1997 FORD F-150

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

26 Recalls for 1997 FORD F-150

Recall Date Component Summary
August 17, 2000 FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS MANUFACTURED AT THE KANSAS CITY OR NORFOLK ASSEMBLY PLANTS. THE FRONT FUEL LINE ASSEMBLY COULD HAVE A HOLE RUBBED THROUGH IN ONE OF TWO LOCATIONS. THE FIRST LOCATION IS BELOW THE FUEL RAIL CONNECTION WHERE THE FLEXIBLE HOSE IS CRIMPED TO THE STEEL TUBE. THE BRACKET THAT ATTACHES THE FRONT FUEL LINE TO THE TRANSMISSION COULD HAVE BEEN BENT DURING ASSEMBLY. THE SECOND LOCATION IS AT THE REAR STEEL TUBE SECTION FORWARD OF THE REAR BRACKET. DURING INSTALLATION THE REAR STEEL TUBES OF THE FRONT FUEL LINE ASSEMBLY COULD HAVE BEEN BENT DOWNWARD. IN VEHICLES EQUIPPED WITH A MANUAL 4XZ4 TRANSFER CASE SHIFTER, THE SHIFTER LINKAGE MAY CONTACT THE STEEL TUBES AS IT IS BEING SHIFTED BETWEEN 4H, 4L, 2L AND NEUTRAL.

Remedy:

DEALERS WILL INSPECT THESE LINES AND REPLACE THE FRONT FUEL LINE ASSEMBLY IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 27, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

May 13, 1998 WHEELS:LUGS/NUTS/BOLTS

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES AND LIGHT DUTY PICKUP TRUCKS. THE LUG NUTS ON THESE VEHICLES MAY NOT CREATE SUFFICIENT CLAMP LOAD ALLOWING WHEEL MOVEMENT IN RELATION TO THE HUB/ROTOR MOUNTING SURFACE.

Remedy:

OWNERS OF THESE VEHICLES WILL BE RECEIVING TWO NOTIFICATIONS. THE FIRST NOTIFICATION, WHICH BEGAN IN MAY 1998, WILL PROVIDE AN INTERIM REPAIR PROCEDURE UNTIL PARTS BECOME AVAILABLE. THIS INTERIM PROCEDURE CAN BE COMPLETED BY OWNERS OR THEIR DEALERS. IT SPECIFIES THAT THE LUG NUT TORQUE MUST BE VERIFIED TO BE 100 LBS. THEN THE LUG NUTS NEED TO BE TIGHTENED AN ADDITIONAL 1/8 TO 1/4 TURN MORE. THERE WILL BE A SECOND OWNER NOTIFICATION, WHICH IS EXPECTED TO BEGIN JULY 20, 1998, UNDER WHICH DEALERS WILL INSPECT THE WHEEL STUDS AND REPLACE THE WHEEL LUG NUTS.

January 21, 1998 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH A 4.2L ENGINE AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN ONE OF THE FOLLOWING STATES: ALASKA, MONTANA, NORTH DAKOTA, MINNESOTA, WISCONSIN, NEW YORK, VERMONT, NEW HAMPSHIRE, MAINE, MICHIGAN, IDAHO, WYOMING, SOUTH DAKOTA, COLORADO, NEBRASKA, KANSAS, IOWA, MISSOURI, ILLINOIS, INDIANA, OHIO, PENNSYLVANIA, AND MASSACHUSETTS. THE THROTTLE IS UNABLE TO RETURN TO IDLE DUE TO ICE FORMING IN THE THROTTLE BODY WHEN THE TEMPERATURE RANGES FROM -10 TO -40 DEGREES FAHRENHEIT.

Remedy:

DEALERS WILL INSTALL A REVISED PCV SYSTEM ON THESE VEHICLES.

September 9, 1997 POWER TRAIN:AUTOMATIC TRANSMISSION | POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE TRANSMISSION BRACKET END FITTING CAN SEPARATE FROM THE SHIFT CABLE ASSEMBLY RESULTING IN OPERATOR INABILITY TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION.

Remedy:

DEALERS WILL INSTALL A NEW TRANSMISSION SHIFT CONTROL CABLE.

October 7, 1997 POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND MULTI-PURPOSE PASSENGER VEHICLES. IF THE AUTOMATIC TRANSMISSION SHIFT CABLE ASSEMBLY WAS NOT FULLY ATTACHED TO THE STEERING COLUMN BRACKET, THE SHIFT CABLE ASSEMBLY CAN COME OUT OF THE BRACKET. THE VEHICLE OPERATOR WOULD THEN NOT BE ABLE TO SHIFT THE TRANSMISSION FROM ONE OF THE DRIVE GEAR POSITIONS INTO THE PARK POSITION EVEN THOUGH THE GEAR SHIFT SELECTOR WOULD INDICATE “PARK.”

Remedy:

DEALERS WILL MAKE THE PROPER ATTACHMENT OF THE TRANSMISSION SHIFT CONTROL CABLE TO THE STEERING COLUMN BRACKET AND ADD A TIE STRAP TO THAT CONNECTION.

July 15, 1998 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY | SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

VEHICLE DESCRIPTION: LIGHT DUTY 4-WHEEL DRIVE PICKUP TRUCKS. IF THE VEHICLE IS OVERLOADED, THE REAR LEAF SPRINGS CAN BE OVERSTRESSED. A FATIGUE FRACTURE OF THE SPRING CAN OCCUR. THE CENTER LEAF OF THE SPRING CAN FRACTURE AT THE FORWARD EDGE OF THE SPRING SEAT AND, IN SOME CASES, CONTACT THE FUEL TANK.

Remedy:

DEALERS WILL INSPECT THE REAR SPRINGS AND INSTALL AN ADDITIONAL CLIP ON THE FORWARD END OF THE REAR SPRINGS TO PREVENT FUEL TANK CONTACT IN THE EVENT OF A LEAF FRACTURE. ANY FRACTURED SPRINGS WILL BE REPLACED.

August 29, 1996 EQUIPMENT:OTHER:LABELS

THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, “TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.”

Remedy:

OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.

September 25, 1996 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

THE RETAINER CLIP THAT HOLDS THE MASTER CYLINDER PUSH ROD TO THE BRAKE PEDAL ARM IS MISSING.

Remedy:

DEALERS WILL INSPECT TO VERIFY THAT THE RETAINER CLIPS ARE INSTALLED AND IF CLIPS ARE MISSING WILL INSTALL CLIPS.

December 27, 1996 SEAT BELTS:FRONT:ANCHORAGE | SEAT BELTS:FRONT:ANCHORAGE

THE SEAT ELT ANCHORAGE ATTACHMENTS ARE MISSING OR MISINSTALLED ON THESE VEHICLES.

Remedy:

DEALERS WILL INSPECT AND, AS NECESSARY, REPAIR THE SEAT BELT ANCHORAGE ATTACHMENTS.

December 18, 1996 VEHICLE SPEED CONTROL

VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, MONTANA, NORTH DAKOTA, MINNESOTA, WISCONSIN, MICHIGAN (UPPER PENINSULA), NEW YORK, MAINE, VERMONT, AND NEW HAMPSHIRE. OPERATION AT HIGHWAY SPEEDS DURING EXTREME COLD, NORTHERN CLIMATE WINTER CONDITIONS, CAN RESULT IN ICE FORMING IN THE THROTTLE BODY OF THE ENGINE.

Remedy:

DEALERS WILL INSTALL A FOAM INSULATING SLEEVE ON THE LINE FROM THE PCV TO THE HOSE FITTING ON THE THROTTLE PLATE.

July 29, 2011 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.

Remedy:

FORD WILL NOTIFY OWNERS AND INSTRUCT THEM TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN DEALER TO HAVE THE FUEL TANK STRAPS REPLACED WITH STRAPS THAT HAVE INCREASED CORROSION PROTECTION. EARLY IN THIS CAMPAIGN, IF REPLACEMENT STRAPS ARE NOT AVAILABLE, DEALERS MAY INSTALL A CABLE SUPPORT UNDER THE STRAP AS AN INTERIM REPAIR OR A STEEL REINFORCEMENT OVER THE EXISTING STRAP AS A PERMANENT REPAIR. ANY REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. FORD’S RECALL CAMPAIGN NUMBER IS 11S21

May 11, 2009 EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, “LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.” THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy:

DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

April 7, 2009 EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, “LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.” THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Remedy:

SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

August 11, 2008 EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, “LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.”

Remedy:

K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.

August 28, 2007 EQUIPMENT:ELECTRICAL

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Remedy:

ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.

July 17, 2006 EXTERIOR LIGHTING

CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Remedy:

TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.

August 1, 2006 EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Remedy:

MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JULY 28, 2006. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.

July 17, 2006 EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Remedy:

AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

June 29, 2006 EXTERIOR LIGHTING

CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, “LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.”

Remedy:

AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.

June 12, 2006 EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN EAGLE EYES HEADLAMPS, P/NOS. FR208-B101R, FR208-B101L, FR208-B001R, AND FR208-B001L, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE PASSENGER VEHICLES LISTED ABOVE. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Remedy:

SABRY LEE WILL NOTIFY OWNERS AND OFFER FULL CREDIT FOR ANY NONCOMPLIANT HEADLAMP. THE RECALL IS EXPECTED TO BEGIN ON JUNE 14, 2006. OWNERS MAY CONTACT SABRY LEE ACCOUNT EXECUTIVE AT 1-866-467-2279.

March 21, 2006 EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN POLI-AUTO COMBINATION HEADLAMP ASSEMBLIES, P/NOS. 11-728, 11-728D, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708P, 11-735, 11-725, 11-726, 11-716 (P&C), 11-721-1, 11-733, 11-729, 11-730, AND 11-732, SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, “LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.”

Remedy:

POLI-AUTO WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE HEADLAMPS AT ITS ORIGINAL PURCHASE PRICE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2006. OWNERS MAY CONTACT POLI-AUTO AT 305-477-1356.

March 13, 2006 EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, “LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.”

Remedy:

ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.

September 7, 2005 VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.

Remedy:

BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)

May 27, 2003 STEERING:GEAR BOX:SHAFT SECTOR

ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE INTERMEDIATE SHAFT YOKE SEPARATES FROM THE STEERING GEAR INPUT SHAFT, THE STEERING SYSTEM BECOMES DISCONNECTED.

Remedy:

DEALERS WILL INSPECT THE STEERING INTERMEDIATE SHAFT YOKE TO DETERMINE IF THE YOKE IS FULLY SEATED ON THE STEERING GEAR INPUT SHAFT. IF THE YOKE IS FULLY SEATED NO SERVICE IS REQUIRED. IF THE YOKE IS NOT FULLY SEATED AND BOLT GROOVE AND SPLINE IS VISIBLE, THE INTERMEDIATE SHAFT AND BOLT WILL BE REPLACED AS WELL AS THE BOLT AT THE STEERING COLUMN CONNECTION. OWNER NOTIFICATION BEGAN ON MAY 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

May 22, 2001 TIRES:TREAD/BELT

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY.

EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE.

VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000.

CERTAIN 1991 THROUGHT 2002 FORD EXPLORER
CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC
CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER
CERTAIN 1991 THROUGH 2001 RANGER
CERTAIN 1999 THROUGH 2001 EXPEDITION
CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES
CERTAIN 1991 THROUGH 1994 BRONCO

NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.

Remedy:

THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.

June 19, 2000 EXTERIOR LIGHTING

VEHICLE DESCRIPTION: MINI VANS, LIGHT PICKUP TRUCKS, AND SPORT UTILITY VEHICLES. OFF LEASE CANADIAN VEHICLES EQUIPPED WITH DAYTIME RUNNING LIGHTS WHICH MEET CANADIAN REQUIREMENTS AND NOT THE PHOTOMETRIC REQUIREMENTS OF FMVSS 108, “LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.” ACCORDING TO FORD, THE VEHICLES WERE IMPORTED INTO THE U.S. ERRONEOUSLY.

Remedy:

DEALERS WILL BE ADVISED TO DEACTIVATE THE RUNNING LIGHT FUNCTION AND TO COMPLETE ANY OUTSTANDING SAFETY RECALLS ON THESE VEHICLES.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

0 Complaints sent to the Center for Auto Safety for 1997 FORD F-150

skip to NHTSA complaints

Date Component  

0 Complaints submitted to NHTSA for 1997 FORD F-150

skip to CAS complaints

Date Component  
Is the government investigating the safety of your vehicle? Find out here.

28 Investigations for 1997 FORD F-150

Date Opened Date Closed Component  
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
STEERING
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:MOUNTING
ENGINE AND ENGINE COOLING
STEERING
VEHICLE SPEED CONTROL:LINKAGES
POWER TRAIN:AUTOMATIC TRANSMISSION
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY
VEHICLE SPEED CONTROL:LINKAGES
VEHICLE SPEED CONTROL
SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY
STEERING
SUSPENSION
WHEELS
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
VEHICLE SPEED CONTROL:CRUISE CONTROL
WHEELS
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:MOUNTING
ENGINE AND ENGINE COOLING:ENGINE
ELECTRICAL SYSTEM
POWER TRAIN
SEAT BELTS:FRONT:ANCHORAGE
SEAT BELTS:FRONT:ANCHORAGE
Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

299 Service Alerts for 1997 FORD F-150

Date Description
April 21, 2016 070000 FUEL SYSTEM, GASOLINE

Safety recall 11S21 – Fuel tank strap fracture – requests for recall service action

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 2, 2002 125100 EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 21, 2016 070000 FUEL SYSTEM, GASOLINE

For 1997-2003 F-150, 2004 F-150 Heritage, 1997-1999 F-250 Light Duty, or 2002-2003 Blackwood vehicles Safety Recall 11S21 has been issued for vehicles that are operated in high corrosion areas for an extended period, where one or both fuel

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 022140 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

SUBJECT REGARDING THE AVAILABILITY OF REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING REAR SPRING RATTLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 022140 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

SUBJECT REGARDING REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING A REAR SPRING RATTLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 022140 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

SOME VEHICLES BUILT WITH 3-LEAF OR 4-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 17, 1997 980000 UNKNOWN OR OTHER

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 14, 1996 116000 ELECTRICAL SYSTEM:IGNITION

ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 27, 1996 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 29, 1996 061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1996 105300 POWER TRAIN:DRIVELINE:DRIVESHAFT

DRIVELINE CLUNK OR ACCEL OR DECEL. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1996 061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

FEAD BELT SQUEAL, COLD ONLY. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 21, 1996 061000 ENGINE AND ENGINE COOLING:ENGINE

INFORMATION ON ENGINE OIL LEAK AT THE OIL PAN, FRONT COVER &/OR THE FRONT & REAR CRANKSHAFT OIL SEAL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 1996 073200 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 1996 063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 7, 1996 138600 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 8, 1996 102000 POWER TRAIN:MANUAL TRANSMISSION

E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 8, 1998 162000 STRUCTURE:BODY

SOME VEHICLES MAY EXHIBIT CAB VIBRATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 22, 2001 160000 STRUCTURE

SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 110000 ELECTRICAL SYSTEM

SOME TEXAS DEPARTMENT OF TRANSPORTATION (DOT) TRUCKS MAY ENCOUNTER A RADIO FREQUENCY INTERFERENCE (RFI) CONDITION WHEN USING HAND HELD TWO-WAY RADIOS IN THE RANGE OF 47.18 MHZ. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 13, 2003 061000 ENGINE AND ENGINE COOLING:ENGINE

SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START,

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2003 120000 EXTERIOR LIGHTING

DAMAGED REAR LICENSE PLATE LAMPS DUE TO ROCKS AND/OR GRAVEL HITTING THE LAMP ASSEMBLIES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 22, 2002 061000 ENGINE AND ENGINE COOLING:ENGINE

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 050000 PARKING BRAKE

A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 16, 1998 162000 STRUCTURE:BODY

SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 16, 1998 162000 STRUCTURE:BODY

REPAIRS TO VINYL COVERED SURFACES. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1996 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

INVESTIGATING 7.3L IRREGULAR IDLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1996 106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1996 190000 TIRES

FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 15, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 15, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT HIGH IDLE AND/OR PCV SYSTEM ICING AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES ON VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THORUGH 1/24/2000. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2007 061000 ENGINE AND ENGINE COOLING:ENGINE

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE–SPARK PLUG THREAD REPAIR PROCEDURE–NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 022141 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:LEAF

SUBJECT REGARDING REAR SPRING RATTLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2003 090000 FUEL SYSTEM, OTHER

ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2003 010000 STEERING

REDUCED POWER STEERING ASSIST AND/OR POWER STEERING LEAKS WHEN DRIVEN IN TEMPERATURES EQUAL TO OR LESS THAN -25 DEGREES CELCIUS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2003 173100 LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

LOCKING TAILGATE LOCKS ITSELF. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 1999 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 17, 2001 103800 POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

BRAKE SHIFT INTERLOCK.*JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 2001 091100 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 13, 2000 110000 ELECTRICAL SYSTEM

A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 200000 WHEELS

SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 010000 STEERING

SOME VEHICLES MAY EXHIBIT A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 160000 STRUCTURE

SOME SUPER CAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 – 1600 RPM OR A CAB VIBRATION AT 1800 – 1900 RPM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

MALFUNCTION INDICATOR LAMP ON, WITH P0300 – P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

COLD ENGINE KNOCK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 10, 2000 161000 STRUCTURE:FRAME AND MEMBERS

VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 2, 1997 102000 POWER TRAIN:MANUAL TRANSMISSION

SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 23, 1996 162300 STRUCTURE:BODY:DOOR

WINDNOISE CONCERNS IN THE RIGHT DOOR A-PILLAR AREA OF THE SUPERCAB. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 23, 1996 116000 ELECTRICAL SYSTEM:IGNITION

CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 23, 1996 102000 POWER TRAIN:MANUAL TRANSMISSION

INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 23, 1996 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

INVESTIGATING 7.3L IRREGULAR IDLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2003 010000 STEERING

TIE ROD END INSPECTION PROCEDURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2003 090000 FUEL SYSTEM, OTHER

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 27, 1998 020000 SUSPENSION

A VIBRATION AT HIGHWAY SPEEDS MAY BE FELT ON SOME VEHICLES. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1997 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1997 135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

ENGINEERING IS ADDRESSING THE ISSUE OF INTERMITTENT/UNABLE TO ADJUST MIRROR CONCERNS. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1997 161000 STRUCTURE:FRAME AND MEMBERS

F SERIES FLARESIDE WHEN EQUIPPED WITH THE CAB STEP, WILL NOT HAVE MUD FLAPS. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1997 980000 UNKNOWN OR OTHER

THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1997 021000 SUSPENSION:FRONT

FOR CONCERNS OF NOISY/SQUEAKY STEERING AND DIAGNOSIS IS FOR THE PITMAN ARM, RECOMMENDED SERVICE IS TO REPLACE THE PITMAN ARM. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 6, 1997 090000 FUEL SYSTEM, OTHER

INSTRUCTIONS FOR DIAGNOSING FUEL GUAGE CONCERNS. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 1997 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 1997 980000 UNKNOWN OR OTHER

THE SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES 4X4 LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 23, 1998 061000 ENGINE AND ENGINE COOLING:ENGINE

THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 23, 1998 162000 STRUCTURE:BODY

INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 1996 114000 ELECTRICAL SYSTEM:WIRING

WIRING – ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 23, 1998 114200 ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH

CONDITION WITH WATER INTRUSION INTO THE GENERIC ELECTRONIC MODULE ( GEM ) MAY OCCUR ON SOME VEHICLES. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 14, 2005 060000 ENGINE AND ENGINE COOLING

WDS COP KIT DIAGNOSTIC TIP – COIL ON PLUG (COP) IGNITION SYSTEMS – ENGINE MISFIRE OR ROUGH RUNNING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 1997 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 1997 980000 UNKNOWN OR OTHER

SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 19, 1998 160000 STRUCTURE

SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 19, 1998 034530 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 18, 1998 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 18, 1998 034530 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 21, 1996 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

BRAKES – ELIMINATION OF SANDING ROTORS AND DRUMS – SERVICE TIP. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 21, 1996 131000 VISIBILITY:WINDSHIELD

WINDSHIELD AND INTERIOR GLASS – FOG/FILM. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 1996 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION – E40D – REVISED DESIGN FORWARD PLANET THRUST WASHER – SERVICE TIP. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 1996 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSMISSION – E40D – 4R70W – 4R44E – 5R55E – NEW DIGITAL TRANSMISSION RANGE SENSOR – DIAGNOSIS SERVICE TIP. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 1996 103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

TORQUE CONVERTER – LEAK TEST PROCEDURE – SERVICE TIP. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1997 070000 FUEL SYSTEM, GASOLINE

EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 1997 061000 ENGINE AND ENGINE COOLING:ENGINE

BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 1997 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 1998 202000 WHEELS:HUBCAP/COVER

IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 1998 980000 UNKNOWN OR OTHER

BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 16, 1996 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

MALFUNCTION INDICATOR LAMP (MIL) – DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMORY. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 2, 1996 980000 UNKNOWN OR OTHER

NOISE – RATTLE – SUMMARY OF CONCERNS – SERVICE TIPS. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 2, 1996 116000 ELECTRICAL SYSTEM:IGNITION

RUNS ROUGH – MALFUNCTION INDICATOR LAMP (MIL) ON – DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY – VEHICLES BUILT THROUGH 10/14/96 WITH 4.6L ENGINE. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 2, 1996 980000 UNKNOWN OR OTHER

DOOR – POWER POINT ACCESS DOOR BREAKS – VEHICLES BUILT THROUGH 8/31/96. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 2, 1996 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) – SERVICE PROCEDURES – SERVICE TIP. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 2, 1996 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

MALFUNCTION INDICATOR LAMP (MIL) – DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 AND/OR P0308 STORED IN MEMORY. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 2, 1996 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH

LOCKS – REPLACE AND/OR REPAIR ANY LOCK COMPONENT – SERVICE TIP. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 162000 STRUCTURE:BODY

EXPERIENCING WHISTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AT HIGHWAY SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

SUBJECT REGARDING FRONT DIFFERENTIAL NOISE INVESTIGATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2004 017500 STEERING:LINKAGES:TIE ROD ASSEMBLY

CUSTOMER MAINTENANCE REMINDER – LITERATURE PROGRAM 04L19 – TIE ROD INSPECTION PROCEDURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION REGARDING TRANSMISSION TROUBLE CODES. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 014100 STEERING:RACK AND PINION:PINION SHAFT

INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 162000 STRUCTURE:BODY

INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 20, 1999 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 6, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

VEHICLES WITH 4.2L ENGINE (CANADIAN) MAY BACKFIRE ON ACCELERATION AT ALL AMBIENT TEMPERATURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 6, 1999 980000 UNKNOWN OR OTHER

VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 10, 1997 102000 POWER TRAIN:MANUAL TRANSMISSION

A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2004 015200 STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

POWER STEERING LEAK – SERVICE TIP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2004 022140 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

REAR LEAF SPRING NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 22, 2004 130000 VISIBILITY

POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER’S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2002 020000 SUSPENSION

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 1998 200000 WHEELS

SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 1998 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 25, 2000 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

ENGINE OVERHEATING- WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 071000 FUEL SYSTEM, GASOLINE:STORAGE

FOR CUSTOMER CONCERNS OF STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OF EXCESSIVE FUEL PRESSURE. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

DRIVELINE RATTLE OVER BUMPS. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 131000 VISIBILITY:WINDSHIELD

DIAGNOSIS WINDNOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2000 100000 POWER TRAIN

SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 27, 1997 162300 STRUCTURE:BODY:DOOR

TECHNICIANS ARE EXPERIENCING DIFFICULTY REMOVING DOOR TRIM PANELS. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 6, 1997 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

GEM CONCERN – CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC’S RECEIVED IN MEMORY. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 7, 1997 126200 EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

CONCERNS WITH THE MULTI-FUNCTION SWITCH. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 10, 1997 105000 POWER TRAIN:DRIVELINE

DRIVELINE CLUNKING OR GRUNTING NOISE. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 3, 1998 500000 CHILD SEAT

INSTALL A REVISED CHILD SEAT TETHER KIT.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 3, 1998 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 106100 POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING

SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 162300 STRUCTURE:BODY:DOOR

SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 110000 ELECTRICAL SYSTEM

INFORMATION REGARDING A NEW SERVICE PART RELEASED FOR THE LICENSE PLATE LIGHT CIRCUIT WHICH WILL REDUCE THE COSE OF REPAIRS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 162300 STRUCTURE:BODY:DOOR

SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 18, 1998 036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ON SOME VEHICLES REPEAT REPAIRS MAY BE MADE TO 4-WHEEL ANTI-LOCK BRAKING SYSTEMS (4WABS) DUE TO MISDIAGNOSIS OF 4WABS CONCERNS WHICH MAY RESULT IN REPLACEMENT OF FUNCTIONAL COMPONENTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 022140 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 1998 980000 UNKNOWN OR OTHER

MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 9, 1999 116000 ELECTRICAL SYSTEM:IGNITION

CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

COLD ENGINE KNOCK 5.4L ACTION. *AK

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1998 105300 POWER TRAIN:DRIVELINE:DRIVESHAFT

VIBRATION AT CRUISE OVER 50 MPH. *AK

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1998 162300 STRUCTURE:BODY:DOOR

VEHICLES EXHIBIT CRACKS IN DOOR SHEET METAL AT LOWER REAR OF THE WINDOW OPENING NEAR BELT MOLDING. *AK

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 28, 1999 036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 28, 1999 125000 EXTERIOR LIGHTING:BRAKE LIGHTS

CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 162200 STRUCTURE:BODY:BUMPERS

ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 14, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 14, 1999 980000 UNKNOWN OR OTHER

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 17, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 3, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 30, 2003 114000 ELECTRICAL SYSTEM:WIRING

AFTERMARKET WIRING ALTERATIONS – SERVICE TIP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 1999 030000 SERVICE BRAKES, HYDRAULIC

VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 1999 036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 1999 100000 POWER TRAIN

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 1999 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 21, 2003 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

NEW TRANSMISSION COOLER FLUSHER – SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2005 105000 POWER TRAIN:DRIVELINE

A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 16, 1998 980000 UNKNOWN OR OTHER

THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 13, 1998 190000 TIRES

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 31, 2003 017500 STEERING:LINKAGES:TIE ROD ASSEMBLY

TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 2003 110000 ELECTRICAL SYSTEM

VARIOUS INTERMITTENT ELECTRICAL CONCERNS INCLUDING BUT NOT LIMITED TO SOME ACCESSORIES REMAINING POWERED UP WITH THE KEY OUT OF THE IGNITION, MULTIPLE SYSTEM WARNING LIGHTS WITH SHORT TO POWER OR LOW BATTERY VOLTAGE DIAGNOSTIC TROUBLE CODES

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 17, 1998 162300 STRUCTURE:BODY:DOOR

LOCKS FAILED. YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 23, 2004 061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE MISFIRE OR RUNNING – COIL ON PLUG (COP) IGNITION SYSTEMS – WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 12, 2001 070000 FUEL SYSTEM, GASOLINE

SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 21, 2002 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 17, 2001 162300 STRUCTURE:BODY:DOOR

SOME VEHICLES MAY EXPERIENCE A COSMETIC CRACK IN THE OUTER DOOR PANEL AT THE LOWER REAR CORNER OF WINDOW OPENING.*JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 2, 1998 045300 SERVICE BRAKES, AIR:DISC:ROTOR

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1997 102000 POWER TRAIN:MANUAL TRANSMISSION

NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 3, 1997 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 13, 2000 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 160000 STRUCTURE

SOME SUPERCAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 – 1600 RPM OR A CAB VIBRATION AT 1800 – 1900 RPM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 011000 STEERING: STEERING WHEEL/HANDLE BAR

EXPERIENCING A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 180000 VEHICLE SPEED CONTROL

SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 8, 1996 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

CONCERNS OF WINDSHIELD WIPER NOT CLEANING, STREAKING OR SMEARING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 10, 1996 103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 14, 1996 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

CONCERNS OF CHECK ENGINE LIGHT ‘ON’. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 16, 1996 162300 STRUCTURE:BODY:DOOR

INFORMATION ON DIAGNOSING WIND NOISE & WATER LEAKS AT THE LOWER PASSENGER DOOR AREA & 3RD DOOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 17, 1996 102000 POWER TRAIN:MANUAL TRANSMISSION

4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 17, 1996 072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2000 131000 VISIBILITY:WINDSHIELD

CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 7, 1998 110000 ELECTRICAL SYSTEM

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ – 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 1998 020000 SUSPENSION

EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 9, 2014 071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE,

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 9, 2014 350000 EQUIPMENT

FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE,

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 4, 2003 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

DRIVER’S SIDE DOOR GLASS THAT BINDS WHEN OPERATED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 1997 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 1997 061000 ENGINE AND ENGINE COOLING:ENGINE

SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 12, 1998 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXPERIENCING A ” BUZZING ” OR ” RATTLING ” NOISE FROM THE EXHAUST SYSTEM. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 1999 060000 ENGINE AND ENGINE COOLING

SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 3, 1999 162300 STRUCTURE:BODY:DOOR

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT – SERVICE TIP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 20, 2001 103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 2, 1998 980000 UNKNOWN OR OTHER

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 2, 1998 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

COLD AIR MAY BE FELT ON THE FLOOR WHILE IN HEAT MODE ON SOME VEHICLES. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2005 022000 SUSPENSION:REAR

REAR AXLE NOISE REPAIR. *SC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 21, 2003 061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 20, 2000 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 3, 1997 220000 SEATS

INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 31, 1997 114100 ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 7, 2000 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 071000 FUEL SYSTEM, GASOLINE:STORAGE

STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OR EXCESSIVE FUEL PRESSURE AND/OR MIL ACTIVATION WITH DTCS. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

DRIVELINE RATTLE OVER BUMPS. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 131000 VISIBILITY:WINDSHIELD

WIND NOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 980000 UNKNOWN OR OTHER

DRIVELINE CLUNK, 4.2L BACKFIRE, 4.6L LACK OF POWER, 4.6L MISFIRE/MIL LIGHT ISSUES, AND WINDNOISE. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 1997 061000 ENGINE AND ENGINE COOLING:ENGINE

FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 21, 2005 063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2005 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

INTERMITTENT ROUGH IDLE – NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2005 106000 POWER TRAIN:AXLE ASSEMBLY

AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 15, 1999 162300 STRUCTURE:BODY:DOOR

INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 7, 2000 980000 UNKNOWN OR OTHER

INSTALLATION OF VINYL FLOOR MATS SERVICE TIP. AK

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 7, 2000 980000 UNKNOWN OR OTHER

FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 7, 2000 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

TRANSMISSION FLUID LEAKS AT RADIATOR. YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 7, 2000 073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 7, 2000 221200 SEATS:FRONT ASSEMBLY:RECLINER

THE SEAT BACK MAY NOT LATCH/ LOCK IN THE DESIRED POSITION AND REMAIN FOLDED FORWARD OVER THE SEAT CUSHION. YD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 27, 2002 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME BI-FUEL CANG AND LPG VEHICLES MAY EXHIBIT A NO START CONDITION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2014 071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2014 071120 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2014 091120 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:MOUNTING

FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 131000 VISIBILITY:WINDSHIELD

EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

SOME 4X4 VEHICLES MAY EXHIBIT A MOAN NOISE FROM THE FRONT DIFFERENTIAL WHEN THE VEHICLE IS OPERATING IN 4X2 MODE AND GOES AWAY WHEN OPERATING IN 4X4 MODE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 161000 STRUCTURE:FRAME AND MEMBERS

SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 106100 POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING

SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 12, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

VEHICLES MAY EXPERIENCE A MOANING NOISE HEARD AT APPROXIMATELY 1100 RPM WITH THE A/C COMPRESSOR ENGAGED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 12, 1999 105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 23, 1998 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 15, 2003 180000 VEHICLE SPEED CONTROL

DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 25, 1996 036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 13, 2000 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2001 203000 WHEELS:LUGS/NUTS/BOLTS

SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING MISFIRE CODES ON ALL ENGINES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

INFORMATION ON DIAGNOSTICING ERRATIC WINDSHIELD WIPER OPERATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 180000 VEHICLE SPEED CONTROL

INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

COLD START ENGINE NOISE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 19, 1998 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2003 063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

BROKEN EXHAUST MANIFOLD STUDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 30, 2002 073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 30, 2002 180000 VEHICLE SPEED CONTROL

DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 2, 2002 032100 SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 3, 1997 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 162300 STRUCTURE:BODY:DOOR

INFORMATION REGARDING VEHICLES THAT EXHIBIT CRACKS IN THE DOOR SHEET METAL. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 014100 STEERING:RACK AND PINION:PINION SHAFT

INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 162000 STRUCTURE:BODY

INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 060000 ENGINE AND ENGINE COOLING

INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 18, 1999 114000 ELECTRICAL SYSTEM:WIRING

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2005 106000 POWER TRAIN:AXLE ASSEMBLY

REAR AXLE NOISE REPAIR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2004 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 28, 1999 060000 ENGINE AND ENGINE COOLING

CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 034400 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM

CONDITIONS ON REAR DRUM GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 14, 1999 980000 UNKNOWN OR OTHER

FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 14, 1999 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2002 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SNOW PACKING OF THE AIR FILTER WHEN DRIVING IN SEVERE SNOW CONDITIONS MAY EXHIBIT LOSS OF POWER AND / OR THE MALFUNCTION INDICATOR LAMP ILLUMINATING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 10, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 13, 2004 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2001 034430 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM

SOME VEHICLES MAY EXHIBIT A GRABBING CONDITION FROM THE REAR DRUM BRAKES DURING THE FIRST FEW BRAKE APPLICATIONS AFTER EXTENDED HUMIDITY EXPOSURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2001 113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY

CONCERNS WITH CORRODED POSITIVE STARTER CABLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2001 091110 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:FILLING/CHARGING

DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 100000 POWER TRAIN

BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1998 980000 UNKNOWN OR OTHER

SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 26, 2003 061000 ENGINE AND ENGINE COOLING:ENGINE

VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 26, 2003 070000 FUEL SYSTEM, GASOLINE

COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2003 173100 LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 162000 STRUCTURE:BODY

SOME VEHICLES MAY EXHIBIT DENTS ON THE WHEEL WELL SHEET METAL OF THE PCIK-UP BOX AREA WHEN USED IN OFF-ROAD APPLICATIONS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 162300 STRUCTURE:BODY:DOOR

SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 3, 2003 090000 FUEL SYSTEM, OTHER

POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 162200 STRUCTURE:BODY:BUMPERS

INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 162300 STRUCTURE:BODY:DOOR

THIS ONLINE BULLETIN ADDRESSES CONCERNS WITH CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 30, 1998 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 30, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

CONCERNS WITH REDUCED POWER, STALLING, HESITATION, AND SURGE. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 30, 1998 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 30, 1998 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1996 103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 14, 2001 106100 POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING

A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. THIS MAY BE CAUSED BY THE EXTENSION HOUSING BUSHING OR SEAL WALKING / SPINNING OUT DUE T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 18, 1998 354600 EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES

RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 16, 1996 103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER

TRANSAXLE – TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES – SERVICE TIP. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 2001 173100 LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

SOME VEHICLES EQUIPPED WITH REMOTE LOCKING TAILGATES MAY EXHIBIT A TAILGATE LOCKING ITSELF WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS OR IS SLAMMED SHUT. *ET

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 022140 SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY

SOME VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 106100 POWER TRAIN:AXLE ASSEMBLY:BANJO HOUSING

EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 105000 POWER TRAIN:DRIVELINE

CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 105000 POWER TRAIN:DRIVELINE

EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT

EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 135000 VISIBILITY:REARVIEW MIRRORS/DEVICES

INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 19, 1997 180000 VEHICLE SPEED CONTROL

INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 24, 1997 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

SOFT BRAKE PEDAL. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 17, 1997 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 25, 1997 061000 ENGINE AND ENGINE COOLING:ENGINE

VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE – CHECK FOR DAMAGE TO CAMSHAFT. *TW

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 17, 1997 160000 STRUCTURE

FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 11, 2002 061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2003 061000 ENGINE AND ENGINE COOLING:ENGINE

REMOTE OIL FILTER ADAPTOR REPLACEMENT – NEW SERVICE PART. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 4, 2003 017500 STEERING:LINKAGES:TIE ROD ASSEMBLY

TIE ROD END INSPECTION PROCEDURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

1997 FORD F-150

search for another vehicle

Loading...