2011 TOYOTA Prius

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

7 Recalls for 2011 TOYOTA Prius

Recall Date Component Summary
January 16, 2013 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE | SEATS

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Remedy:

Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

October 4, 2018 HYBRID PROPULSION SYSTEM

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.

Remedy:

Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota’s number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.

June 30, 2016 AIR BAGS:SIDE/WINDOW

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2010-2012 Toyota Prius, 2010 and 2012 Toyota Prius Plug-in Hybrid, and 2011-2012 Lexus CT200h vehicles. A weld in the curtain shield air bag inflator may crack causing one or both portions of the inflator to eject into the passenger cabin.

Remedy:

Toyota will notify owners, and dealers will install retention brackets to the curtain shield air bags, free of charge. The recall began on October 17, 2016. Owners may contact Toyota Customer Service Department at 1-800-331-4331. Toyota’s number for this recall is Toyota G0U, and Lexus GLJ.

June 2, 2016 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Remedy:

SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

November 19, 2014 SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4×2 and 4×4, Camry, Highlander, Tundra 4×2 and 4×4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Remedy:

SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

February 12, 2014 ELECTRICAL SYSTEM:SOFTWARE | HYBRID PROPULSION SYSTEM: INVERTER

Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.

Remedy:

Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.

January 16, 2013 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE | SEATS

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Remedy:

Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

24 Complaints sent to the Center for Auto Safety for 2011 TOYOTA Prius

skip to NHTSA complaints

Date Component  
lights (exterior & interior)
engine
lights (exterior & interior)
engine
lights (exterior & interior)
accessories (cd/tape, radio, navigation system, etc)
lights (exterior & interior)
brakes
electrical/battery
brakes
brakes
lights (exterior & interior)
power options (window/door/seat/roof)
brakes
accelerator/throttle

361 Complaints submitted to NHTSA for 2011 TOYOTA Prius

skip to CAS complaints

Date Component  
SERVICE BRAKES
ODI Number: 11415084
SERVICE BRAKES
ODI Number: 11414244
SERVICE BRAKES
ODI Number: 11413412
SERVICE BRAKES
ODI Number: 11408362
SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 11406997
ELECTRICAL SYSTEM | SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 11403403
ENGINE | SERVICE BRAKES
ODI Number: 11403571
AIR BAGS
ODI Number: 11398373
AIR BAGS
ODI Number: 10926056
AIR BAGS
ODI Number: 10920327
AIR BAGS
ODI Number: 10917264
ENGINE | SERVICE BRAKES
ODI Number: 10919246
AIR BAGS
ODI Number: 10919228
SERVICE BRAKES
ODI Number: 10919223
AIR BAGS
ODI Number: 10913726
AIR BAGS
ODI Number: 10913830
AIR BAGS
ODI Number: 10913803
AIR BAGS
ODI Number: 10909874
ELECTRICAL SYSTEM | UNKNOWN OR OTHER
ODI Number: 10908584
STEERING
ODI Number: 11003309
EXTERIOR LIGHTING
ODI Number: 10993510
ELECTRICAL SYSTEM
ODI Number: 10994385
ELECTRICAL SYSTEM:HORN
ODI Number: 10995896
VEHICLE SPEED CONTROL
ODI Number: 10995694
VEHICLE SPEED CONTROL
ODI Number: 10995691
ELECTRONIC STABILITY CONTROL
ODI Number: 10992773
AIR BAGS
ODI Number: 10991022
SERVICE BRAKES
ODI Number: 10984549
EXTERIOR LIGHTING
ODI Number: 10969193
ENGINE
ODI Number: 11014079
FUEL/PROPULSION SYSTEM
ODI Number: 10906450
AIR BAGS
ODI Number: 10904901
AIR BAGS
ODI Number: 10899564
AIR BAGS
ODI Number: 10898755
VISIBILITY/WIPER
ODI Number: 10904597
AIR BAGS
ODI Number: 10898697
AIR BAGS
ODI Number: 10896439
SERVICE BRAKES
ODI Number: 10898350
AIR BAGS
ODI Number: 10893278
AIR BAGS
ODI Number: 10893954
EXTERIOR LIGHTING
ODI Number: 10959463
SERVICE BRAKES
ODI Number: 10959811
AIR BAGS
ODI Number: 10955606
EXTERIOR LIGHTING
ODI Number: 10956508
AIR BAGS
ODI Number: 10956651
STRUCTURE
ODI Number: 10957374
EXTERIOR LIGHTING
ODI Number: 10948073
SERVICE BRAKES
ODI Number: 11389770
ELECTRICAL SYSTEM | POWER TRAIN | SERVICE BRAKES
ODI Number: 11389268
SERVICE BRAKES | STEERING | VEHICLE SPEED CONTROL
ODI Number: 11375891
ENGINE
ODI Number: 10939761
EXTERIOR LIGHTING
ODI Number: 10938709
AIR BAGS | UNKNOWN OR OTHER
ODI Number: 10929844
ENGINE | SERVICE BRAKES | SUSPENSION
ODI Number: 10929842
UNKNOWN OR OTHER
ODI Number: 10933938
ENGINE
ODI Number: 10929407
ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 10927167
AIR BAGS
ODI Number: 10927288
AIR BAGS | SERVICE BRAKES
ODI Number: 11349454
SERVICE BRAKES
ODI Number: 11343823
ENGINE | POWER TRAIN
ODI Number: 11340192
ELECTRICAL SYSTEM | HYBRID PROPULSION SYSTEM
ODI Number: 11327176
ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 11324854
SERVICE BRAKES
ODI Number: 11325426
FUEL/PROPULSION SYSTEM
ODI Number: 11324344
ELECTRICAL SYSTEM
ODI Number: 11323020
EXTERIOR LIGHTING
ODI Number: 11319191
SERVICE BRAKES
ODI Number: 11316561
ELECTRICAL SYSTEM
ODI Number: 11318582
HYBRID PROPULSION SYSTEM | SERVICE BRAKES
ODI Number: 11316593
ENGINE | SERVICE BRAKES
ODI Number: 11318682
ENGINE
ODI Number: 11311876
SERVICE BRAKES
ODI Number: 11308721
SERVICE BRAKES
ODI Number: 11307942
ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 11306621
FUEL/PROPULSION SYSTEM | STEERING | WHEELS
ODI Number: 11303039
SERVICE BRAKES
ODI Number: 11301874
SERVICE BRAKES | UNKNOWN OR OTHER
ODI Number: 11307535
EXTERIOR LIGHTING
ODI Number: 11299922
SERVICE BRAKES
ODI Number: 11298570
SERVICE BRAKES
ODI Number: 11291099
ELECTRICAL SYSTEM
ODI Number: 11287861
EXTERIOR LIGHTING
ODI Number: 11282595
EXTERIOR LIGHTING
ODI Number: 11278809
SERVICE BRAKES
ODI Number: 11279326
ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 11251981
ENGINE | POWER TRAIN
ODI Number: 11245992
ELECTRICAL SYSTEM | ENGINE | FUEL/PROPULSION SYSTEM
ODI Number: 11242826
SERVICE BRAKES
ODI Number: 11241575
ENGINE | SERVICE BRAKES
ODI Number: 11234233
ENGINE | FUEL/PROPULSION SYSTEM
ODI Number: 11269305
SERVICE BRAKES
ODI Number: 11267321
SERVICE BRAKES
ODI Number: 11267710
SERVICE BRAKES
ODI Number: 11266931
SERVICE BRAKES
ODI Number: 11255326
ELECTRICAL SYSTEM
ODI Number: 11253987
AIR BAGS | ELECTRICAL SYSTEM
ODI Number: 11253469
SERVICE BRAKES | UNKNOWN OR OTHER
ODI Number: 11207630
ELECTRICAL SYSTEM | ELECTRONIC STABILITY CONTROL
ODI Number: 11205273
ENGINE
ODI Number: 11204529
ENGINE
ODI Number: 11206017
POWER TRAIN | SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 11203669
ENGINE | POWER TRAIN
ODI Number: 11195556
ELECTRONIC STABILITY CONTROL | SERVICE BRAKES | STEERING
ODI Number: 11194409
UNKNOWN OR OTHER
ODI Number: 11231686
SERVICE BRAKES
ODI Number: 11222966
SERVICE BRAKES
ODI Number: 11228248
ELECTRICAL SYSTEM
ODI Number: 11221795
SERVICE BRAKES
ODI Number: 11219901
VISIBILITY:SUN/MOON ROOF ASSEMBLY
ODI Number: 11210658
ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 11210091
SERVICE BRAKES
ODI Number: 11172197
AIR BAGS
ODI Number: 11174374
SERVICE BRAKES
ODI Number: 11173044
SERVICE BRAKES
ODI Number: 11173684
SERVICE BRAKES
ODI Number: 11173173
SERVICE BRAKES
ODI Number: 11173804
ENGINE | HYBRID PROPULSION SYSTEM
ODI Number: 11166493
SERVICE BRAKES
ODI Number: 11166767
SERVICE BRAKES
ODI Number: 11164546
SERVICE BRAKES
ODI Number: 11164336
SERVICE BRAKES
ODI Number: 11164990
SERVICE BRAKES
ODI Number: 11162558
SERVICE BRAKES
ODI Number: 11162961
ELECTRICAL SYSTEM | ENGINE
ODI Number: 11160962
STRUCTURE:BODY
ODI Number: 11157205
SERVICE BRAKES
ODI Number: 11162242
SERVICE BRAKES
ODI Number: 11139105
AIR BAGS | VISIBILITY:SUN/MOON ROOF ASSEMBLY
ODI Number: 11139768
EXTERIOR LIGHTING
ODI Number: 11133428
STEERING | UNKNOWN OR OTHER
ODI Number: 11139205
SERVICE BRAKES
ODI Number: 11139660
UNKNOWN OR OTHER
ODI Number: 11133556
SERVICE BRAKES
ODI Number: 11130222
SERVICE BRAKES
ODI Number: 11123397
ELECTRICAL SYSTEM | ENGINE
ODI Number: 11128145
SERVICE BRAKES
ODI Number: 11129186
ELECTRICAL SYSTEM
ODI Number: 11128651
SERVICE BRAKES
ODI Number: 11129167
UNKNOWN OR OTHER
ODI Number: 11122748
SERVICE BRAKES
ODI Number: 11122139
SERVICE BRAKES
ODI Number: 11121916
EXTERIOR LIGHTING
ODI Number: 11101182
AIR BAGS:FRONTAL:DRIVER CLOCKSPRING/SPIRAL CASSETTE | ELECTRICAL SYSTEM
ODI Number: 11091012
SERVICE BRAKES
ODI Number: 11088447
ELECTRICAL SYSTEM | ENGINE | SERVICE BRAKES
ODI Number: 11084932
SERVICE BRAKES
ODI Number: 11190607
SERVICE BRAKES
ODI Number: 11192179
SERVICE BRAKES
ODI Number: 11192342
AIR BAGS
ODI Number: 11190710
ENGINE
ODI Number: 11185732
ELECTRICAL SYSTEM | ELECTRONIC STABILITY CONTROL | ENGINE
ODI Number: 11185909
SERVICE BRAKES
ODI Number: 11184751
SERVICE BRAKES
ODI Number: 11183661
ELECTRICAL SYSTEM | ENGINE
ODI Number: 11183833
SERVICE BRAKES
ODI Number: 11182549
SERVICE BRAKES
ODI Number: 11183178
UNKNOWN OR OTHER
ODI Number: 11174887
ENGINE | POWER TRAIN
ODI Number: 11180311
UNKNOWN OR OTHER
ODI Number: 11083558
SERVICE BRAKES
ODI Number: 11080403
SERVICE BRAKES
ODI Number: 11075085
ELECTRICAL SYSTEM | VISIBILITY/WIPER
ODI Number: 11074922
ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 11072238
POWER TRAIN
ODI Number: 11156058
ELECTRICAL SYSTEM | ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 11154783
FUEL/PROPULSION SYSTEM | UNKNOWN OR OTHER
ODI Number: 11156577
SERVICE BRAKES
ODI Number: 11153522
ELECTRICAL SYSTEM | ENGINE
ODI Number: 11156109
SERVICE BRAKES
ODI Number: 11154502
ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 11150662
ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 11143620
UNKNOWN OR OTHER
ODI Number: 11150044
SERVICE BRAKES
ODI Number: 11144888
ENGINE | FUEL/PROPULSION SYSTEM | VEHICLE SPEED CONTROL
ODI Number: 11141949
AIR BAGS | ELECTRICAL SYSTEM | HYBRID PROPULSION SYSTEM
ODI Number: 11142471
ELECTRICAL SYSTEM | ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 11142932
UNKNOWN OR OTHER
ODI Number: 11114974
ELECTRICAL SYSTEM
ODI Number: 11112149
POWER TRAIN
ODI Number: 11110635
POWER TRAIN
ODI Number: 11110634
ELECTRICAL SYSTEM
ODI Number: 11110383
POWER TRAIN
ODI Number: 11111076
SERVICE BRAKES
ODI Number: 11110691
SERVICE BRAKES
ODI Number: 11064384
SERVICE BRAKES
ODI Number: 11061959
POWER TRAIN
ODI Number: 11051229
EXTERIOR LIGHTING
ODI Number: 11032983
SERVICE BRAKES
ODI Number: 11032263
EXTERIOR LIGHTING
ODI Number: 11023977
ENGINE
ODI Number: 11020933
ELECTRICAL SYSTEM | ENGINE
ODI Number: 11020650
AIR BAGS
ODI Number: 11019096
VEHICLE SPEED CONTROL
ODI Number: 11019401
STRUCTURE:BODY
ODI Number: 11020167
EXTERIOR LIGHTING
ODI Number: 11020317
EXTERIOR LIGHTING
ODI Number: 10889190
SERVICE BRAKES
ODI Number: 10887699
ENGINE
ODI Number: 10886061
SERVICE BRAKES
ODI Number: 10883472
POWER TRAIN | SERVICE BRAKES
ODI Number: 10875765
EXTERIOR LIGHTING
ODI Number: 10876013
EXTERIOR LIGHTING
ODI Number: 10876301
SERVICE BRAKES
ODI Number: 10876751
ELECTRICAL SYSTEM
ODI Number: 10872516
AIR BAGS | SEAT BELTS
ODI Number: 10874869
SERVICE BRAKES
ODI Number: 10872736
ELECTRICAL SYSTEM
ODI Number: 10871109
UNKNOWN OR OTHER
ODI Number: 10871597
EXTERIOR LIGHTING
ODI Number: 10871062
SERVICE BRAKES
ODI Number: 10870444
UNKNOWN OR OTHER
ODI Number: 10871324
SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 10862322
EXTERIOR LIGHTING
ODI Number: 10860952
ENGINE
ODI Number: 10861668
AIR BAGS
ODI Number: 10851233
EXTERIOR LIGHTING
ODI Number: 10850218
TRACTION CONTROL SYSTEM
ODI Number: 10840217
EXTERIOR LIGHTING | SEAT BELTS
ODI Number: 10845561
EXTERIOR LIGHTING
ODI Number: 10849787
ELECTRICAL SYSTEM:SOFTWARE
ODI Number: 10837480
ENGINE
ODI Number: 10825916
ENGINE
ODI Number: 10817455
EXTERIOR LIGHTING
ODI Number: 10807405
SERVICE BRAKES
ODI Number: 10789755
ENGINE | POWER TRAIN
ODI Number: 10790539
ELECTRICAL SYSTEM
ODI Number: 10790330
EXTERIOR LIGHTING
ODI Number: 10788695
SERVICE BRAKES
ODI Number: 10786107
SEATS
ODI Number: 10780827
SERVICE BRAKES
ODI Number: 10779464
AIR BAGS | SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 10775436
ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 10778422
EXTERIOR LIGHTING
ODI Number: 10765251
SERVICE BRAKES
ODI Number: 10764721
SERVICE BRAKES
ODI Number: 10763269
ENGINE | SERVICE BRAKES | SUSPENSION
ODI Number: 10760730
UNKNOWN OR OTHER
ODI Number: 10759621
SERVICE BRAKES
ODI Number: 10749001
SERVICE BRAKES
ODI Number: 10747550
SERVICE BRAKES
ODI Number: 10748303
STRUCTURE:BODY
ODI Number: 10733102
AIR BAGS | ELECTRICAL SYSTEM | SERVICE BRAKES
ODI Number: 10734475
ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 10731939
SERVICE BRAKES
ODI Number: 10722368
SERVICE BRAKES
ODI Number: 10722312
VEHICLE SPEED CONTROL
ODI Number: 10716440
STRUCTURE:BODY
ODI Number: 10712423
TIRES
ODI Number: 10705920
SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER
ODI Number: 10681449
AIR BAGS
ODI Number: 10679523
AIR BAGS
ODI Number: 10680758
ENGINE
ODI Number: 10680247
STEERING
ODI Number: 10671670
EXTERIOR LIGHTING
ODI Number: 10668420
POWER TRAIN
ODI Number: 10662026
SERVICE BRAKES
ODI Number: 10658834
AIR BAGS
ODI Number: 10649707
ELECTRONIC STABILITY CONTROL
ODI Number: 10640440
SERVICE BRAKES | STRUCTURE:BODY
ODI Number: 10637465
SERVICE BRAKES
ODI Number: 10637080
ELECTRICAL SYSTEM
ODI Number: 10633661
ELECTRICAL SYSTEM | LATCHES/LOCKS/LINKAGES
ODI Number: 10631371
SERVICE BRAKES
ODI Number: 10629738
VEHICLE SPEED CONTROL
ODI Number: 10620999
ELECTRICAL SYSTEM | EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
ODI Number: 10615506
HYBRID PROPULSION SYSTEM: INVERTER
ODI Number: 10609388
VEHICLE SPEED CONTROL
ODI Number: 10607388
EXTERIOR LIGHTING
ODI Number: 10608204
SERVICE BRAKES
ODI Number: 10605972
ELECTRICAL SYSTEM
ODI Number: 10605946
STEERING
ODI Number: 10605625
SERVICE BRAKES
ODI Number: 10597489
SERVICE BRAKES | STRUCTURE:BODY
ODI Number: 10598545
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | INTERIOR LIGHTING
ODI Number: 10592093
SERVICE BRAKES
ODI Number: 10592233
EXTERIOR LIGHTING
ODI Number: 10592620
AIR BAGS
ODI Number: 10593558
SERVICE BRAKES
ODI Number: 10586111
ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 10586089
AIR BAGS | SEAT BELTS
ODI Number: 10578503
EXTERIOR LIGHTING
ODI Number: 10576419
SERVICE BRAKES
ODI Number: 10576223
SERVICE BRAKES
ODI Number: 10573948
SERVICE BRAKES
ODI Number: 10573896
FUEL/PROPULSION SYSTEM | SERVICE BRAKES
ODI Number: 10573372
ELECTRICAL SYSTEM | HYBRID PROPULSION SYSTEM: INVERTER
ODI Number: 10573249
EXTERIOR LIGHTING
ODI Number: 10565610
ELECTRICAL SYSTEM | SERVICE BRAKES | UNKNOWN OR OTHER
ODI Number: 10564732
ENGINE
ODI Number: 10562720
TIRES
ODI Number: 10558441
STRUCTURE:BODY
ODI Number: 10558365
SERVICE BRAKES
ODI Number: 10553888
SERVICE BRAKES
ODI Number: 10550145
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10550735
SERVICE BRAKES
ODI Number: 10547701
SERVICE BRAKES
ODI Number: 10545180
SERVICE BRAKES
ODI Number: 10545179
SERVICE BRAKES
ODI Number: 10542220
ENGINE AND ENGINE COOLING:COOLING SYSTEM | VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
ODI Number: 10532319
TIRES | WHEELS
ODI Number: 10532003
ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 10533189
VISIBILITY:SUN/MOON ROOF ASSEMBLY
ODI Number: 10524176
ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 10512632
ELECTRICAL SYSTEM | ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 10513264
EXTERIOR LIGHTING
ODI Number: 10510462
EXTERIOR LIGHTING
ODI Number: 10510461
SERVICE BRAKES
ODI Number: 10505147
SERVICE BRAKES
ODI Number: 10507516
SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 10502597
SERVICE BRAKES
ODI Number: 10504303
SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 10499911
AIR BAGS | SEATS | SERVICE BRAKES
ODI Number: 10498096
TIRES | WHEELS
ODI Number: 10496716
SERVICE BRAKES
ODI Number: 10492965
TIRES
ODI Number: 10493198
EXTERIOR LIGHTING
ODI Number: 10493291
EXTERIOR LIGHTING
ODI Number: 10490549
VEHICLE SPEED CONTROL
ODI Number: 10491947
SERVICE BRAKES
ODI Number: 10489219
SERVICE BRAKES
ODI Number: 10484633
SEATS
ODI Number: 10485278
ENGINE
ODI Number: 10480584
SERVICE BRAKES | STRUCTURE:BODY
ODI Number: 10482485
EXTERIOR LIGHTING
ODI Number: 10476948
SERVICE BRAKES
ODI Number: 10477385
VEHICLE SPEED CONTROL
ODI Number: 10471467
FUEL/PROPULSION SYSTEM | SERVICE BRAKES
ODI Number: 10460127
VEHICLE SPEED CONTROL
ODI Number: 10460939
SERVICE BRAKES
ODI Number: 10459051
TIRES
ODI Number: 10457885
TIRES
ODI Number: 10457883
ENGINE
ODI Number: 10457152
SERVICE BRAKES
ODI Number: 10458927
VEHICLE SPEED CONTROL
ODI Number: 10456141
ELECTRONIC STABILITY CONTROL
ODI Number: 10454049
AIR BAGS | SEAT BELTS
ODI Number: 10453247
SERVICE BRAKES, HYDRAULIC
ODI Number: 10454198
ENGINE AND ENGINE COOLING
ODI Number: 10451014
EXTERIOR LIGHTING | VISIBILITY
ODI Number: 10448023
VISIBILITY
ODI Number: 10443927
VISIBILITY
ODI Number: 10441538
ENGINE AND ENGINE COOLING | VEHICLE SPEED CONTROL
ODI Number: 10441676
SERVICE BRAKES, HYDRAULIC
ODI Number: 10435637
VISIBILITY
ODI Number: 10436840
ELECTRICAL SYSTEM | VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10437623
SUSPENSION
ODI Number: 10435352
POWER TRAIN
ODI Number: 10432919
ENGINE AND ENGINE COOLING
ODI Number: 10433593
SEATS | SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
ODI Number: 10429445
POWER TRAIN
ODI Number: 10423463
SEATS
ODI Number: 10417663
AIR BAGS
ODI Number: 10413491
SERVICE BRAKES, HYDRAULIC
ODI Number: 10415273
EQUIPMENT
ODI Number: 10408896
VEHICLE SPEED CONTROL
ODI Number: 10396689
UNKNOWN OR OTHER | VISIBILITY
ODI Number: 10393328
POWER TRAIN
ODI Number: 10393790
ENGINE
ODI Number: 10887400
VEHICLE SPEED CONTROL
ODI Number: 10684300
SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 10500800
Is the government investigating the safety of your vehicle? Find out here.

1 Investigations for 2011 TOYOTA Prius

Date Opened Date Closed Component  
SERVICE BRAKES, HYDRAULIC:POWER ASSIST
Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

376 Service Alerts for 2011 TOYOTA Prius

Date Description
March 9, 2022 050000 PARKING BRAKE

TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the Repair Procedure in this bulletin to replace the loose or damaged carpet floor retai

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2022 220000 SEATS

TSB: Some 2010 ? 2022 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 12, 2022 190000 TIRES

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 12, 2022 200000 WHEELS

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 12, 2022 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 23, 2021 160000 STRUCTURE

TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 2021 284300 BACK OVER PREVENTION: SENSING SYSTEM: RADAR

TSB: For proper calibration of the millimeter wave radar sensor, the vehicle and radar target must be on a level surface with a consistent plane. If a level surface with a consistent plane is not available, use the Floor Slope Compensation

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 2021 264300 FORWARD COLLISION AVOIDANCE: SENSING SYSTEM: RADAR

TSB: For proper calibration of the millimeter wave radar sensor, the vehicle and radar target must be on a level surface with a consistent plane. If a level surface with a consistent plane is not available, use the Floor Slope Compensation

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 4, 2001 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Replacement vin plates.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 18, 1991 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Product general information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 28, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Technician Certification Requirements.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 30, 1989 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Product general information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 9, 1993 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Product general information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 8, 1991 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Product general information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 17, 2021 140000 AIR BAGS

Toyota Safety Recall and Service Campaign – Technician Certification Requirements

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 12, 2021 030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 12, 2021 280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 18, 2021 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0012-21.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 2021 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0044-16.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 5, 2021 220000 SEATS

TSB: Some 2010 ? 2021 model year Toyota vehicles may exhibit paint stains after the removal of Rapgard?. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard?. The wrinkles may trap water an

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 3, 2021 350000 EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2020 030000 BRAKES (PWS)

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2020 280000 BACK OVER PREVENTION

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 12, 2021 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

OBSOLETE NOTICE January 12, 2021: This bulletin is now obsolete. Please see T-SB-0003-21.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 11, 2021 119310 ELECTRICAL SYSTEM:PROPULSION SYSTEM:INVERTER

TSB: Some 2010 ? 2015 model year Prius and 2012 ? 2017 model year Prius V vehicles may exhibit a MIL ON condition with Diagnostic Trouble Codes (DTCs) P0A94, P324E, P0A1A, and/or P3004, indicating a malfunction has occurred in the inverter

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 21, 2020 062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS

TT: HVAC drain tube is found to be blocked/clogged.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2020 030000 SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 14, 2020 353000 EQUIPMENT:ELECTRICAL

TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Perform t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 17, 2020 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: Some 2010 – 2015 model year Prius and 2012 – 2017 model year Prius V vehicles may exhibit a MIL ON condition with Diagnostic Trouble Codes (DTCs) P0A94, P324E, P0A1A, and/or P3004, indicating a malfunction has occurred in the inverter

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 17, 2020 100000 HYBRID POWERTRAIN: INVERTER

TSB: Some 2010 – 2015 model year Prius and 2012 – 2017 model year Prius V vehicles may exhibit a MIL ON condition with Diagnostic Trouble Codes (DTCs) P0A94, P324E, P0A1A, and/or P3004, indicating a malfunction has occurred in the inverter

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 17, 2020 060000 ENGINE (PWS)

TSB: Some 2010 – 2015 model year Prius and 2012 – 2017 model year Prius V vehicles may exhibit a MIL ON condition with Diagnostic Trouble Codes (DTCs) P0A94, P324E, P0A1A, and/or P3004, indicating a malfunction has occurred in the inverter

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 5, 2020 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 5, 2020 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 23, 2020 020000 SUSPENSION

TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see T-SB-0063-20.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 23, 2020 200000 WHEELS

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 26, 2020 350000 EQUIPMENT

TT: For proper calibration of the millimeter wave radar sensor, the vehicle must be on a level surface. If a level surface is not available, this tech tip should be used in conjunction with the repair manual to set the angle of the front mi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 26, 2020 280000 BACK OVER PREVENTION

TT: For proper calibration of the millimeter wave radar sensor, the vehicle must be on a level surface. If a level surface is not available, this tech tip should be used in conjunction with the repair manual to set the angle of the front mi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 110000 ELECTRICAL SYSTEM

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2020 060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE August 11, 2020: This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 5, 2020 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 5, 2020 110000 ELECTRICAL SYSTEM

TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 5, 2020 350000 EQUIPMENT

TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid Vehic

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 18, 2020 110000 ELECTRICAL SYSTEM

TSB: Some 2004 ? 2020 model year Hybrid vehicles may exhibit an excessive buildup of dust, lint, or debris in the HV battery intake filter or cooling fan. The condition could reduce the efficiency of the HV battery cooling system. Perform t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 30, 2020 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

TT: HVAC drain tube is found to be blocked/clogged.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 7, 2020 350000 EQUIPMENT

TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 6, 2020 350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2020 110000 ELECTRICAL SYSTEM

TT: This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue ch

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 6, 2020 350000 EQUIPMENT

TSB: Some 2004 ? 2017 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bull

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 23, 2019 350000 EQUIPMENT

Region Letter: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following infor

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 23, 2019 350000 EQUIPMENT

Region Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 23, 2019 350000 EQUIPMENT

Dealer Package: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following info

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 23, 2019 350000 EQUIPMENT

Dealer Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2020 350000 EQUIPMENT

OBSOLETE NOTICE February 12, 2020: This bulletin is now obsolete. Please see T-SB-0010-20.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 27, 2020 350000 EQUIPMENT

TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 9, 2019 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 9, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2019 100000 POWER TRAIN

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2019 110000 ELECTRICAL SYSTEM

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2019 060000 ENGINE (PWS)

TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 30, 2019 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

Warranty Enhancement Program: Toyota has received reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve in some vehicles. If this occurs, the vehicle may illumin

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 30, 2019 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Warranty Enhancement Program: Toyota has received reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve in some vehicles. If this occurs, the vehicle may illumin

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 30, 2019 060000 ENGINE (PWS)

Warranty Enhancement Program: Toyota has received reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve in some vehicles. If this occurs, the vehicle may illumin

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 28, 2019 030000 BRAKES (PWS)

Warranty Enhancement Program: Toyota has received reports indicating various brake system related warning lamps illuminate due to internal malfunctions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 28, 2019 030000 SERVICE BRAKES, HYDRAULIC

Dealer Package: Toyota has received reports about certain internal malfunctions of the brake booster assemblies in some of the subject vehicles. Although the brake booster and brake booster pump assemblies are covered by Toyota?s New Vehic

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 28, 2019 030000 BRAKES (PWS)

Dealer Package: Toyota has received reports about certain internal malfunctions of the brake booster assemblies in some of the subject vehicles. Although the brake booster and brake booster pump assemblies are covered by Toyota?s New Vehic

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 14, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: OBSOLETE NOTICE April 4, 2019: This bulletin is now obsolete. Please see T-SB-0038-19.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2019 353000 EQUIPMENT:ELECTRICAL

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. In some in

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. In some in

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. In some in

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 8, 2019 121000 EXTERIOR LIGHTING:HEADLIGHTS

Dealer Package: May 8, 2019 The interim repair Op Codes have been removed as Toyota now has sufficient inventory of repair kit part number 04007-52147. Toyota has received a number of reports regarding the halogen head lamps on certain 2010

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 6, 2019 121000 EXTERIOR LIGHTING:HEADLIGHTS

Customer Support Program Bulletin: Toyota has received reports of customer concerns in which their vehicle?s halogen low beam headlamp bulbs lifetime is shorter than expected.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2019 030000 SERVICE BRAKES, HYDRAULIC

Customer Support Program Bulletin: Toyota has received reports indicating various brake system related warning lamps illuminate due to internal malfunctions.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2019 030000 SERVICE BRAKES, HYDRAULIC

Dealer Letter: March 7, 2019 ZJB Phase 2 Launch for Certain 2011 ? 2015 Model Year Prius Vehicles and Certain 2012 ? 2015 Model Year Prius PHV vehicles. Toyota has received reports about certain internal malfunctions of the brake booster as

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2019 030000 BRAKES (PWS)

Dealer Letter: March 7, 2019 ZJB Phase 2 Launch for Certain 2011 ? 2015 Model Year Prius Vehicles and Certain 2012 ? 2015 Model Year Prius PHV vehicles. Toyota has received reports about certain internal malfunctions of the brake booster as

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 6, 2019 030000 SERVICE BRAKES, HYDRAULIC

TSB: Some 2011 ? 2015 model year Prius and 2012 ? 2015 model year Prius Plug-in Hybrid vehicles may exhibit a condition where the brake, ABS, and/or TRAC warning light(s) are on and/or a Check VSC message displays. Diagnostic Trouble Codes

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 6, 2019 036400 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

TSB: Some 2011 ? 2015 model year Prius and 2012 ? 2015 model year Prius Plug-in Hybrid vehicles may exhibit a condition where the brake, ABS, and/or TRAC warning light(s) are on and/or a Check VSC message displays. Diagnostic Trouble Codes

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 4, 2019 350000 EQUIPMENT

TSB: The purpose of this general information Service Bulletin is to inform the market that sub-component diagnosis and replacement is now available for the hybrid inverter with converter assembly equipped on 2010 ? 2015 model year Prius and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 8, 2016 060000 ENGINE (PWS)

TSB: Revision Notice: Applicability has been updated to include 2015 Prius PHV, 2015-2016 Prius V, and 2015 Prius Vehicles. The Introduction, Parts Information, Required Tools & Equipment, and Repair Procedure sections have been updated.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 14, 2016 060000 ENGINE (PWS)

TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 25, 2019 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TT: HVAC drain tube is found to be blocked/clogged.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 14, 2016 110000 ELECTRICAL SYSTEM

TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 8, 2016 060000 ENGINE (PWS)

TSB: Revision Notice: Applicability has been updated to include 2015 Prius PHV, 2015-2016 Prius V, and 2015 Prius Vehicles. The Introduction, Parts Information, Required Tools & Equipment, and Repair Procedure sections have been updated.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 2, 2015 350000 EQUIPMENT

TSB: This bulletin includes basic procedures for performing a Rescue Charge on Ni-MH High Voltage (HV) Batteries. This bulletin should be used in conjunction with the Repair Manual while performing Rescue Charge. The GRX-5100 should be used

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 2017 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TT: Some Customers may complain about a Hybrid Vehicle Battery cooling system warning message. This warning message may appear when the HV Battery cooling system loses efficiency due to debris on the filter and or some object obstructing

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 6, 2017 110000 ELECTRICAL SYSTEM

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 10, 2018 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The trail period of service is provided upon the vehicle purchase. Once the subscription has expired the DCM (Telematics Transceiver) will

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2016 110000 ELECTRICAL SYSTEM

TSB: Some 2010 ? 2014 Prius and 2012 ? 2014 Prius V model vehicles may exhibit a MIL ?ON? condition with DTCs P0A94, P324E, P0A1A, or P3004, indicating a malfunction has occurred in the hybrid inverter assembly. To help identify the specifi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2016 350000 EQUIPMENT

TSB: Some 2010 ? 2014 Prius and 2012 ? 2014 Prius V model vehicles may exhibit a MIL ?ON? condition with DTCs P0A94, P324E, P0A1A, or P3004, indicating a malfunction has occurred in the hybrid inverter assembly. To help identify the specifi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 31, 2016 110000 ELECTRICAL SYSTEM

Warranty Policy Bulletin (POL14-05): Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by the hybrid system diagno

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 31, 2016 350000 EQUIPMENT

Warranty Policy Bulletin (POL14-05): Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by the hybrid system diagno

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2016 110000 ELECTRICAL SYSTEM

Dealer Letter: In these vehicles, Toyota has received some reports where the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by hybrid system diagnostic trouble

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2016 350000 EQUIPMENT

Dealer Letter: In these vehicles, Toyota has received some reports where the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by hybrid system diagnostic trouble

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 26, 2018 100000 POWER TRAIN

Warranty Policy Bulletin: Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by the hybrid system diagnostic trouble

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 26, 2018 110000 ELECTRICAL SYSTEM

Warranty Policy Bulletin: Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by the hybrid system diagnostic trouble

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 21, 2016 350000 EQUIPMENT

Update on Technician Certification Requirements.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 21, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Update on Technician Certification Requirements.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 31, 2018 350000 EQUIPMENT

TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 31, 2018 350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 31, 2018 355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 31, 2018 350000 EQUIPMENT

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 31, 2018 355100 EQUIPMENT:OTHER:LABELS

Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 31, 2018 110000 ELECTRICAL SYSTEM

Warranty Program Bulletin: Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by the hybrid system diagnostic troubl

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2016 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: Some 2010 ? 2014 Prius and 2012 ? 2014 Prius V model vehicles may exhibit a MIL ?ON? condition with DTCs P0A94, P324E, P0A1A, or P3004, indicating a malfunction has occurred in the hybrid inverter assembly. To help identify the specif

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2016 060000 ENGINE (PWS)

TSB: Some 2010 ? 2014 Prius and 2012 ? 2014 Prius V model vehicles may exhibit a MIL ?ON? condition with DTCs P0A94, P324E, P0A1A, or P3004, indicating a malfunction has occurred in the hybrid inverter assembly. To help identify the specif

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2016 162000 STRUCTURE:BODY

TSB: On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard?

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 11, 2016 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TT: HV Batteries have liquid filled cell modules, to prevent leakage from cells, it is very important to confirm the proper orientation mark of the DRC.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 11, 2016 350000 EQUIPMENT

TT: HV Batteries have liquid filled cell modules, to prevent leakage from cells, it is very important to confirm the proper orientation mark of the DRC.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2017 110000 ELECTRICAL SYSTEM

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has expired the DCM (Telematics Transceiver) wi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2017 350000 EQUIPMENT

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has expired the DCM (Telematics Transceiver) wi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2017 353000 EQUIPMENT:ELECTRICAL

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has expired the DCM (Telematics Transceiver) wi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2016 160000 STRUCTURE

TSB: On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard?

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2016 356000 EQUIPMENT ADAPTIVE/MOBILITY

TSB: On some vehicles, when Rapgard? is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard?

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2016 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: Some 2010 ? 2014 Prius and 2012 ? 2014 Prius V model vehicles may exhibit a MIL ?ON? condition with DTCs P0A94, P324E, P0A1A, or P3004, indicating a malfunction has occurred in the hybrid inverter assembly. To help identify the specifi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2016 350000 EQUIPMENT

TSB: Some 2010 ? 2014 Prius and 2012 ? 2014 Prius V model vehicles may exhibit a MIL ?ON? condition with DTCs P0A94, P324E, P0A1A, or P3004, indicating a malfunction has occurred in the hybrid inverter assembly. To help identify the specifi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: Some 2010 ? 2014 Prius and 2012 ? 2014 Prius V model vehicles may exhibit a MIL ?ON? condition with DTCs P0A94, P324E, P0A1A, or P3004, indicating a malfunction has occurred in the hybrid inverter assembly. To help identify the specifi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 31, 2016 110000 ELECTRICAL SYSTEM

Warranty Policy Bulletin (POL14-05): Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by the hybrid system diagno

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 31, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Warranty Policy Bulletin (POL14-05): Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by the hybrid system diagno

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2016 110000 ELECTRICAL SYSTEM

Dealer Letter: In these vehicles, Toyota has received some reports where the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by hybrid system diagnostic trouble

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Dealer Letter: In these vehicles, Toyota has received some reports where the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by hybrid system diagnostic trouble

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 20, 2018 120000 EXTERIOR LIGHTING

Warranty Policy Bulletin: Toyota has received reports of customer concerns in which their vehicle’s halogen low beam headlamp bulbs lifetime is shorter than expected.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 6, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 6, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 6, 2015 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 25, 2015 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under warranty.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 25, 2015 353000 EQUIPMENT:ELECTRICAL

TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under warranty.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 26, 2014 110000 ELECTRICAL SYSTEM

The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. If the operator attempts to ready-on or start the vehicle while there is tension on

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 12, 2014 350000 EQUIPMENT

For the models listed above, the Electronic Parts Catalog (EPC) may not include enough detail to determine appropriate keys and receiver replacement parts. This Tech Tip will help you identify the system type prior to ordering replacement

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 24, 2015 100000 POWER TRAIN

TechTip: Condition – The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 6, 2015 110000 ELECTRICAL SYSTEM

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has lapsed the DCM will be in an inactive state

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 12, 2014 063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

Some 2010 ? 2015 model year Prius, 2012 ? 2015 Prius PHV, and 2012 ? 2016 Prius V vehicles equipped with a 2ZR-FXE engine may exhibit a MIL ?ON? condition with Diagnostic Trouble Codes (DTCs) P2111 (Throttle Actuator Control System) and P0A

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 23, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

In late April 2014, Toyota will be mailing an update to the Owner?s Manual for certain 2010 through 2013 Model Year Prius Plug-in Hybrid Vehicles (PHV) and certain 2012 through 2013 RAV4 Electric Vehicles (EV). Sample Owner Letter labels ar

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 25, 2013 130000 VISIBILITY

Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2017 162000 STRUCTURE:BODY

TSB: REVISION NOTICE March 07, 2017 Rev1: ? Applicability has been updated to include 2017 model year Toyota vehicles. On some vehicles, when Rapgard? is removed the paint may have a stained appearance. These stains appear to be under the c

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 15, 2013 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Technicians should confirm the following key points to minimize the potential for future MIL “ON” concerns after HV battery replacement.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 4, 2013 350000 EQUIPMENT

Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicability.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 11, 2013 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 11, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 23, 2013 355100 EQUIPMENT:OTHER:LABELS

This bulletin is now obsolete. Please see T-SB-0054-13.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 23, 2013 350000 EQUIPMENT

California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guide

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 4, 2013 280000 BACK OVER PREVENTION

If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 4, 2013 358100 EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT

If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 2017 350000 EQUIPMENT

TT: Previously, an error message was received when performing DCM activation initiated by Techstream. This condition has been remedied, and DCM activation utilizing Techstream can now be resumed.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 27, 2017 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

TT: Rev2 Some Customers may complain about a Hybrid Vehicle Battery cooling system warning message. This warning message may appear when the HV Battery cooling system loses efficiency due to debris on the filter and or some object obstruc

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 21, 2018 121000 EXTERIOR LIGHTING:HEADLIGHTS

TSB: REVISION NOTICE February 21, 2018 Rev2: ? Applicability has been updated to include 2012 model year Prius vehicles. ? The Required Tools & Equipment section has been updated. October 17, 2017 Rev1: ? The Repair Procedure section h

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 3, 2016 350000 EQUIPMENT

TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under warranty.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 8, 2017 353000 EQUIPMENT:ELECTRICAL

TT: An error message is received when performing DCM activation initiated by Techstream. This is a known condition and will be remedied in the near future. Please discontinue DCM activations utilizing Techstream until further notice.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 20, 2017 140000 AIR BAGS

TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 20, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 19, 2013 130000 VISIBILITY

The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 2, 2013 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

If a customer states there is an unpleasant odor in the vehicle from the HVAC system, there are various factors that may be involved.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 2, 2013 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

If a customer states there is an unpleasant odor in the vehicle from the HVAC system, there are various factors that may be involved.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 23, 2013 132000 VISIBILITY:GLASS, SIDE/REAR

The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 4, 2013 140000 AIR BAGS

Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 4, 2013 220000 SEATS

Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 4, 2013 350000 EQUIPMENT

Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 24, 2013 110000 ELECTRICAL SYSTEM

These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 24, 2013 353000 EQUIPMENT:ELECTRICAL

These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 2, 2013 060000 ENGINE (PWS)

Due to the improved performance and durability of 0w-20 synthetic oil, Toyota has extended the oil change intervals to 10,000 miles for most vehicles that require this oil. With this change, the following should be noted

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 12, 2013 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 19, 2013 130000 VISIBILITY/WIPER (PWS)

This bulletin is now obsolete. Please see T-SB-0185-13.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 9, 2013 050000 PARKING BRAKE

A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 9, 2013 350000 EQUIPMENT

A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 11, 2016 118000 ELECTRICAL SYSTEM:SOFTWARE

Tech Tip: Some customers may experience difficulty programming HomeLink.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 15, 2015 118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 15, 2015 060000 ENGINE (PWS)

TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 7, 2016 980000 UNKNOWN OR OTHER

TSB: Obsolete Notice This bulletin is now obsolete. Please see T-SB-0027-15.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 14, 2014 140000 AIR BAGS

Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 2014 190000 TIRES

Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 28, 2014 350000 EQUIPMENT

Customer complains of Bluetooth connectivity concerns such as: Difficulty to pair phone, Intermittent Bluetooth failure to connect to the vehicle when first turning on the vehicle. These concerns can be caused by changes made on the custom

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 25, 2013 060000 ENGINE (PWS)

Starting with 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0W-20 viscosity engine oil. There a re man benefits of this oil.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 20, 2014 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

For vehicles that are used under certain severe operating conditions, the HV Battery Cooling Fan may experience an excessive buildup of dust, lint, or other debris that can reduce the efficiency of the HV Battery Cooling System. HV Battery

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 4, 2014 060000 ENGINE (PWS)

Starting with the 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. There are multiple benefits of this oil. Due to the improved performance and durability of 0w-20 synthetic oil, Toyot

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 20, 2013 100000 POWER TRAIN

This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 22, 2017 110000 ELECTRICAL SYSTEM

TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 19, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Some customers may inquire about the frequency and power output of the Smart Key/Smart Entry systems used on various models. The Smart Key/Smart Entry systems conform to all applicable FCC rules. This bulletin details the applicable specifi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 8, 2014 060000 ENGINE (PWS)

Tech Tip: Starting with the 2010 Model Year, Toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. There are multiple benefits of this oil including: Reduced friction and wear on engine surfaces, Improved fuel

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 2, 2018 350000 EQUIPMENT

TSB: The purpose of this Service Bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in Toyota vehicles. As an additional resource, if the vehicle is equipped with factory leather seats, the ve

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 7, 2014 353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 25, 2014 353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 25, 2017 120000 EXTERIOR LIGHTING

Dealer Letter: Toyota has received a number of reports regarding the halogen head lamps on certain 2010 ? 2011 model year Prius vehicles. In these reports, customers have indicated that their vehicle?s halogen low beam headlamp bulb lifetim

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 25, 2017 121000 EXTERIOR LIGHTING:HEADLIGHTS

Region Letter: Toyota has received a number of reports regarding the halogen head lamps on certain 2010 ? 2011 model year Prius vehicles. In these reports, customers have indicated that their vehicle?s halogen low beam headlamp bulb lifetim

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 25, 2017 120000 EXTERIOR LIGHTING

Dealer Email: Toyota has received a number of reports regarding the halogen head lamps on certain 2010 ? 2011 model year Prius vehicles. In these reports, customers have indicated that their vehicle?s halogen low beam headlamp bulb lifetime

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 25, 2017 120000 EXTERIOR LIGHTING

Region Email: Toyota has received a number of reports regarding the halogen head lamps on certain 2010 ? 2011 model year Prius vehicles. In these reports, customers have indicated that their vehicle?s halogen low beam headlamp bulb lifetime

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 29, 2014 110000 ELECTRICAL SYSTEM

Tech Tip: Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 29, 2014 130000 VISIBILITY

Tech Tip: Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 12, 2014 118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bullet

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 7, 2016 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

TSB: For vehicles that are used under certain severe operating conditions, the HV Battery Cooling Fan may experience an excessive buildup of dust, lint, or other debris that can reduce the efficiency of the HV Battery Cooling System. HV Ba

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 2016 110000 ELECTRICAL SYSTEM

TT: Some customers may encounter Bluetooth connectivity concerns such as: ? Difficulty pairing the phone. ? Intermittent Bluetooth failure to connect when first turning on the vehicle. ? Various Bluetooth Audio functions are no lon

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 27, 2013 110000 ELECTRICAL SYSTEM

The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 31, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

TSB: Some Prius, Prius V, and Prius PHV vehciles may exhibit a rough idle or tapping noise from the HV transaxle at cold start. The Check Engine Light may also illuminate with (DTC) P0401 (Exhaust Gas Recirculation Flow Insufficient Detecte

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 7, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 6, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active. The first year of service is provided in the vehicle purchase price. Once the subscription has lapsed the DCM will be in an inactive state

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 14, 2014 140000 AIR BAGS

Tech Tip: Safety Connect is a vehicle option which requires a subscription fee for the system to be

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 14, 2014 118000 ELECTRICAL SYSTEM:SOFTWARE

Tech Tip: Safety Connect is a vehicle option which requires a subscription fee for the system to be

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 10, 2016 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Some 2004 ? 2017 model year Toyota vehicles may exhibit odor

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 10, 2016 100000 POWER TRAIN

Warranty Policy Bulletin: Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 10, 2016 110000 ELECTRICAL SYSTEM

Warranty Policy Bulletin: Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 9, 2016 100000 POWER TRAIN

Warranty Dealer Package: Warranty Enhancement Program to extend the warranty coverage for repairs related failure of the Intelligent Power Module (IPM). The vehicles covered under this Warranty Enhancement must first have Safety Recall E0E

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 9, 2016 110000 ELECTRICAL SYSTEM

Warranty Dealer Package: Warranty Enhancement Program to extend the warranty coverage for repairs related failure of the Intelligent Power Module (IPM). The vehicles covered under this Warranty Enhancement must first have Safety Recall E0E

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 30, 2013 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

Some 2010-2012 model year Prius vehicles equipped with a 2ZR-FXE engine may exhibit a MIL “ON” condition with Diagnostic Trouble Code P0401 (Exhaust Gas Recirculation Flow insufficient Detected) present. The Exhaust Gas Recirculation Valve

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 25, 2017 120000 EXTERIOR LIGHTING

Warranty Policy Bulletin: Toyota has received reports of customer concerns in which their vehicle’s halogen low beam headlamp bulbs lifetime is shorter than expected. The Halogen Low Beam Headlamp Bulb is covered by Toyota’s New Vehicle Lim

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 25, 2017 121000 EXTERIOR LIGHTING:HEADLIGHTS

Dealer Daily Message: Customer Support Program ZHB Certain 2010- 2011 Model Year Prius Coverage for Halogen Low Beam Headlamp Bulbs ? Customer Support Program ZHB Dealer Letter now available on TIS.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 31, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

TSB: Some Prius, Prius V and Prius PHV vehicles may exhibit a vibration due to rough idle and/or tapping noise from the HV transaxle at cold start. The Check Engine Light may also illuminate with (DTC) P0401 (Exhaust Gas Recirculation Flow

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 29, 2016 118000 ELECTRICAL SYSTEM:SOFTWARE

TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 16, 2016 060000 ENGINE AND ENGINE COOLING

TSB: NOTE Service Bulletin No. T-SB-0168-16 ?2ZR-FXE Engine Oil Consumption Inspection Procedure? MUST be performed BEFORE continuing with the procedure in this bulletin. Some 2010 ? 2014 model year Prius PHV, Prius V, and Prius vehicles

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 16, 2016 060000 ENGINE AND ENGINE COOLING

TSB: Some 2010 ? 2014 model year Prius, Prius V, and Prius PHV vehicles equipped with 2ZR-FXE engines may exhibit engine oil consumption. The piston and ring assembly has been redesigned to minimize oil consumption. Use the Inspection Pro

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 15, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Region Letter: In these vehicles, Toyota has received some reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve. If this occurs, the vehicle may illuminate the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 15, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Region email: In these vehicles, Toyota has received some reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve. If this occurs, the vehicle may illuminate the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 15, 2015 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 15, 2015 060000 ENGINE (PWS)

TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 14, 2015 110000 ELECTRICAL SYSTEM

TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 14, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 17, 2012 353000 EQUIPMENT:ELECTRICAL

Some 2010 ? 2011 model year Prius vehicles may exhibit a condition where a halogen low beam headlamp bulb lifetime is shorter than customer expectation. A modified wiring harness is available to address this condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 2012 162000 STRUCTURE:BODY

Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 22, 2013 190000 TIRES

Please refer to the following recommendations for the best practices for vehicle tire rotations.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2018 190000 TIRES

TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 6, 2018 120000 EXTERIOR LIGHTING

Warranty Policy Bulletin: Toyota has received reports of customer concerns in which their vehicle?s halogen low beam headlamp bulbs lifetime is shorter than expected.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 22, 2014 980000 UNKNOWN OR OTHER

This bulletin is no longer applicable and is now obsolete.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2018 190000 TIRES

TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 6, 2018 121000 EXTERIOR LIGHTING:HEADLIGHTS

Warranty Policy Bulletin: Toyota has received reports of customer concerns in which their vehicle?s halogen low beam headlamp bulbs lifetime is shorter than expected.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 6, 2018 121300 EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH

Warranty Policy Bulletin: Toyota has received reports of customer concerns in which their vehicle?s halogen low beam headlamp bulbs lifetime is shorter than expected.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 21, 2017 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: This bulletin is regarding best practices when handling navigation systems that use Hard Disc Drive or Micro SD Card memory.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 2, 2017 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 or P1AC000 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 11, 2018 350000 EQUIPMENT

TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 10, 2018 100001 HYBRID PROPULSION SYSTEM

Warranty Policy Bulletin: Toyota has received some reports indicating the Intelligent Power Module (IPM) located inside the inverter assembly of the hybrid system may fail. This condition is indicated by the hybrid system diagnostic trouble

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Warranty Policy Bulletin (POL16-04): In these vehicles, Toyota has received some reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve. If this occurs, the vehi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Dealer Letter: In these vehicles, Toyota has received some reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve. If this occurs, the vehicle may illuminate the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Dealer email: In these vehicles, Toyota has received some reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve. If this occurs, the vehicle may illuminate the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 31, 2013 353000 EQUIPMENT:ELECTRICAL

Some 2010-2011 model year Prius vehicles may exhibit a MIL “ON” condition with DTCs P3190, P3191, P0A0F, and/or purge VSV/PCV line separation from the throttle body housing.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 29, 2013 118000 ELECTRICAL SYSTEM:SOFTWARE

Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 21, 2012 030000 BRAKES (PWS)

Some 2010 ? 2012 model year Prius and 2012 model year Prius PHV vehicles may exhibit uneven brake pad wear on the rear brake pads. The vehicle may also exhibit a grinding or scraping noise due to the uneven brake pad wear. An updated rear p

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 21, 2012 060000 ENGINE (PWS)

Starting with the 2010 MY, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 13, 2012 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

For the models listed, the Electronic Parts Catalog may not include enough detail to determine appropriate keys and receiver replacement parts. This Tech Tip will help you identify the system type prior to ordering replacement keys.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 7, 2012 060000 ENGINE (PWS)

Starting with the 2010 MY, Toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 2013 118000 ELECTRICAL SYSTEM:SOFTWARE

Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 29, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This communication pertains to a current safety recall being conducted by the Southeast Toyota Distributors LLC (SET). TMS is sending this communication for informational purposes in the event you are contacted by a customer covered by th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 28, 2013 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

On certain 2011 and 2012 model year Prius and Highlander HV vehicles, there is a possibility that the exhaust gas control actuator may develop a coolant leak. If a coolant leak occurs, the Water Temp indicator Lamp and Check engine Lamp wi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 10, 2013 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

technicians should confirm the following key points to minimize the potential for future MIL “ON” concerns after HV Battery Replacement.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 3, 2013 140000 AIR BAGS

Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 29, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin is now obsolete. Please see T-SB-0012-13.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 25, 2018 121000 EXTERIOR LIGHTING:HEADLIGHTS

Dealer Daily Message: **UPDATED Dealer Letter Available on TIS** Customer Support Program ZHB Certain 2010- 2011 Model Year Prius Coverage for Halogen Low Beam Headlamp Bulbs. Customer Support Program ZHB Certain 2010- 2011 Model Year Prius

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 25, 2018 121000 EXTERIOR LIGHTING:HEADLIGHTS

Warranty Policy Bulletin: Toyota has received reports of customer concerns in which their vehicle?s halogen low beam headlamp bulbs lifetime is shorter than expected.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 25, 2018 121000 EXTERIOR LIGHTING:HEADLIGHTS

Dealer Package: The attached Dealer Letter has been updated. Refer to the details below. January 25, 2018 The claim filing details have been updated to clarify remedy OP Codes and Interim Op Codes for vehicles that are currently exhibiting

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 25, 2018 121000 EXTERIOR LIGHTING:HEADLIGHTS

Region Email: Toyota has received a number of reports regarding the halogen head lamps on certain 2010 ? 2011 model year Prius vehicles. In these reports, customers have indicated that their vehicle?s halogen low beam headlamp bulb lifetime

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 25, 2018 121000 EXTERIOR LIGHTING:HEADLIGHTS

Region Email: Toyota has received a number of reports regarding the halogen head lamps on certain 2010 ? 2011 model year Prius vehicles. In these reports, customers have indicated that their vehicle?s halogen low beam headlamp bulb lifetime

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 5, 2018 110000 ELECTRICAL SYSTEM

TSB: REVISION NOTICE January 05, 2018 Rev1: ? Applicability has been updated to include 2012 ? 2017 Camry HV and Prius C, 2015 ? 2017 Prius V, 2006 ? 2017 Highlander HV, 2010 ? 2016 Prius, and 2016 ? 2017 RAV4 HV model year vehicles. ? Th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 5, 2018 100001 HYBRID PROPULSION SYSTEM

TSB: REVISION NOTICE January 05, 2018 Rev1: ? Applicability has been updated to include 2012 ? 2017 Camry HV and Prius C, 2015 ? 2017 Prius V, 2006 ? 2017 Highlander HV, 2010 ? 2016 Prius, and 2016 ? 2017 RAV4 HV model year vehicles. ? Th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 2, 2017 121300 EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH

Warranty Policy Bulletin: Toyota has received reports of customer concerns in which their vehicle?s halogen low beam headlamp bulbs lifetime is shorter than expected.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2017 121300 EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH

Dealer Daily Message: Certain 2010- 2011 Model Year Prius Coverage for Halogen Low Beam Headlamp Bulbs ? The coverage parameter details have been updated to clarify coverage for vehicles that have exhibited the condition in the past.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2017 121300 EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH

Dealer Package: November 1, 2017 The coverage parameter details have been updated to clarify coverage for vehicles that have exhibited the condition in the past. Toyota has received a number of reports regarding the halogen head lamps on ce

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 30, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 27, 2017 162300 STRUCTURE:BODY:DOOR

TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 17, 2017 121000 EXTERIOR LIGHTING:HEADLIGHTS

TSB: REVISION NOTICE October 17, 2017 Rev1: ? The Repair Procedure section has been updated. Some 2010 ? 2011 model year Prius vehicles may exhibit a condition where a halogen low beam headlamp bulb lifetime is shorter than customer expecta

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 23, 2015 353000 EQUIPMENT:ELECTRICAL

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 23, 2015 353000 EQUIPMENT:ELECTRICAL

TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2015 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2015 353000 EQUIPMENT:ELECTRICAL

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 22, 2014 100000 POWER TRAIN

Electronic Communication: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for repairs related to failure of the Intelligent Power Mod

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 22, 2014 110000 ELECTRICAL SYSTEM

Electronic Communication: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for repairs related to failure of the Intelligent Power Mod

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 10, 2015 110000 ELECTRICAL SYSTEM

TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 9, 2015 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 12, 2014 110000 ELECTRICAL SYSTEM

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 13, 2015 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 2, 2015 353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 2, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 12, 2015 353000 EQUIPMENT:ELECTRICAL

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 12, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 12, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 15, 2014 060000 ENGINE AND ENGINE COOLING

Tech Tip: Some customers may experience a Knocking sound and/or Runs Rough on engine start following a cold soak. This may or may not occur with DTC(s) P0300, P0301, P0302, P0303 and / or P0304.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 13, 2014 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 13, 2014 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 13, 2014 118000 ELECTRICAL SYSTEM:SOFTWARE

Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 10, 2015 110000 ELECTRICAL SYSTEM

TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 10, 2015 353000 EQUIPMENT:ELECTRICAL

TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 9, 2015 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 13, 2015 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2015 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: When updating either the navigation or radio firmware, verify the vehicle applicability BEFORE beginning the update.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2015 353000 EQUIPMENT:ELECTRICAL

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

TT: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems. Refer to the chart below for a comprehensive list of all current and previously issued USB SSTs and their applicabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 2, 2015 353000 EQUIPMENT:ELECTRICAL

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 2, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 2, 2015 118000 ELECTRICAL SYSTEM:SOFTWARE

TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 16, 2014 100000 POWER TRAIN

TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 16, 2014 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 16, 2014 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 14, 2014 110000 ELECTRICAL SYSTEM

Dealer Letter: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for repairs related failure of the Intelligent Power Module (IPM). The

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 14, 2014 100000 HYBRID POWERTRAIN: INVERTER

Dealer Letter: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for repairs related failure of the Intelligent Power Module (IPM). The

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 13, 2014 110000 ELECTRICAL SYSTEM

Region Letter: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for repairs related to failure of the Intelligent Power Module (IPM).

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 13, 2014 100000 HYBRID POWERTRAIN: INVERTER

Region Letter: In our continuing efforts to ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for repairs related to failure of the Intelligent Power Module (IPM).

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 19, 2014 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

Tech Tip: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 19, 2014 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Tech Tip: Since MY 2011, several different update or upgrade USB SSTs have been issued for Toyota audio and navigation systems.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 14, 2014 100000 HYBRID POWERTRAIN: INVERTER

TSB: The purpose of this general information Service Bulletin is to inform the market that sub-component diagnosis and replacement is now available for the Hybrid Inverter with Converter assembly equipped on 2010 – 2014 model year Prius veh

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 30, 2015 060000 ENGINE AND ENGINE COOLING

TSB: Some 2010 – 2013 model year Prius and 2012 – 2013 model year Prius V vehicles may exhibit a MIL “ON” condition with Diagnostic Trouble Code(s) (DTCs) P0A0F (Engine Failed to Start), caused by Purge VSV/PCV line separation from the th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 30, 2015 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

TSB: Some 2010 – 2013 model year Prius and 2012 – 2013 model year Prius V vehicles may exhibit a MIL “ON” condition with Diagnostic Trouble Code(s) (DTCs) P0A0F (Engine Failed to Start), caused by Purge VSV/PCV line separation from the th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 2015 100000 HYBRID POWERTRAIN: INVERTER

TSB: The purpose of this general information Service Bulletin is to inform the market that sub-component diagnosis and replacement is now available for the Hybrid Inverter with Converter assembly equipped on 2010 – 2015 model year Prius and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 2015 100001 HYBRID PROPULSION SYSTEM

TSB: The purpose of this general information Service Bulletin is to inform the market that sub-component diagnosis and replacement is now available for the Hybrid Inverter with Converter assembly equipped on 2010 – 2015 model year Prius and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 30, 2015 060000 ENGINE AND ENGINE COOLING

TSB: Some 2010 – 2013 model year Prius and 2012 – 2013 model year Prius V vehicles may exhibit a MIL “ON” condition with Diagnostic Trouble Code(s) (DTCs) P0A0F (Engine Failed to Start), caused by Purge VSV/PCV line separation from the th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 30, 2015 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

TSB: Some 2010 – 2013 model year Prius and 2012 – 2013 model year Prius V vehicles may exhibit a MIL “ON” condition with Diagnostic Trouble Code(s) (DTCs) P0A0F (Engine Failed to Start), caused by Purge VSV/PCV line separation from the th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 2, 2015 060000 ENGINE (PWS)

TSB: OBSOLETE NOTICE-May 26, 2015: This bulletin is now obsolete. Please see T-SB-0041-15.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 2, 2015 100001 HYBRID PROPULSION SYSTEM

TSB: OBSOLETE NOTICE-May 26, 2015: This bulletin is now obsolete. Please see T-SB-0041-15.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 16, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Warranty Policy Bulletin (POL16-04): Toyota has received reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve in some vehicles. If this occurs, the vehicle may

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 16, 2016 060000 ENGINE (PWS)

Warranty Policy Bulletin (POL16-04): Toyota has received reports of a rough idle and/or rattle noise from the transaxle at cold start due to a sticking Exhaust Gas Recirculation (EGR) Valve in some vehicles. If this occurs, the vehicle may

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2016 060000 ENGINE AND ENGINE COOLING

TSB: REVISION NOTICE August 11, 2016 Rev1: Applicability has been updated to include 2016 model year Prius V vehicles. Any previous printed versions of this bulletin should be discarded. Some 2010 – 2015 model year Prius (2ZR-FXE equipp

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 11, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

TSB: REVISION NOTICE August 11, 2016 Rev1: Applicability has been updated to include 2016 model year Prius V vehicles. Any previous printed versions of this bulletin should be discarded. Some 2010 – 2015 model year Prius (2ZR-FXE equipp

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 19, 2015 060000 ENGINE AND ENGINE COOLING

TSB: Some 2010 – 2015 model year Prius (2ZR-FXE equipped) vehicles and 2012 – 2015 model year Prius PHV and Prius V (2ZR-FXE equipped) vehicles may exhibit a “runs rough” and/or MIL “ON” condition with DTC(s) P030# (Misfire) during light ac

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 19, 2015 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

TSB: Some 2010 – 2015 model year Prius (2ZR-FXE equipped) vehicles and 2012 – 2015 model year Prius PHV and Prius V (2ZR-FXE equipped) vehicles may exhibit a “runs rough” and/or MIL “ON” condition with DTC(s) P030# (Misfire) during light ac

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 11, 2016 110000 ELECTRICAL SYSTEM

TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 11, 2016 350000 EQUIPMENT

TT: HV BATTERIES HAVE LIQUID FILLED CELL MODULES, TO PREVENT LEAKAGE FROM CELLS, IT IS VERY IMPORTANT TO CONFIRM THE PROPER ORIENTATION MARK OF THE DRC.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 23, 2012 060000 ENGINE (PWS)

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 22, 2010 046100 SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE

TOYOTA: WHEN STOPPED THERE MAY BE AN ABNORMAL NOISE WHEN THE BRAKE PEDAL IS RELEASED. THIS IS A SOFTWARE PROBLEM. 2010-2011 PRIUS. *RM

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 15, 2015 110000 ELECTRICAL SYSTEM

TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 15, 2015 060000 ENGINE (PWS)

TT: THE VEHICLE MAY BE DIFFICULT TO START OR HAVE AN ABNORMALLY LOW OR ROUGH IDLE AFTER THE BATTERY HAS BEEN DISCONNECTED OR POWER TO THE ENGINE ECM HAS BEEN INTERRUPTED.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 2, 2015 060000 ENGINE AND ENGINE COOLING

TSB: OBSOLETE NOTICE-May 26, 2015: This bulletin is now obsolete. Please see T-SB-0041-15.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 14, 2014 350000 EQUIPMENT

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 13, 2012 350000 EQUIPMENT

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 24, 2013 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 4, 2013 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 25, 2013 010000 STEERING

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 7, 2012 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 25, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 7, 2016 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TSB: FOR VEHICLES THAT ARE USED UNDER CERTAIN SEVERE OPERATING CONDITIONS, THE HV BATTERY COOLING FAN MAY EXPERIENCE AN EXCESSIVE BUILDUP OF DUST, LINT, OR OTHER DEBRIS THAT CAN REDUCE THE EFFICIENCY OF THE HV BATTERY COOLING SYSTEM. HV BA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 7, 2016 100001 HYBRID PROPULSION SYSTEM

TSB: FOR VEHICLES THAT ARE USED UNDER CERTAIN SEVERE OPERATING CONDITIONS, THE HV BATTERY COOLING FAN MAY EXPERIENCE AN EXCESSIVE BUILDUP OF DUST, LINT, OR OTHER DEBRIS THAT CAN REDUCE THE EFFICIENCY OF THE HV BATTERY COOLING SYSTEM. HV BA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 7, 2016 110000 ELECTRICAL SYSTEM

TSB: FOR VEHICLES THAT ARE USED UNDER CERTAIN SEVERE OPERATING CONDITIONS, THE HV BATTERY COOLING FAN MAY EXPERIENCE AN EXCESSIVE BUILDUP OF DUST, LINT, OR OTHER DEBRIS THAT CAN REDUCE THE EFFICIENCY OF THE HV BATTERY COOLING SYSTEM. HV BA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 7, 2016 100001 HYBRID PROPULSION SYSTEM

TSB: FOR VEHICLES THAT ARE USED UNDER CERTAIN SEVERE OPERATING CONDITIONS, THE HV BATTERY COOLING FAN MAY EXPERIENCE AN EXCESSIVE BUILDUP OF DUST, LINT, OR OTHER DEBRIS THAT CAN REDUCE THE EFFICIENCY OF THE HV BATTERY COOLING SYSTEM. HV BA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 6, 2011 140000 AIR BAGS

TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 6, 2011 220000 SEATS

TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 27, 2013 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 25, 2013 358100 EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 15, 2012 350000 EQUIPMENT

TOYOTA: VEHICLE’S SMART KEY IS INOPERATIVE, IF ANOTHER VEHICLE’S REMOTE KEY IS IN OR NEAR BY, WHEN ATTEMPTING TO START VEHICLE. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 15, 2012 356000 EQUIPMENT ADAPTIVE/MOBILITY

TOYOTA: VEHICLE’S SMART KEY IS INOPERATIVE, IF ANOTHER VEHICLE’S REMOTE KEY IS IN OR NEAR BY, WHEN ATTEMPTING TO START VEHICLE. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 31, 2016 110000 ELECTRICAL SYSTEM

WARRANTY POLICY BULLETIN (POL14-05): TOYOTA HAS RECEIVED SOME REPORTS INDICATING THE INTELLIGENT POWER MODULE (IPM) LOCATED INSIDE THE INVERTER ASSEMBLY OF THE HYBRID SYSTEM MAY FAIL. THIS CONDITION IS INDICATED BY THE HYBRID SYSTEM DIAGNO

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 31, 2016 100000 HYBRID POWERTRAIN: INVERTER

WARRANTY POLICY BULLETIN (POL14-05): TOYOTA HAS RECEIVED SOME REPORTS INDICATING THE INTELLIGENT POWER MODULE (IPM) LOCATED INSIDE THE INVERTER ASSEMBLY OF THE HYBRID SYSTEM MAY FAIL. THIS CONDITION IS INDICATED BY THE HYBRID SYSTEM DIAGNO

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2016 110000 ELECTRICAL SYSTEM

DEALER LETTER: IN THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS WHERE THE INTELLIGENT POWER MODULE (IPM) LOCATED INSIDE THE INVERTER ASSEMBLY OF THE HYBRID SYSTEM MAY FAIL. THIS CONDITION IS INDICATED BY HYBRID SYSTEM DIAGNOSTIC TROUBLE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2016 100000 HYBRID POWERTRAIN: INVERTER

DEALER LETTER: IN THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS WHERE THE INTELLIGENT POWER MODULE (IPM) LOCATED INSIDE THE INVERTER ASSEMBLY OF THE HYBRID SYSTEM MAY FAIL. THIS CONDITION IS INDICATED BY HYBRID SYSTEM DIAGNOSTIC TROUBLE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 20, 2014 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

TOYOTA: BULLETIN PROVIDING INFORMATION ON THE MAINTENANCE AND CLEANING OF EXCESSIVE DUST, LINT, AND/OR OTHER DEBRIS THAT COULD BUILDUP ON HV BATTERY COOLING FAN THAT REDUCES EFFICIENCY OF THE SYSTEM. *PE MODEL 2010-2013 PRIUS. UP

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 20, 2014 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

TOYOTA: BULLETIN PROVIDING INFORMATION ON THE MAINTENANCE AND CLEANING OF EXCESSIVE DUST, LINT, AND/OR OTHER DEBRIS THAT COULD BUILDUP ON HV BATTERY COOLING FAN THAT REDUCES EFFICIENCY OF THE SYSTEM. *PE MODEL 2010-2013 PRIUS. UP

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 15, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 30, 2015 060000 ENGINE (PWS)

TOYOTA: DIAGNOSTIC TROUBLE CODE (DTC) POAOF ENGINE FAILS TO START, WITH MALFUNCTION INDICATOR LAMP (MIL) ON DUE TO PURGE VSV/PCV LINE SEPARATION OF THROTTLE BODY HOUSING. MODEL 2010-13 PRIUS, PRIUS V. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 14, 2015 350000 EQUIPMENT

TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 14, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 10, 2010 356000 EQUIPMENT ADAPTIVE/MOBILITY

TOYOTA: FLOOR MAT INSTALLATION DURING PDS. VEHICLES EQUIPPED WITH DRIVER’S SIDE FLOOR MAT RETAINING CLIPS TO SECURE THE FLOOR MAT IN CORRECT POSITION. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 2, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 21, 2012 030000 BRAKES (PWS)

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

WARRANTY POLICY BULLETIN (POL16-04): IN THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS OF A ROUGH IDLE AND/OR RATTLE NOISE FROM THE TRANSAXLE AT COLD START DUE TO A STICKING EXHAUST GAS RECIRCULATION (EGR) VALVE. IF THIS OCCURS, THE VEHI

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

DEALER LETTER: IN THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS OF A ROUGH IDLE AND/OR RATTLE NOISE FROM THE TRANSAXLE AT COLD START DUE TO A STICKING EXHAUST GAS RECIRCULATION (EGR) VALVE. IF THIS OCCURS, THE VEHICLE MAY ILLUMINATE THE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

DEALER EMAIL: IN THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS OF A ROUGH IDLE AND/OR RATTLE NOISE FROM THE TRANSAXLE AT COLD START DUE TO A STICKING EXHAUST GAS RECIRCULATION (EGR) VALVE. IF THIS OCCURS, THE VEHICLE MAY ILLUMINATE THE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 15, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

REGION LETTER: IN THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS OF A ROUGH IDLE AND/OR RATTLE NOISE FROM THE TRANSAXLE AT COLD START DUE TO A STICKING EXHAUST GAS RECIRCULATION (EGR) VALVE. IF THIS OCCURS, THE VEHICLE MAY ILLUMINATE THE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 15, 2016 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

REGION EMAIL: IN THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS OF A ROUGH IDLE AND/OR RATTLE NOISE FROM THE TRANSAXLE AT COLD START DUE TO A STICKING EXHAUST GAS RECIRCULATION (EGR) VALVE. IF THIS OCCURS, THE VEHICLE MAY ILLUMINATE THE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 11, 2013 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 30, 2013 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 13, 2012 181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 11, 2016 350000 EQUIPMENT

TECH TIP: SOME CUSTOMERS MAY EXPERIENCE DIFFICULTY PROGRAMMING HOMELINK.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 22, 2013 190000 TIRES

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 13, 2013 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 14, 2014 350000 EQUIPMENT

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 15, 2015 060000 ENGINE (PWS)

TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. THIS BUL

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 17, 2012 121000 EXTERIOR LIGHTING:HEADLIGHTS

TOYOTA: TO ADDRESS THE ISSUE OF HALOGEN LOW BEAM HEADLAMP BULB SHORTAGE OF LIFE, THE WIRING HARNESS WAS MODIFIED AND IS AVAILABLE. MODELS 2010-2011 PRIUS. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 2012 190000 TIRES

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 2, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

SUMMARY TO BE PROVIDED ON A FUTURE DATE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2011 TOYOTA Prius

search for another vehicle