Skip to content2001 CHRYSLER Voyager
7 Recalls for 2001 CHRYSLER Voyager
| Recall Date | Component | Summary |
|---|---|---|
| 2010-08-10 | EQUIPMENT | CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP. Remedy: CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713. |
| 2006-03-13 | SERVICE BRAKES, HYDRAULIC | CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK. Remedy: AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354. |
| 2004-11-02 | EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. | ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS. Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. |
| 2003-09-26 | EQUIPMENT | AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. Remedy: AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER. |
| 2003-10-24 | FUEL SYSTEM, GASOLINE | CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK. Remedy: WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. |
| 2001-05-08 | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM | VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE. Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403. |
| 2001-05-31 | LATCHES/LOCKS/LINKAGES:DOORS:LATCH | THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2001 PLYMOUTH VOYAGER, CHRYSLER TOWN & COUNTRY, AND DODGE CARAVAN/GRAND CARAVAN MINI VANS THAT ARE NOT EQUIPPED WITH THE REMOTE KEYLESS ENTRY OPTION. THE SLIDING DOOR LATCHES ON THESE VEHICLES COULD RELEASE DURING CERTAIN SEVERE ACCIDENT CONDITIONS THAT INVOLVE THE SLIDING DOOR. Remedy: DEALER WILL REPLACE BOTH SLIDING DOOR KEY CYLINDER-TO-BELL CRANK LINKS ON THE SLIDING DOORS FREE OF CHARGE (PARTS AND LABOR). DAIMLERCHRYSLER HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO REPLACE THE SLIDING DOOR KEY CYLINDER-TO-BELL CRANK LINKS. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403, CONCERNING THIS PROGRAM. |
2 Complaints sent to the Center for Auto Safety for 2001 CHRYSLER Voyager
| Date | Component | |||
|---|---|---|---|---|
| 2008-08-30 | air conditioning/heat | |||
| 2008-08-30 | air conditioning/heat |
86 Complaints submitted to NHTSA for 2001 CHRYSLER Voyager
| Date | Component | |||
|---|---|---|---|---|
| 2005-02-24 |
AIR BAGS
ODI Number: 10113580 | |||
| 2006-11-25 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 10174237 | |||
| 2006-01-04 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 10146933 | |||
| 2005-08-03 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 10131441 | |||
| 2005-02-20 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 10111860 | |||
| 2004-10-19 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 10096049 | |||
| 2016-09-29 |
AIR BAGS | UNKNOWN OR OTHER
ODI Number: 10910531 | |||
| 2017-06-06 |
AIR BAGS | ELECTRICAL SYSTEM | ELECTRICAL SYSTEM:HORN
ODI Number: 10993491 | |||
| 2020-08-25 |
POWER TRAIN
ODI Number: 11351122 | |||
| 2018-08-21 |
AIR BAGS | ELECTRICAL SYSTEM
ODI Number: 11121509 | |||
| 2016-01-27 |
AIR BAGS
ODI Number: 10822456 | |||
| 2015-02-01 |
AIR BAGS
ODI Number: 10680305 | |||
| 2014-09-25 |
POWER TRAIN
ODI Number: 10639150 | |||
| 2014-05-16 |
ENGINE
ODI Number: 10588977 | |||
| 2014-04-09 |
AIR BAGS
ODI Number: 10578671 | |||
| 2013-06-12 |
AIR BAGS
ODI Number: 10519558 | |||
| 2012-03-13 |
SUSPENSION
ODI Number: 10451404 | |||
| 2012-01-30 |
AIR BAGS
ODI Number: 10445809 | |||
| 2010-06-07 |
ELECTRICAL SYSTEM
ODI Number: 10335013 | |||
| 2009-03-10 |
EXTERIOR LIGHTING
ODI Number: 10261396 | |||
| 2008-12-16 |
ELECTRICAL SYSTEM
ODI Number: 10251982 | |||
| 2008-06-02 |
ELECTRICAL SYSTEM
ODI Number: 10229502 | |||
| 2008-05-01 |
AIR BAGS
ODI Number: 10226395 | |||
| 2008-04-20 |
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10225169 | |||
| 2007-12-05 |
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10210876 | |||
| 2007-12-04 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10210826 | |||
| 2007-12-12 |
EXTERIOR LIGHTING:HEADLIGHTS
ODI Number: 10211767 | |||
| 2007-01-18 |
AIR BAGS
ODI Number: 10179011 | |||
| 2006-11-25 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 10174237 | |||
| 2006-12-12 |
AIR BAGS:FRONTAL
ODI Number: 10175895 | |||
| 2006-11-09 |
STEERING:RACK AND PINION:RACK
ODI Number: 10173011 | |||
| 2006-06-04 |
WHEELS
ODI Number: 10158942 | |||
| 2006-03-20 |
AIR BAGS
ODI Number: 10153192 | |||
| 2006-03-30 |
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
ODI Number: 10154232 | |||
| 2006-03-02 |
STEERING:RACK AND PINION
ODI Number: 10151639 | |||
| 2006-01-04 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 10146933 | |||
| 2005-11-02 |
SUSPENSION:FRONT:CONTROL ARM
ODI Number: 10141598 | |||
| 2005-09-23 |
EQUIPMENT:APPLIANCE:AIR CONDITIONER
ODI Number: 10138802 | |||
| 2005-09-07 |
SEAT BELTS:REAR/OTHER
ODI Number: 10135560 | |||
| 2005-08-03 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 10131441 | |||
| 2005-07-12 |
AIR BAGS
ODI Number: 10128425 | |||
| 2005-07-08 |
SEATS
ODI Number: 10129165 | |||
| 2005-07-12 |
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
ODI Number: 10128522 | |||
| 2005-06-08 |
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS | VISIBILITY:GLASS, SIDE/REAR
ODI Number: 10124553 | |||
| 2005-02-20 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 10111860 | |||
| 2005-02-07 |
AIR BAGS
ODI Number: 10111546 | |||
| 2005-02-24 |
AIR BAGS
ODI Number: 10113580 | |||
| 2005-01-26 |
FUEL SYSTEM, GASOLINE:DELIVERY
ODI Number: 10109783 | |||
| 2004-12-21 |
EXTERIOR LIGHTING:HEADLIGHTS
ODI Number: 10101308 | |||
| 2004-10-24 |
ELECTRICAL SYSTEM | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 10096316 | |||
| 2004-10-19 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 10096049 | |||
| 2004-09-15 |
AIR BAGS
ODI Number: 10092324 | |||
| 2004-08-30 |
ELECTRICAL SYSTEM
ODI Number: 10088828 | |||
| 2004-07-13 |
ELECTRICAL SYSTEM:WIRING
ODI Number: 10081013 | |||
| 2004-08-12 |
AIR BAGS:FRONTAL
ODI Number: 10082038 | |||
| 2004-06-29 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
ODI Number: 10079023 | |||
| 2004-03-30 |
AIR BAGS
ODI Number: 10065235 | |||
| 2004-04-05 |
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH | ENGINE AND ENGINE COOLING:COOLING SYSTEM | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING | LATCHES/LOCKS/LINKAGES | POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10064568 | |||
| 2004-01-08 |
AIR BAGS
ODI Number: 10050203 | |||
| 2004-01-16 |
ELECTRICAL SYSTEM
ODI Number: 10048640 | |||
| 2003-12-10 |
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
ODI Number: 10046534 | |||
| 2003-11-24 |
VISIBILITY:WINDSHIELD
ODI Number: 10047463 | |||
| 2003-08-14 |
VISIBILITY:WINDSHIELD
ODI Number: 10026983 | |||
| 2003-08-01 |
VISIBILITY:WINDSHIELD
ODI Number: 10026973 | |||
| 2003-06-09 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM
ODI Number: 10022623 | |||
| 2003-05-29 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10021848 | |||
| 2003-04-14 |
SUSPENSION:FRONT:MACPHERSON STRUT
ODI Number: 10015794 | |||
| 2003-03-30 |
SEAT BELTS
ODI Number: 10013673 | |||
| 2003-04-03 |
UNKNOWN OR OTHER
ODI Number: 10013926 | |||
| 2003-03-24 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10012307 | |||
| 2003-02-10 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10006866 | |||
| 2003-02-10 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10006861 | |||
| 2003-01-06 |
EXTERIOR LIGHTING:TAIL LIGHTS
ODI Number: 10002074 | |||
| 2002-12-10 |
SUSPENSION
ODI Number: 8024061 | |||
| 2002-11-13 |
EXTERIOR LIGHTING:HEADLIGHTS
ODI Number: 8022629 | |||
| 2002-08-07 |
SUSPENSION:FRONT
ODI Number: 8015706 | |||
| 2002-06-28 |
STRUCTURE:BODY:BUMPERS
ODI Number: 8012896 | |||
| 2002-05-15 |
AIR BAGS
ODI Number: 8009888 | |||
| 2002-05-03 |
AIR BAGS:FRONTAL
ODI Number: 8009134 | |||
| 2002-01-03 |
CHILD SEAT:HARNESS BUCKLE:CONVERTIBLE
ODI Number: 8001409 | |||
| 2001-04-17 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 886150 | |||
| 2002-09-20 |
VISIBILITY:WINDSHIELD
ODI Number: 767477 | |||
| 2002-04-21 |
AIR BAGS
ODI Number: 760985 | |||
| 2002-03-11 |
SEAT BELTS:FRONT:ANCHORAGE
ODI Number: 759220 | |||
| 2001-09-04 |
SUSPENSION:FRONT
ODI Number: 751606 | |||
| 2002-10-25 |
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ODI Number: 568029 |
6 Investigations for 2001 CHRYSLER Voyager
| Date Opened | Date Closed | Component | |
|---|---|---|---|
| 2005-02-02 | 2005-06-01 | ELECTRICAL SYSTEM | |
| 2005-06-01 | 2006-05-02 | EXTERIOR LIGHTING:HEADLIGHTS | |
| 2005-02-02 | 2005-06-01 | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH | |
| 2005-02-02 | 2005-06-01 | EXTERIOR LIGHTING:HEADLIGHTS | |
| 2005-06-01 | 2006-05-02 | ELECTRICAL SYSTEM | |
| 2005-06-01 | 2006-05-02 | EXTERIOR LIGHTING:HEADLIGHTS:SWITCH |
139 Service Alerts for 2001 CHRYSLER Voyager
| Date | Description |
|---|---|
| 2013-03-20 | 160000 STRUCTURE
82212076, 82203694 – Fabric Cleaner This “fabric cleaner” is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-02-26 | 060000 ENGINE AND ENGINE COOLING
Valve Body. These may cause over drive cycling. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-04-22 | 110000 ELECTRICAL SYSTEM
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-04-22 | 350000 EQUIPMENT
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are nece Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-04-30 | 160000 STRUCTURE
Disinfectant Solution Recommended for COVID-19 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2020-04-30 | 350000 EQUIPMENT
Disinfectant Solution Recommended for COVID-19 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2019-11-20 | 160000 STRUCTURE
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2019-11-20 | 350000 EQUIPMENT
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2019-11-20 | 160000 STRUCTURE
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2019-11-20 | 350000 EQUIPMENT
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-23 | 114000 ELECTRICAL SYSTEM:WIRING
Return: Wiring Assy – Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. P Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-22 | 350000 EQUIPMENT
05182535AD – Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Pl Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-22 | 120000 LIGHTING (PWS)
05182535AD – Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Pl Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-17 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Return: Lamp Assy – CHMSL& Cargo Light You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of follow ing part numbers:55372082AE, 55372082AD, 55372082AC, 55372082AB, 553720 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-17 | 110000 ELECTRICAL SYSTEM
Inspect and Return: Solenoid Module – Transmission You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of follow ing part numbers:52120000AA, 52119435AF, 05078709AB. S Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-22 | 350000 EQUIPMENT
Inspect and Return: Trim Cover Assy – A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for id Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-18 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Warranty Operations Newsletter Updates from Warranty Operations Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2013-03-20 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
82212076, 82203694 – Fabric Cleaner This “fabric cleaner” is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-17 | 117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
1NT30XDVAC – Inspect and Return: Panel – Instrument Panel You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 1N T30XDVAC. See attachments for identifyin Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-06-02 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Warranty Operations Newsletter Updates from Warranty Operations Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-18 | 350000 EQUIPMENT
CBXDP361AA Return: Spacer Kit – Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Replacement part number is CBXDP361AB w hich is in stock a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-08-12 | 110000 ELECTRICAL SYSTEM
P/N CBSZR068AA: Inspect & Return: Module Kit – Occupant Restraint You have been identified as either having stock, or have stock in transit to your dealership. Please return part number CBSZR068AA as per the QIR attached. Replacement par Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2016-11-16 | 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Wiper If Mopar OE wipers are unavailable, the below alternatives can be offered instead. 05066964A$ = WBRW0011A$ 05066973A$ = WB000019A$ or WBF00019A$ 05096134A$ = WB000027A$ or WBF00028A$ 55154762A$ = WB000013A$ 68001330A$ = WB000019 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-11-10 | 160000 STRUCTURE
SOME MINIVANS MAY EXHIBIT A HOWL SOUND WHEN DRIVING AT SPEEDS BETWEEN 45 AND 70 MPH AND THAT MAY BE MOST NOTICEABLE AT 58 – 60 MPH. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-10-28 | 061000 ENGINE AND ENGINE COOLING:ENGINE
ENGINE SPARK KNOCK. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-10-21 | 061000 ENGINE AND ENGINE COOLING:ENGINE
CAMSHAFT / BEARING SERVICE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-02-17 | 110000 ELECTRICAL SYSTEM
INSTRUMENT PANEL ILLUMINATION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-12-03 | 046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR
ANTI-LOCK BRAKE REAR WHEEL SPEED SENSOR REPLACEMENT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-02-11 | 110000 ELECTRICAL SYSTEM
INFORMATION ON REMOVABLE FLOOR CONSOLE ELECTRICAL CONNECTOR. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-09-28 | 221600 SEATS:FRONT ASSEMBLY:POWER ADJUST
THIS BULLETIN INVOLVES INSTALLING A REVISED POWER SEAT ADJUSTER DRIVE BLOCK SCREW TO THE INBOARD SIDE OF THE POWER SEAT TRACK(S). *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2006-08-25 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-09-14 | 061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
INFORMATION ON BELT-LIKE SQUEAL SOUND AT HIGH ENGINE RPM. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-08-31 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
INFORMATION ON REPORTED INCIDENTS OF STUCK OIL PRESSURE RELIEF VALVE ASSEMBLIES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-01-12 | 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
INFORMATION REGARDING TRANSAXLE COOLER LINE SPLICE KIT. *JB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-03-18 | 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
SUBJECT REGARDING POOR REAR AIR CONDITIONER PERFORMANCE – LOW OUTPUT FROM HEADLINER VENTS. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-04-22 | 980000 UNKNOWN OR OTHER
SUBJECT REGARDING MALFUNCTION INDICATOR LAMP ILLUMINATION, ERRONOUS DIAGNOSTIC TROUBLE CODE (DTC) P0456, EVAP LEAK MONITOR 0.020 LEAK DETECTED. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-05-20 | 010000 STEERING
SUBJECT REGARDING STEERING SHUDDER. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-03-25 | 110000 ELECTRICAL SYSTEM
SUBJECT REGARDING REMOTE KEYLESS ENTRY PROGRAMMING PROCEDURES. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-02-11 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
EXHIBITING ENGINE SAG / HESITATION AND/OR CLOSED THROTTLE START STALL, DIAGNOSTIC TROUBLE CODE P0123. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-09-23 | 034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *YD THIS BULLETIN SUPERSEDES 05-001-02 DATED MARCH 4, 2002. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2006-03-09 | 034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-07-22 | 980000 UNKNOWN OR OTHER
SOME VEHICLES NOT EQUIPPED WITH ANTI-SKID BRAKE SYSTEM (ABS) MAY HAVE THE ABS, BRAKE AND TRAC OFF LAMPS ILLUMINATED ON THE INSTRUMENT CLUSTER. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-08-05 | 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
SUBJECT REGARDING AIR CONDITIONER TEMPERATURE DIFFERENTIAL (STRATIFICATION) BETWEEN LEFT AND RIGHT FRONT PANEL OUTLETS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-08-12 | 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
CUSTOMER MAY COMPLAIN THAT THE HVAC DRAIN WATER LEAKS UNDER PASSENGER SIDE CARPET. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-08-26 | 980000 UNKNOWN OR OTHER
CONCERNS WITH THE ABS, BRAKE AND TRAC OFF CLUSTER LAMPS ILLUMINATED ON VEHICLES NOT EQUIPPED WITH ABS BRAKES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-08-19 | 034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM
SUBJECT REGARDING REAR BRAKE CYCLIC RUBBING SOUND FROM REAR OF VEHICLE DURING MEDIUM TO LIGHT BRAKE APPLICATION ON VEHICLES WITH REAR DRUM BRAKES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-09-09 | 162000 STRUCTURE:BODY
PASSENGER COMPARTMENT FLOOR WATER LEAK. *TT THIS BULLETIN SUPERSEDES BULLETIN 23-010-04 DATED 04-29-04. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-09-02 | 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, DIAGNOSTIC TROUBLE CODE (DTC) P0442, P0455, OR P0456 – LEAK DETECTION PUMP (LDP), LEAK DETECTED. THIS BULLETIN SUPERSEDES 25-001-02 DATED FEB 11, 2002. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-09-29 | 162000 STRUCTURE:BODY
SUBJECT REGARDING QUAD SEAT CUPHOLDER TO FLOORMAT INTERFERENCE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-09-22 | 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
SUBJECT REGARDING POWER MODE CLOSES LIFTGATE BUT WILL NOT OPEN THE LIFTGATE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-09-15 | 162300 STRUCTURE:BODY:DOOR
SOME VEHICLES MAY EXHIBIT A GROWLING SOUND WHEN BEING SLID AND / OR A RATCHETING / CREAKING SOUND WHEN THE POWER SLIDING DOOR IS CINCHING CLOSED. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-09-22 | 220000 SEATS
SOME VEHICLES MAY EXHIBIT A RATTLE SOUND FROM THE QUAD SEAT(S) AND / OR 50 / 50 REAR BENCH SEAT(S) AND / OR A GROAN SOUND WHEN THE SEAT(S) ARE TUMBLED FORWARD AND / OR SEAT(S) MAY BE DIFFICULT TO UNLATCH FOR TUMBLE OR EASY ENTRY. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-09-08 | 220000 SEATS
SOME VEHICLES MAY EXHIBIT A RATTLE SOUND FROM THE QUAD SEAT(S) AND / OR 50 / 50 REAR BENCH SEAT(S) AND / OR A GROAN SOUND WHEN THE SEAT(S) ARE TUMBLED AND / OR MAY BE DIFFICULT TO UNLATCH SEAT(S) FOR TUMBLE OR EASY ENTRY. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-09-29 | 140000 AIR BAGS
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-11-02 | 010000 STEERING
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-08-22 | 046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR
ANTI-LOCK BRAKE REAR WHEEL SPEED SENSOR REPLACEMENT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-10-02 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
AUTOMATIC TRANSMISSION DIAGNOSTIC TEARDOWN PROCEDURE. VARIOUS MODELS INCLUDING THE 2004 RAM TRUCK, DURANGO, SEBRING CONVERTIBLE, CHEROKEE, VISION, NEON, AND VOYAGER. *TT *SC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-05-04 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
THIS BULLETIN REINFORCES A REQUIREMENT TO CEASE THE CURRENT PRACTICE OF USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS IN ALL DIAMLER CHRYSLER ENGINES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-06-01 | 221700 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
A CONDITION MAY EXIST WHERE THE HEATED SEAT MAY BE INOPERATIVE DUE TO AN OPEN CIRCUIT IN THE HEATING ELEMENT. THIS BULLETIN INVOLVES INSTALLING A HEATING ELEMENT REPAIR KIT AND / OR REPLACING THE SEAT BACK. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-05-25 | 110000 ELECTRICAL SYSTEM
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-04-06 | 190000 TIRES
SOME VEHICLE OPERATORS MAY COMPLAIN OF A HOWL / DRONE / MOAN / HUMMING / CYCLIC SOUND WHEN DRIVING AT SPEEDS BETWEEN 45 AND 70 MPH (72 AND 112 KM/H) AND MAY BE MOST NOTICEABLE AT 58-60 MPH (93-96 KM/H). *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-04-06 | 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
OWNERS MAY COMPLAIN THAT THE ENGINE COOLING FANS RUNNING CONSTANTLY, COMING ON AS THE VEHICLE COMES TO A STOP, OR THAT THE COOLING FANS MAY BE INTERMITTENTLY RUNNING UNDER COOL WEATHER OR COOL ENGINE CONDITIONS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-04-20 | 034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND / OR LOW SPEED TURNS SUCH AS A PARKING LOT MANEUVER, WITH NO BRAKE PEDAL PRESSURE APPLIED. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-06-24 | 980000 UNKNOWN OR OTHER
FLASH PROGRAMMING FAILURE RECOVERY. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-04-01 | 135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-03-18 | 162000 STRUCTURE:BODY
SUBJECT REGARDING QUARTER WINDOW WEATHERSTRIP LOOSE. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-05-27 | 220000 SEATS
SUBJECT REGARDING ASSIST FEATURE INOPERATIVE ON QUAD OR SPLIT REAR BENCH SEATS. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-06-24 | 220000 SEATS
SUBJECT REGARDING QUAD SEAT RELEASE HANDLE SCREW SHEARED OFF IN SHAFT. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-04-29 | 015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM
SUBJECT REGARDING POWER STEERING MOAN/GROAN SOUND. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-02-04 | 980000 UNKNOWN OR OTHER
ON SOME VEHICLES, THE QUAD SEAT CUPHOLDER COMPENSATION FLAP IS BROKEN. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-01-11 | 015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM
INFORMATION ON POWER STEERING MOANING/GROANING SOUND. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-01-11 | 061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
SUBJECT REGARDING BELT LIKE SQUEAL SOUND AT HIGH ENGINE RPM. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-03-02 | 061000 ENGINE AND ENGINE COOLING:ENGINE
IRREGULAR ENGINE SNAPPING SOUND. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-09-21 | 135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-06-10 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
SUBJECT REGARDING STUCK OIL PRESSURE RELIEF VALVE FOR VEHICLES BUILT PRIOR TO JANUARY 1, 2002 EQUIPPED WITH A 3.3 L OR 3.8 L ENGINE. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-11-02 | 061000 ENGINE AND ENGINE COOLING:ENGINE
SUBJECT REGARDING CAMSHAFT / BEARING SERVICE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-01-16 | 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
SOME VEHICLES MAY EXPERIENCE A NO START CONDITION IN COLD TEMPERATURES DUE TO 5 VOLT REGULATOR FAILURE IN THE SBEC PCM MODULE. *JB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-12-29 | 220000 SEATS
A CONDITION MAY EXIST WHERE THE CHILD SEAT ANCHOR AND TETHER WIRES HAVE SURFACE RUST ON THEM. *JB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-12-29 | 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
SOME VEHICLES MAY EXHIBIT A POWER MODE THAT CLOSES THE LIFT GATE, BUT DOES OPEN THE LIFT GATE. *JB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-02-16 | 354300 EQUIPMENT:MECHANICAL:CARRIER/RACK
INFORMATION REGARDING ROOF RACK NOISE / HOWL. *JB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-01-26 | 980000 UNKNOWN OR OTHER
ON SOME VEHICLES THE INSTRUMENT PANEL / HOOD HINGE RATTLES. *JB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-12-29 | 980000 UNKNOWN OR OTHER
SUBJECT REGARDING REMOTE KEYLESS ENTRY TRANSMITTER PROGRAMMING. *JB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-06-01 | 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
AIR CONDITIONER COMPRESSOR FAILURE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-06-20 | 110000 ELECTRICAL SYSTEM
BATTERY LIGHT ILLUMINATION, ERRONEOUS DIAGNOSTIC TROUBLE CODE (DTC) P1594. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-04-27 | 110000 ELECTRICAL SYSTEM
VEHICLES NOT EQUIPPED WITH ANTI-LOCK BRAKE SYSTEM (ABS) BRAKES MAY HAVE THE ABS, BRAKE, AND TRAC OFF LAMPS ILLUMINATED ON THE INSTRUMENT CLUSTER OR VEHICLES NOT EQUIPPED WITH SENTRY KEY IMMOBILIZER (SKIM) MAY HAVE THE SECURITY/VTA LAMP ILLU Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-02-14 | 100000 POWER TRAIN
POOR SHIFT QUALITY. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-09-28 | 123000 EXTERIOR LIGHTING:TAIL LIGHTS
CONCERN WITH TAIL LAMP EXPERIENCING A LOOSE CONDITION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-10-26 | 190000 TIRES
SOME CUSTOMERS MAY COMPLAIN OF A HOWL/ DRONE/ MOAN/ HUMMING/CYCLIC SOUND WHEN DRIVING AT SPEEDS BETWEEN 45 AND 70 MPH. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-11-23 | 221600 SEATS:FRONT ASSEMBLY:POWER ADJUST
ON SOME VEHCLES, THE POWER SEAT HAS SLIGHT FORE/AFT MOVEMENT MOST NOTICEABLE DURING ACCELERATION OR BRAKING. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-11-23 | 011000 STEERING: STEERING WHEEL/HANDLE BAR
EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-11-23 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
SOME VEHICLES MAY EXHIBIT MODERATE TO SEVERE HIGH WAY SPEED 45-60 MPH VEHICLE SURGE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-11-02 | 090000 FUEL SYSTEM, OTHER
A CONDITION MAY EXIST WHERE THE FUEL GAUGE INDICATOR VISIBLY DROPS 1/4 TO 1/2 TANK WHILE DRIVING. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-08-07 | 061000 ENGINE AND ENGINE COOLING:ENGINE
SOME VEHICLES WERE BUILT AND SHIPPED TO DEALERS WITH CAMSHAFTS THAT MAY HAVE AN IMPROPERLY MACHINED OIL GROOVE. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-08-17 | 354300 EQUIPMENT:MECHANICAL:CARRIER/RACK
VEHICLES MAY EXPERIENCE WIND NOISE, POSSIBLY DESCRIBED AS HOWL SOUND, MAY BE HEARD WHEN DRIVING AT HIGHWAY SPEEDS. THE ROOF RACK CROSSBARS CAN BE THE CAUSE OF THIS TYPE OF SOUND. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-08-03 | 015300 STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID
INFORMATION ON NEW POWER STEERING FLUID.*SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-12-29 | 110000 ELECTRICAL SYSTEM
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-05-27 | 021400 SUSPENSION:FRONT:MACPHERSON STRUT
CREAKING/SQUAWKING SOUND FROM FRONT STRUT AREA. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-05-25 | 061000 ENGINE AND ENGINE COOLING:ENGINE
LONG CRANK OR IDLE FLUCATION IN COLD TEMPERATURE WITH E20 – E30 ETHANOL FUEL BLENDS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-07-25 | 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
VEHICLE WITH PROPERLY FUNCTIONING EVAPORATIVE EMISSIONS SYSTEM REPEATEDLY SETS DIAGNOSTIC TROUBLE CODE P0456 WHEN CUSTOMER REGULARLY COMMUTES ON A STEEP GRADE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-03-11 | 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
SUBJECT REGARDING COOLING FAN SOUND/VIBRATION. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-03-13 | 137200 VISIBILITY:REAR WINDOW WIPER/WASHER:MOTOR
RAPID RESPONSE TRANSMITTAL REGARDING INOPERATIVE REAR WIPER MOTOR. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-03-16 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
INFORMATION ON DIAGNOSING ENGINE SAG / HESITATION AND / OR CLOSED THROTTLE START STALL CONDITION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-03-09 | 137000 VISIBILITY:REAR WINDOW WIPER/WASHER
A CONDITION MAY EXIST WHERE THE REAR WIPER MAY BE INOPERATIVE OR INTERMITTENTLY INOPERATIVE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-02-02 | 162000 STRUCTURE:BODY
THIS BULLETIN STATES THAT ALL FACTORY INSTALLED EQUIPMENT, SUCH AS A SUNROOF, MEET THE UPPER INTERIOR HEAD PROTECTION REQUIREMENTS OF FMVSS 201. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-02-09 | 034430 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM
ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS CAUSING RUST TO DEVELOP ON THE REAR BRAKE DRUM AND SHOE FRICTION SURFACES. THIS CONDITION CAN LEAD TO TEMPORARY FREEZI Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-08-04 | 010000 STEERING
STEERING SHUDDER. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-08-29 | 010000 STEERING
POP/TICK SOUND IN STEERING WHEEL AREA. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-08-15 | 110000 ELECTRICAL SYSTEM
POWERTRAIN WIRING HARNESS BRACKET PACKAGE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2006-09-23 | 040000 SERVICE BRAKES, AIR
SNOW/WATER INGESTION INTO REAR BRAKE DRUM. *KB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-04-22 | 980000 UNKNOWN OR OTHER
SUBJECT REGARDING SPIRAL PLATE DIESEL BATTERY TESTING, CHARGING, AND VEHICLE STORAGE PROCEDURES. *SLC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-07-06 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
SUBJECT REGARDING GEAR SHIFT LEVER AND BRAKE TRANSMISSION SHIFT INTERLOCK (BTSI) SERVICE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-08-03 | 010000 STEERING
INFORMATION ON VEHICLES EXHIBITING A STEERING HISS OR SWOOSH SOUND. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-07-06 | 021000 SUSPENSION:FRONT
EXPERIENCING A SQUAWK / CREAK / GROAN SOUND FROM FRONT SUSPENSION WHILE DRIVING OVER ROUGH / BUMPY ROADS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-10-16 | 062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
SOME VEHICLES MAY EXPERIENCE AN INTERFERENCE CONDITION BETWEEN THE (CRS) COOLANT RECOVERY SYSTEM HOSE AND THE POWERTRAIN WIRING HARNESS THAT COULD RESULT IN THE CRS HOSE BECOMING PINCHED AND BLOCKING THE FLOW OF COOLANT BETWEEN THE CRS BOTT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-10-10 | 354300 EQUIPMENT:MECHANICAL:CARRIER/RACK
ADVANCE SERVICE INFORMATION REGARDING ROOF RACK CROSS RAIL INSTALLATION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-10-06 | 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
ADVANCE SERVICE INFORMATION REGARDING VEHICLES EXHIBITING WATER LEAKAGE FROM THE HEATER – A/C UNIT AIR FLITER ACCESS DOOR LOCATED IN THE UPPER LEFT AREA OF THE FRONT PASSENGER SIDE FOOT WELL. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-10-27 | 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
SOME VEHICLES MAY EXHIBIT A POWER MODE THAT CLOSES THE LEFT GATE BUT WILL NOT OPEN THE LIFT GATE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-10-13 | 110000 ELECTRICAL SYSTEM
A CONDITION MAY EXIST WHERE THE INSTRUMENT CLUSTER, OVERHEAD CONSOLE DISPLAY, HVAC CONTROL AND RADIO BUTTONS DO NOT ILLUMINATE WHEN THE HEADLAMPS ARE TURNED ON AND / OR THE ANTILOCK BRAKE SYSTEM (ABS) LAMP IS ON, THE OVERHEAD CONSOLE DISPLA Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-10-06 | 110000 ELECTRICAL SYSTEM
THIS BULLETIN PROVIDES INFORMATION RELATED TO THE ELECTRICAL SYSTEM TO CLARIFY SYSTEM OPERATION / FEATURES / DIAGNOSTIC TROUBLE CODES (DTC’S) THAT COULD BE CONFUSING TO TECHNICIANS THAT ARE UNFAMILIAR WITH 2001 MINIVANS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-10-27 | 034520 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
SOME LOW MILEAGE VEHICLES MAY EXHIBIT A LOUD SQUEAL SOUND FROM THE REAR DISC BRAKES THAT IS MOST NOTICEABLE WHEN THE BRAKES ARE LIGHTLY APPLIED AT LOWER SPEEDS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-05-18 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
SURGE WITH TRANSMISSION AT FULL LOCK-UP. *MJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-05-11 | 010000 STEERING
POWER STEERING RETURN HOSE SEEPAGE. *MJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2004-05-18 | 221200 SEATS:FRONT ASSEMBLY:RECLINER
SEAT RECLINER CABLE ADJUSTMENT PROCEDURE. *MJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2007-09-27 | 162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
POWER SLIDING DOOR ADJUSTMENT AND DIAGNOSIS AID. *KB UPDATED 10/26/07. *NJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-04-01 | 980000 UNKNOWN OR OTHER
SUBJECT REGARDING SERVICE / DIAGNOSTIC MANUAL REVISIONS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-05-04 | 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
SOME VEHICLE OPERATORS MAY COMPLAIN OF NO HEAT IN ANY MODE, FROM THE FRONT RIGHT SIDE OF THE VEHICLE. THIS BULLETIN INVOLVES REPLACING THE BLEND AIR DOOR SHAFT WITH A NEW PART. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-05-25 | 350000 EQUIPMENT
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-11-17 | 110000 ELECTRICAL SYSTEM
SUBJECT REGARDING CIRCUITS EFFECTED BY IGNITION OFF DRAW (IOD) FUSE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-05-04 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
THIS BULLETIN REINFORCES A REQUIREMENT TO CEASE THE CURRENT PRACTICE OF USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS IN ALL DAIMLERCHRYSLER ENGINES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-06-01 | 980000 UNKNOWN OR OTHER
THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE PAGES REQUIRING HAND WRITTEN CHANGES TO EXISTING PAGES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-05-01 | 980000 UNKNOWN OR OTHER
THIS TECHNICAL SERVICE BULLETIN CONTAINS BOTH UPDATED SELF-ADHESIVE SERVICE AND / OR DIAGNOSTIC MANUAL PAGES AND UPDATE PAGES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-06-22 | 061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
ON SOME VEHICLES, THE ACCESSORY DRIVE BELT MAY SQUEAL OR THE BELT HAS JUMPED OFF THE PULLEYS. THIS BULLETIN INVOLVES INSTALLING A FOAM SEAL ON THE WIPER MODULE RIGHT DRAIN TUBE CONNECTOR. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-06-22 | 162300 STRUCTURE:BODY:DOOR
THIS BULLETIN INVOLVES REPLACING LOOSE OR MISSING SLIDING DOOR B PILLAR WEATHERSTRIP. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-03-16 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-12-21 | 110000 ELECTRICAL SYSTEM
SERVICE ACTION REGARDING VEHICLES SHIPPED WITH IGNITION OFF DRAW (IOD) FUSE INSTALLED. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-12-15 | 135000 VISIBILITY:REARVIEW MIRRORS/DEVICES
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-12-08 | 110000 ELECTRICAL SYSTEM
SUBJECT REGARDING SAFETY SYSTEMS – VEHICLE MODIFICATIONS / REPAIR. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-03-02 | 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2005-03-16 | 020000 SUSPENSION
RATTLE/KNOCKING SOUND FROM THE FRONT SUSPENSION. *SC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |