1991 CHEVROLET Cavalier

The first problem I have encountered is the poor body of the car. The panels below the car have completely diminished. Anything remaining of them is either rotting and rusting away, or has paint removed from them. The paint is also coming out of the front plastic bumper and from the front hood of the car. Some rust is also appearing at the sides. When I step into the highway at the speed of a minimum 100 km/h, this trash is anything but quiet. Apart from the engine, which is now broken, the gaskets or whatever keeps the air out doesn’t keep it out. Instead, some air comes in and thus making that noise; like having your windows open and getting all that noise of the air. It’s no different when closed. The rubber seal of the doors is extremely poor in this regard.My second problem has been the engine. My engine’s motor is broken down. No mechanic can fix it. I tried to go through Chevrolet and one of their local dealerships. But just the cost of refurbishing my engine would aproximatily add up to $2,500 (Might as well buy a new car instead!).

My son lost control of a 1991 chevrolet cavalier and was ejected after he was forced off the road. when entering the median, his car was skidding broadside and eventually rolled over three times. as the car rolled, the driver side door opened which defeated the ability of the seat belt to hold him inside because the seat belt design had the shoulder harness anchored to the top of the door/window frame and the lap belt anchored to the bottom of the door. *jb

The first problem i have encountered is the poor body of the car. the panels below the car have completely diminished. anything remaining of them is either rotting and rusting away, or has paint removed from them. the paint is also coming out of the front plastic bumper and from the front hood of the car. some rust is also appearing at the sides. when i step into the highway at the speed of a minimum 100 km/h, this trash is anything but quiet. apart from the engine, which is now broken, the gaskets or whatever keeps the air out doesn't keep it out. instead, some air comes in and thus making that noise; like having your windows open and getting all that noise of the air. it's no different when closed. the rubber seal of the doors is extremely poor in this regard. my second problem has been the engine. my engine's motor is broken down. no mechanic can fix it. i tried to go through chevrolet and one of their local dealerships. but just the cost of refurbishing my engine would aproximatily add up to $2,500 (might as well buy a new car instead!).

While tightening up the lug nuts on the wheel, pieces of metal sheared off and dropped small pieces of metal on the ground. *ak the lug nuts in question were newly purchased. part#254 abn 10.9 manufactured by r+b inc. *scc *jb

No one was injured. i was driving to work and had almost got there when i heard a bang on the side of the car and saw the tread fly off back behind from my drivers side front tire. tire stayed aired up as i got off the interstate i80, and pulled in the parking lot. i got out to examine the damage. the ground effects on my drivers side were hanging by like one screw. the tire was still aired up but there was no tread left on the tire. it ripped half of my front bumper off dented my front quarter panel and drivers door and ground effects were destroyed. firestone ,p205/60r15 90s m+s firehawk ss10 my car 1991 chevrolet, z24 cavalier. *ak

While driving down 25-35mph vehicle stalled out and died without warning. dealer replaced fuel pump filter. *ak

Failure on the front driver and left rear seat belt buckle, seat belt comes out of the buckle. *ak

Failure on the driver side seat mount that holds the seat in place is broken, causing the driver side seat to move. *ak

Failure on the driver side seat mount that holds the seat in place is broken, causing the driver side seat to move. *ak

The wiring under the hood overheated and caught on fire. *ak

Drivers side seat broke after being struck by a school bus. *ak

Engine compartment fire an electrical short in the harness. tt

The brakes take a lot more force in order to stop the car. please describe. tt

While driving experienced intermittent failure, initially dash and rear lights were inoperative, also driving at night headlight suddenly went out due to short

Vehicle horn came off the steering wheel, caused loss of steering. *ak

While driving, experienced intermittent failure, intially dash and rear lights were inoperative, also driving at night headlight went out due to short. *ak

The fuel pump goes out in the cold weather. please describe details. *ak

The windsheild wiper stopped work and the ignition switch was replaced. tt

While driving at any speed, rear door latch failed, causing rear hatch door to pop open on its own; no warning. tt

Had to have transmission replaced three times. was throwing out transmission fluid. tt

Transaxle failure. *ak

After slightly bumping a parking stopper, the vehicle accelerator stuck open and caused the vehicle to suddenly take off, resulting in an accident. *ak

Headlight go out intermittently at high and low beam. tt

Distributor becomes wet and fails. tt

Electrical short circuit, causing the wiring harness to catch fire. tt

Tie rods came completely off at 46,000 miles. tt

While driving a pin within the tilt steering wheel came loose,nearly causing loss of steering control. please give any further details. *ak

Starter was replaced, and did not fit properly in the vehicle, causing the starter to com eloose/ shake. bolts need to be replaced. *ak

Windshield wipers will quit during operation, causing poor visibility. *ak

While traveling the brakes would make a loud noise. dealer and manufacturer have been contacted. please provide further informantion. *ak

Defective fan motor melted which could cause a fire. *ak

Seat belt guide loops on passenger side are cracked. noticed recall on website (#92v003000). called dealer & manufacturer & was told by both vehicle was not included in recall. owner would need to pay for repairs. *ak

Consumer was driving at 35 mph on the interstate when he suffered a heart attack. vehicle flipped over the gurdrail. the consumer's air bag driver side did not deploy, and consumer was killed in the accident. *ak

The starter has been replaced twice, once in december of 96, in february of 97 at 70,000 miles. because the overrun clutch burns out, the starter is being replaced again for the third time for the same reason at 89,000 miles. the flywheel has also been replaced in january of 97 because of this problem. *ak

Owner states that after 45 minutes when the car was left after it had been driven vehice blew up, causing a melt down, fire department was unable to determine the cause of the fire. *ak

While driving experienced driver's seat track and anchor failure, seat brackets cracked/broke on both sides, causing seat to move/rock rearward, as a result, foot came off pedal and vehicle stalled out. *ak

Engine compartment fire, pe93-090, the vehicle was in motion and the vehicle cut off and caught on fire in the engine.*ak

While in stop position vehicle rpms revved up, then lurched forward, for no apparent reason. *ak

The plastic piece that goes over the button on the female part has come off, making it easy to unbuckle and harder to buckle properly.*ak

Back seat is not connected to the car and rear seat belts are missing.

The rear window of this vehicle blew out as one large piece (with gasket material) and shattered into numerous pieces upon road impact. i suspect that this is very unusual and should be documented with the manufacture & other organizations. also, if a problem exist with this vehicle, maybe the manufacturer will replace the part.

An '88 blue dodge van (vin 2b6gb113y3jk56747)crashed into my little girls car the 1991 cavalier. expert reconstructionist (tx dept. of public safety) blame my little girl for having ran the stop sign and hitting the van, causing an indirect death of three and the direct death was an abandon utility pole. i do not believe that if the car was to hit the van it would have caused so much damage. my daughter states that she came to a complete stop and proceeded entering the intersection at 6 mph. how can a small car do so much damage even if it was to have runned the stop sign. i believe that the van hit the car causing the roof of the cavalier to collapse and doing irrepairable damage to my little girls friend. my little girl had multiple contursions to the head when the roof caved in and her ankle had three fractures on her left ankle. there was evidence in the driver side that the bottom side of the door was pinged inward and the roof over her head was caved in. luckily the two girls survived. even though one is a vegetable my little girl is not the same and her youth has been stolen by this accident. she has recurring nightmares and a brain contussion that might not go away until all the pressure has been relieved and that is going to take time. why did the roof collapse injuring both occupants who were wearing seatbelts? why did they have to use the jaws-of-life to rescue both girls? *ak

I purchased this vehicle for a teenage driver. i have spent well over $l,000 to bring it up to speed - fuel filter, oil & air filters, serpentine belt radiator ignition switch (key & tumbler), tires, front brake pads, front brake rotors, rear brake shoes. it will soon need a new muffler, and my mechanic now informs me that the cylinder head gasket is leaking. he said he sees quite a few of cavaliers with this problem and wonders if there is a silent recall that could help me with the possible $600.00 cost to repair. *ak

Steering stiffened/locked as driver was pulling into parking space, causing minor contact with adjacent parked vehicle. following contact, vehicle stopped and steering wheel realigned (with great effort) to complete parking. after parking, key could not be removed from ignition switch, and vehicle would not continue running after starting (only 1-2 seconds). after local chevrolet dealership retrieved vehicle, service rep stated he "knew what happened" when incident described and vehicle identified as '91 cavalier. ignition switch assembly replaced, no problem since. vehicle repair cost $327; damage to adjacent vehicle $450. i think this ignition switch failure mode, involving steering wheel locking, is a dangerous safety defect. as a minimum, i feel i should be reimbursed for all repair costs and damages.

Alternator failed.

Oil pan failed.

Transmission locked into gear, causing vehicle to stall.

Air conditioner failed.

Windshield wipers fail without adding pressure to the ignition switch, only operate when holding ignition switch.

Driver's side wiring harness caught on fire. the electrical system remained functioning and the engine continued to run. the vehicle was burned from the back of the dash foreward. front suspension melted and the front brakes fused into one piece.

Starter and flywheel become noisy and the vehicle will not start.

Driver's seat frame weld broke. *ak

Prom failure.

Valve cover gasket failed,causing oil leak.

Front and rear engine mounts failed.

Transmission mount failed.

Belt tensioner failed.

Head gaskets leak.

Electrical short in steering column, causing radio and windshield wipers to become inoperative.

Son driving on slippery snow-covered road with little strreet lighting, driver lost control, vehicle veered off road and struck a tree, driver's seatback failed and driver was ejected backward through rear window and was killed. *ak

Dash padding replaced due to warping. *aw

Brakes replaced 5 times. *aw

Brake pads seem to break when they get very hot. *dsh

Driver's seat back collapsed during accident/ejecting driver from vehicle. *sd

There is no summary currently available

There is no summary currently available