Skip to content
2002 TOYOTA Prius
2 Recalls for 2002 TOYOTA Prius
| Recall Date | Component | Summary |
|---|---|---|
| 2011-06-01 | STEERING:ELECTRIC POWER ASSIST SYSTEM | TOYOTA IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2003 PRIUS PASSENGER CARS MANUFACTURED FROM JANUARY 28, 2000, THROUGH MAY 30, 2003. THE STEERING LINKAGE MAY LOOSEN, RESULTING IN REDUCED ELECTRIC STEERING ASSISTANCE WHEN MAKING A LEFT TURN. Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE NUTS IN THE STEERING LINKAGE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 8, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331. |
| 2006-07-19 | ENGINE AND ENGINE COOLING | ON CERTAIN PASSENGER VEHICLES, DUE TO IMPROPER MOLDING OF THE RESIN BODY OF THE CRANKSHAFT POSITION SENOR INSTALLED ON THE ENGINE BLOCK, ENGINE OIL MAY PENETRATE THE SEAL AND ENTER THE SENSOR WIRING CONNECTOR. THE WIRE HARNESS CONNECTOR MAY NOT BE SUFFICIENTLY ATTACHED TO THE LOCKING TAB OF THE SENSOR WIRING CONNECTOR. Remedy: DEALERS WILL REPLACE THE CRANKSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON JULY 26, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331. |
3 Complaints sent to the Center for Auto Safety for 2002 TOYOTA Prius
| Date | Component | |||
|---|---|---|---|---|
| 2017-07-05 | ||||
| 2011-05-12 | steering | |||
| 2011-05-12 | driveline (differential, transfer case, u-joints) |
167 Complaints submitted to NHTSA for 2002 TOYOTA Prius
| Date | Component | |||
|---|---|---|---|---|
| 2010-03-10 |
SERVICE BRAKES, HYDRAULIC | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 10318625 | |||
| 2010-03-08 |
ELECTRICAL SYSTEM | STEERING:HYDRAULIC POWER ASSIST SYSTEM
ODI Number: 10317566 | |||
| 2016-10-18 |
ELECTRICAL SYSTEM | FUEL/PROPULSION SYSTEM
ODI Number: 10917169 | |||
| 2016-09-26 |
STEERING
ODI Number: 10909742 | |||
| 2020-09-22 |
STEERING
ODI Number: 11360535 | |||
| 2020-09-22 |
SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 11360482 | |||
| 2020-01-25 |
EXTERIOR LIGHTING
ODI Number: 11301782 | |||
| 2020-02-02 |
STEERING
ODI Number: 11306536 | |||
| 2019-11-22 |
STEERING
ODI Number: 11281901 | |||
| 2019-05-20 |
STEERING
ODI Number: 11208587 | |||
| 2019-04-14 |
STEERING
ODI Number: 11196121 | |||
| 2018-09-28 |
STEERING
ODI Number: 11132139 | |||
| 2017-12-29 |
STEERING
ODI Number: 11057469 | |||
| 2016-04-22 |
STEERING
ODI Number: 10860969 | |||
| 2016-04-15 |
STEERING
ODI Number: 10859763 | |||
| 2015-11-16 |
STEERING
ODI Number: 10790663 | |||
| 2015-04-03 |
STEERING
ODI Number: 10703517 | |||
| 2015-03-13 |
STEERING:RACK AND PINION
ODI Number: 10694049 | |||
| 2015-03-06 |
STEERING
ODI Number: 10692550 | |||
| 2015-01-02 |
STEERING
ODI Number: 10669531 | |||
| 2014-11-11 |
STEERING
ODI Number: 10654276 | |||
| 2014-09-18 |
STEERING
ODI Number: 10637285 | |||
| 2014-03-21 |
STEERING
ODI Number: 10573965 | |||
| 2014-01-23 |
STEERING
ODI Number: 10561265 | |||
| 2014-01-13 |
ELECTRICAL SYSTEM | STEERING
ODI Number: 10559537 | |||
| 2013-12-01 |
STEERING
ODI Number: 10554286 | |||
| 2013-10-28 |
SERVICE BRAKES
ODI Number: 10549793 | |||
| 2013-10-24 |
STEERING
ODI Number: 10549318 | |||
| 2013-09-05 |
STEERING
ODI Number: 10542178 | |||
| 2013-08-06 |
VEHICLE SPEED CONTROL
ODI Number: 10533835 | |||
| 2013-07-16 |
STEERING
ODI Number: 10525124 | |||
| 2013-04-03 |
STEERING
ODI Number: 10505563 | |||
| 2013-03-20 |
STEERING:ELECTRIC POWER ASSIST SYSTEM
ODI Number: 10503828 | |||
| 2013-03-04 |
SERVICE BRAKES
ODI Number: 10501175 | |||
| 2013-03-04 |
STEERING
ODI Number: 10501172 | |||
| 2013-01-03 |
ELECTRICAL SYSTEM
ODI Number: 10490855 | |||
| 2013-01-03 |
STEERING
ODI Number: 10490854 | |||
| 2013-01-04 |
STEERING
ODI Number: 10491440 | |||
| 2012-11-15 |
STEERING
ODI Number: 10484748 | |||
| 2012-10-06 |
ELECTRICAL SYSTEM | ELECTRONIC STABILITY CONTROL
ODI Number: 10478896 | |||
| 2012-03-09 |
STEERING
ODI Number: 10451025 | |||
| 2012-01-09 |
STEERING
ODI Number: 10443150 | |||
| 2011-12-02 |
STEERING
ODI Number: 10438105 | |||
| 2011-11-15 |
STEERING:ELECTRIC POWER ASSIST SYSTEM
ODI Number: 10435707 | |||
| 2011-07-26 |
ENGINE AND ENGINE COOLING | STEERING:ELECTRIC POWER ASSIST SYSTEM | VEHICLE SPEED CONTROL
ODI Number: 10415148 | |||
| 2011-06-02 |
STEERING
ODI Number: 10404245 | |||
| 2011-01-30 |
STEERING
ODI Number: 10379577 | |||
| 2011-01-29 |
STEERING
ODI Number: 10379557 | |||
| 2011-01-29 |
SERVICE BRAKES, ELECTRIC | SERVICE BRAKES, HYDRAULIC
ODI Number: 10379516 | |||
| 2010-12-14 |
STEERING
ODI Number: 10370601 | |||
| 2010-12-15 |
STEERING
ODI Number: 10370737 | |||
| 2010-11-15 |
STEERING
ODI Number: 10365853 | |||
| 2010-11-10 |
ELECTRICAL SYSTEM
ODI Number: 10365308 | |||
| 2010-10-05 |
STEERING
ODI Number: 10359279 | |||
| 2010-10-15 |
UNKNOWN OR OTHER
ODI Number: 10360899 | |||
| 2010-09-23 |
STEERING
ODI Number: 10357256 | |||
| 2010-07-29 |
STEERING
ODI Number: 10346103 | |||
| 2010-08-05 |
STEERING
ODI Number: 10347471 | |||
| 2010-07-27 |
STEERING
ODI Number: 10345615 | |||
| 2010-06-16 |
SERVICE BRAKES, HYDRAULIC
ODI Number: 10336682 | |||
| 2010-06-11 |
STEERING
ODI Number: 10335842 | |||
| 2010-06-11 |
STEERING
ODI Number: 10335829 | |||
| 2010-04-06 |
SERVICE BRAKES, HYDRAULIC | VEHICLE SPEED CONTROL
ODI Number: 10324246 | |||
| 2010-03-30 |
STEERING
ODI Number: 10322916 | |||
| 2010-03-19 |
SERVICE BRAKES, HYDRAULIC
ODI Number: 10320924 | |||
| 2010-03-17 |
SERVICE BRAKES, HYDRAULIC
ODI Number: 10320493 | |||
| 2010-03-10 |
SERVICE BRAKES, HYDRAULIC | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 10318625 | |||
| 2010-03-08 |
ELECTRICAL SYSTEM | STEERING:HYDRAULIC POWER ASSIST SYSTEM
ODI Number: 10317566 | |||
| 2010-03-03 |
STEERING
ODI Number: 10316137 | |||
| 2010-02-25 |
SERVICE BRAKES, HYDRAULIC
ODI Number: 10314276 | |||
| 2010-03-03 |
STEERING
ODI Number: 10316104 | |||
| 2010-02-23 |
VEHICLE SPEED CONTROL
ODI Number: 10313092 | |||
| 2010-02-15 |
ELECTRICAL SYSTEM | POWER TRAIN:AXLE ASSEMBLY
ODI Number: 10310513 | |||
| 2010-02-04 |
SERVICE BRAKES, ELECTRIC
ODI Number: 10305938 | |||
| 2010-02-09 |
SERVICE BRAKES, HYDRAULIC | TRACTION CONTROL SYSTEM | VEHICLE SPEED CONTROL
ODI Number: 10307794 | |||
| 2010-02-09 |
SERVICE BRAKES, HYDRAULIC | TRACTION CONTROL SYSTEM
ODI Number: 10307761 | |||
| 2010-02-04 |
VEHICLE SPEED CONTROL
ODI Number: 10306160 | |||
| 2010-02-09 |
SERVICE BRAKES, HYDRAULIC | VEHICLE SPEED CONTROL
ODI Number: 10307865 | |||
| 2010-02-09 |
SERVICE BRAKES, ELECTRIC
ODI Number: 10308008 | |||
| 2010-02-06 |
VEHICLE SPEED CONTROL
ODI Number: 10307057 | |||
| 2010-02-09 |
STEERING
ODI Number: 10307994 | |||
| 2010-01-19 |
STEERING
ODI Number: 10300253 | |||
| 2009-11-09 |
EXTERIOR LIGHTING:HEADLIGHTS
ODI Number: 10291481 | |||
| 2009-10-29 |
SERVICE BRAKES, HYDRAULIC
ODI Number: 10290212 | |||
| 2009-08-31 |
STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
ODI Number: 10282424 | |||
| 2009-07-23 |
POWER TRAIN
ODI Number: 10278141 | |||
| 2009-05-15 |
TIRES
ODI Number: 10268839 | |||
| 2009-02-18 |
ENGINE AND ENGINE COOLING | SERVICE BRAKES, HYDRAULIC
ODI Number: 10259245 | |||
| 2009-02-20 |
ELECTRICAL SYSTEM
ODI Number: 10259448 | |||
| 2009-02-04 |
STEERING
ODI Number: 10257478 | |||
| 2009-01-17 |
STEERING
ODI Number: 10255422 | |||
| 2009-01-08 |
SERVICE BRAKES, HYDRAULIC
ODI Number: 10254313 | |||
| 2009-01-02 |
STEERING
ODI Number: 10253545 | |||
| 2008-10-15 |
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
ODI Number: 10245605 | |||
| 2008-08-15 |
STEERING
ODI Number: 10238360 | |||
| 2008-07-27 |
STEERING
ODI Number: 10235943 | |||
| 2008-05-12 |
ENGINE AND ENGINE COOLING
ODI Number: 10227397 | |||
| 2008-02-12 |
TIRES
ODI Number: 10217791 | |||
| 2008-01-22 |
ELECTRICAL SYSTEM | STEERING:GEAR BOX:SHAFT SECTOR
ODI Number: 10215661 | |||
| 2007-10-09 |
STEERING:RACK AND PINION
ODI Number: 10205275 | |||
| 2007-10-15 |
STEERING:RACK AND PINION
ODI Number: 10205751 | |||
| 2007-09-26 |
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS | POWER TRAIN:AXLE ASSEMBLY
ODI Number: 10204905 | |||
| 2007-09-06 |
SEAT BELTS:FRONT
ODI Number: 10202673 | |||
| 2007-07-24 |
SUSPENSION:REAR
ODI Number: 10198038 | |||
| 2007-04-05 |
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
ODI Number: 10187099 | |||
| 2007-02-14 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10182540 | |||
| 2007-01-10 |
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
ODI Number: 10178383 | |||
| 2007-01-02 |
ELECTRICAL SYSTEM
ODI Number: 10177550 | |||
| 2006-11-29 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10174640 | |||
| 2006-10-04 |
SUSPENSION | TIRES
ODI Number: 10171185 | |||
| 2006-09-28 |
STEERING:ELECTRIC POWER ASSIST SYSTEM
ODI Number: 10169560 | |||
| 2006-08-24 |
STEERING:ELECTRIC POWER ASSIST SYSTEM
ODI Number: 10166452 | |||
| 2006-09-12 |
STEERING:COLUMN
ODI Number: 10167957 | |||
| 2006-09-04 |
SERVICE BRAKES, HYDRAULIC:POWER ASSIST
ODI Number: 10167311 | |||
| 2006-07-14 |
STEERING:ELECTRIC POWER ASSIST SYSTEM
ODI Number: 10162369 | |||
| 2006-07-14 |
STEERING:ELECTRIC POWER ASSIST SYSTEM | STEERING:RACK AND PINION
ODI Number: 10162368 | |||
| 2006-07-14 |
STEERING:ELECTRIC POWER ASSIST SYSTEM
ODI Number: 10162367 | |||
| 2006-02-17 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 10150556 | |||
| 2006-01-24 |
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
ODI Number: 10148436 | |||
| 2005-11-28 |
ELECTRICAL SYSTEM | POWER TRAIN:AXLE ASSEMBLY | VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
ODI Number: 10143809 | |||
| 2005-10-15 |
SUSPENSION | TIRES:TREAD/BELT
ODI Number: 10139794 | |||
| 2005-10-06 |
UNKNOWN OR OTHER
ODI Number: 10139899 | |||
| 2005-09-30 |
VEHICLE SPEED CONTROL
ODI Number: 10138243 | |||
| 2005-06-01 |
ELECTRICAL SYSTEM
ODI Number: 10123865 | |||
| 2005-06-01 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10123765 | |||
| 2005-04-04 |
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
ODI Number: 10117706 | |||
| 2005-04-11 |
TIRES:TREAD/BELT
ODI Number: 10116707 | |||
| 2005-03-23 |
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
ODI Number: 10111792 | |||
| 2005-01-05 |
TIRES:TREAD/BELT
ODI Number: 10101638 | |||
| 2005-01-07 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10103549 | |||
| 2004-11-22 |
TIRES:SIDEWALL
ODI Number: 10100315 | |||
| 2004-09-28 |
TIRES:SIDEWALL
ODI Number: 10094486 | |||
| 2004-08-30 |
SUSPENSION:REAR:SHOCK ABSORBER
ODI Number: 10090265 | |||
| 2004-07-30 |
STEERING
ODI Number: 10082996 | |||
| 2004-08-12 |
AIR BAGS
ODI Number: 10086711 | |||
| 2004-07-07 |
STRUCTURE
ODI Number: 10080557 | |||
| 2004-05-24 |
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
ODI Number: 10073043 | |||
| 2004-05-15 |
ELECTRICAL SYSTEM:12V/24V/48V BATTERY | ELECTRICAL SYSTEM:IGNITION:MODULE | STEERING:RACK AND PINION:RACK | TIRES:TREAD/BELT | VEHICLE SPEED CONTROL:CRUISE CONTROL
ODI Number: 10072650 | |||
| 2004-04-28 |
TIRES
ODI Number: 10067957 | |||
| 2004-03-18 |
TIRES:SIDEWALL
ODI Number: 10063465 | |||
| 2004-03-26 |
ENGINE AND ENGINE COOLING | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY | STEERING:LINKAGES
ODI Number: 10065050 | |||
| 2004-02-19 |
TIRES:TREAD/BELT
ODI Number: 10051649 | |||
| 2003-12-17 |
SUSPENSION
ODI Number: 10051648 | |||
| 2003-12-03 |
TIRES
ODI Number: 10049942 | |||
| 2003-12-09 |
STEERING:RACK AND PINION
ODI Number: 10049471 | |||
| 2003-12-02 |
POWER TRAIN:AUTOMATIC TRANSMISSION | TIRES
ODI Number: 10041850 | |||
| 2003-08-31 |
TIRES
ODI Number: 10036941 | |||
| 2003-08-30 |
STEERING:RACK AND PINION
ODI Number: 10036913 | |||
| 2003-08-25 |
TIRES:TREAD/BELT
ODI Number: 10034551 | |||
| 2003-08-05 |
STEERING:HYDRAULIC POWER ASSIST SYSTEM
ODI Number: 10030871 | |||
| 2003-07-16 |
SUSPENSION
ODI Number: 10029432 | |||
| 2003-06-24 |
SUSPENSION | TIRES
ODI Number: 10023675 | |||
| 2003-06-26 |
AIR BAGS | ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10019719 | |||
| 2003-06-10 |
STEERING:RACK AND PINION
ODI Number: 10021367 | |||
| 2003-04-12 |
TIRES
ODI Number: 10014314 | |||
| 2003-01-08 |
ELECTRICAL SYSTEM
ODI Number: 10000827 | |||
| 2002-12-04 |
AIR BAGS
ODI Number: 8023657 | |||
| 2002-09-18 |
STEERING:RACK AND PINION:RACK
ODI Number: 8018983 | |||
| 2002-06-28 |
ELECTRICAL SYSTEM:12V/24V/48V BATTERY | ELECTRICAL SYSTEM:IGNITION
ODI Number: 8012973 | |||
| 2002-02-27 |
ELECTRICAL SYSTEM:12V/24V/48V BATTERY | ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | UNKNOWN OR OTHER
ODI Number: 8004689 | |||
| 2019-05-13 |
STEERING
ODI Number: 11207300 | |||
| 2002-07-03 |
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
ODI Number: 786031 | |||
| 2002-08-28 |
TIRES
ODI Number: 766371 | |||
| 2002-08-28 |
STEERING:RACK AND PINION | SUSPENSION:FRONT
ODI Number: 766351 | |||
| 2002-02-26 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 758691 | |||
| 2002-11-29 |
FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM
ODI Number: 568314 | |||
| 2002-05-01 |
EXTERIOR LIGHTING
ODI Number: 565550 |
0 Investigations for 2002 TOYOTA Prius
| Date Opened | Date Closed | Component |
|---|
133 Service Alerts for 2002 TOYOTA Prius
| Date | Description |
|---|---|
| 2022-04-14 | 350000 EQUIPMENT
Toyota Safety Recall and Service Campaign – Technician Certification Requirements 4.14.2022 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2022-05-31 | 350000 EQUIPMENT
TSB: This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2022-05-31 | 119100 ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY
TSB: This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2022-03-17 | 030000 SERVICE BRAKES, HYDRAULIC
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2022-03-17 | 280000 BACK OVER PREVENTION
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2022-01-12 | 190000 TIRES
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2022-01-12 | 200000 WHEELS
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2022-01-12 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-05-04 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Replacement vin plates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1991-01-18 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1989-06-30 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1993-04-09 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1991-01-08 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2021-03-17 | 140000 AIR BAGS
Toyota Safety Recall and Service Campaign – Technician Certification Requirements Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2021-03-12 | 030000 BRAKES (PWS)
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2021-03-12 | 280000 BACK OVER PREVENTION
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2021-02-03 | 350000 EQUIPMENT
TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-12-14 | 030000 BRAKES (PWS)
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-12-14 | 280000 BACK OVER PREVENTION
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-12-14 | 030000 SERVICE BRAKES, HYDRAULIC
TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-06-23 | 020000 SUSPENSION
TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see T-SB-0063-20. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-06-23 | 200000 WHEELS
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-04-07 | 350000 EQUIPMENT
TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-04-06 | 350000 EQUIPMENT
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-05-01 | 110000 ELECTRICAL SYSTEM
TT: This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue ch Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-01-27 | 350000 EQUIPMENT
TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2019-07-01 | 100000 POWER TRAIN
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2019-07-01 | 110000 ELECTRICAL SYSTEM
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2019-07-01 | 060000 ENGINE (PWS)
TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2019-09-30 | 110000 ELECTRICAL SYSTEM
Dealer Package: 09/30/19 A watermark has been added to the Dealer Letter to indicate that ZTI expired on September 30, 2019. In our continuing efforts to assure the best in customer satisfaction, Toyota will initiate a Customer Support Prog Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2019-09-30 | 350000 EQUIPMENT
Dealer Package: 09/30/19 A watermark has been added to the Dealer Letter to indicate that ZTI expired on September 30, 2019. In our continuing efforts to assure the best in customer satisfaction, Toyota will initiate a Customer Support Prog Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-09-14 | 060000 ENGINE (PWS)
TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-09-14 | 110000 ELECTRICAL SYSTEM
TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2018-09-11 | 010000 STEERING
Dealer Package: September 11, 2018 A watermark has been added to the Dealer Letter to indicate that ZTP expired on September 10, 2018. Toyota has received reports of customer concerns regarding an unusual steering wheel vibration when the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2018-09-11 | 350000 EQUIPMENT
Dealer Package: September 11, 2018 A watermark has been added to the Dealer Letter to indicate that ZTP expired on September 10, 2018. Toyota has received reports of customer concerns regarding an unusual steering wheel vibration when the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2018-09-11 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Dealer Package: September 11, 2018 A watermark has been added to the Dealer Letter to indicate that ZTP expired on September 10, 2018. Toyota has received reports of customer concerns regarding an unusual steering wheel vibration when the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-12-02 | 350000 EQUIPMENT
TSB: This bulletin includes basic procedures for performing a Rescue Charge on Ni-MH High Voltage (HV) Batteries. This bulletin should be used in conjunction with the Repair Manual while performing Rescue Charge. The GRX-5100 should be used Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2017-01-06 | 110000 ELECTRICAL SYSTEM
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-07-21 | 350000 EQUIPMENT
Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-07-21 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2018-07-31 | 350000 EQUIPMENT
TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2018-08-31 | 350000 EQUIPMENT
Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2018-08-31 | 355100 EQUIPMENT:OTHER:LABELS
Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-05-11 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
TT: HV Batteries have liquid filled cell modules, to prevent leakage from cells, it is very important to confirm the proper orientation mark of the DRC. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-05-11 | 350000 EQUIPMENT
TT: HV Batteries have liquid filled cell modules, to prevent leakage from cells, it is very important to confirm the proper orientation mark of the DRC. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-09-25 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under warranty. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-09-25 | 353000 EQUIPMENT:ELECTRICAL
TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under warranty. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-08-24 | 100000 POWER TRAIN
TechTip: Condition – The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-08-12 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
TechTip: When a DTC is detected by the HV Battery ECU, the HV Control ECU will automatically store a P3000, Information Code 123 ?HV Battery Control System Malfunction? DTC. The purpose of the P3000/123 is to capture the state of the Hybri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-04-15 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Technicians should confirm the following key points to minimize the potential for future MIL “ON” concerns after HV battery replacement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-04-23 | 355100 EQUIPMENT:OTHER:LABELS
This bulletin is now obsolete. Please see T-SB-0054-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-04-23 | 350000 EQUIPMENT
California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-04-04 | 280000 BACK OVER PREVENTION
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-04-04 | 358100 EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-10-03 | 350000 EQUIPMENT
TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under warranty. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2017-07-20 | 140000 AIR BAGS
TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2017-07-20 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-12-19 | 130000 VISIBILITY
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-12-19 | 130000 VISIBILITY/WIPER (PWS)
This bulletin is now obsolete. Please see T-SB-0185-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-10-23 | 132000 VISIBILITY:GLASS, SIDE/REAR
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-11-04 | 140000 AIR BAGS
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-11-04 | 220000 SEATS
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-11-04 | 350000 EQUIPMENT
Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-09-09 | 050000 PARKING BRAKE
A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-09-09 | 350000 EQUIPMENT
A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-01-15 | 118000 ELECTRICAL SYSTEM:SOFTWARE
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-01-15 | 060000 ENGINE (PWS)
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-01-14 | 140000 AIR BAGS
Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2017-11-21 | 350000 EQUIPMENT
TSB: OBSOLETE NOTICE November 21, 2017: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-02-05 | 030000 SERVICE BRAKES, HYDRAULIC
A key part to maintain the proper function and safe operation of the vehicle’s braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-02-05 | 350000 EQUIPMENT
A key part to maintain the proper function and safe operation of the vehicle’s braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-02-27 | 110000 ELECTRICAL SYSTEM
The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-02-20 | 100000 POWER TRAIN
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2017-11-22 | 110000 ELECTRICAL SYSTEM
TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-07-07 | 353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-06-12 | 118000 ELECTRICAL SYSTEM:SOFTWARE
TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-07-25 | 353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-02-07 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-05-01 | 060000 ENGINE (PWS)
Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-05-01 | 280000 BACK OVER PREVENTION
Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-11-29 | 118000 ELECTRICAL SYSTEM:SOFTWARE
TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-09-15 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-09-15 | 060000 ENGINE (PWS)
TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2017-02-02 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 or P1AC000 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2018-01-11 | 350000 EQUIPMENT
TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-01-29 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin is now obsolete. Please see T-SB-0012-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-01-29 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-01-02 | 118000 ELECTRICAL SYSTEM:SOFTWARE
Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-01-10 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
technicians should confirm the following key points to minimize the potential for future MIL “ON” concerns after HV Battery Replacement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-01-03 | 140000 AIR BAGS
Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2017-10-30 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2017-10-27 | 162300 STRUCTURE:BODY:DOOR
TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-01-15 | 060000 ENGINE (PWS)
TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. THIS BUL Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-04-10 | 110000 ELECTRICAL SYSTEM
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2012-06-13 | 181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-08-23 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
SPECIAL SERVICE CAMPAIGN 40G. HV BATTERY MODIFICATION DATED 07/19/2004. *TT (REVISED). *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-05-16 | 110000 ELECTRICAL SYSTEM
FUEL GAUGE INCLINATION METER RESET. *TT *JB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-05-13 | 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-04-10 | 110000 ELECTRICAL SYSTEM
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-04-10 | 353000 EQUIPMENT:ELECTRICAL
TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-05-13 | 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-08-20 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
Tech Tip: When a DTC is detected by the HV Battery ECU, the HV Control ECU will automatically store a P3000, Information Code 123 ?HV Battery Control System Malfunction? DTC. The purpose of the P3000/123 is to capture the state of the Hybri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-08-20 | 100001 HYBRID PROPULSION SYSTEM
Tech Tip: When a DTC is detected by the HV Battery ECU, the HV Control ECU will automatically store a P3000, Information Code 123 ?HV Battery Control System Malfunction? DTC. The purpose of the P3000/123 is to capture the state of the Hybri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-07-23 | 353000 EQUIPMENT:ELECTRICAL
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-05-11 | 110000 ELECTRICAL SYSTEM
TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-05-11 | 350000 EQUIPMENT
TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-09-15 | 110000 ELECTRICAL SYSTEM
TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-09-15 | 060000 ENGINE (PWS)
TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2015-07-23 | 353000 EQUIPMENT:ELECTRICAL
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-03-05 | 110000 ELECTRICAL SYSTEM
MULTIPLEX COMMUNICATION SYSTEM – REPAIR MANUAL CORRECTION VOL I. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2007-09-21 | 061000 ENGINE AND ENGINE COOLING:ENGINE
MALFUNCTION INDICATOR LAMP (MIL) ON DIAGNOSTIC TROUBLE CODE (DTC) P3130, AND INFORMATION CODE 346. *KB UPDATED 10/26/07. *NJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-05-31 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
DIAGNOSTICS – HV BATTERY CONTROL SYSTEM. REPAIR MANUAL CORRECTION. 00400-RM883-U1. 00400-RM778-U1. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-12-20 | 061000 ENGINE AND ENGINE COOLING:ENGINE
ENGINE OIL SPECIFICATIONS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-03-18 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
REPAIR MANUAL CORRECTION. *SC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2011-09-06 | 140000 AIR BAGS
TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2011-09-06 | 220000 SEATS
TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2011-06-29 | 016000 STEERING:ELECTRIC POWER ASSIST SYSTEM
TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. UNUSUAL STEERING VIBRATION WHEN THE DRIVER RELEASES THE STEERING WHEEL. 2001-2003 PRIUS. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2011-06-23 | 016000 STEERING:ELECTRIC POWER ASSIST SYSTEM
TOYOTA: UNUSUAL STEERING WHEEL VIBRATION WHEN THE DRIVER RELEASES THE STEERING WHEEL. WARRANTY EXTENSION. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-11-20 | 061000 ENGINE AND ENGINE COOLING:ENGINE
MASTER, HYBRID AND MALFUNCTION INDICATOR LIGHT ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P3125. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2009-06-17 | 061000 ENGINE AND ENGINE COOLING:ENGINE
TOYOTA: SOME VEHICLES MAY EXHIBIT A MIL ON CONDITION IF AN ABNORMALLY LOW ENGINE POWER OUTPUT OR FAILURE TO START HAS BEEN DETECTED DURING A PARTICULAR THS DRIVE CYCLE. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2009-06-17 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
TOYOTA: SOME VEHICLES MAY EXHIBIT A MIL ON CONDITION IF AN ABNORMALLY LOW ENGINE POWER OUTPUT OR FAILURE TO START HAS BEEN DETECTED DURING A PARTICULAR THS DRIVE CYCLE. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2014-08-20 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-05-28 | 016000 STEERING:ELECTRIC POWER ASSIST SYSTEM
CUSTOMER SUPPORT PROGRAM – WARRANTY COVERAGE ENHANCEMENT ON THE ELECTRONICALLY-ASSISTED POWER STEERING SYSTEM. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-08-01 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2007-09-01 | 061000 ENGINE AND ENGINE COOLING:ENGINE
MASTER, HYBRID, AND MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P3190, P3191 AND P3101. *TT UPDATED 10/26/07. *NJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-10-02 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
CUSTOMER MAY COMPLAIN OF NOT BEING ABLE TO START THEIR VEHICLES AFTER EXTENDED PARKING TIMES AND/OR REPEATED SHORT DRIVING TIMES. THE PURPOSE OF THIS BULLETIN IS TO INFORM OF A NEW BATTERY AND MOUNTING HARDWARE TO IMPROVE THE STORAGE CAPAC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-03-16 | 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY
SPECIAL SERVICE CAMPAIGN (SSC) 40G – BATTERY MODIFICATION CHEMICAL UPDATE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-08-02 | 110000 ELECTRICAL SYSTEM
TECHNICAL INFORMATION REGARDING NAVIGATION, ENERGY MONITOR, CONSUMPTION AND CASSETTE EJECT MALFUNCTION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-08-02 | 980000 UNKNOWN OR OTHER
SOME VEHICLES MAY EXPERIENCE A MALFUNCTION INDICATOR LIGHT ON WITH DIAGNOSTIC TROUBLE CODE P1436 STORED IN THE ENGINE CONTROL MODULE (ECM). *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-07-12 | 980000 UNKNOWN OR OTHER
SOME VEHICLES MAY EXHIBIT A MASTER, HYBRID AND MALFUNCTION INDICATOR WARNING LIGHT ON CONDITION IF AN ABNORMALLY LOW ENGINE POWER OUTPUT HAS BEEN DETECTED DURING A PARTICULAR DRIVE CYCLE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-08-09 | 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
THIS PURPOSE OF THIS BULLETIN IS TO CLARIFY THE NAVIGATION SYSTEM SPECIFICATIONS FOR CERTAIN VEHICLES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2007-04-26 | 980000 UNKNOWN OR OTHER
TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2010-02-04 | 061000 ENGINE AND ENGINE COOLING:ENGINE
TOYOTA: TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
2002 TOYOTA Prius
search for another vehicle