1999 VOLVO S80

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

5 Recalls for 1999 VOLVO S80

Recall Date Component Summary
August 24, 2000 SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT

VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.

Remedy:

DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.

March 29, 2007 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Remedy:

CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

November 15, 2006 VEHICLE SPEED CONTROL

ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.

Remedy:

DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

September 13, 2004 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.

Remedy:

DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.

April 7, 2002 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

ON SOME PASSENGER VEHICLES, CERTAIN ELECTRIC COOLING FANS COULD BE INADEQUATE IN A HOT CLIMATE. UNDER CERTAIN CIRCUMSTANCES, EXCESSIVE HEAT COULD BE GENERATED.

Remedy:

DEALERS WILL REPLACE THE ENGINE COOLING FAN. OWNER NOTIFICATION BEGAN APRIL 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-458-1552.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

0 Complaints sent to the Center for Auto Safety for 1999 VOLVO S80

skip to NHTSA complaints

Date Component  

206 Complaints submitted to NHTSA for 1999 VOLVO S80

skip to CAS complaints

Date Component  
ELECTRICAL SYSTEM | POWER TRAIN | VEHICLE SPEED CONTROL
ODI Number: 10358708
VEHICLE SPEED CONTROL
ODI Number: 10335919
STRUCTURE
ODI Number: 10187942
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 551710
AIR BAGS | ELECTRICAL SYSTEM | STEERING
ODI Number: 11373728
SERVICE BRAKES | VEHICLE SPEED CONTROL | WHEELS
ODI Number: 11373727
ELECTRONIC STABILITY CONTROL | SUSPENSION | VEHICLE SPEED CONTROL
ODI Number: 11084691
ELECTRICAL SYSTEM | FUEL/PROPULSION SYSTEM
ODI Number: 11034282
ENGINE | VEHICLE SPEED CONTROL
ODI Number: 10820242
STEERING
ODI Number: 10610714
ELECTRICAL SYSTEM | ENGINE | SERVICE BRAKES
ODI Number: 10558799
ENGINE
ODI Number: 10473816
FUEL SYSTEM, GASOLINE
ODI Number: 10436884
STEERING
ODI Number: 10416712
ENGINE AND ENGINE COOLING
ODI Number: 10411937
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 10414964
VEHICLE SPEED CONTROL
ODI Number: 10402818
FUEL SYSTEM, GASOLINE
ODI Number: 10394198
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10376279
VEHICLE SPEED CONTROL
ODI Number: 10365229
ENGINE AND ENGINE COOLING | POWER TRAIN | SUSPENSION:FRONT | VEHICLE SPEED CONTROL
ODI Number: 10366607
ELECTRICAL SYSTEM | POWER TRAIN | VEHICLE SPEED CONTROL
ODI Number: 10358708
TIRES
ODI Number: 10339646
VEHICLE SPEED CONTROL
ODI Number: 10335919
AIR BAGS:FRONTAL | SEAT BELTS
ODI Number: 10317792
VEHICLE SPEED CONTROL
ODI Number: 10302622
FUEL SYSTEM, GASOLINE | VEHICLE SPEED CONTROL
ODI Number: 10296838
VEHICLE SPEED CONTROL
ODI Number: 10285946
ENGINE AND ENGINE COOLING
ODI Number: 10286770
ELECTRICAL SYSTEM
ODI Number: 10279894
FUEL SYSTEM, GASOLINE
ODI Number: 10276559
ENGINE AND ENGINE COOLING
ODI Number: 10275217
ENGINE AND ENGINE COOLING
ODI Number: 10268790
VEHICLE SPEED CONTROL
ODI Number: 10268111
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
ODI Number: 10267782
ELECTRICAL SYSTEM
ODI Number: 10263057
ENGINE AND ENGINE COOLING
ODI Number: 10263901
VEHICLE SPEED CONTROL
ODI Number: 10262512
SUSPENSION:FRONT
ODI Number: 10256555
VISIBILITY:SUN/MOON ROOF ASSEMBLY
ODI Number: 10256908
VISIBILITY:SUN/MOON ROOF ASSEMBLY
ODI Number: 10256907
ELECTRICAL SYSTEM | ENGINE AND ENGINE COOLING | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE) | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | STEERING | STEERING:LINKAGES:TIE
ODI Number: 10251514
SEAT BELTS
ODI Number: 10248779
ENGINE AND ENGINE COOLING:ENGINE | UNKNOWN OR OTHER
ODI Number: 10238674
STEERING
ODI Number: 10231141
FUEL SYSTEM, GASOLINE
ODI Number: 10230174
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10223125
EXTERIOR LIGHTING:HEADLIGHTS | SUSPENSION
ODI Number: 10219993
VEHICLE SPEED CONTROL
ODI Number: 10221277
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
ODI Number: 10218761
ELECTRICAL SYSTEM
ODI Number: 10193587
STRUCTURE
ODI Number: 10187942
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
ODI Number: 10177479
SUSPENSION:FRONT
ODI Number: 10178947
ELECTRICAL SYSTEM | SUSPENSION:FRONT
ODI Number: 10177705
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE | VEHICLE SPEED CONTROL:CRUISE CONTROL
ODI Number: 10174461
SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
ODI Number: 10175912
ENGINE AND ENGINE COOLING:ENGINE | VEHICLE SPEED CONTROL
ODI Number: 10171355
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | VEHICLE SPEED CONTROL:CRUISE CONTROL
ODI Number: 10168924
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
ODI Number: 10167172
VEHICLE SPEED CONTROL
ODI Number: 10162832
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | ENGINE AND ENGINE COOLING | POWER TRAIN:AUTOMATIC TRANSMISSION | STEERING:HYDRAULIC POWER ASSIST SYSTEM | SUSPENSION:FRONT
ODI Number: 10158043
VEHICLE SPEED CONTROL
ODI Number: 10159220
VEHICLE SPEED CONTROL
ODI Number: 10158975
VEHICLE SPEED CONTROL
ODI Number: 10156225
EXTERIOR LIGHTING
ODI Number: 10156565
ELECTRICAL SYSTEM
ODI Number: 10154351
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY | FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM | POWER TRAIN:AUTOMATIC TRANSMISSION | SUSPENSION:FRONT
ODI Number: 10152819
VEHICLE SPEED CONTROL
ODI Number: 10150186
SEAT BELTS:FRONT:RETRACTOR
ODI Number: 10151142
ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC) | ENGINE AND ENGINE COOLING:ENGINE | SERVICE BRAKES, HYDRAULIC
ODI Number: 10147731
VEHICLE SPEED CONTROL
ODI Number: 10148313
VEHICLE SPEED CONTROL
ODI Number: 10148905
VEHICLE SPEED CONTROL
ODI Number: 10145396
ELECTRICAL SYSTEM
ODI Number: 10146673
VEHICLE SPEED CONTROL
ODI Number: 10142412
VEHICLE SPEED CONTROL
ODI Number: 10143175
VEHICLE SPEED CONTROL
ODI Number: 10142005
VEHICLE SPEED CONTROL
ODI Number: 10143675
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 10139681
ENGINE AND ENGINE COOLING | VEHICLE SPEED CONTROL
ODI Number: 10141529
VEHICLE SPEED CONTROL
ODI Number: 10141147
ELECTRICAL SYSTEM
ODI Number: 10140083
ELECTRICAL SYSTEM:WIRING
ODI Number: 10137523
ELECTRICAL SYSTEM:IGNITION:MODULE
ODI Number: 10137671
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
ODI Number: 10137272
ELECTRICAL SYSTEM:IGNITION:MODULE
ODI Number: 10138995
ELECTRICAL SYSTEM
ODI Number: 10136070
VEHICLE SPEED CONTROL
ODI Number: 10135135
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP | VEHICLE SPEED CONTROL
ODI Number: 10134981
VEHICLE SPEED CONTROL
ODI Number: 10134845
VEHICLE SPEED CONTROL
ODI Number: 10136599
ELECTRICAL SYSTEM
ODI Number: 10134829
VEHICLE SPEED CONTROL
ODI Number: 10135870
VEHICLE SPEED CONTROL
ODI Number: 10134327
ENGINE AND ENGINE COOLING:ENGINE | VEHICLE SPEED CONTROL
ODI Number: 10136123
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 10135330
ELECTRICAL SYSTEM
ODI Number: 10136510
ELECTRICAL SYSTEM
ODI Number: 10134105
VEHICLE SPEED CONTROL
ODI Number: 10133059
FUEL SYSTEM, OTHER
ODI Number: 10133647
FUEL SYSTEM, GASOLINE:DELIVERY
ODI Number: 10133047
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
ODI Number: 10133792
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
ODI Number: 10133631
VEHICLE SPEED CONTROL
ODI Number: 10134206
ENGINE AND ENGINE COOLING | VEHICLE SPEED CONTROL
ODI Number: 10132993
ELECTRICAL SYSTEM
ODI Number: 10132416
ELECTRICAL SYSTEM:IGNITION | FUEL SYSTEM, OTHER
ODI Number: 10133658
ENGINE AND ENGINE COOLING
ODI Number: 10131203
ELECTRICAL SYSTEM
ODI Number: 10131184
ELECTRICAL SYSTEM
ODI Number: 10131176
VEHICLE SPEED CONTROL
ODI Number: 10131356
ENGINE AND ENGINE COOLING | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 10131165
ELECTRICAL SYSTEM | POWER TRAIN
ODI Number: 10131007
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
ODI Number: 10131123
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
ODI Number: 10131256
ENGINE AND ENGINE COOLING
ODI Number: 10131112
VEHICLE SPEED CONTROL
ODI Number: 10130941
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ODI Number: 10130940
ELECTRICAL SYSTEM:IGNITION:MODULE
ODI Number: 10131215
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 10128615
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 10128613
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 10121070
ELECTRICAL SYSTEM
ODI Number: 10122028
AIR BAGS
ODI Number: 10119530
WHEELS
ODI Number: 10117781
ENGINE AND ENGINE COOLING
ODI Number: 10114624
AIR BAGS
ODI Number: 10107661
SUSPENSION:FRONT
ODI Number: 10108722
STEERING:RACK AND PINION
ODI Number: 10101403
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 10098694
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
ODI Number: 10100106
VEHICLE SPEED CONTROL
ODI Number: 10093515
AIR BAGS
ODI Number: 10091325
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
ODI Number: 10088972
SEATS:FRONT ASSEMBLY:POWER ADJUST
ODI Number: 10089617
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
ODI Number: 10089590
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10083032
ENGINE AND ENGINE COOLING | EQUIPMENT:ELECTRICAL
ODI Number: 10069358
UNKNOWN OR OTHER
ODI Number: 10068570
POWER TRAIN
ODI Number: 10070447
ENGINE AND ENGINE COOLING
ODI Number: 10070071
ENGINE AND ENGINE COOLING | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 10059235
UNKNOWN OR OTHER
ODI Number: 10059224
STEERING
ODI Number: 10059473
EXTERIOR LIGHTING:HEADLIGHTS | POWER TRAIN:AUTOMATIC TRANSMISSION | STEERING:HYDRAULIC POWER ASSIST SYSTEM | STEERING:LINKAGES:TIE ROD ASSEMBLY | VEHICLE SPEED CONTROL:CRUISE CONTROL
ODI Number: 10059976
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10056834
STEERING
ODI Number: 10054194
ENGINE AND ENGINE COOLING:ENGINE | VEHICLE SPEED CONTROL
ODI Number: 10049436
STEERING:RACK AND PINION
ODI Number: 10045519
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10037241
ELECTRICAL SYSTEM
ODI Number: 10036637
POWER TRAIN:AXLE ASSEMBLY
ODI Number: 10030818
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
ODI Number: 10023782
STRUCTURE | VISIBILITY:SUN/MOON ROOF ASSEMBLY
ODI Number: 10017846
AIR BAGS:SIDE/WINDOW
ODI Number: 10016332
STEERING:HYDRAULIC POWER ASSIST SYSTEM
ODI Number: 10013633
AIR BAGS:SIDE/WINDOW
ODI Number: 10010364
VEHICLE SPEED CONTROL
ODI Number: 10011815
ELECTRICAL SYSTEM | ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
ODI Number: 10005694
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
ODI Number: 10004281
SUSPENSION:FRONT:CONTROL ARM
ODI Number: 8018235
ELECTRICAL SYSTEM:IGNITION:MODULE | EQUIPMENT:APPLIANCE:AIR CONDITIONER | VISIBILITY:POWER WINDOW DEVICES AND CONTROLS | VISIBILITY:SUN/MOON ROOF ASSEMBLY
ODI Number: 8017817
VEHICLE SPEED CONTROL
ODI Number: 8012766
EXTERIOR LIGHTING:HEADLIGHTS | EXTERIOR LIGHTING:HEADLIGHTS | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY | POWER TRAIN:AUTOMATIC TRANSMISSION | SEATS:FRONT ASSEMBLY:RECLINER | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR | STRUCTURE:BODY:DO
ODI Number: 8000744
ENGINE | VEHICLE SPEED CONTROL
ODI Number: 10823300
VEHICLE SPEED CONTROL
ODI Number: 10238000
POWER TRAIN:AXLE ASSEMBLY | SUSPENSION:FRONT:CONTROL ARM
ODI Number: 880812
SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
ODI Number: 874761
ELECTRICAL SYSTEM | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
ODI Number: 878186
ELECTRICAL SYSTEM:WIRING
ODI Number: 875509
SUSPENSION:FRONT:CONTROL ARM
ODI Number: 877354
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ODI Number: 868886
SUSPENSION:FRONT:CONTROL ARM
ODI Number: 867242
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP | STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 868636
SUSPENSION:FRONT:WHEEL BEARING
ODI Number: 866124
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
ODI Number: 856843
AIR BAGS:FRONTAL | AIR BAGS:FRONTAL | AIR BAGS:SIDE/WINDOW | VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 853218
FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
ODI Number: 767606
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ODI Number: 764181
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | POWER TRAIN:AUTOMATIC TRANSMISSION | POWER TRAIN:DRIVELINE:DRIVESHAFT | STEERING:LINKAGES:TIE ROD ASSEMBLY | STRUCTURE:FRAME AND MEMBERS
ODI Number: 761186
SUSPENSION:FRONT:CONTROL ARM | SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
ODI Number: 760585
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 758996
WHEELS
ODI Number: 756356
FUEL SYSTEM, GASOLINE:DELIVERY
ODI Number: 753380
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 732762
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 730944
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM | STEERING:RACK AND PINION:RACK
ODI Number: 731015
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
ODI Number: 728934
VEHICLE SPEED CONTROL | VEHICLE SPEED CONTROL
ODI Number: 727347
SUSPENSION:FRONT
ODI Number: 726344
AIR BAGS:FRONTAL
ODI Number: 724593
STEERING:LINKAGES:TIE ROD ASSEMBLY
ODI Number: 725262
STRUCTURE:FRAME AND MEMBERS | SUSPENSION:FRONT
ODI Number: 721272
STRUCTURE:FRAME AND MEMBERS | SUSPENSION:FRONT
ODI Number: 718578
ELECTRICAL SYSTEM
ODI Number: 566698
ENGINE AND ENGINE COOLING:ENGINE | ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 566698
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
ODI Number: 566698
SUSPENSION
ODI Number: 566698
EXTERIOR LIGHTING:BRAKE LIGHTS | EXTERIOR LIGHTING:HEADLIGHTS
ODI Number: 566698
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
ODI Number: 565833
TIRES:SIDEWALL
ODI Number: 558408
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
ODI Number: 556544
SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
ODI Number: 556229
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 551710
SEAT BELTS:FRONT:ANCHORAGE
ODI Number: 549987
Is the government investigating the safety of your vehicle? Find out here.

2 Investigations for 1999 VOLVO S80

Date Opened Date Closed Component  
VEHICLE SPEED CONTROL
VEHICLE SPEED CONTROL
Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

311 Service Alerts for 1999 VOLVO S80

Date Description
May 6, 2022 353000 EQUIPMENT:ELECTRICAL

ICUP/Google Built-In Diagnostic Operations

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 6, 2022 980000 UNKNOWN OR OTHER

ICUP/Google Built-In Diagnostic Operations

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 23, 2020 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Battery Charger/maintainer requirement

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 23, 2020 980000 UNKNOWN OR OTHER

Battery Charger/maintainer requirement

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2022 980000 UNKNOWN OR OTHER

The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 7, 2022 134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

Panoramic sunroof, sealing strip has a gap

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 7, 2022 350000 EQUIPMENT

Panoramic sunroof, sealing strip has a gap

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 3, 2022 110000 ELECTRICAL SYSTEM

Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 3, 2022 350000 EQUIPMENT

Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 9, 2022 350000 EQUIPMENT

VIDA QR Scanner Mobile App

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 19, 2021 350000 EQUIPMENT

Volvo?s Warranty Department tracks Retailer warranty spending by utilizing the Warranty Retailer Counseling Process (WRCP). The WRCP is used to gauge individual retailer performance on objective measures over time. By setting clear performa

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 10, 2020 140000 AIR BAGS

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 18, 2020 350000 EQUIPMENT

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 18, 2020 356000 EQUIPMENT ADAPTIVE/MOBILITY

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 31, 2020 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 5, 2020 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 14, 2020 110000 ELECTRICAL SYSTEM

This is a Service Manager Bulletin: Volvo Lithium-ion Hybrid Battery Packs shipping and handling to Volvo Reman

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 2, 2020 356000 EQUIPMENT ADAPTIVE/MOBILITY

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 17, 2020 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Service Manager Bulletin: Vehicle Type and Platform Information

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 24, 2020 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. For battery replacements under warranty, the code generated by the BT3300 m

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 9, 2019 110000 ELECTRICAL SYSTEM

Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. For battery replacements under warranty, the code generated by the BT3300 m

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 6, 2019 110000 ELECTRICAL SYSTEM

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 9, 2019 350000 EQUIPMENT

This is a Service Manager Bulletin: Technician Skillset Requirments

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 24, 2017 110000 ELECTRICAL SYSTEM

This is a Technical Journal: Replacing CEM or Recommunicating with a ‘sleeping’ vehicle

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 3, 2017 350000 EQUIPMENT

Mandatory Special Tool List

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 19, 2019 110000 ELECTRICAL SYSTEM

This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other co

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 14, 2019 110000 ELECTRICAL SYSTEM

This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other co

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 9, 2019 110000 ELECTRICAL SYSTEM

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 15, 2016 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA 201

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 15, 2016 136300 VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES

This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA 201

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 15, 2016 350000 EQUIPMENT

This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA 201

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 15, 2016 356000 EQUIPMENT ADAPTIVE/MOBILITY

This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA 201

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 21, 2016 200000 WHEELS

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 21, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 30, 2020 350000 EQUIPMENT

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 17, 2019 350000 EQUIPMENT

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 16, 2019 060000 ENGINE AND ENGINE COOLING

This is a Technical Journal: Oil in cooling system. New cleaning method developed.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 18, 2017 350000 EQUIPMENT

Service Manager Bulletin TITLE : Service Action Notification Re – Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 – 323 and SMB00 – 323A YEA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 13, 2017 110000 ELECTRICAL SYSTEM

This is a Service Product Journal: VIDA will not support Windows 8.1 after June 30th 2017

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 13, 2017 350000 EQUIPMENT

This is a Service Product Journal: VIDA will not support Windows 8.1 after June 30th 2017

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 24, 2017 110000 ELECTRICAL SYSTEM

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 15, 2017 110000 ELECTRICAL SYSTEM

Technical Journal TITLE : The Error Frame Finder (EFF) can be an aid in fault tracing intermittent CAN network problems by providing a visible indication of error frames that are being transmitted on the network when the fault becomes activ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 15, 2017 160000 STRUCTURE

Technical Journal TITLE : The Error Frame Finder (EFF) can be an aid in fault tracing intermittent CAN network problems by providing a visible indication of error frames that are being transmitted on the network when the fault becomes activ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 3, 2016 200000 WHEELS

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 3, 2016 350000 EQUIPMENT

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 3, 2016 356000 EQUIPMENT ADAPTIVE/MOBILITY

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 9, 2016 200000 WHEELS

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 9, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 8, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

While performing repairs, on vehicles covered by Volvo’s New Vehicle Warranty, the Technical Help Desk may support the dealer by providing a specific diagnostic labor operation. This will aid the Warranty Administrator when claiming reimbur

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 8, 2016 356000 EQUIPMENT ADAPTIVE/MOBILITY

While performing repairs, on vehicles covered by Volvo’s New Vehicle Warranty, the Technical Help Desk may support the dealer by providing a specific diagnostic labor operation. This will aid the Warranty Administrator when claiming reimbur

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 4, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Please use attached file to create new version of bulletin. Please remove original bulletin by same number dated 2/18/2010.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 3, 2017 350000 EQUIPMENT

Dice Tool bulletin explaining the offer.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 22, 2017 070000 FUEL SYSTEM, GASOLINE

This is a Technical Journal: Washer system layout for identifying leakage points REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 25153 Technical Service PARTNER : ISSUE DATE : STATUS DATE : 3 US 7510 Volvo Car USA 201

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 18, 2017 350000 EQUIPMENT

VOLVO CARS SERVICE AND PARTS BUSINESS Service Manager Bulletin TITLE : The Volvo Replacement Part Lifetime Warranty GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Warranty United States 00 342 REFERENCE BULLETINS : DATE : YEAR MONTH DAY SER

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 10, 2017 110000 ELECTRICAL SYSTEM

Descripition of Goodwill Policy and Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 10, 2017 350000 EQUIPMENT

Descripition of Goodwill Policy and Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 11, 2017 110000 ELECTRICAL SYSTEM

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 11, 2017 350000 EQUIPMENT

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 18, 2017 010000 STEERING

VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo C

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 14, 2017 350000 EQUIPMENT

This is a Service Manager Bulletin: The online bookstore, www.volvotechinfo.com, serves Volvo Retailers, employees, Independent Repairers and customers throughout the United States and Canada by providing easy order-access to service, parts

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 24, 2017 110000 ELECTRICAL SYSTEM

This is a Technical Journal: Replacing CEM or Recommunicating with a ‘sleeping’ vehicle

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 29, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

VOLVO CARS SERVICE AND PARTS BUSINESS Service Manager Bulletin TITLE : Workshop Systems Requirements and Guidelines VIDA in 2015 , Peer – to – Peer Infrastructure GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada 00 33

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 3, 2017 350000 EQUIPMENT

This is a Service Manager Bulletin: Service Scheduling system enhancements. Improving Service Action/Recall scheduling.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 28, 2017 110000 ELECTRICAL SYSTEM

MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 15, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Retailers should only use a Volvo part number on claims for items purchased directly from Volvo. Failure to follow this policy will result in claim adjustments. Warranty reimbursement rates and quantity limits for the parts listed, with the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 23, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Service Manager Bulletin: Technician Skillset Requirments

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 15, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Retailers should only use a Volvo part number on claims for items purchased directly from Volvo. Failure to follow this policy will result in claim adjustments. Warranty reimbursement rates and quantity limits for the parts listed, with the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 9, 2019 062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

This is a Technical Journal: Oil in cooling system. New cleaning method developed.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 9, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Technical Journal: Oil in cooling system. New cleaning method developed.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 9, 2019 060000 ENGINE (PWS)

This is a Technical Journal: Oil in cooling system. New cleaning method developed.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 7, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Service Manager Bulletin: Claiming for Map Upgrades is not a matter for warranty. Claims submitted for map upgrades will be debited

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 12, 2019 118000 ELECTRICAL SYSTEM:SOFTWARE

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 3, 2019 131000 VISIBILITY:WINDSHIELD

This is a Service Manager Bulletin: Windshield replacement products.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 14, 2019 180000 VEHICLE SPEED CONTROL

This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 14, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 14, 2019 030000 BRAKES (PWS)

This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 13, 2018 110000 ELECTRICAL SYSTEM

Technical Journal TITLE : Keyless Drive receiver issues ( short remote control range , key messages ) REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 27316 – PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North America Y

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 13, 2018 160000 STRUCTURE

Technical Journal TITLE : Keyless Drive receiver issues ( short remote control range , key messages ) REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 27316 – PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North America Y

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 13, 2018 350000 EQUIPMENT

Technical Journal TITLE : Keyless Drive receiver issues ( short remote control range , key messages ) REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 27316 – PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North America Y

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 13, 2018 356000 EQUIPMENT ADAPTIVE/MOBILITY

Technical Journal TITLE : Keyless Drive receiver issues ( short remote control range , key messages ) REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 27316 – PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North America Y

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 9, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 9, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 20, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 5, 2019 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Service Product Journal: Information Notice. We process the personal data that you provide in connection with the creation of your VIDA account. The purpose of our processing is to administer your VIDA account (from registration t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 2019 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. For battery replacements under warranty, the code generated by the BT3300 m

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 27, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 27, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 24, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 24, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 22, 2018 350000 EQUIPMENT

This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it’s dealer or any shop maintaining or repairing Volvo’s. The equipment can be provided by Volvo’s equipment supplier

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 22, 2018 356000 EQUIPMENT ADAPTIVE/MOBILITY

This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it’s dealer or any shop maintaining or repairing Volvo’s. The equipment can be provided by Volvo’s equipment supplier

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 16, 2019 350000 EQUIPMENT

This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 16, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 14, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Parts Bulletin: Hazmat Return Transportation Documentation and requirements

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 18, 2018 200000 WHEELS

Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 18, 2018 350000 EQUIPMENT

Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 18, 2018 356000 EQUIPMENT ADAPTIVE/MOBILITY

Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 2, 2018 350000 EQUIPMENT

This is a Service Product Journal: Software Purchase Failed – General error occured – VDS / SPA / CMA cars. Download software fix

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 2, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Service Product Journal: Software Purchase Failed – General error occured – VDS / SPA / CMA cars. Download software fix

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 4, 2018 350000 EQUIPMENT

This is a Technical Journal: Vehicle Key Not Found

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 4, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Technical Journal: Vehicle Key Not Found

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 13, 2019 350000 EQUIPMENT

This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 13, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 11, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Description of Goodwill Policy and Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 200000 WHEELS

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 27, 2018 110000 ELECTRICAL SYSTEM

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 27, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 110000 ELECTRICAL SYSTEM

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 24, 2018 110000 ELECTRICAL SYSTEM

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 24, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 13, 2018 353000 EQUIPMENT:ELECTRICAL

Technical Journal TITLE : Keyless Drive receiver issues ( short remote control range , key messages ) REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 27316 – PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North America Y

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 9, 2018 110000 ELECTRICAL SYSTEM

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 9, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2018 110000 ELECTRICAL SYSTEM

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2018 110000 ELECTRICAL SYSTEM

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 2, 2018 110000 ELECTRICAL SYSTEM

This is a Service Product Journal: Software Purchase Failed – General error occured – VDS / SPA / CMA cars. Download software fix

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 2, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Service Product Journal: Software Purchase Failed – General error occured – VDS / SPA / CMA cars. Download software fix

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 110000 ELECTRICAL SYSTEM

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2018 150000 SEAT BELTS

This bulletin is a service manager bulletin. Seat Belt Extender.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2018 356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin is a service manager bulletin. Seat Belt Extender.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 200000 WHEELS

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 29, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2018 150000 SEAT BELTS

This bulletin is a service manager bulletin. Seat Belt Extender.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2018 356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin is a service manager bulletin. Seat Belt Extender.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 4, 2018 350000 EQUIPMENT

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 4, 2018 356000 EQUIPMENT ADAPTIVE/MOBILITY

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 22, 2018 350000 EQUIPMENT

This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it’s dealer or any shop maintaining or repairing Volvo’s. The equipment can be provided by Volvo’s equipment supplier

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2018 150000 SEAT BELTS

This bulletin is a service manager bulletin. Seat Belt Extender.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin is a service manager bulletin. Seat Belt Extender.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2018 356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin is a service manager bulletin. Seat Belt Extender.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 4, 2018 350000 EQUIPMENT

This is a Technical Journal: Vehicle Key Not Found

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 4, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Technical Journal: Vehicle Key Not Found

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 18, 2018 190000 TIRES

Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 18, 2018 200000 WHEELS

Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 18, 2018 350000 EQUIPMENT

Road Force wheel balancing is the proper tool for diagnosing and repairing such issues and all of our retailers need to be prepared for these issues.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 20, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 20, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

Software Installation Policy changes – Canada

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 23, 2019 110000 ELECTRICAL SYSTEM

Effective immediately, all 12V batteries may be tested using the hand held battery tester 9513030 (BT3300). The VIDA test is still available but no longer required. For battery replacements under warranty, the code generated by the BT3300 m

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 16, 2018 350000 EQUIPMENT

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 16, 2018 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 16, 2019 350000 EQUIPMENT

This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 16, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 16, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

This is a Special Tool Bulletin: Newsletter 81 Mandatory Tools

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 4, 2018 350000 EQUIPMENT

Description of Goodwill Policy and Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 14, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Parts Bulletin: Hazmat Return Transportation Documentation and requirements

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 18, 2018 350000 EQUIPMENT

This is a Service Manager Bulletin. This bulletin is a list of equipment recommended by Volvo to it’s dealer or any shop maintaining or repairing Volvo’s. The equipment can be provided by Volvo’s equipment supplier

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 14, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 14, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

This is a Technical Journal: When sensitive information, like vehicle speed, brake usage, etc. (customer behavoiur information) of a car is required from Volvo Car Corporation from external sources, either of these two documents should be f

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 13, 2019 350000 EQUIPMENT

This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 13, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

This is a Service Manager Bulletin: Volvo Special Tool Warranty Coverage and Claims Process

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 9, 2019 060000 ENGINE AND ENGINE COOLING

This is a Technical Journal: Oil in cooling system. New cleaning method developed.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 4, 2018 350000 EQUIPMENT

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 4, 2018 356000 EQUIPMENT ADAPTIVE/MOBILITY

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 17, 2017 200000 WHEELS

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 17, 2017 150000 SEAT BELTS

This bulletin is a service manager bulletin. Seat Belt Extender.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2018 160000 STRUCTURE

VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo C

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2018 350000 EQUIPMENT

VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo C

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 28, 2017 110000 ELECTRICAL SYSTEM

This is a Technical Journal: Configuration Test Software

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2018 350000 EQUIPMENT

VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo C

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 4, 2017 350000 EQUIPMENT

MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 3, 2017 350000 EQUIPMENT

This is a Service Product Journal:

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 24, 2017 200000 WHEELS

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 4, 2017 110000 ELECTRICAL SYSTEM

MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 3, 2017 350000 EQUIPMENT

This is a Service Product Journal:

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 3, 2017 353000 EQUIPMENT:ELECTRICAL

This is a Service Product Journal:

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 9, 2017 350000 EQUIPMENT

Warranty, customer pay and/or internal repairs performed must be verified by a punched time flag on the back of the Repair Order hard copy. Each repair line must have a separate and identifiable time punch for the respective repair for all

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 9, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Warranty, customer pay and/or internal repairs performed must be verified by a punched time flag on the back of the Repair Order hard copy. Each repair line must have a separate and identifiable time punch for the respective repair for all

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 9, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The Warranty Retailer Counseling Process (WRCP) is used to gauge individual retailer performance on objective measures over time. By setting clear performance expectations and parameters and assisting retailers in focusing on individual pro

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 8, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Service Manager Bulletin TITLE : Service Action Notification Re – Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 – 323 and SMB00 – 323A YEA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 19, 2017 350000 EQUIPMENT

VOLVO CARS SERVICE AND PARTS BUSINESS Service Manager Bulletin TITLE : Workshop Systems Requirements and Guidelines VIDA in 2015 , Peer – to – Peer Infrastructure GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada 00 33

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 19, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

VOLVO CARS SERVICE AND PARTS BUSINESS Service Manager Bulletin TITLE : Workshop Systems Requirements and Guidelines VIDA in 2015 , Peer – to – Peer Infrastructure GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada 00 33

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 11, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 18, 2017 140000 AIR BAGS

Service Manager Bulletin TITLE : Service Action Notification Re – Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 – 323 and SMB00 – 323A YEA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 18, 2017 151400 SEAT BELTS:FRONT:BUCKLE ASSEMBLY

Service Manager Bulletin TITLE : Service Action Notification Re – Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 – 323 and SMB00 – 323A YEA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 18, 2017 176100 LATCHES/LOCKS/LINKAGES:HOOD:LATCH

Service Manager Bulletin TITLE : Service Action Notification Re – Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 – 323 and SMB00 – 323A YEA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 18, 2017 143100 AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

Service Manager Bulletin TITLE : Service Action Notification Re – Mails GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : Product Safety & Compliance United States and Canada 00 325 REFERENCE BULLETINS : DATE : SMB00 – 323 and SMB00 – 323A YEA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 19, 2017 340000 COMMUNICATION

VOLVO CARS SERVICE AND PARTS BUSINESS Service Manager Bulletin TITLE : Workshop Systems Requirements and Guidelines VIDA in 2015 , Peer – to – Peer Infrastructure GROUP : NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada 00 33

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 11, 2017 354000 EQUIPMENT:MECHANICAL

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 11, 2017 282000 BACK OVER PREVENTION: WARNINGS

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 11, 2017 340000 COMMUNICATION

Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2016 118000 ELECTRICAL SYSTEM:SOFTWARE

This document is a Technical Journal: Information about valid Software partnumbers to order and download Software for “PDS” Pre-Delivery Service

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 28, 2017 200000 WHEELS

This is a Parts Bulletin: Wheel Cross Reference, used to assist in identifying the correct spare replacement wheel, by stamping, name and size.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 23, 2016 200000 WHEELS

Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 23, 2016 201000 WHEELS:RIM

Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 13, 2000 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

INFORMATION ON MINIMIZING TIME ASSOCIATED WITH TCM DIAGNOSTIC TROUBLE CODES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 17, 2000 010000 STEERING

SUBJECT REGARDING AN SOFTWARE UPGRADE FOR THE SPEED SENSITIVE STEERING TO IMPROVE STEERING COMFORT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 13, 2000 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

EXPERIENCING A SQUEAK TYPE NOISE HEARD FROM THE WINDOW REGULATOR WHEN THE WINDOW GLASS IS MOVING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 21, 2000 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

SUBJECT REGARDING CABIN AIR FILTER REPLACEMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2000 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

NEW REAR BRAKE PADS FOR CUSTOMER COMPLAINTS OF VIBRATION WHEN BRAKING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 22, 2002 110000 ELECTRICAL SYSTEM

CEM FAULT TRACING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 25, 2002 138120 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT

CLIMATE CONTROL MODULE (CCM) MALFUNCTION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 15, 2002 061000 ENGINE AND ENGINE COOLING:ENGINE

CRANK NO START, NO FUEL PRESSURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 13, 1999 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

CONDITIONS ON THE FRONT WINDOW REGULATOR MECHANISM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 12, 1999 134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

ON SOME VEHICLES, THE METAL SUNROOF FASTENERS HOLDING THE RIGHT AND LEFT SIDE COVERS TO THE GLASS ASSEMBLY MAY COME LOOSE AND RESULT IN A RATTLING NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 11, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

CONCERNS WITH PROPER TRANSMISSION FLUID USAGE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2000 221600 SEATS:FRONT ASSEMBLY:POWER ADJUST

CUSTOMER MAY EXPERIENCE MINIMAL FORE AND AFT MOVEMENT DURING ACCELERATION AND DECELERATION WHEN DRIVING A CAR EQUIPPED WITH POWER SEATS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 18, 1999 980000 UNKNOWN OR OTHER

SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE AND ELECTRONIC THROTTLE SYSTEM LIGHTS ON THE DASH PANEL ILLUMINATED WITH ECM DTC 91A7, 903C, 91F0, 532D OR A COMBINATION THEREOF. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 10, 1998 114200 ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH

SERVICE CAMPAIGN – REGARDING SOFTWARE DOWNLOAD PROCEDURES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 18, 1999 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

SUBJECT ON THE RADIO RECEPTION / ANTENNA. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 15, 1999 015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM

SUBJECT REGARDING POWER STEERING SYSTEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 16, 1999 162300 STRUCTURE:BODY:DOOR

ON SOME VEHICLES, WHEN USING THE REMOTE CONTROL TO UNLOCK THE DOORS, ONE OR MORE OF THE DOORS MAY NOT UNLOCK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 22, 1998 114200 ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH

SUBJECT REGARDING ECC SOFTWARE UPGRADE – FUNCTION ID: 207. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 3, 2016 150000 SEAT BELTS

Seat Belt Extender

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 3, 2016 356000 EQUIPMENT ADAPTIVE/MOBILITY

Seat Belt Extender

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 24, 2000 110000 ELECTRICAL SYSTEM

THIS BULLETIN MENTIONS THAT SEVERAL CHANGES HAVE BEEN TO THE ELECTRICAL SYSTEM ON SOME VEHICLES AS WELL AS DIFFERENT TERMINOLOGY USED TO DESCRIBE THE VARIOUS PRODUCTION WEEK CHANGES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 125100 EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

THIS SERVICE BULLETIN DESCRIBES HOW TO REPLACE THE HIGH-LEVEL BRAKE LIGHT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1999 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

INFORMATION ON REPLACING HEATED OXYGEN SENSOR (HO2S). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 2, 1999 140000 AIR BAGS

SUBJECT REGARDING SRS DIAGNOSTIC TROUBLE CODES – DIAGNOSTIC CORRECTION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2000 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

INFORMATION REPLACING THE POWER WINDOW REGULATOR FOR THE FRONT SIDE DOOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2000 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

SOME CUSTOMERS MAY COMPLAIN ABOUT RADIO REFERENCE ON THE AM WAVE BAND AROUND 900 KHZ. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 8, 1998 150000 SEAT BELTS

SUBJECT ON SEATBELTS / CHILD SEAT SAFETY – ALR/ELR. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2003 030000 SERVICE BRAKES, HYDRAULIC

BRAKE VIBRATIONS, ANALYSIS AND CORRECTIVE ACTION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2005 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

EXCESSIVE HEAT MAY BE GENERATED BY THE RUNNING OF COOLING FAN. RECALL CAMPAIGN 141 TO INSPECT/REPLACE ENGINE COOLING FAN CONTROL MODULE (EFCM) AND COOLING FAN ASSEMBLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 21, 2016 350000 EQUIPMENT

*No Description

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 17, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The Volvo Technical Helpdesk (THD) is a central contact point available to authorized Volvo dealer technicians to assist with difficult to repair situations. If for some reason our technical experts cannot solve an issue directly, it will b

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 27, 2016 118000 ELECTRICAL SYSTEM:SOFTWARE

A new feature will be available in VIDA version 16.4 where by users will be automatically informed when their passwords are about to expire. The pop-up window example, in the attachment, will be shown 14 days prior to the expiraton date.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 23, 2016 114000 ELECTRICAL SYSTEM:WIRING

Alternative solution when VIDA is unavailable or the Electronic Wiring Diagrams function in VIDA is unstable. Access by using the applicable URL.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 23, 2016 118000 ELECTRICAL SYSTEM:SOFTWARE

Alternative solution when VIDA is unavailable or the Electronic Wiring Diagrams function in VIDA is unstable. Access by using the applicable URL.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 27, 2016 118000 ELECTRICAL SYSTEM:SOFTWARE

Below error message may be shown in VIDA when selecting the Software tab in VIDA. With this message, it will not be possible to purchase Software Products. “124 – Client ID is not registered”

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 27, 2016 118000 ELECTRICAL SYSTEM:SOFTWARE

VIDA users are not able to check Operations & Packages An error message will be shown saying “Database error. Please contact System Administrator”

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 10, 2006 190000 TIRES

VOLVO RECOMMENDED WINTER TIRES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2003 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSMISSION, SHUDDER DURING UPSHIFT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 2000 162000 STRUCTURE:BODY

ON SOME VEHICLES, THE LOWER A POST TRIM BETWEEN THE FENDER AND COWL MAY BECOME LOOSE CAUSING A MISALIGNMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2004 180000 VEHICLE SPEED CONTROL

ELECTRONIC THROTTLE MODULE (ETM), CLEANING. *MJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1999 980000 UNKNOWN OR OTHER

SOME MODELS MAY HAVE A CONDITION WHERE THE CHECK ENGINE AND ELECTRONIC THROTTLE SYSTEM LIGHTS ON THE DASH PANEL MAY ILLIMINATE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 980000 UNKNOWN OR OTHER

INFORMATION ON THE 1999 GENUINE VOLVO CARE — PREPAID FACTORY SCHEDULED MAINTENANCE SERVICE PROGRAM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 17, 2004 221600 SEATS:FRONT ASSEMBLY:POWER ADJUST

SMALL FORE AND AFT OR ROCKING MOVEMENT OF THE SEAT DURING ACCELERATIONS ND DECELERATION MIGHT BE EXPERIENCED IN CERTAIN CASES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 7, 2006 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

TRANSMISSION CONTROL MODULE (TCM) UPGRADES AVAILABLE TO CORRECT COMPLAINTS/SYMPTOMS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 6, 2004 021000 SUSPENSION:FRONT

BALL JOINT REPLACEMENT NEW METHODS (REPLACES ALL PREVIOUS METHODS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 13, 2004 020000 SUSPENSION

TIGHTENING, NEW BALL JOINT NUT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 29, 2003 106000 POWER TRAIN:AXLE ASSEMBLY

FRONT AXLE PING NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2002 061000 ENGINE AND ENGINE COOLING:ENGINE

OIL PUMP ATTACHMENT SCREWS, COPPER WASHER INSTALLATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 7, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

WARRANTY, CUSTOMER PAY AND/OR INTERNAL REPAIRS PERFORMED MUST BE VERIFIED BY A PUNCHED TIME FLAG ON THE BACK OF THE REPAIR ORDER HARD COPY. EACH REPAIR LINE MUST HAVE A SEPARATE AND IDENTIFIABLE TIME PUNCH FOR THE RESPECTIVE REPAIR FOR ALL

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2000 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

DIAGNOSIS AND CHECK LIST FOR AUTOMATIC TRANSMISSIONS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2000 013000 STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

INFORMATION ON INSTALLING AN ADDITIONAL GUIDE SLEEVE – AUTOMATIC GEARBOX. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 28, 1999 980000 UNKNOWN OR OTHER

INFORMATION ON VEHICLES EXHIBITING THE CHECK ENGINE AND ELECTRONIC THROTTLE SYSTEM LIGHTS ON THE DASH PANEL ILLUMINATED WITH ECM DTC 91A7, 903C, F1F0, 532D OR A COMGINATION THEREOF. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 12, 1999 015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM

INFORMATION ON THE POWER STEERING SYSTEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 28, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SUBJECT REGARDING GUIDELINES ON RECHARGING AIR CONDITIONER SYSTEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2001 111100 ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

POSITIVE BATTERY CABLE, NEW ROUTING. *YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 8, 2016 350000 EQUIPMENT

VOLVO CARS SERVICE AND PARTS BUSINESS SERVICE MANAGER BULLETIN TITLE : RETAIL CAR DELIVERY PROCESS ALL MY 2016 S60 , V60 , XC60 , XC70 AND S80 GROUP : NO:ISSUING DEPARTMENT : CAR MARKET : UNITED STATES AND CANADA 17 2016A SERVICE OPERATIONS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 8, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

VOLVO CARS SERVICE AND PARTS BUSINESS SERVICE MANAGER BULLETIN TITLE : RETAIL CAR DELIVERY PROCESS ALL MY 2016 S60 , V60 , XC60 , XC70 AND S80 GROUP : NO:ISSUING DEPARTMENT : CAR MARKET : UNITED STATES AND CANADA 17 2016A SERVICE OPERATIONS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2001 110000 ELECTRICAL SYSTEM

THIS SERVICE BULLETIN EXPLAINS HOW TO FAULT TRACE SOURCES ELECTRICAL INTERFERENCE WITH THE AM RADIO FOR 2001 V70, XC70 AND 1999 S80 MODEL VEHICLES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2001 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

THIS BULLETIN DESCRIBES HOW TO MOVE THE CABLE HARNESS THAT CARRIES THE CABLES FOR THE GEAR SELECTOR MODULE WHEN DIAGNOSTIC TROUBLE CODE (DTC) TRANSMISSION CONTROL MODULE (TCM) 0094 IS STORED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2001 110000 ELECTRICAL SYSTEM

THIS SERVICE BULLETIN DESCRIBES HOW TO CLEAN THE ELECTRONIC THROTTLE MODULE (ETM) BORE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2001 182000 VEHICLE SPEED CONTROL:LINKAGES

THIS SERVICE BULLETIN DESCRIBES HOW TO CLEAN THE ELECTRONIC THROTTLE MODULE (ETM) BORE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 5, 2001 125000 EXTERIOR LIGHTING:BRAKE LIGHTS

BRAKE LIGHT BULB REPLACEMENTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 11, 2001 061000 ENGINE AND ENGINE COOLING:ENGINE

INFORMATION ON OIL LEAKAGE FROM FLYWHEEL / FLEXPLATE, REAR CRANKSHAFT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2001 061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER

INFORMATION REGARDING OIL DELIVERY PIPE REPLACEMENT FOR THE TURBOCHARGER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 30, 2002 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SUBJECT REGARDING DELAYED AIR CONDITIONER COMPRESSOR START UP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 14, 2001 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

INFORMATION REGARDING PURGE VALVE, DIAGNOSTIC INFORMATION. *YH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 19, 1999 012200 STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE

INFORMATION PERTAINING TO SECURITY OPTIONS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2003 063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

NEW BRACKET IN THE SUB-FRAME FOR MOUNTING THE CATALYTIC CONVERTER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 22, 2003 980000 UNKNOWN OR OTHER

CERTIFIED PRE-OWNED UPGRADE MY1999 AND 2000 S80 PEACE OF MIND ENHANCEMENT PROGRAM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 16, 2008 072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

NEW FUEL PUMP FOR STARTING PROBLEMS WHEN PARKED DOWNHILL. *NJ UPDATED 6/5/08. *NJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 8, 2001 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

WINDSHIELD WIPER SQUEAK CONDITION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 6, 2001 120000 EXTERIOR LIGHTING

A CONDITION MAY EXIST WERE CONDENSATION MAY ACCUMULATE ON THE INSIDE OF THE LICENSE PLATE LAMP HOUSING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 24, 2001 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

SUBJECT REGARDING MASS AIR FLOW SENSOR REPLACEMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 24, 2001 162300 STRUCTURE:BODY:DOOR

SUBJECT REGARDING NEW PLASTIC COATED DOOR STOPS INTRODUCED INTO PRODUCTION TO ADDRESS THE ISSUES OF CORROSION, GRINDING NOISE, AND EXCESSIVE OPENING / CLOSING FORCE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 25, 2012 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

VOLVO: THERE IS A SOFTWARE UPDATE. *RM UPDATED 4/11/2012. *KB UPDATED 4/13/12. *PE UPDATED 5/15/12. *PE UPDATED 6/4/12. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 110000 ELECTRICAL SYSTEM

EXPERIENCING POSSIBLE DIAGNOSTIC TROUBLE CODE FOR MISFIRE; TACHOMETER NEEDLE FLUCTUATES; ENGINE DIFFICULT TO START. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 071110 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

INFORMATION ON SPECIAL TOOL – FUEL CAP, TEST EQUIPMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 21, 2016 118000 ELECTRICAL SYSTEM:SOFTWARE

THIS IS A TECHNICAL JOURNAL: THIS JOURNAL IS A GUIDE FOR PERFORMING SOFTWARE DOWNLOADS. SERVICE: *SEE GUIDE UPDATED OCT. 12, 2016 FOR RELEVANT P5/SPA SOFTWARE DOWNLOAD INFORMATION: P5_SPA_SW_GUIDE.PDF SEE VIDA SOFTWARE TAB FOR ALL OTHER VEH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2016 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

THIS IS A SERVICE PRODUCT JOURNAL : THE PREVIOUSLY REPORTED ISSUE WITH VIDA 2015 AND BATTERY TESTING HAS BEEN RESOLVED. VIDA 2015 BATTERY TESTING IS THE ONLY APPROVED METHOD FOR PRODUCING BATTERY TEST CODES. THE USE OF VIDA CLASSIC OR OTHER

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 30, 2001 980000 UNKNOWN OR OTHER

SUBJECT REGARDING SW-DELAYED A/C COMPRESSOR START UP. *YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 4, 2004 161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

SUB FRAME SQUEAKING NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 7, 2004 221600 SEATS:FRONT ASSEMBLY:POWER ADJUST

MECHANICAL FRONT SEATS, ADJUSTING SEAT SLIDE RAIL LOCKING POSITION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 28, 1999 350000 EQUIPMENT

BRIEF INFORMATION REGARDING VADIS TIPS #6. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2004 220000 SEATS

FRONT SEAT, MECHANICAL, ADJUSTING. PLAY/CLEARANCE/CLICKING AT THE LOWER MOUNTINGS FOR THE FRONT HEIGHT ADJUSTER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 17, 2001 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

INFORMATION REGARDING OSCILLATING TORQUE DURING ACCELERATION. *YH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2003 220000 SEATS

NOISE OR ROCKING MOTION FROM THE SEAT RAILS ON MANUAL FRONT SEATS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 21, 2003 061000 ENGINE AND ENGINE COOLING:ENGINE

ROUGH COLD START. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING OIL DELIVERY PIPE, REPLACEMENT. *YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 28, 2005 022000 SUSPENSION:REAR

REAR SUSPENSION POPPING/SPRING NOISE. TO INCLUDE VOLVO XC90 1999-2000. *SC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 9, 2005 112000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

ALTERNATOR CHARGING PROBLEMS. *SC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 22, 1998 116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

SUBJECT ON KEY LOCK CABLE INSPECTION / CONNECT. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 20, 2006 180000 VEHICLE SPEED CONTROL

ELECTRONIC THROTTLE SYSTEM SOFTWARE UPGRADE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 16, 2006 180000 VEHICLE SPEED CONTROL

ELECTRONIC THROTTLE MODULE (ETM) EXTENDED WARRANTY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 20, 2006 063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)

WARRANTY COVERAGE SHOULD A CUSTOMER EPXERIENCE A DEFECT WIT THE ETM SYSTEM BEYOND THE TERMS OF THE NORMAL NEW CAR WARRANTY. *TT TROUBLESHOOTING ELECTRONIC THROTTLE SYSTEM (ETS). *TT CHECKING CRANKCASE VENTILATION SYSTEM. *TT CLEANI

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2003 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION SHUDDER DURING UPSHIFT (MOST COMMON DURING THE 2-3 SHIFT). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 30, 2001 033100 SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

THIS BULLETIN STATES THAT CERTAIN MODELS NOW HAVE DIFFERENT BRAKE PEDAL FEEL DUE TO THE BRAKE BOOSTER CHARACTERISTICS. WITH NEWER CARS, THE BRAKE BOOSTER IS MORE SENSITIVE TO CHANGES IN THE VACUUM FROM THE ENGINE, WHICH MAY RESULT IN SLIG

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 27, 2001 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

SUBJECT REGARDING MASS AIR FLOW SENSOR REPLACEMENT. WHEN REPLACING A MASS AIR FLOW SENSOR (MAF), ESPECIALLY WHEN DIAGNOSTIC TROUBLE CODES HAVE BEEN LOGGED IN MEMORY, IT IS IMPORTANT TO RESET THE ENGINE MANAGEMENT CONTROL UNIT (ECM) ADAPT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 5, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING B6304S / B6294S ROUGH COLDSTART. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2001 220000 SEATS

SUBJECT REGARDING WHIPS-INDICATOR, NEW TEST METHOD. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2000 105300 POWER TRAIN:DRIVELINE:DRIVESHAFT

THIS SERVICE BULLETIN DESCRIBES HOW TO REPLACE THE SEALING RING FOR THE VISCOUS COUPLING ON THE DRIVE SHAFT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2000 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

THIS BULLETIN DESCRIBES THE FAULT TRACING AND CORRECTIVE ACTION FOR TRANSMISSION SHUDDER DURING UPSHIFT (2-3 SHIFTS). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 31, 2002 162300 STRUCTURE:BODY:DOOR

DOOR LOCK LOGIC. *SLC *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2001 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

INFORMATION REGARDING LONG CRANKING/TACH JUMPING/MISFIRE DTC. *YH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 5, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING ,ALL MODEL YEARS, CLIMATE CONTROL MODULE RECIRCULATION TIMER FUNCTION. *YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 5, 2001 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SUBJECT REGARDING ,ALL MODEL YEARS, CLIMATE CONTROL MODULE RECIRCULATION TIMER FUNCTION. *YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2001 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

SUBJECT REGARDING GEAR SELECTOR ASSEMBLY, DIAGNOSTIC TROUBLE CODE TRANSMISSION CONTROL MODULE 0094. *SLC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 3, 2001 353000 EQUIPMENT:ELECTRICAL

TRIP COMPUTER SCROLLING FUNCTION, ERRATIC. *YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 27, 2001 010000 STEERING

SUBJECT REGARDING SOFTWARE FUNCTION ID 664, STEERING WHEEL MODULE -DIAGNOSTIC TROUBLE CODE, ELECTRONIC CONTROL MODULE-928C, AND CENTRAL ELECTRONIC MODULE-1A5B. *YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 11, 2001 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

INFORMATION REGARDING EVAPORATOR TEMPERATURE SENSOR. *YH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2001 111100 ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

SUBJECT REGARDING NEW ROUTING FOR POSITIVE BATTERY CABLE. *SLC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 13, 2011 151000 SEAT BELTS:FRONT

VOLVO: FOR OWNERS WHO REQUIRE FRONT SEAT BELT EXTENDERS WHICH ARE AVAILABLE. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 24, 2001 021500 SUSPENSION:FRONT:CONTROL ARM

SUBJECT REGARCING BALL JOINT REPLACEMENT, RECALL 99. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 22, 2000 162000 STRUCTURE:BODY

EXPERIENCING CHIRPING SOUND FROM GLOVE BOX. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

1999 VOLVO S80

search for another vehicle

Loading...