Skip to content
1994 FORD Aerostar
5 Recalls for 1994 FORD Aerostar
| Recall Date | Component | Summary |
|---|---|---|
| 1999-02-09 | ELECTRICAL SYSTEM:IGNITION:SWITCH | VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE. Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY. |
| 1999-02-09 | ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | VEHICLE DESCRIPTION: MINI VANS. HEAT GENERATION IN THE WIRING HARNESS TO THE FUEL PUMP/SENDER ASSEMBLY CAN CAUSE AN ELECTRICAL SHORT. THE VEHICLE COULD EXPERIENCE A LOSS OF POWER AND BECOME IMMOBILIZED AND THE FUEL GAUGE MAY BE ERRATIC. Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS IN THE FUEL PUMP GROUND CIRCUIT THAT WILL BE INSTALLED AT THE FUEL PUMP INERTIA SHUT-OFF SWITCH. |
| 1998-04-08 | SERVICE BRAKES, AIR:DISC:ROTOR | EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE. Remedy: AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT. |
| 1997-11-13 | POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) | VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT. Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED. |
| 2006-03-13 | SERVICE BRAKES, HYDRAULIC | CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK. Remedy: AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354. |
4 Complaints sent to the Center for Auto Safety for 1994 FORD Aerostar
| Date | Component | |||
|---|---|---|---|---|
| 2012-08-06 | electrical/battery | |||
| 2011-05-12 | fuel system | |||
| 2011-05-12 | ||||
| 2011-05-12 | power options (window/door/seat/roof) |
299 Complaints submitted to NHTSA for 1994 FORD Aerostar
| Date | Component | |||
|---|---|---|---|---|
| 1997-05-08 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 812109 | |||
| 2001-03-29 |
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
ODI Number: 884563 | |||
| 2001-02-20 |
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
ODI Number: 880813 | |||
| 1998-09-09 |
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
ODI Number: 827758 | |||
| 2002-02-15 |
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
ODI Number: 564596 | |||
| 1996-09-24 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 509105 | |||
| 1996-11-21 |
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 511633 | |||
| 1996-07-31 |
SUSPENSION
ODI Number: 506930 | |||
| 1996-07-31 |
ENGINE AND ENGINE COOLING
ODI Number: 506930 | |||
| 1996-07-31 |
POWER TRAIN:CLUTCH ASSEMBLY:BELL HOUSING
ODI Number: 506930 | |||
| 1996-07-31 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 506930 | |||
| 1996-06-17 |
SEATS:FRONT ASSEMBLY:RECLINER
ODI Number: 505683 | |||
| 1995-10-01 |
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
ODI Number: 488852 | |||
| 1995-10-01 |
ELECTRICAL SYSTEM:STARTER ASSEMBLY
ODI Number: 488852 | |||
| 1995-10-01 |
UNKNOWN OR OTHER
ODI Number: 488852 | |||
| 1995-10-01 |
UNKNOWN OR OTHER
ODI Number: 488852 | |||
| 1995-10-01 |
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
ODI Number: 488852 | |||
| 1995-10-01 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
ODI Number: 488852 | |||
| 1996-06-10 |
SEATS | STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 985400 | |||
| 1999-08-19 |
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
ODI Number: 845400 | |||
| 1999-07-07 |
ENGINE AND ENGINE COOLING:COOLING SYSTEM
ODI Number: 841800 | |||
| 1995-01-31 |
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 480161 | |||
| 1995-01-31 |
SUSPENSION:FRONT:SHOCK ABSORBER
ODI Number: 480161 | |||
| 1995-01-31 |
STRUCTURE:BODY:DOOR
ODI Number: 480161 | |||
| 1995-01-31 |
STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 480161 | |||
| 1995-01-31 |
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 480161 | |||
| 1994-11-10 |
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
ODI Number: 477783 | |||
| 1998-05-18 |
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 823400 | |||
| 2000-04-06 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 721100 | |||
| 1995-01-02 |
STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 480354 | |||
| 1997-06-05 |
SEATS
ODI Number: 812800 | |||
| 2017-10-25 |
AIR BAGS | SEAT BELTS
ODI Number: 11039844 | |||
| 2013-08-12 |
ELECTRICAL SYSTEM
ODI Number: 10534938 | |||
| 2012-06-13 |
ELECTRICAL SYSTEM
ODI Number: 10461633 | |||
| 2009-07-08 |
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | FUEL SYSTEM, GASOLINE
ODI Number: 10276149 | |||
| 2008-07-05 |
AIR BAGS | ELECTRICAL SYSTEM | ELECTRICAL SYSTEM:HORN | VEHICLE SPEED CONTROL
ODI Number: 10233257 | |||
| 2008-02-12 |
ELECTRICAL SYSTEM:12V/24V/48V BATTERY | ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR | ELECTRICAL SYSTEM:IGNITION:MODULE | ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID | EXTERIOR LIGHTING:BRAKE LIGHTS | EXTERIOR LIGHTING:HEADLIGHTS | EXTERIOR LIGHTING:
ODI Number: 10217895 | |||
| 2008-02-06 |
ELECTRICAL SYSTEM:IGNITION
ODI Number: 10217101 | |||
| 2006-09-17 |
STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 10168462 | |||
| 2005-11-23 |
TIRES:TREAD/BELT
ODI Number: 10145392 | |||
| 2005-10-21 |
AIR BAGS | ELECTRICAL SYSTEM:HORN | VEHICLE SPEED CONTROL:CRUISE CONTROL
ODI Number: 10140413 | |||
| 2006-02-01 |
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10132510 | |||
| 2004-11-13 |
VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING
ODI Number: 10098779 | |||
| 2004-08-10 |
AIR BAGS
ODI Number: 10087578 | |||
| 2004-03-10 |
AIR BAGS | ELECTRICAL SYSTEM:HORN | SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT | SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP
ODI Number: 10061851 | |||
| 2003-11-12 |
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP | STEERING:COLUMN
ODI Number: 10046772 | |||
| 2003-10-23 |
STRUCTURE:FRAME AND MEMBERS
ODI Number: 10043414 | |||
| 2003-07-08 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10026717 | |||
| 2003-06-25 |
AIR BAGS:FRONTAL
ODI Number: 10024907 | |||
| 2003-05-29 |
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
ODI Number: 10021807 | |||
| 2003-05-05 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 10017023 | |||
| 2003-05-15 |
SUSPENSION:REAR:SPRINGS
ODI Number: 10018749 | |||
| 2003-03-25 |
TIRES
ODI Number: 10012463 | |||
| 2003-02-24 |
ELECTRICAL SYSTEM:IGNITION:SWITCH | ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 10008035 | |||
| 2003-09-12 |
AIR BAGS:FRONTAL
ODI Number: 10008823 | |||
| 2003-02-25 |
AIR BAGS
ODI Number: 10008076 | |||
| 2002-12-31 |
STEERING:COLUMN
ODI Number: 10001727 | |||
| 2002-05-20 |
EQUIPMENT:ELECTRICAL
ODI Number: 8010099 | |||
| 2002-05-23 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 8010438 | |||
| 2002-03-22 |
ELECTRICAL SYSTEM:WIRING
ODI Number: 8006247 | |||
| 1996-06-20 |
STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 985903 | |||
| 1996-04-11 |
AIR BAGS:FRONTAL
ODI Number: 982653 | |||
| 1996-06-28 |
FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
ODI Number: 986273 | |||
| 1996-07-10 |
ENGINE AND ENGINE COOLING
ODI Number: 986694 | |||
| 1996-04-17 |
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
ODI Number: 982869 | |||
| 2002-09-30 |
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 8019900 | |||
| 1996-06-11 |
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
ODI Number: 985512 | |||
| 1995-11-08 |
AIR BAGS:FRONTAL
ODI Number: 974806 | |||
| 1996-03-11 |
AIR BAGS:FRONTAL | AIR BAGS:FRONTAL
ODI Number: 980506 | |||
| 1995-11-01 |
AIR BAGS:FRONTAL | SEAT BELTS:FRONT:BUCKLE ASSEMBLY
ODI Number: 974330 | |||
| 1996-02-01 |
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
ODI Number: 978595 | |||
| 1996-01-31 |
EQUIPMENT:ELECTRICAL
ODI Number: 978502 | |||
| 1996-01-16 |
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
ODI Number: 977589 | |||
| 1995-09-01 |
SUSPENSION:FRONT:SHOCK ABSORBER
ODI Number: 971469 | |||
| 1995-07-19 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 969090 | |||
| 1995-08-23 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
ODI Number: 970970 | |||
| 1995-10-17 |
ELECTRICAL SYSTEM:HORN | ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE | POWER TRAIN | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | STRUCTURE:BODY:DO
ODI Number: 973463 | |||
| 1995-08-29 |
TIRES
ODI Number: 971199 | |||
| 1995-06-22 |
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
ODI Number: 967496 | |||
| 1995-08-28 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
ODI Number: 971150 | |||
| 1995-08-28 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS | STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 971110 | |||
| 1995-08-16 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
ODI Number: 970671 | |||
| 1995-07-19 |
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 969190 | |||
| 1995-03-03 |
SUSPENSION:REAR
ODI Number: 961083 | |||
| 1995-02-24 |
SEATS:FRONT ASSEMBLY:RECLINER
ODI Number: 960570 | |||
| 1995-02-13 |
SEATS:FRONT ASSEMBLY:RECLINER
ODI Number: 959973 | |||
| 1995-02-22 |
FUEL SYSTEM, GASOLINE
ODI Number: 960387 | |||
| 1995-05-04 |
STEERING
ODI Number: 964822 | |||
| 2001-11-27 |
AIR BAGS | ELECTRICAL SYSTEM:HORN | VEHICLE SPEED CONTROL
ODI Number: 899547 | |||
| 2001-11-27 |
INTERIOR LIGHTING
ODI Number: 899511 | |||
| 2001-11-30 |
POWER TRAIN:AXLE ASSEMBLY
ODI Number: 899755 | |||
| 2001-11-26 |
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
ODI Number: 899421 | |||
| 2001-09-17 |
AIR BAGS | ELECTRICAL SYSTEM:HORN
ODI Number: 896389 | |||
| 2001-05-23 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 889015 | |||
| 2001-03-29 |
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
ODI Number: 884563 | |||
| 2001-04-02 |
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
ODI Number: 884888 | |||
| 2001-05-08 |
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
ODI Number: 887759 | |||
| 2001-04-02 |
AIR BAGS:FRONTAL
ODI Number: 884817 | |||
| 2001-04-18 |
ELECTRICAL SYSTEM:IGNITION
ODI Number: 886189 | |||
| 2001-02-20 |
WHEELS
ODI Number: 880888 | |||
| 2001-02-20 |
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
ODI Number: 880813 | |||
| 2001-01-08 |
TIRES:TREAD/BELT
ODI Number: 877675 | |||
| 2000-10-10 |
SEAT BELTS:FRONT:RETRACTOR
ODI Number: 872663 | |||
| 2000-11-21 |
AIR BAGS | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 875363 | |||
| 2000-11-20 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 875249 | |||
| 2000-07-31 |
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
ODI Number: 866414 | |||
| 2000-08-22 |
SEAT BELTS:FRONT:RETRACTOR
ODI Number: 868354 | |||
| 2000-07-24 |
AIR BAGS
ODI Number: 865885 | |||
| 2000-06-16 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
ODI Number: 863702 | |||
| 2000-06-01 |
FUEL SYSTEM, OTHER
ODI Number: 862864 | |||
| 2000-05-17 |
AIR BAGS | ELECTRICAL SYSTEM:HORN | VEHICLE SPEED CONTROL
ODI Number: 862034 | |||
| 2000-04-05 |
AIR BAGS:FRONTAL
ODI Number: 859728 | |||
| 2000-04-11 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 860072 | |||
| 2000-05-22 |
ELECTRICAL SYSTEM:12V/24V/48V BATTERY | ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 862287 | |||
| 2000-05-22 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 862247 | |||
| 2000-01-03 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 853653 | |||
| 2000-02-01 |
VEHICLE SPEED CONTROL
ODI Number: 855914 | |||
| 2000-01-31 |
EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH
ODI Number: 855824 | |||
| 2000-03-03 |
AIR BAGS
ODI Number: 857902 | |||
| 1999-09-08 |
SUSPENSION:REAR
ODI Number: 847072 | |||
| 1999-09-15 |
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 847803 | |||
| 1999-10-15 |
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS
ODI Number: 850896 | |||
| 1999-09-08 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 847138 | |||
| 1999-06-17 |
VISIBILITY:WINDSHIELD
ODI Number: 840317 | |||
| 1999-07-29 |
ELECTRICAL SYSTEM:WIRING
ODI Number: 843776 | |||
| 1999-07-16 |
ELECTRICAL SYSTEM:HORN | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 842475 | |||
| 1999-07-28 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 843641 | |||
| 1999-07-28 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 843625 | |||
| 1999-06-22 |
ELECTRICAL SYSTEM
ODI Number: 840648 | |||
| 1999-08-12 |
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
ODI Number: 838790 | |||
| 1999-07-30 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 843966 | |||
| 1999-07-27 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 843511 | |||
| 1999-07-27 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 843508 | |||
| 1999-07-30 |
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | UNKNOWN OR OTHER
ODI Number: 843903 | |||
| 1999-03-24 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
ODI Number: 836086 | |||
| 1999-03-24 |
WHEELS
ODI Number: 836084 | |||
| 1999-05-28 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 838641 | |||
| 1999-05-05 |
ELECTRICAL SYSTEM:IGNITION:SWITCH | VEHICLE SPEED CONTROL
ODI Number: 837469 | |||
| 1999-05-17 |
AIR BAGS
ODI Number: 836375 | |||
| 1999-05-28 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 838584 | |||
| 1999-05-04 |
AIR BAGS
ODI Number: 837432 | |||
| 1999-05-27 |
AIR BAGS
ODI Number: 838553 | |||
| 1999-05-27 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 838508 | |||
| 1999-05-10 |
AIR BAGS | ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 837677 | |||
| 1999-04-20 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 836867 | |||
| 1999-04-28 |
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | UNKNOWN OR OTHER
ODI Number: 837221 | |||
| 1998-09-09 |
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
ODI Number: 827758 | |||
| 1998-12-31 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 832896 | |||
| 1998-12-14 |
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
ODI Number: 832242 | |||
| 1998-11-09 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
ODI Number: 830463 | |||
| 1998-11-09 |
LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
ODI Number: 830430 | |||
| 1998-11-30 |
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 831447 | |||
| 1998-09-28 |
EXTERIOR LIGHTING:HEADLIGHTS
ODI Number: 828245 | |||
| 1998-08-21 |
AIR BAGS:FRONTAL | AIR BAGS:FRONTAL | VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
ODI Number: 827081 | |||
| 1998-08-06 |
ELECTRICAL SYSTEM:WIRING | ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ODI Number: 826383 | |||
| 1998-08-14 |
ENGINE AND ENGINE COOLING:COOLING SYSTEM | EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH | UNKNOWN OR OTHER
ODI Number: 826711 | |||
| 1998-03-12 |
ELECTRICAL SYSTEM:WIRING
ODI Number: 821924 | |||
| 1998-06-08 |
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
ODI Number: 824044 | |||
| 1998-07-14 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 825395 | |||
| 1998-01-22 |
SEATS
ODI Number: 820323 | |||
| 1997-12-03 |
POWER TRAIN:AUTOMATIC TRANSMISSION | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 819660 | |||
| 1997-10-16 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 817149 | |||
| 1998-03-02 |
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
ODI Number: 821754 | |||
| 1997-09-03 |
AIR BAGS:FRONTAL
ODI Number: 815956 | |||
| 1997-08-06 |
SERVICE BRAKES, AIR:DISC:ROTOR
ODI Number: 815131 | |||
| 1997-06-16 |
AIR BAGS:FRONTAL
ODI Number: 813101 | |||
| 1997-06-02 |
SEATS:FRONT ASSEMBLY:RECLINER
ODI Number: 810957 | |||
| 1997-09-03 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 814449 | |||
| 1997-07-10 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
ODI Number: 814057 | |||
| 1997-03-27 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
ODI Number: 810466 | |||
| 1997-08-27 |
ELECTRICAL SYSTEM:WIRING
ODI Number: 815710 | |||
| 1997-05-08 |
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 812109 | |||
| 1997-03-25 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 808994 | |||
| 1996-08-02 |
STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS
ODI Number: 800391 | |||
| 1996-10-09 |
ELECTRICAL SYSTEM:HORN
ODI Number: 803389 | |||
| 1998-10-20 |
ELECTRICAL SYSTEM:IGNITION
ODI Number: 781478 | |||
| 1996-07-31 |
AIR BAGS:FRONTAL | AIR BAGS:FRONTAL
ODI Number: 800271 | |||
| 1996-07-30 |
AIR BAGS:FRONTAL
ODI Number: 800248 | |||
| 1996-09-06 |
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
ODI Number: 801975 | |||
| 1996-10-03 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
ODI Number: 803163 | |||
| 1996-11-19 |
SUSPENSION:FRONT
ODI Number: 802678 | |||
| 1999-11-01 |
AIR BAGS
ODI Number: 784262 | |||
| 1999-11-01 |
VEHICLE SPEED CONTROL
ODI Number: 784262 | |||
| 1999-11-01 |
ELECTRICAL SYSTEM:HORN
ODI Number: 784262 | |||
| 1996-09-04 |
ELECTRICAL SYSTEM:IGNITION
ODI Number: 801780 | |||
| 2002-07-29 |
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
ODI Number: 764871 | |||
| 2002-03-21 |
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 759619 | |||
| 2001-11-27 |
AIR BAGS
ODI Number: 754991 | |||
| 2001-07-01 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 747646 | |||
| 2001-06-27 |
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 747478 | |||
| 2001-06-25 |
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 747364 | |||
| 2001-05-01 |
AIR BAGS:FRONTAL
ODI Number: 744794 | |||
| 2001-04-22 |
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR | FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY | POWER TRAIN:DRIVELINE:DRIVESHAFT
ODI Number: 744382 | |||
| 2001-01-30 |
SEAT BELTS:FRONT:ANCHORAGE
ODI Number: 740196 | |||
| 2000-10-17 |
AIR BAGS
ODI Number: 734571 | |||
| 2000-10-12 |
ELECTRICAL SYSTEM
ODI Number: 734168 | |||
| 2000-08-31 |
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 729662 | |||
| 2000-08-28 |
AIR BAGS | ELECTRICAL SYSTEM:HORN
ODI Number: 729311 | |||
| 2000-08-04 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 726602 | |||
| 2000-07-18 |
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR | POWER TRAIN:AUTOMATIC TRANSMISSION | POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
ODI Number: 725657 | |||
| 2000-06-14 |
AIR BAGS:FRONTAL | SEAT BELTS
ODI Number: 724005 | |||
| 2000-01-20 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 717622 | |||
| 2000-01-15 |
EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH | EXTERIOR LIGHTING:TURN SIGNAL:SWITCH | VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 717370 | |||
| 2000-01-05 |
POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
ODI Number: 716941 | |||
| 1999-12-21 |
AIR BAGS | UNKNOWN OR OTHER
ODI Number: 716294 | |||
| 1999-09-20 |
AIR BAGS
ODI Number: 711638 | |||
| 1999-09-15 |
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
ODI Number: 711394 | |||
| 1999-07-10 |
ELECTRICAL SYSTEM:WIRING
ODI Number: 708476 | |||
| 1999-07-13 |
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
ODI Number: 708557 | |||
| 1999-06-22 |
AIR BAGS | ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD | ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS | ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY | STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT
ODI Number: 707784 | |||
| 1999-06-22 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 707783 | |||
| 1999-06-21 |
STEERING:RACK AND PINION
ODI Number: 707710 | |||
| 1999-06-04 |
AIR BAGS
ODI Number: 707189 | |||
| 1999-05-23 |
ENGINE AND ENGINE COOLING:ENGINE | EXTERIOR LIGHTING:HEADLIGHTS
ODI Number: 706777 | |||
| 1999-05-22 |
FUEL SYSTEM, GASOLINE
ODI Number: 706766 | |||
| 1999-05-16 |
SEAT BELTS
ODI Number: 706551 | |||
| 1999-05-13 |
EXTERIOR LIGHTING:TURN SIGNAL:SWITCH
ODI Number: 706490 | |||
| 1999-05-13 |
ENGINE AND ENGINE COOLING:COOLING SYSTEM | ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
ODI Number: 706467 | |||
| 1999-03-31 |
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 705149 | |||
| 1999-03-25 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 704910 | |||
| 1999-04-05 |
STRUCTURE:BODY
ODI Number: 705284 | |||
| 1999-03-23 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 704811 | |||
| 1999-03-23 |
AIR BAGS
ODI Number: 704803 | |||
| 1999-03-08 |
WHEELS
ODI Number: 704153 | |||
| 1999-02-27 |
ELECTRICAL SYSTEM:IGNITION
ODI Number: 703798 | |||
| 1999-01-29 |
POWER TRAIN:AUTOMATIC TRANSMISSION | STEERING:HYDRAULIC POWER ASSIST SYSTEM | STEERING:RACK AND PINION
ODI Number: 702726 | |||
| 1999-01-29 |
SEATS
ODI Number: 702725 | |||
| 1998-11-21 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 700796 | |||
| 2002-02-15 |
STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
ODI Number: 564596 | |||
| 2002-02-15 |
AIR BAGS
ODI Number: 564596 | |||
| 2001-09-06 |
TIRES:TREAD/BELT
ODI Number: 562981 | |||
| 2001-04-25 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 560922 | |||
| 2001-01-09 |
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ODI Number: 558844 | |||
| 2001-01-09 |
POWER TRAIN:AUTOMATIC TRANSMISSION | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 558844 | |||
| 2001-01-09 |
STRUCTURE:BODY:DOOR | VEHICLE SPEED CONTROL
ODI Number: 558844 | |||
| 2001-01-09 |
STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT | STEERING:LINKAGES:TIE ROD ASSEMBLY
ODI Number: 558844 | |||
| 2001-01-09 |
ELECTRICAL SYSTEM:IGNITION | ELECTRICAL SYSTEM:IGNITION | ELECTRICAL SYSTEM:STARTER ASSEMBLY
ODI Number: 558844 | |||
| 2001-01-09 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
ODI Number: 558844 | |||
| 2001-01-09 |
EQUIPMENT:APPLIANCE:AIR CONDITIONER | VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
ODI Number: 558844 | |||
| 2001-01-09 |
TIRES
ODI Number: 558844 | |||
| 2001-01-09 |
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
ODI Number: 558844 | |||
| 2000-10-16 |
POWER TRAIN
ODI Number: 556110 | |||
| 2000-10-24 |
TIRES | TIRES
ODI Number: 556816 | |||
| 1999-12-15 |
EXTERIOR LIGHTING:TURN SIGNAL | STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
ODI Number: 549983 | |||
| 2000-01-10 |
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
ODI Number: 550308 | |||
| 1999-07-23 |
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
ODI Number: 547540 | |||
| 1997-02-05 |
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 546625 | |||
| 1997-02-05 |
STEERING:RACK AND PINION
ODI Number: 546624 | |||
| 1997-02-05 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 546623 | |||
| 1999-08-02 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 547693 | |||
| 1999-06-08 |
ELECTRICAL SYSTEM:IGNITION:SWITCH | ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 546028 | |||
| 1999-07-20 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 547394 | |||
| 1999-07-20 |
ELECTRICAL SYSTEM:HORN
ODI Number: 547394 | |||
| 1999-07-20 |
VEHICLE SPEED CONTROL
ODI Number: 547394 | |||
| 1999-07-20 |
AIR BAGS
ODI Number: 547394 | |||
| 1999-07-19 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 547360 | |||
| 1999-07-19 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 547360 | |||
| 1999-05-25 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 545736 | |||
| 1999-05-25 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 545736 | |||
| 1999-05-25 |
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 545736 | |||
| 1999-05-12 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 545577 | |||
| 1999-04-16 |
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 545087 | |||
| 1999-04-16 |
VISIBILITY:REARVIEW MIRRORS/DEVICES
ODI Number: 545087 | |||
| 1999-04-16 |
EXTERIOR LIGHTING:TAIL LIGHTS
ODI Number: 545087 | |||
| 1999-03-02 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT | POWER TRAIN:DRIVELINE:DRIVESHAFT
ODI Number: 544211 | |||
| 1998-12-31 |
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
ODI Number: 543173 | |||
| 1998-12-18 |
EQUIPMENT:MECHANICAL:ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT
ODI Number: 543097 | |||
| 1998-12-18 |
TIRES
ODI Number: 543097 | |||
| 1999-01-25 |
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
ODI Number: 542480 | |||
| 1998-08-05 |
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
ODI Number: 538843 | |||
| 1998-09-11 |
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
ODI Number: 539961 | |||
| 1998-05-28 |
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
ODI Number: 536343 | |||
| 1998-05-13 |
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
ODI Number: 535501 | |||
| 1998-03-31 |
POWER TRAIN:AUTOMATIC TRANSMISSION
ODI Number: 533419 | |||
| 1998-03-26 |
VEHICLE SPEED CONTROL
ODI Number: 533234 | |||
| 1998-04-10 |
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
ODI Number: 534253 | |||
| 1998-03-19 |
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
ODI Number: 533110 | |||
| 1998-03-03 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 531758 | |||
| 1998-02-20 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 530998 | |||
| 1997-09-26 |
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 528354 | |||
| 1997-12-10 |
SEAT BELTS:FRONT:ANCHORAGE
ODI Number: 526062 | |||
| 1997-12-10 |
SUSPENSION
ODI Number: 526062 | |||
| 1997-12-09 |
POWER TRAIN:AUTOMATIC TRANSMISSION | POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 526017 | |||
| 1997-12-10 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 526314 | |||
| 1997-08-06 |
EQUIPMENT:APPLIANCE:AIR CONDITIONER
ODI Number: 522547 | |||
| 1997-11-20 |
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
ODI Number: 523458 | |||
| 1997-10-04 |
STRUCTURE:BODY:HATCHBACK/LIFTGATE
ODI Number: 524150 | |||
| 1997-08-26 |
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 518492 | |||
| 1997-07-01 |
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
ODI Number: 519012 | |||
| 1997-05-06 |
ELECTRICAL SYSTEM:WIRING
ODI Number: 516975 | |||
| 1997-03-27 |
UNKNOWN OR OTHER
ODI Number: 515976 | |||
| 1997-05-12 |
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE
ODI Number: 517144 | |||
| 1997-04-21 |
AIR BAGS
ODI Number: 516624 | |||
| 1997-02-20 |
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ODI Number: 514913 | |||
| 1995-04-21 |
STEERING
ODI Number: 482840 | |||
| 1995-04-21 |
STRUCTURE:BODY:DOOR
ODI Number: 482840 | |||
| 1995-04-21 |
SUSPENSION:FRONT:SHOCK ABSORBER
ODI Number: 482840 | |||
| 1995-02-15 |
STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 481984 | |||
| 1995-02-15 |
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 481984 |
5 Investigations for 1994 FORD Aerostar
| Date Opened | Date Closed | Component | |
|---|---|---|---|
| 1998-02-13 | 1998-07-14 | VEHICLE SPEED CONTROL:LINKAGES | |
| 2002-10-10 | 2003-03-10 | STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE | |
| 1999-01-07 | 2000-11-14 | POWER TRAIN | |
| 1998-07-31 | 1999-01-07 | POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) | |
| 1998-07-14 | 1999-02-12 | VEHICLE SPEED CONTROL:LINKAGES |
66 Service Alerts for 1994 FORD Aerostar
| Date | Description |
|---|---|
| 1996-10-10 | 162620 STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT
CONCERNS W/ LIFTGATE OPENING EFFORTS &/OR THE LIFTGATE NOT STAYING OPEN, ESPECIALLY IN COLD AMBIENT TEMPS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-09-02 | 125100 EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-03-17 | 980000 UNKNOWN OR OTHER
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-02-16 | 162200 STRUCTURE:BODY:BUMPERS
FRONT AND REAR BUMPERS MADE OF XENOY PLASTIC HAVE HAD THE CONDUCTIVE PRIMER REMOVED FROM SERVICE PARTS. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-09-17 | 103800 POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
BRAKE SHIFT INTERLOCK.*JB Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1999-07-26 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-09-02 | 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
EXPERIENCING A “THUMPING” NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-10-25 | 102000 POWER TRAIN:MANUAL TRANSMISSION
INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-04-13 | 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-04-27 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-05-01 | 106000 POWER TRAIN:AXLE ASSEMBLY
AEROSTAR E4WD MODELS MAY EXPERIENCE FRONT AXLE LUBRICANT LEAKAGE FROM THE VENT TUBE UNDER SOME DRIVING CONDITIONS. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-02-17 | 061000 ENGINE AND ENGINE COOLING:ENGINE
BLOWER MOTOR- “CHIRP” OR “SQUEAK” FROM BLOWER MOTOR AT LOW SPEEDS. *JD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-01-23 | 062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-11-18 | 114000 ELECTRICAL SYSTEM:WIRING
WIRING – ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-11-23 | 106000 POWER TRAIN:AXLE ASSEMBLY
CONCERNS WITH FRONT DRIVE AXLE FLUID MAY LEAK OUT OF THE VENT UNDER SOME DRIVING MODES ON SOME VEHICLES. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-01-23 | 062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-01-19 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-01-19 | 034530 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-03-18 | 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-03-18 | 034530 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-10-21 | 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
BRAKES – ELIMINATION OF SANDING ROTORS AND DRUMS – SERVICE TIP. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-10-21 | 131000 VISIBILITY:WINDSHIELD
WINDSHIELD AND INTERIOR GLASS – FOG/FILM. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-11-18 | 103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
TORQUE CONVERTER – LEAK TEST PROCEDURE – SERVICE TIP. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-03-18 | 034500 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1999-09-20 | 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-11-10 | 113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY
VEHICLES EXHIBITING A “SQUEAKING” OR “CHIRPING” FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-06-25 | 061000 ENGINE AND ENGINE COOLING:ENGINE
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-05-01 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
TRANSFER CASE MAY LEAK FLUID FROM THE CASE VENT TUBE. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-05-01 | 116000 ELECTRICAL SYSTEM:IGNITION
VEHICLES MAY HAVE A DISCONNECT OF THE IGNITION CONTROL MODULE (ICM) CONNECTOR OR MOISTURE BUILDUP WITHIN THE CONNECTOR. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-05-01 | 061000 ENGINE AND ENGINE COOLING:ENGINE
UNKNOWN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-10-01 | 162000 STRUCTURE:BODY
A WINDNOISE MAY BE HEARD AT THE A-PILLAR IN SOME VEHICLES. THIS MAY BE CAUSED BY INCOMPLETE SEALING AT THE A-PILLAR. INSTALL A FOAM SEALANT INTO THE LOWER SECTION OF THE A-PILLAR TO SEAL AN AIR LEAK IN THE A-PILLAR. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-10-01 | 036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PAR Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-09-01 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
HIGH ALTITUDE TRANSMISSION AVAILABLE. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-03-18 | 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
THIS BULLETIN CONTAINS SERVICE TIPS WHEN SERVICING ANY BRAKE RELATED ROUGHNESS / PULL CONCERNS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1999-06-28 | 125000 EXTERIOR LIGHTING:BRAKE LIGHTS
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1999-08-01 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1999-05-03 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2003-07-21 | 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
NEW TRANSMISSION COOLER FLUSHER – SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-04-13 | 190000 TIRES
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-03-01 | 138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
CHIRP OR SQUEAK NOISE FROM BLOWER MOTOR AT LOW SPEEDS. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1994-12-01 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
KNOCKING NOISE FROM LOWER END #1 MAIN BEARING DURING ACCELERATION. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-03-01 | 138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
UNKNOWN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2000-11-13 | 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-10-10 | 162620 STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE
CONCERNS W/ LIFTGATE OPENING EFFORTS &/OR THE LIFTGATE NOT STAYING OPEN, ESPECIALLY IN COLD AMBIENT TEMPS. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-12-07 | 110000 ELECTRICAL SYSTEM
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ – 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-03-01 | 138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
CHIRP OR SQUEAK FROM BLOWER MOTOR. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-02-01 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
KNOCKING NOISE FROM LOWER FRONT OF ENGINE COMPARTMENT. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-10-12 | 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
EXPERIENCING A ” BUZZING ” OR ” RATTLING ” NOISE FROM THE EXHAUST SYSTEM. *YC Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1999-09-06 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-03-17 | 061000 ENGINE AND ENGINE COOLING:ENGINE
BLOWER MOTOR- “CHIRPING” OR “SQUEAKING” FROM BLOWER MOTOR AT LOW SPEEDS. *JD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-04-01 | 116200 ELECTRICAL SYSTEM:IGNITION:MODULE
MIL LAMP MAY TURN ON OR FLASH INTERMITTENTLY MAY BE DUE TO THE POWERTRAIN CONTROL MODULE (PCM) INCORRECTLY CALCULATING THE VEHICLE ENGINE LOAD DURING LIGHT THROTTLE. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-11-23 | 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-12-01 | 980000 UNKNOWN OR OTHER
SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-03-25 | 010000 STEERING
EXPERIENCING A RAPPING OR CLANGING NOISE WHEN THE STEERING WHEEL IS TURNED RAPIDLY OR WHEN TURNING ON A BUMPY ROAD SURFACE. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2002-09-02 | 032100 SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-03-03 | 103000 POWER TRAIN:AUTOMATIC TRANSMISSION
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-09-01 | 015200 STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
VEHICLE MAY EXHIBIT A MOAN WHEN TURNING – TO CORRECT THIS CONDITION, REPLACE THE HIGH PRESSURE HOSE WITH A TUNED HOSE. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1999-06-14 | 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 2001-10-01 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1999-08-01 | 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1998-03-18 | 354600 EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES
RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-12-16 | 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS
BRAKES – BRAKE SERVICE – SERVICE TIPS. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-12-16 | 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH
SLIDING DOOR – DAMAGED OR MISADJUSTED LATCH MECHANISM. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1996-12-16 | 103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
TRANSAXLE – TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES – SERVICE TIP. *TW Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1997-02-17 | 160000 STRUCTURE
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
| 1995-05-01 | 138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
UNKNOWN Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication") |
1994 FORD Aerostar
search for another vehicle