1996 SATURN SC

Transmission from the beginning had interm problems. SES lightwould come on and off. brought car to saturn under the 12,000 mile warrantee for used cars and after many different repairs that I did not pay for they finally found the problem a frayed wire. Once this was done it was okay for a while. At 106,000 miles there was a clunking sound and my mechanic had to replace the transmission with a rebuilt one. For one year after 6/03 problems again developed which he believes may be of an electrical nature and replaced the wiring which was corroded from the transmission actuator to the harness. The problem still has not been corrected and they are looking further. My mechanic who I have been going to for 16 years is excellent and valso mentioned that this car, not mine specifically has many innate problems. i would say the quality control in the manufacturing process is very poor. i would say also that this is one of the worst cars I ever owned and would never buy another saturn again. As far as electrically I had to put in a new part so the lights would work when I opened up the doors. I could go on and on, but this is a disgrace.

The transmission diff. pin came out and putting a hole in side of the casing. This happen 2 times 6 months apart

Sunroof-Plastic guide in the track broke on the right side Radiator-plastic on sides of radiator cracked repaced it only two weeks later same leak again

Oil went in to the coolant system I was not notified of the recall because it was a used car I bought the car in 1997 at 08894 miles I brought the car to Saturn after I paid to have the system flushed out thinking it was vandalism on 09/05/01 at 32223 miles that

I have always had a problem with the steering from the time I purchased the car, it is manual. I started having severe difficulty and pain in both wrists,undergoing a neurology examinarion,I found out I have severe carpal tunnel syndrome, that needs to be addressed by operating on it. It was caused by hard turning and stress on the wrists, operating is the only way to be corrected.

Head Gasket Blown, Head Cracked, Engine Oil and Coolant Mixing. This is a well known Manufacturer’s defect. Saturn says they will not cover the expenses as I am out of the warranty period (6 years or 100,000 MIles)

Ligthly applied brake to slow down to stop at intersection; though i had foot pressing hard on brake car would not stop, entered intersection and struck a passing car; this was within an hour of picking up the car from garage where repairs had been done because of this problem; air bags did not activate at impact

Tl* the contact owns a 1996 sc1 saturn. the contact stated that the horn sounded independently while the vehicle was parked overnight. the vehicle was not equipped with an anti-theft system. the vehicle was taken to the dealer for inspection who advised that the fuse would have to be removed in order to shut the horn off. in addition, the horn assembly would need replacing. the vehicle was not repaired. the manufacture was contacted and stated that the contact’s vehicle was not under recall. the failure mileage was unavailable and the current mileage was 18,782.

As the original owner of a 1996 saturn sc1 with 68,000 miles, this car has had four head gaskets replaced originating when this car was under a year old. in addition to these repeated catastrophic engine failures multiple replacements of alarm systems, radio, electrical issues and a defective front seat. this is what i purchased from saturn and i have all documentation. the most recent head gasket failure occurred in november ¿06. as i was exasperated by saturn and this vehicle i was sold, i sued the saturn corporation in the richmond county small claims division for the cost of the fourth head gasket. *tr

Tl*the contact owns a 1996 saturn sc. the contact stated that when he purchased the vehicle, the dashboard had one long crack and one short crack. the current mileage is 42,000 and failure mileage was 33,000.

I drive a 1996 saturn sc-1. while trying to back out of the driveway yesterday, the gearshift went "limp" and i was unable to put the car into gear and drive. i removed the center console, and found that what i later found out to be the "shifter linkage bushing" had broken in half, and would need to be replaced. should have been a simple fix. after two auto parts stores, the saturn dealership, and a lot of online research, i find out that saturn decided to stop making that part, and that the only way to fix the problem is to replace the entire cable assembly going into the transmission. so, for a .50 cent part, i would be forced to pay several hundred dollars to get this fixed, as replacing a bushing is something i am capable of doing at home, but cracking open the transmission is not. i am appalled that saturn doesn't make or carry the parts to replace an item on a car that is only 8 years old. i realize they still have a fix for this, but i would categorize that fix as extortion. i thought i was alo0ne with this problem, but it is well documented on the web by other saturn owners. here is a good link to a forum discussing this: http://www.chaosmagnet.com/blog/archives/000112.html i am currently using zip ties to keep the linkage in place because i refuse to pay four or five hundred dollars, (the part alone cost almost $200) to fix this. i pray there is something the nhtsa can do about this, because i can't make enough waves on my own to get anything done about this. thank you in advance.*ak

Windshield wipers turn "on" in the "off" position. i must turn "on" the wipers in order to turn them "off". no delay wiper speed.*ak

While driving down the freeway on my way to work in rush hour traffic my car began to shake. as i slowed there was a tearing sound from the drivers front tire. almost instantly parts from that part of the car, such as the fender and wheel well, began breaking off of the car. then i felt something rip out from under the dashboard at my feet and the car began to practically steer itself, i realized that i was in trouble. i was able to get the car off the road without hurting myself or anyone else. when i got out of the car i could see that from the front bumper to the front of the drivers side door the car had been stripped down to the frame. the main wiring harness that runs from the battery, through the side of the car and into the dash had been ripped out and wrapped around the front axel. this has resulted in my vehicle being a total loss. the estimate for repairs is $3,600.00 and once the car is repaired there is no guarantee that there may be further damage within the electrical system of the car. the insurance company will be picking the car up from the shop tomorrow. there is no reason why the main wiring harness for a vehicle should be wired through a fiberglass fender assembly and secured to it. this is a major design problem.*ak

Head gasket blown, head cracked, engine oil and coolant mixing. this is a well known manufacturer's defect. saturn says they will not cover the expenses as i am out of the warranty period (6 years or 100,000 miles)

The vehicle is currently experiencing horn problems. the fuse have to be removed in order for the horn to stop blowing. currently, vehicle is being driven without the use of the horn. dealer and manufacturer have been notified, but they insist that a recall has not been initiated. *ak

June 1999 saturn sent a notice regarding the cylinder head defect that may occur. they extended warranty to 100,000 miles or 6 years. however knowing there is a defect in their workmanship, i attempted contact with less than 69,000 miles on my saturn when the cylinder head showed all the signs of a crack. this included oil in the radiator. saturn accepts no liability for this seeing it out of the six year warranty period. however it is well within the 100,000 mile mileage period.

Shift linkage bushing unavailable for replacement from manufacturer.*ak

Drivers seat won't stay in upright position when i lean back with slight pressure, whether i am in motion or not. this has been an ongoing problem for about a month. as a previous owner of many cars, i have never heard of this type of problem. also the trunk latch is not operable using the cable.

Vehicle has poor stability,pulling either sides due to right wheel being bent causing frame to shift, vehicle purchased in this condition on 01/03/96. *ak

The rear suspension broke. please describe. tt

Vehicle would stall periodically without any type of prior warning. vehicle has been taken to dealer on six different occasions, and dealer replaced cranked sensor/idle speed control motor, and turned screw for idle and etc. although repairs were done, it did not remedy the problem. also, manufacturer was contacted by dealer. *ak

While driving cruise control automatically took off, causing sudden acceleration up to 90 mp. ,consumer tried taking the car out of gear, but nothing solved the problem save cutting the car off. *ak

Cylinder head cracked. nlm

Apparently saturn and gm knew that the valve body assembly in this model was wrong. i have taken it to two different saturn dealers and was never told of this recurring problem. my car is in the shop for the second time to have this problem specifically adressed. the car thuds into reverse and has trouble going into gear. it also tugs when shifting. mr

No summary listed for above vehicle. *ak

Front of rear seats are high-back of seat is low-child car seats do not fit properly unless you put something under the seat to support it-which is against the law and not safe for the child-i was told by saturn they could not help me with the problem-2 men from saturn told me to put a rolled up towel under the seat to make it fit.

During rainy weather anti-lock brakes locked up causing vehicle to rear-end another vehicle. *tt

Vehicle continually leaks water into vehicle causing damage to the electrical system as well as carpeting etc.

Cylinder head cracked at 52000, second port developed a crack allowing oil into cooling system.

During collision seat back collapsed.

While in collision the air bag had no deployment, driver ended up in the back seat of vehicle.

While in collision, the seat belt tore loose and did not protect consumer.

Generator failure, car stopped suddenly in traffic.

Brake system completely failed.

A/c system failed.

Steering column makes clicking noise when turning left. *dh

Glazed rotors cause brakes to squeal.