2011 TOYOTA RAV4 Recalls, Complaints and Investigations

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

12 Recalls for 2011 TOYOTA RAV4

Recall Date	Component	Summary
2013-01-16	AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE \| SEATS	Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed. Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
2016-08-12	SUSPENSION:REAR	Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle’s alignment. Remedy: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota’s numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
2016-06-02	SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER	Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed. Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
2016-02-19	SEAT BELTS:REAR/OTHER	Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame. Remedy: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota’s number for this recall is G0F.
2015-10-22	VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts. Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota’s number for this recall is C0M.
2015-09-18	VISIBILITY/WIPER	Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor. Remedy: Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota’s customer service number at 1-800-331-4331.
2014-11-19	SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER	Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4×2 and 4×4, Camry, Highlander, Tundra 4×2 and 4×4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring. Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
2013-08-28	SUSPENSION:REAR	Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle’s alignment. Remedy: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
2013-04-09	EQUIPMENT:OTHER:LABELS	Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, “Tire Selection and Rims.” Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
2013-01-16	AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE \| SEATS	Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed. Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
2012-08-02	SUSPENSION:REAR	Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle’s alignment. Remedy: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
2012-02-01	AIR BAGS:SIDE/WINDOW	TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 RAV4 VEHICLES, MANUFACTURED FROM NOVEMBER 24, 2011, THROUGH DECEMBER 19, 2011. IN THE CURTAIN SHIELD AIRBAGS, PROPELLANT WITH THE INCORRECT SPECIFICATION WAS USED FOR THE INITIATOR ASSEMBLED IN THE AIRBAG INFLATOR. IN THIS CONDITION, THE INFLATOR MAY NOT PERFORM PROPERLY, CAUSING ONE OR BOTH CURTAIN SHIELD AIRBAGS TO NOT DEPLOY. Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE VEHICLE IDENTIFICATION NUMBER TO IDENTIFY THE CURTAIN SHIELD ASSEMBLIES AND REPLACE THE ASSEMBLIES AS NECESSARY WITH NEW ONES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 8, 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

7 Complaints sent to the Center for Auto Safety for 2011 TOYOTA RAV4

skip to NHTSA complaints

Date			Component
2022-08-04			suspension
2021-03-20			engine
2018-08-17
2018-05-12
2015-02-06			OTHER (identify in Problem Description Box)
2015-01-16			accelerator/throttle
2011-10-08			seats & seat belts

249 Complaints submitted to NHTSA for 2011 TOYOTA RAV4

skip to CAS complaints

Date			Component
2016-11-07			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10924649
2016-11-07			VISIBILITY/WIPER ODI Number: 10924624
2016-10-13			AIR BAGS \| SEAT BELTS ODI Number: 10915702
2016-10-17			ELECTRICAL SYSTEM \| VISIBILITY:POWER WINDOW DEVICES AND CONTROLS ODI Number: 10916401
2016-09-27			VISIBILITY/WIPER ODI Number: 10910051
2016-10-01			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10910907
2016-10-06			SEAT BELTS ODI Number: 10914233
2017-06-28			ELECTRICAL SYSTEM:WIRING ODI Number: 11002293
2017-07-03			VISIBILITY/WIPER ODI Number: 11002801
2017-06-30			POWER TRAIN ODI Number: 11002463
2017-06-05			POWER TRAIN ODI Number: 10993273
2017-05-30			VEHICLE SPEED CONTROL ODI Number: 10992142
2017-05-09			SUSPENSION ODI Number: 10984480
2017-04-11			AIR BAGS ODI Number: 10971942
2017-04-10			ELECTRICAL SYSTEM:CYBERSECURITY ODI Number: 10970208
2017-08-09			STEERING ODI Number: 11013842
2017-08-14			VEHICLE SPEED CONTROL ODI Number: 11015191
2016-09-15			VISIBILITY/WIPER ODI Number: 10906861
2016-09-15			VISIBILITY/WIPER ODI Number: 10906854
2016-09-13			UNKNOWN OR OTHER ODI Number: 10906101
2016-09-19			SEAT BELTS ODI Number: 10907645
2016-09-14			SUSPENSION ODI Number: 10906356
2016-09-02			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10903340
2016-08-27			VISIBILITY/WIPER ODI Number: 10901903
2016-08-18			WHEELS ODI Number: 10896851
2016-08-24			SEAT BELTS ODI Number: 10898222
2016-08-20			SEAT BELTS ODI Number: 10897320
2016-08-25			VISIBILITY/WIPER ODI Number: 10898493
2016-08-17			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10896593
2017-03-15			UNKNOWN OR OTHER ODI Number: 10965509
2017-03-03			VEHICLE SPEED CONTROL ODI Number: 10958530
2017-02-08			POWER TRAIN ODI Number: 10950337
2017-02-07			VEHICLE SPEED CONTROL ODI Number: 10950154
2016-12-27			EXTERIOR LIGHTING ODI Number: 10937568
2016-11-29			VEHICLE SPEED CONTROL ODI Number: 10928520
2016-12-05			AIR BAGS \| SEAT BELTS ODI Number: 10929851
2020-08-06			ELECTRICAL SYSTEM \| ENGINE ODI Number: 11343634
2020-04-24			AIR BAGS \| AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION \| SEAT BELTS ODI Number: 11322182
2020-04-21			ELECTRICAL SYSTEM ODI Number: 11321789
2020-02-20			SUSPENSION ODI Number: 11310280
2020-02-02			ENGINE ODI Number: 11306606
2020-01-16			SUSPENSION \| VISIBILITY/WIPER ODI Number: 11299767
2019-12-25			SERVICE BRAKES ODI Number: 11291196
2020-01-01			STRUCTURE:BODY ODI Number: 11292504
2019-12-17			POWER TRAIN ODI Number: 11289644
2019-11-08			FUEL/PROPULSION SYSTEM \| SERVICE BRAKES ODI Number: 11278906
2019-10-26			UNKNOWN OR OTHER ODI Number: 11271178
2019-10-24			STRUCTURE:BODY ODI Number: 11270639
2019-08-19			VISIBILITY/WIPER ODI Number: 11244852
2019-08-19			STRUCTURE:BODY ODI Number: 11244851
2019-08-19			ENGINE ODI Number: 11244998
2019-07-30			POWER TRAIN \| STEERING ODI Number: 11240743
2019-07-23			AIR BAGS ODI Number: 11234036
2019-05-16			POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER ODI Number: 11208025
2019-05-25			ELECTRICAL SYSTEM ODI Number: 11209983
2019-05-08			VISIBILITY:SUN/MOON ROOF ASSEMBLY ODI Number: 11206202
2019-06-20			POWER TRAIN ODI Number: 11221459
2019-06-06			VISIBILITY/WIPER ODI Number: 11218401
2019-06-08			ELECTRONIC STABILITY CONTROL \| STRUCTURE:BODY ODI Number: 11218631
2019-02-01			ENGINE ODI Number: 11173588
2019-01-30			UNKNOWN OR OTHER ODI Number: 11173088
2019-01-21			VISIBILITY/WIPER ODI Number: 11171127
2019-01-07			VEHICLE SPEED CONTROL ODI Number: 11164834
2018-12-31			AIR BAGS \| SERVICE BRAKES \| STRUCTURE:BODY ODI Number: 11164251
2019-01-11			VEHICLE SPEED CONTROL ODI Number: 11166482
2018-12-21			AIR BAGS \| AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION \| SEAT BELTS ODI Number: 11162947
2018-12-17			SERVICE BRAKES ODI Number: 11162097
2018-12-27			ELECTRONIC STABILITY CONTROL ODI Number: 11163618
2018-08-22			ENGINE \| FUEL/PROPULSION SYSTEM ODI Number: 11121613
2018-06-11			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 11101092
2018-05-27			STEERING ODI Number: 11098236
2018-05-03			ELECTRICAL SYSTEM ODI Number: 11091660
2018-05-11			ENGINE ODI Number: 11093422
2019-03-25			ELECTRONIC STABILITY CONTROL \| UNKNOWN OR OTHER ODI Number: 11191478
2019-03-18			SERVICE BRAKES ODI Number: 11189733
2019-03-15			ENGINE \| SERVICE BRAKES \| UNKNOWN OR OTHER ODI Number: 11187171
2019-03-12			ELECTRICAL SYSTEM ODI Number: 11186033
2019-03-03			ENGINE ODI Number: 11183825
2019-02-15			ENGINE \| SERVICE BRAKES \| STRUCTURE:BODY ODI Number: 11180213
2018-02-26			VISIBILITY/WIPER ODI Number: 11074979
2018-03-04			POWER TRAIN ODI Number: 11076169
2018-03-10			VISIBILITY/WIPER ODI Number: 11078461
2018-12-06			ELECTRICAL SYSTEM ODI Number: 11156467
2018-10-24			SUSPENSION ODI Number: 11142513
2018-08-12			ELECTRICAL SYSTEM ODI Number: 11119486
2018-07-27			UNKNOWN OR OTHER \| WHEELS ODI Number: 11114163
2018-06-30			UNKNOWN OR OTHER ODI Number: 11104870
2018-06-28			VEHICLE SPEED CONTROL ODI Number: 11104514
2018-01-27			WHEELS ODI Number: 11065453
2018-02-06			ENGINE ODI Number: 11067207
2018-01-23			ELECTRONIC STABILITY CONTROL \| ENGINE ODI Number: 11064498
2017-11-28			POWER TRAIN \| VEHICLE SPEED CONTROL ODI Number: 11051045
2017-11-14			AIR BAGS ODI Number: 11046036
2017-10-06			POWER TRAIN ODI Number: 11032024
2018-04-04			POWER TRAIN ODI Number: 11031188
2017-10-05			WHEELS ODI Number: 11031835
2017-09-12			STEERING \| SUSPENSION ODI Number: 11022779
2017-09-15			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 11023669
2017-09-14			ELECTRICAL SYSTEM ODI Number: 11023440
2016-08-03			SEAT BELTS ODI Number: 10892799
2016-07-28			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10889358
2016-07-21			VISIBILITY/WIPER ODI Number: 10887443
2016-07-13			VISIBILITY/WIPER ODI Number: 10884540
2016-07-06			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10881202
2016-06-30			SEAT BELTS \| SEATS \| VISIBILITY/WIPER ODI Number: 10881926
2016-06-15			ENGINE ODI Number: 10874501
2016-06-14			SUSPENSION ODI Number: 10874212
2016-06-01			SEAT BELTS ODI Number: 10871877
2016-05-27			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10871180
2016-05-16			VISIBILITY/WIPER ODI Number: 10865202
2016-05-09			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10864040
2016-04-26			ENGINE \| VEHICLE SPEED CONTROL ODI Number: 10861584
2016-05-03			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10862766
2016-04-22			VISIBILITY/WIPER ODI Number: 10860887
2016-05-03			SERVICE BRAKES ODI Number: 10862746
2016-04-21			VISIBILITY/WIPER ODI Number: 10860701
2016-05-03			VISIBILITY/WIPER ODI Number: 10862732
2016-04-21			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10860815
2016-04-16			VISIBILITY/WIPER ODI Number: 10859892
2016-04-08			SEAT BELTS ODI Number: 10854420
2016-04-13			VISIBILITY/WIPER ODI Number: 10855315
2016-04-11			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10854944
2016-04-08			VISIBILITY/WIPER ODI Number: 10854359
2016-04-19			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10860275
2016-04-15			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10859778
2016-04-18			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10860096
2016-04-18			AIR BAGS ODI Number: 10860077
2016-04-07			VISIBILITY/WIPER ODI Number: 10854126
2016-04-05			VEHICLE SPEED CONTROL ODI Number: 10853530
2016-03-23			VISIBILITY/WIPER ODI Number: 10851245
2016-03-23			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10851211
2016-04-05			VEHICLE SPEED CONTROL ODI Number: 10853620
2016-03-24			VISIBILITY/WIPER ODI Number: 10851343
2016-03-21			VISIBILITY/WIPER ODI Number: 10850824
2016-02-24			ELECTRICAL SYSTEM \| ELECTRONIC STABILITY CONTROL \| VEHICLE SPEED CONTROL ODI Number: 10838035
2016-03-01			SERVICE BRAKES ODI Number: 10839286
2016-02-18			ELECTRICAL SYSTEM \| SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10837030
2016-01-22			VISIBILITY/WIPER ODI Number: 10821760
2015-12-29			VISIBILITY/WIPER ODI Number: 10816750
2015-12-17			VISIBILITY/WIPER ODI Number: 10810942
2015-12-02			STRUCTURE:BODY ODI Number: 10808041
2015-12-10			SUSPENSION ODI Number: 10809457
2015-10-11			ENGINE \| VEHICLE SPEED CONTROL ODI Number: 10781294
2015-08-09			SUSPENSION ODI Number: 10747251
2015-07-15			ELECTRICAL SYSTEM \| ENGINE ODI Number: 10734399
2015-06-11			SERVICE BRAKES ODI Number: 10724673
2015-04-29			VEHICLE SPEED CONTROL ODI Number: 10713640
2015-04-30			ENGINE \| SERVICE BRAKES ODI Number: 10713699
2015-03-15			SERVICE BRAKES ODI Number: 10694350
2015-03-20			SEATS ODI Number: 10700790
2015-03-20			FUEL/PROPULSION SYSTEM \| SERVICE BRAKES \| UNKNOWN OR OTHER ODI Number: 10700601
2015-03-03			STEERING ODI Number: 10691935
2015-02-06			ELECTRICAL SYSTEM \| ENGINE \| SERVICE BRAKES ODI Number: 10681838
2015-02-13			VEHICLE SPEED CONTROL ODI Number: 10683384
2015-02-04			AIR BAGS \| SERVICE BRAKES ODI Number: 10681099
2014-12-26			FUEL SYSTEM, GASOLINE \| SERVICE BRAKES ODI Number: 10668407
2014-12-21			ENGINE \| SERVICE BRAKES ODI Number: 10667543
2014-12-15			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10664466
2014-12-11			SERVICE BRAKES ODI Number: 10663676
2014-12-18			VISIBILITY/WIPER ODI Number: 10667024
2014-11-25			SERVICE BRAKES ODI Number: 10660869
2014-10-14			STRUCTURE:BODY ODI Number: 10644497
2014-09-30			VEHICLE SPEED CONTROL ODI Number: 10640254
2014-09-28			SERVICE BRAKES ODI Number: 10639593
2014-09-28			POWER TRAIN ODI Number: 10639664
2014-09-27			SERVICE BRAKES ODI Number: 10639519
2014-09-03			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10630430
2014-08-28			AIR BAGS \| SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10629084
2014-07-18			ENGINE \| SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10614616
2014-07-03			SUSPENSION ODI Number: 10606305
2014-06-05			VEHICLE SPEED CONTROL ODI Number: 10595112
2014-05-12			AIR BAGS \| POWER TRAIN ODI Number: 10587904
2014-04-22			POWER TRAIN \| STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS \| SUSPENSION ODI Number: 10584186
2014-04-14			STEERING ODI Number: 10579598
2014-04-13			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES \| TRACTION CONTROL SYSTEM \| VEHICLE SPEED CONTROL:CRUISE CONTROL ODI Number: 10579408
2014-04-10			VEHICLE SPEED CONTROL ODI Number: 10578965
2014-04-10			STEERING \| TIRES ODI Number: 10578806
2014-03-26			FUEL SYSTEM, GASOLINE ODI Number: 10574864
2014-03-25			VEHICLE SPEED CONTROL ODI Number: 10574821
2014-03-29			VEHICLE SPEED CONTROL ODI Number: 10575572
2014-02-20			ENGINE \| VEHICLE SPEED CONTROL ODI Number: 10565197
2014-02-18			VEHICLE SPEED CONTROL ODI Number: 10564820
2014-01-25			ENGINE \| POWER TRAIN ODI Number: 10561460
2014-01-23			SERVICE BRAKES ODI Number: 10561277
2014-01-02			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10558142
2013-12-23			SUSPENSION ODI Number: 10556726
2013-12-31			VEHICLE SPEED CONTROL ODI Number: 10557927
2014-01-07			VISIBILITY/WIPER ODI Number: 10558886
2013-12-10			TIRES ODI Number: 10555427
2013-11-08			VEHICLE SPEED CONTROL ODI Number: 10551585
2013-07-17			ENGINE ODI Number: 10525389
2013-07-11			VEHICLE SPEED CONTROL ODI Number: 10523408
2013-06-18			VEHICLE SPEED CONTROL ODI Number: 10520367
2013-06-11			AIR BAGS ODI Number: 10516225
2013-04-29			VEHICLE SPEED CONTROL ODI Number: 10509878
2013-04-07			SUSPENSION \| VEHICLE SPEED CONTROL ODI Number: 10507378
2013-04-05			VEHICLE SPEED CONTROL ODI Number: 10507225
2013-03-08			SERVICE BRAKES ODI Number: 10502106
2013-02-08			POWER TRAIN ODI Number: 10496842
2013-01-30			POWER TRAIN ODI Number: 10495203
2013-01-29			SERVICE BRAKES ODI Number: 10495034
2013-01-14			FUEL/PROPULSION SYSTEM ODI Number: 10492856
2012-12-26			VEHICLE SPEED CONTROL ODI Number: 10490058
2012-12-04			ENGINE AND ENGINE COOLING ODI Number: 10487392
2012-11-16			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10484882
2012-11-01			VEHICLE SPEED CONTROL ODI Number: 10482831
2012-10-21			FUEL/PROPULSION SYSTEM \| VEHICLE SPEED CONTROL ODI Number: 10481284
2012-10-11			SERVICE BRAKES ODI Number: 10479823
2012-10-15			TIRES ODI Number: 10480118
2012-10-04			FUEL/PROPULSION SYSTEM \| VEHICLE SPEED CONTROL ODI Number: 10478644
2012-08-24			VEHICLE SPEED CONTROL ODI Number: 10472340
2012-08-05			AIR BAGS ODI Number: 10469226
2012-08-02			ENGINE \| SERVICE BRAKES \| STRUCTURE:BODY ODI Number: 10469013
2012-07-17			ENGINE \| POWER TRAIN ODI Number: 10466312
2012-07-17			AIR BAGS \| ENGINE \| STRUCTURE:BODY ODI Number: 10465931
2012-06-07			FUEL/PROPULSION SYSTEM \| SERVICE BRAKES ODI Number: 10460922
2012-06-19			SEATS ODI Number: 10462264
2012-05-23			ELECTRONIC STABILITY CONTROL \| SERVICE BRAKES ODI Number: 10459380
2012-05-03			AIR BAGS ODI Number: 10457369
2012-04-24			VEHICLE SPEED CONTROL ODI Number: 10456359
2012-04-23			SERVICE BRAKES, HYDRAULIC \| SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP ODI Number: 10456110
2012-04-20			UNKNOWN OR OTHER ODI Number: 10455922
2012-05-02			ELECTRONIC STABILITY CONTROL \| POWER TRAIN \| VEHICLE SPEED CONTROL ODI Number: 10457174
2012-03-31			UNKNOWN OR OTHER ODI Number: 10454108
2012-04-04			SERVICE BRAKES, HYDRAULIC \| SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES \| VEHICLE SPEED CONTROL ODI Number: 10454080
2012-02-14			VEHICLE SPEED CONTROL ODI Number: 10447984
2012-01-20			VEHICLE SPEED CONTROL ODI Number: 10444622
2012-01-18			ENGINE AND ENGINE COOLING ODI Number: 10444437
2011-11-28			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10437616
2011-11-27			STEERING ODI Number: 10437379
2011-11-17			SERVICE BRAKES, HYDRAULIC \| STRUCTURE \| VEHICLE SPEED CONTROL ODI Number: 10436244
2011-11-14			POWER TRAIN \| VEHICLE SPEED CONTROL ODI Number: 10435596
2011-10-19			STRUCTURE:BODY ODI Number: 10430864
2011-09-29			UNKNOWN OR OTHER ODI Number: 10427960
2011-08-17			FUEL SYSTEM, GASOLINE ODI Number: 10419836
2011-07-31			VEHICLE SPEED CONTROL ODI Number: 10417314
2011-07-19			EXTERIOR LIGHTING:TURN SIGNAL ODI Number: 10413588
2011-06-02			VEHICLE SPEED CONTROL ODI Number: 10404236
2011-05-12			SERVICE BRAKES, HYDRAULIC ODI Number: 10401568
2011-05-13			VEHICLE SPEED CONTROL ODI Number: 10400814
2011-04-28			ENGINE AND ENGINE COOLING:EXHAUST SYSTEM ODI Number: 10398169
2011-04-21			VEHICLE SPEED CONTROL ODI Number: 10396998
2011-03-31			VEHICLE SPEED CONTROL ODI Number: 10393848
2011-02-24			VEHICLE SPEED CONTROL ODI Number: 10384341
2011-01-31			FUEL SYSTEM, GASOLINE ODI Number: 10379768
2011-01-16			VEHICLE SPEED CONTROL ODI Number: 10378897
2011-01-24			STEERING ODI Number: 10378414
2015-11-09			POWER TRAIN ODI Number: 10789400
2016-01-27			ENGINE \| VEHICLE SPEED CONTROL ODI Number: 10822500

Is the government investigating the safety of your vehicle? Find out here.

1 Investigations for 2011 TOYOTA RAV4

Date Opened	Date Closed	Component
2012-02-14	2012-05-08	AIR BAGS:SIDE/WINDOW

Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

307 Service Alerts for 2011 TOYOTA RAV4

Date	Description
2022-04-14	350000 EQUIPMENT Toyota Safety Recall and Service Campaign – Technician Certification Requirements 4.14.2022 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-17	030000 SERVICE BRAKES, HYDRAULIC TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-17	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-28	350000 EQUIPMENT CSP: Customer Support Program ZKG – Paint Repair Process Operation Flow Chart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-09	050000 PARKING BRAKE TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the Repair Procedure in this bulletin to replace the loose or damaged carpet floor retai Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-02-01	220000 SEATS TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	190000 TIRES POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	200000 WHEELS POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-11-23	160000 STRUCTURE TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-10-28	160000 STRUCTURE DL: CUSTOMER SUPPORT PROGRAM ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2001-05-04	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Replacement vin plates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1991-01-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-12-12	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1989-06-30	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1993-04-09	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1991-01-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-17	140000 AIR BAGS Toyota Safety Recall and Service Campaign – Technician Certification Requirements Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-12	030000 BRAKES (PWS) TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-12	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0012-21. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0044-16. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-05	220000 SEATS TSB: Some 2010 ? 2021 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water an Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-02-03	350000 EQUIPMENT TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	030000 BRAKES (PWS) TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-21	062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS TT: HVAC drain tube is found to be blocked/clogged. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	030000 SERVICE BRAKES, HYDRAULIC TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL DL: Toyota plans to send Safety Recall Follow-Up Notices for the above referenced campaigns to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-14	350000 EQUIPMENT TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-14	356000 EQUIPMENT ADAPTIVE/MOBILITY TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL DE: Safety Recall is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Follow-Up Notices to remind owners whose vehicles have not yet had Safety Recall repairs completed for the ca Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL RE: Toyota will be sending Safety Recall Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL DL: Safety Recall completion is an important part of our commitment to customer satisfaction of Toyota products. Toyota will be conducting follow-up notifications to remind owners whose vehicles have not yet had Safety Recall repairs comp Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL RL: Toyota plans to conduct Safety Recall follow-up notifications to owners whose vehicles have not yet had the following Safety Recall repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-03	063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but part Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-23	020000 SUSPENSION TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see T-SB-0063-20. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-23	200000 WHEELS TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-14	350000 EQUIPMENT ZKG WEBSITE PROPER PHOTOGRAPH SUBMISSION Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-14	356000 EQUIPMENT ADAPTIVE/MOBILITY ZKG WEBSITE PROPER PHOTOGRAPH SUBMISSION Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-15	162000 STRUCTURE:BODY TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-15	350000 EQUIPMENT TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-15	160000 STRUCTURE DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-15	350000 EQUIPMENT DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-30	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM TT: HVAC drain tube is found to be blocked/clogged. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-06	162000 STRUCTURE:BODY DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-06	350000 EQUIPMENT DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-06	356000 EQUIPMENT ADAPTIVE/MOBILITY DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-03	063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but part Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-07	350000 EQUIPMENT TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-06	350000 EQUIPMENT TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Technical Instructions: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Phase 2 ? Customer Renotification and Repair Phase Repair is Now Available Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super Whit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-12	350000 EQUIPMENT Technical Instructions: Customer Support Program ZKG ? Technical Instructions. December 12, 2019. This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-12	356000 EQUIPMENT ADAPTIVE/MOBILITY Technical Instructions: Customer Support Program ZKG ? Technical Instructions. December 12, 2019. This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-12	350000 EQUIPMENT Dealer Package: December 12, 2019 This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. However, after confirming that the pain Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-12	356000 EQUIPMENT ADAPTIVE/MOBILITY Dealer Package: December 12, 2019 This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. However, after confirming that the pain Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Dealer Package: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied du Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Dealer Email: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied duri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE TSB: Some 2008 ? 2019 model year Toyota vehicles painted with either 070 Blizzard Pearl or 040 Super White may exhibit peeling paint on one or more metal body panels. The paint may peel between the primer and E-coat layer, exposing the gray Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Repair Process: Customer Support Program ZKG ? Paint Repair Process. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Region Letter: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied dur Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Region Email: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied duri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Dealer Daily Message: *Phase 2 ? Customer Renotification and Repair Phase* Repair is Now Available Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Fact Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-02-06	350000 EQUIPMENT TSB: Some 2004 ? 2017 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-23	350000 EQUIPMENT Region Letter: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following infor Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-23	350000 EQUIPMENT Region Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-23	350000 EQUIPMENT Dealer Package: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following info Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-23	350000 EQUIPMENT Dealer Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-19	356000 EQUIPMENT ADAPTIVE/MOBILITY Technical Instructions: December 12, 2019. This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. However, after confirming that Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-02-12	350000 EQUIPMENT OBSOLETE NOTICE February 12, 2020: This bulletin is now obsolete. Please see T-SB-0010-20. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-01-27	350000 EQUIPMENT TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-09	356000 EQUIPMENT ADAPTIVE/MOBILITY TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	100000 POWER TRAIN TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	110000 ELECTRICAL SYSTEM TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	060000 ENGINE (PWS) TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-09-26	030000 BRAKES (PWS) TSB: REVISION NOTICE September 26, 2019 Rev1: ? The Warranty Information, Parts Information, and Repair Procedure sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2018 model year RA Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-08	162000 STRUCTURE:BODY Region Letter: Phase 1 ? Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports ind Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-09	162000 STRUCTURE:BODY Dealer Email: Phase 1 – Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-09	162000 STRUCTURE:BODY Dealer Package: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied du Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-09	162000 STRUCTURE:BODY Dealer Package: Phase 1 – Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports ind Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-08	162000 STRUCTURE:BODY Region Email: Phase 1 – Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-12	030000 SERVICE BRAKES, HYDRAULIC TSB: Some 2009 ? 2018 model year RAV4 and 2017 ? 2018 model year iM vehicles may exhibit a grind/groan noise from the front brake pads. An updated pad kit is now available as a service part. Follow the Repair Procedure in this bulletin to a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-12	034520 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS TSB: Some 2009 ? 2018 model year RAV4 and 2017 ? 2018 model year iM vehicles may exhibit a grind/groan noise from the front brake pads. An updated pad kit is now available as a service part. Follow the Repair Procedure in this bulletin to a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-14	060000 ENGINE (PWS) TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-25	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TT: HVAC drain tube is found to be blocked/clogged. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-14	110000 ELECTRICAL SYSTEM TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-01-06	110000 ELECTRICAL SYSTEM TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	350000 EQUIPMENT TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	356000 EQUIPMENT ADAPTIVE/MOBILITY TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-02	021600 SUSPENSION:FRONT:WHEEL BEARING TSB: Some 2006 – 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this co Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-02	100000 POWER TRAIN TSB: Some 2006 – 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this co Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-12-12	100000 POWER TRAIN TSB: REVISION NOTICE December 12, 2017 Rev1: The Warranty and Parts Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2011 model year RAV4 vehicles equipped with the 2AR Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-21	350000 EQUIPMENT Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-21	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-07-31	350000 EQUIPMENT TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	350000 EQUIPMENT Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	355100 EQUIPMENT:OTHER:LABELS Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	350000 EQUIPMENT Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	355100 EQUIPMENT:OTHER:LABELS Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-12-12	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) TSB: REVISION NOTICE December 12, 2017 Rev1: ? The Warranty and Parts Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2011 model year RAV4 vehicles equipped with the 2 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-12-12	060000 ENGINE (PWS) TSB: REVISION NOTICE December 12, 2017 Rev1: ? The Warranty and Parts Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2011 model year RAV4 vehicles equipped with the 2 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-19	162000 STRUCTURE:BODY TSB: On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard? Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-19	160000 STRUCTURE TSB: On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard? Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-19	356000 EQUIPMENT ADAPTIVE/MOBILITY TSB: On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard? Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	110000 ELECTRICAL SYSTEM TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	350000 EQUIPMENT TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-06	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-06	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-06	118000 ELECTRICAL SYSTEM:SOFTWARE TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-26	110000 ELECTRICAL SYSTEM The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. If the operator attempts to ready-on or start the vehicle while there is tension on Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-08-24	100000 POWER TRAIN TechTip: Condition – The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-14	105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT Some 2006 ? 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this condition Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-04-23	350000 EQUIPMENT In late April 2014, Toyota will be mailing an update to the Owner?s Manual for certain 2010 through 2013 Model Year Prius Plug-in Hybrid Vehicles (PHV) and certain 2012 through 2013 RAV4 Electric Vehicles (EV). Sample Owner Letter labels ar Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-04-23	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL In late April 2014, Toyota will be mailing an update to the Owner?s Manual for certain 2010 through 2013 Model Year Prius Plug-in Hybrid Vehicles (PHV) and certain 2012 through 2013 RAV4 Electric Vehicles (EV). Sample Owner Letter labels ar Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-25	130000 VISIBILITY Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-07	162000 STRUCTURE:BODY TSB: REVISION NOTICE March 07, 2017 Rev1: ? Applicability has been updated to include 2017 model year Toyota vehicles. On some vehicles, when Rapgard? is removed the paint may have a stained appearance. These stains appear to be under the c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-11	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-11	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	355100 EQUIPMENT:OTHER:LABELS This bulletin is now obsolete. Please see T-SB-0054-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	350000 EQUIPMENT California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-04	280000 BACK OVER PREVENTION If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-04	358100 EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-20	140000 AIR BAGS TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-20	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-01	100000 POWER TRAIN The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-20	250000 ELECTRONIC STABILITY CONTROL Some 2006 ? 2012 model year RAV4 vehicles may exhibit a clunking noise coming from the rear of the vehicle. Upon inspection, one or both of the rear stabilizer links may be damaged. Follow the repair in this bulletin to address this conditi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-20	280000 BACK OVER PREVENTION Some 2006 ? 2012 model year RAV4 vehicles may exhibit a clunking noise coming from the rear of the vehicle. Upon inspection, one or both of the rear stabilizer links may be damaged. Follow the repair in this bulletin to address this conditi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-19	130000 VISIBILITY The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	060000 ENGINE (PWS) Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1AR-FE or 2AR-FE engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. Follow the repair proced Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-02	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM If a customer states there is an unpleasant odor in the vehicle from the HVAC system, there are various factors that may be involved. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-02	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER If a customer states there is an unpleasant odor in the vehicle from the HVAC system, there are various factors that may be involved. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-23	132000 VISIBILITY:GLASS, SIDE/REAR The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	140000 AIR BAGS Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	220000 SEATS Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	350000 EQUIPMENT Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	110000 ELECTRICAL SYSTEM These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	353000 EQUIPMENT:ELECTRICAL These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-02	060000 ENGINE (PWS) Due to the improved performance and durability of 0w-20 synthetic oil, Toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. With this change, the following should be noted Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-12	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-19	130000 VISIBILITY/WIPER (PWS) This bulletin is now obsolete. Please see T-SB-0185-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	050000 PARKING BRAKE A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	350000 EQUIPMENT A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-11	118000 ELECTRICAL SYSTEM:SOFTWARE Tech Tip: Some customers may experience difficulty programming HomeLink. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	060000 ENGINE (PWS) TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-14	140000 AIR BAGS Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-23	190000 TIRES Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-28	350000 EQUIPMENT Customer complains of Bluetooth connectivity concerns such as: Difficulty to pair phone, Intermittent Bluetooth failure to connect to the vehicle when first turning on the vehicle. These concerns can be caused by changes made on the custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-25	060000 ENGINE (PWS) Starting with 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0W-20 viscosity engine oil. There a re man benefits of this oil. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-11	350000 EQUIPMENT Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicability. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-05	030000 SERVICE BRAKES, HYDRAULIC A key part to maintain the proper function and safe operation of the vehicle’s braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-05	350000 EQUIPMENT A key part to maintain the proper function and safe operation of the vehicle’s braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This bulletin is now obsolete. Please see T-SB-0041-13 . Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	060000 ENGINE (PWS) Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1AR-FE or 2AR-FE engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. Follow the repair proced Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-04-23	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL In late April 2014, Toyota will be mailing an update to the Owner?s Manual for certain 2010 through 2013 Model Year Prius Plug-in Hybrid Vehicles (PHV) and certain 2012 through 2013 RAV4 Electric Vehicles (EV). Sample Owner Letter labels ar Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-04	060000 ENGINE (PWS) Starting with the 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil. Due to the improved performance and durability of 0w-20 synthetic oil, Toyot Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-25	011000 STEERING: STEERING WHEEL/HANDLE BAR The vehicle will not start or ready-on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-20	100000 POWER TRAIN This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-11-22	110000 ELECTRICAL SYSTEM TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-19	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Some customers may inquire about the frequency and power output of the Smart Key/Smart Entry systems used on various models. The Smart Key/Smart Entry systems conform to all applicable FCC rules. This bulletin details the applicable specifi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-08	060000 ENGINE (PWS) Tech Tip: Starting with the 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. There are multiple benefits of this oil including: Reduced friction and wear on engine surfaces, Improved fuel Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-08	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: REVISION NOTICE March 08, 2017 Rev1: ? Applicability has been updated to include 2015 – 2017 model year Toyota vehicles. ? The Parts Information section has been updated. Some vehicles in particular geographic areas may exhibit a c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-08	140000 AIR BAGS Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-08	140000 AIR BAGS Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-02-02	350000 EQUIPMENT TSB: The purpose of this Service Bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in Toyota vehicles. As an additional resource, if the vehicle is equipped with factory leather seats, the ve Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-07	980000 UNKNOWN OR OTHER TSB: OBSOLETE NOTICE: July 7, 2014: This bulletin is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-07	353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-25	353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-29	110000 ELECTRICAL SYSTEM Tech Tip: Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-29	130000 VISIBILITY Tech Tip: Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-12	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-03-08	110000 ELECTRICAL SYSTEM TT: Some customers may encounter Bluetooth connectivity concerns such as: ? Difficulty pairing the phone. ? Intermittent Bluetooth failure to connect when first turning on the vehicle. ? Various Bluetooth Audio functions are no lon Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-27	110000 ELECTRICAL SYSTEM The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-07	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-30	020000 SUSPENSION TSB: Safety Recall CSJ (?2006 ? 2011 RAV4; Rear Lower Suspension Arm No. 1?) involves inspection of the Rear Suspension Arm No. 1 for the presence of rust, replacement of the suspension arm if necessary, and application of an epoxy material Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-01	060000 ENGINE (PWS) Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-01	280000 BACK OVER PREVENTION Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-11-10	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Some 2004 ? 2017 model year Toyota vehicles may exhibit odor Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-11-29	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	060000 ENGINE (PWS) TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	110000 ELECTRICAL SYSTEM TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-04	162000 STRUCTURE:BODY Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-22	190000 TIRES Please refer to the following recommendations for the best practices for vehicle tire rotations. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-02-12	190000 TIRES TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-02-12	190000 TIRES TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-01-11	350000 EQUIPMENT TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	118000 ELECTRICAL SYSTEM:SOFTWARE Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-12-06	350000 EQUIPMENT A revised procedure has been developed to ensure proper removal and installation of the sun visor. Please use the following procedure for removal and installation of the sun visor. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-12-21	060000 ENGINE (PWS) Starting with the 2010 MY, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-12-07	060000 ENGINE (PWS) Starting with the 2010 MY, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-02	118000 ELECTRICAL SYSTEM:SOFTWARE Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This communication pertains to a current safety recall being conducted by the Southeast Toyota Distributors LLC (SET). TMS is sending this communication for informational purposes in the event you are contacted by a customer covered by th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-10	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY technicians should confirm the following key points to minimize the potential for future MIL “ON” concerns after HV Battery Replacement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-03	140000 AIR BAGS Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This bulletin is now obsolete. Please see T-SB-0012-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-10-30	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-10-27	162300 STRUCTURE:BODY:DOOR TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-23	353000 EQUIPMENT:ELECTRICAL TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-04	021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-04	021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-23	353000 EQUIPMENT:ELECTRICAL TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-02-26	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) Southeast Toyota Accessory Advent Navigation system displays splash screen only or randomly shuts off, Discusses audio system hard reset procedure and updated software card. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-27	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) Revised Document- Southeast Toyota Accessory Advent Navigation system displays splash screen only or randomly shuts off, Discusses audio system hard reset procedure and updated software card. Updated contact information for Radio software Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-30	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-30	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-30	118000 ELECTRICAL SYSTEM:SOFTWARE TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-17	353000 EQUIPMENT:ELECTRICAL TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-17	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-17	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-07	060000 ENGINE AND ENGINE COOLING TT: Starting with 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil. Due to the them improved performance and durability of 0w-20 synthetic oil, To Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	110000 ELECTRICAL SYSTEM TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	110000 ELECTRICAL SYSTEM TSB: THE BREATHER PLUG SHOULD BE REPLACED DURING ANY DIFFERENTIAL/TRANSFER CASE REPAIRS TO PREVENT POSSIBLE REPEAT FAILURES. THE SUBSEQUENT USE OF THE ORIGINAL BREATHER PLUG AFTER A REPAIR HAS BEEN FOUND TO CONTRIBUTE TO THE FAILURE OF THE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	100000 HYBRID POWERTRAIN: INVERTER TSB: THE BREATHER PLUG SHOULD BE REPLACED DURING ANY DIFFERENTIAL/TRANSFER CASE REPAIRS TO PREVENT POSSIBLE REPEAT FAILURES. THE SUBSEQUENT USE OF THE ORIGINAL BREATHER PLUG AFTER A REPAIR HAS BEEN FOUND TO CONTRIBUTE TO THE FAILURE OF THE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-03	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TOYOTA/LEXUS: INFORMATION REGARDING DEALER RE-NOTIFICATION, ON CERTAIN VEHICLES, OF REMEDY INSTRUCTIONS (DVD) VIA SEPARATE COVER. MODELS 2006-2011 RAV4, 2010 HS250TH. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353000 EQUIPMENT:ELECTRICAL TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-10	162000 STRUCTURE:BODY TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353000 EQUIPMENT:ELECTRICAL TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	060000 ENGINE AND ENGINE COOLING TT: Customer complaint of MIL (:Check Engine Light) ON Condition. Health Check retrieves DTC P2118 (Throttle Actuator Motor Current Range/Performance). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-13	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-13	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-13	118000 ELECTRICAL SYSTEM:SOFTWARE Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	110000 ELECTRICAL SYSTEM TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	353000 EQUIPMENT:ELECTRICAL TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-30	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-30	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-30	118000 ELECTRICAL SYSTEM:SOFTWARE TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-17	353000 EQUIPMENT:ELECTRICAL TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-17	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-17	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353000 EQUIPMENT:ELECTRICAL TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	118000 ELECTRICAL SYSTEM:SOFTWARE TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-10	162000 STRUCTURE:BODY TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	100000 POWER TRAIN TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353000 EQUIPMENT:ELECTRICAL TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	118000 ELECTRICAL SYSTEM:SOFTWARE TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	060000 ENGINE AND ENGINE COOLING TT: Customer complaint of MIL (:Check Engine Light) ON Condition. Health Check retrieves DTC P2118 (Throttle Actuator Motor Current Range/Performance). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-07	060000 ENGINE AND ENGINE COOLING TT: Starting with 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil. Due to the them improved performance and durability of 0w-20 synthetic oil, To Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-19	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. Tech Tip: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-19	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) Tech Tip: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-30	022000 SUSPENSION:REAR SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	060000 ENGINE (PWS) TOYOTA: ON CERTAIN VEHICLES, A KNOCK OR RATTLE NOISE, COMING FROM ENGINE COMPARTMENT, IS HEARD DURING A COLD SOAK STARTUP, AND THE CONDITION LASTS APPROXIMATELY ONE SECOND. MODEL YEARS 2009-2012 CAMRY, HIGHLANDER, SIENNA, VENZA, RAV4. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-20	022000 SUSPENSION:REAR TOYOTA: THERE IS A CLUNKING NOISE HEARD COMING FROM REAR OF VEHICLE AND ONE OR BOTH REAR STABILIZER LINKS ARE DAMAGED. MODEL 2006-2012 RAV4. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 – 2014 model year automatic transmissions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	100000 POWER TRAIN TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-08	020000 SUSPENSION TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Flat towing or towing where only the front or rear wheels are supported may damage the all-whee Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-08	200000 WHEELS TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Flat towing or towing where only the front or rear wheels are supported may damage the all-whee Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	110000 ELECTRICAL SYSTEM Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	162300 STRUCTURE:BODY:DOOR Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	350000 EQUIPMENT Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	110000 ELECTRICAL SYSTEM Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	162300 STRUCTURE:BODY:DOOR Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	350000 EQUIPMENT Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-03-13	061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS TOYOTA: CHARGING SYSTEM INOPERATIVE. SOME ENGINES MAY EXHIBIT INSUFFICIENT CHARGING PERFORMANCE FROM THE ALTERNATOR. AN UPDATED PULLEY ASSEMBLY IS AVAILABLE TO ADDRESS THIS CONDITION. *JS Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-03-13	112000 ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR TOYOTA: CHARGING SYSTEM INOPERATIVE. SOME ENGINES MAY EXHIBIT INSUFFICIENT CHARGING PERFORMANCE FROM THE ALTERNATOR. AN UPDATED PULLEY ASSEMBLY IS AVAILABLE TO ADDRESS THIS CONDITION. *JS Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-04	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-27	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-25	010000 STEERING SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-11-07	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-09-06	140000 AIR BAGS TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-09-06	220000 SEATS TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-27	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-25	358100 EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-02	100000 POWER TRAIN TSB: SOME 2006 – 2012 MODEL YEAR 4WD RAV4 VEHICLES MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. FOLLOW THE PROCEDURE IN THIS BULLETIN TO ADDRESS THIS CO Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-02	105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT TSB: SOME 2006 – 2012 MODEL YEAR 4WD RAV4 VEHICLES MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. FOLLOW THE PROCEDURE IN THIS BULLETIN TO ADDRESS THIS CO Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	060000 ENGINE (PWS) SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	060000 ENGINE (PWS) TOYOTA: THERE IS A KNOCKING OR RATTLING NOISE COMING FROM ENGINE COMPARTMENT, FOR A SHORT PERIOD OF TIME, AFTER A COLD SOAK STARTUP. MODEL 2010-2012 CAMRY, 2009-2013 HIGHLANDER, VENZA, 2009-2012 RAV4, 2011-2013 SIENNA. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	350000 EQUIPMENT TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-03-10	356000 EQUIPMENT ADAPTIVE/MOBILITY TOYOTA: FLOOR MAT INSTALLATION DURING PDS. VEHICLES EQUIPPED WITH DRIVER’S SIDE FLOOR MAT RETAINING CLIPS TO SECURE THE FLOOR MAT IN CORRECT POSITION. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-01-04	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TOYOTA: 2009-2011 RAV4. THERE MAY BE A RATTLE NOISE FROM THE TRANSAXLE WHEN DRIVING AROUND 30MPH. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-02	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-11	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-06-13	181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-11	350000 EQUIPMENT TECH TIP: SOME CUSTOMERS MAY EXPERIENCE DIFFICULTY PROGRAMMING HOMELINK. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-22	190000 TIRES SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	060000 ENGINE (PWS) TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. THIS BUL Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-14	021600 SUSPENSION:FRONT:WHEEL BEARING TOYOTA: THE REAR DIFFERENTIAL COUPLING, WHEN DRIVING SOME VEHICLES, MAY EXHIBIT A GROWL NOISE, DUE TO CONTAMINATION TO FRONT BEARING. MODEL 2006-2012 RAV4 (42WD). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-14	105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT TOYOTA: THE REAR DIFFERENTIAL COUPLING, WHEN DRIVING SOME VEHICLES, MAY EXHIBIT A GROWL NOISE, DUE TO CONTAMINATION TO FRONT BEARING. MODEL 2006-2012 RAV4 (42WD). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-12-03	100000 POWER TRAIN DD: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 4W Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-12-03	100000 POWER TRAIN DL: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 4WD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-04	190000 TIRES SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-02	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2011 TOYOTA RAV4

12 Recalls for 2011 TOYOTA RAV4

7 Complaints sent to the Center for Auto Safety for 2011 TOYOTA RAV4

249 Complaints submitted to NHTSA for 2011 TOYOTA RAV4

1 Investigations for 2011 TOYOTA RAV4

307 Service Alerts for 2011 TOYOTA RAV4

2011 TOYOTA RAV4

search for another vehicle

Related

Our Work

Press

About Us

Give Now

Address

Join our Email List

2011 TOYOTA RAV4

12 Recalls for 2011 TOYOTA RAV4

7 Complaints sent to the Center for Auto Safety for 2011 TOYOTA RAV4

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

249 Complaints submitted to NHTSA for 2011 TOYOTA RAV4

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details