCTURE:BODY:DOOR TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	060000 ENGINE (PWS) TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. THIS BUL Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	110000 ELECTRICAL SYSTEM TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-06-13	181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2003-08-04	980000 UNKNOWN OR OTHER 2004 MODEL YEAR PRE-DELIVERY SERVICE (PDS). ALL ’04 MODELS EXCEPT PRIUS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-04-05	110000 ELECTRICAL SYSTEM PASSENGER AIRBAG INDICATOR LAMP MAY SWITCH FROM ON TO OFF FOR FRONT SEAT PASSENGERS WEIGHING APPROXIMATELY LESS THAN 100 POUNDS. TOYOTA. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-05-23	110000 ELECTRICAL SYSTEM OCCUPANT CLASSIFICATION SYSTEM: DTC B1785. THE SRS AND PASSENGER AIRBAG OFF INDICATOR LIGHTS REMAIN ON. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2006-12-04	030000 SERVICE BRAKES, HYDRAULIC TIRE PRESSURE WARNING SYSTEM LIGHT ON. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-12-20	162300 STRUCTURE:BODY:DOOR FRONT DOOR OPENING WEATHERSTRIP BECOMES LOOSE OR COMES OFF EASILY. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-03-01	980000 UNKNOWN OR OTHER INSTALLATION INSTRUCTION CHANGE. *MR Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-03-01	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER A/C COMPRESSOR INSTALLATION PROCEDURE. *MR Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2003-11-04	162810 STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS ACCESSORY HOOD PROTECTOR WITH WEATHERSTRIP. REVISED. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	110000 ELECTRICAL SYSTEM TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	353000 EQUIPMENT:ELECTRICAL TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-23	353000 EQUIPMENT:ELECTRICAL TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	110000 ELECTRICAL SYSTEM TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	060000 ENGINE (PWS) TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-23	353000 EQUIPMENT:ELECTRICAL TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	100000 POWER TRAIN TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-03-02	060000 ENGINE AND ENGINE COOLING TOYOTA: THERE MAY BE DAMAGED CYLINDER HEAD BOLTS THREADS. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-05-07	061000 ENGINE AND ENGINE COOLING:ENGINE EXCESSIVE SULFUR DIOXIDE ODOR. TT UPDATE. TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-02-26	110000 ELECTRICAL SYSTEM OCCUPANT CLASSIFICATION SYSTEM INITIALIZATION (DIAGNOSTIC TROUBLE CODE B1150 & B1650). *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-02-18	061000 ENGINE AND ENGINE COOLING:ENGINE MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0346 (CAMSHAFT POSITION SENSOR). *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-02-09	060000 ENGINE AND ENGINE COOLING MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0031, P0051, P2238 AND/OR P2241. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-02-10	162300 STRUCTURE:BODY:DOOR WIND NOISE COMING FROM BOTH THE FRONT AND REAR DOOR WINDOW GLASS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-09-03	061000 ENGINE AND ENGINE COOLING:ENGINE ENGINE BANK 1 AND BANK 2 A/F AND 02 IDENTIFICATION. VARIOUS TOYOTA MODELS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-04-19	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: 2AZ-FE & 2AZ-FXE THROTTLE BODY. ENGINE CONTROL. PROVIDE UPDATED THROTTLE BODY PART NUMBER INFORMATION FOR CERTAIN VEHICLES. THE DRAIN PIPE HAS BEEN ELIMINATED ON THROTTLE BODY SERVICE PARTS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-02-04	980000 UNKNOWN OR OTHER ZERO POINT CALIBRATION. MR TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-05-27	353000 EQUIPMENT:ELECTRICAL DIAGNOSTIC GUIDE FOR REAR SEAT ENTERTAINMENT SYSTEMS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-09-06	140000 AIR BAGS TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-09-06	220000 SEATS TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	050000 PARKING BRAKE SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2006-05-09	061000 ENGINE AND ENGINE COOLING:ENGINE NO START IN SUB-FREEZING AMBIENT AIR TEMPERATURES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-10-07	199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS TIRE PRESSURE WARNING SYSTEM INFORMATION AND RE-INITIALIZATION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2003-11-04	162810 STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS ACCESSORY HOOD PROTECTOR WITH WEATHERSTRIP. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-11-30	030000 SERVICE BRAKES, HYDRAULIC INTERMITTENT VSC ACTIVATION AFTER STARTING THE ENGINE AND DRIVING STRAIGHT FROM A STOP POSITION. THIS CONDITION IS ALWAYS ACCOMPANIED BY THE INSTRUMENT PANEL VSC LIGHT AND AUDIBLE WARNING BUZZER TURNING ON AT THE SAME TIME. *NM UPDATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-11-12	061000 ENGINE AND ENGINE COOLING:ENGINE REPAIR MANUAL SUPPLEMENT: LEV II EVAP SYSTEM CHECK – DIAGNOSTIC TROUBLE CODE (DTC) P0441, P0442, P0446, P0451, P0452, P0453, P0455 AND P0456. *NM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-01	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-03-24	061000 ENGINE AND ENGINE COOLING:ENGINE FUEL INJECTOR TICKING NOISE. UPDATE. TT ORIGINAL. TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-06-03	100000 POWER TRAIN ENGINE CONTROL MODULE (ECM) CALIBRATION: TRANSMISSION SHIFT FEELING ENHANCEMENT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-06-03	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER COUNTERMEASURES TO THE AIR CONDITIONER (A/C) MAGNETIC CLUTCH RELAY FOR A/C LIGHT FLASHING (INOPERATIVE A/C) ISSUES ON SOME VEHICLES EQUIPPED WITH A MAGNETIC CLUTCH COMPRESSOR. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2008-04-15	121000 EXTERIOR LIGHTING:HEADLIGHTS SOME 2004-07 MODEL YEAR HIGHLANDER OR 2006-07 MODEL YEAR HIGHLANDER HV VEHICLES MAY EXHIBIT A CONDITION WHERE THE HEADLIGHT LENS COVER AND/OR HEADLIGHT BULB IS DISCOLORED. *NJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-07-29	134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY MOON ROOF INITIALIZATION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-04-06	100000 POWER TRAIN THE PROPER IDENTIFICATION OF THE 7 SOLENOIDS USED IN THE U151E/U151F TRANSMISSIONS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2006-02-16	013100 STEERING:GEAR BOX:SHAFT SECTOR STEERING INTERMEDIATE SHAFT NOISE. *AK Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-08-01	100000 POWER TRAIN U140F TRANSMISSION SOLENOID IDENTIFICATION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-09-08	061000 ENGINE AND ENGINE COOLING:ENGINE ACCESSORY DRIVE BELT SQUEAL/ BELT TENSIONER RATTLE. *NM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2007-04-26	980000 UNKNOWN OR OTHER TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-04	190000 TIRES SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2005-01-12	210000 TRAILER HITCHES THE WELD STUD ON THE 2004 AND 2005 MODEL YEAR HIGHLANDER TOWING RECEIVER HITCH ACCESSORY BRACKET TORQUE SPECIFICATION HAS CHANGED. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-08-10	353000 EQUIPMENT:ELECTRICAL POWER WINDOW / ROOF INITIALIZATION PROCEDURES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-08-23	061000 ENGINE AND ENGINE COOLING:ENGINE MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0031 AND/OR P2238. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2004-08-26	103000 POWER TRAIN:AUTOMATIC TRANSMISSION PROPER IDENTIFICATION OF THE 5 SOLENOIDS USED IN THE U240E/U241E AUTOMATIC TRANSAXLES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-02-04	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2003-09-17	980000 UNKNOWN OR OTHER PRE-DELIVERY SERVICE (PDS) INFORMATION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2004 TOYOTA Highlander

5 Recalls for 2004 TOYOTA Highlander

5 Complaints sent to the Center for Auto Safety for 2004 TOYOTA Highlander

282 Complaints submitted to NHTSA for 2004 TOYOTA Highlander

2 Investigations for 2004 TOYOTA Highlander

160 Service Alerts for 2004 TOYOTA Highlander