2009 TOYOTA RAV4 Recalls, Complaints and Investigations

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

16 Recalls for 2009 TOYOTA RAV4

Recall Date	Component	Summary
2013-01-16	AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE \| SEATS	Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed. Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
2016-08-12	SUSPENSION:REAR	Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle’s alignment. Remedy: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota’s numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
2016-06-02	SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER	Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed. Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
2016-02-19	SEAT BELTS:REAR/OTHER	Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame. Remedy: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota’s number for this recall is G0F.
2015-10-22	VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts. Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota’s number for this recall is C0M.
2015-09-18	VISIBILITY/WIPER	Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor. Remedy: Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota’s customer service number at 1-800-331-4331.
2014-11-19	SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER	Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4×2 and 4×4, Camry, Highlander, Tundra 4×2 and 4×4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring. Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
2013-08-28	SUSPENSION:REAR	Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle’s alignment. Remedy: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
2012-10-10	VISIBILITY:POWER WINDOW DEVICES AND CONTROLS	Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat. Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
2013-01-16	AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE \| SEATS	Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed. Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
2012-08-02	SUSPENSION:REAR	Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle’s alignment. Remedy: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
2011-02-24	VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 LEXUS LX570, 2003 THROUGH 2009 TOYOTA 4RUNNER, AND 2006 THROUGH 2010 RAV4 VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER’S FLOOR MAT. Remedy: THE REMEDY IS NOW AVAILABLE. THE SAFETY RECALL BEGAN EARLY APRIL 2011. THE REMEDY WILL INVOLVE MODIFICATION OR REPLACEMENT OF THE ACCELERATOR PEDAL AND REPLACEMENT OF ANY TOYOTA ALL-WEATHER FLOOR MAT. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
2010-01-21	VEHICLE SPEED CONTROL:ACCELERATOR PEDAL	TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION. Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
2010-02-03	EQUIPMENT:OTHER:LABELS	GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, “TIRE SELECTION AND RIMS.” THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS. Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER’S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
2010-02-03	EQUIPMENT:OTHER:LABELS	SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, “TIRE SELECTION AND RIMS.” THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS. Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
2009-06-15	EQUIPMENT:OTHER:LABELS	TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, “TIRE SELECTION AND RIMS.” Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

6 Complaints sent to the Center for Auto Safety for 2009 TOYOTA RAV4

skip to NHTSA complaints

Date			Component
2023-06-07			body & frame
2021-12-07			steering
2021-10-14			accelerator/throttle
2017-07-24
2011-05-12
2011-05-12			brakes

312 Complaints submitted to NHTSA for 2009 TOYOTA RAV4

skip to CAS complaints

Date			Component
2010-08-05			EQUIPMENT:OTHER:LABELS ODI Number: 10347685
2021-03-15			SUSPENSION ODI Number: 11402975
2021-02-15			ENGINE \| SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 11396355
2016-10-24			SUSPENSION ODI Number: 10918466
2016-09-24			SUSPENSION ODI Number: 10909484
2016-09-21			AIR BAGS ODI Number: 10908410
2017-07-07			VISIBILITY:SUN/MOON ROOF ASSEMBLY ODI Number: 11003678
2017-07-01			UNKNOWN OR OTHER ODI Number: 11002653
2017-06-08			ENGINE ODI Number: 10993941
2017-04-01			SEAT BELTS \| UNKNOWN OR OTHER ODI Number: 10969873
2017-04-15			UNKNOWN OR OTHER ODI Number: 10978650
2017-04-10			WHEELS ODI Number: 10971629
2017-03-31			SUSPENSION ODI Number: 10969690
2017-03-22			SUSPENSION ODI Number: 10967886
2017-08-09			SUSPENSION ODI Number: 11013936
2017-07-24			ENGINE ODI Number: 11010250
2017-07-27			POWER TRAIN ODI Number: 11011113
2017-08-01			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 11011968
2016-09-14			ENGINE ODI Number: 10906304
2016-09-08			UNKNOWN OR OTHER ODI Number: 10904684
2016-09-01			WHEELS ODI Number: 10903004
2016-08-30			STRUCTURE:BODY ODI Number: 10899533
2016-08-13			ENGINE \| POWER TRAIN ODI Number: 10895541
2016-08-08			SEAT BELTS ODI Number: 10894081
2016-08-09			SEAT BELTS ODI Number: 10894643
2017-03-14			SUSPENSION ODI Number: 10965942
2017-03-03			SERVICE BRAKES ODI Number: 10958567
2017-03-07			SEAT BELTS \| SUSPENSION ODI Number: 10959201
2017-02-22			ENGINE ODI Number: 10956297
2017-03-01			AIR BAGS ODI Number: 10957768
2017-03-01			SUSPENSION ODI Number: 10957751
2017-02-27			AIR BAGS ODI Number: 10957363
2017-02-07			SUSPENSION ODI Number: 10950001
2017-01-23			SEAT BELTS \| VISIBILITY/WIPER ODI Number: 10946973
2020-12-08			STRUCTURE:BODY ODI Number: 11378431
2017-01-08			FUEL/PROPULSION SYSTEM ODI Number: 10943710
2016-12-06			STEERING ODI Number: 10930216
2020-10-14			ENGINE ODI Number: 11364365
2020-09-11			STRUCTURE:BODY ODI Number: 11354369
2020-08-20			ENGINE ODI Number: 11350573
2020-05-13			POWER TRAIN ODI Number: 11324360
2020-03-06			UNKNOWN OR OTHER ODI Number: 11316507
2020-03-03			ELECTRICAL SYSTEM \| STEERING \| VISIBILITY/WIPER ODI Number: 11315921
2020-02-15			ENGINE \| SUSPENSION \| UNKNOWN OR OTHER ODI Number: 11309344
2020-01-14			FUEL/PROPULSION SYSTEM ODI Number: 11299214
2020-01-07			VEHICLE SPEED CONTROL ODI Number: 11297696
2020-01-07			VEHICLE SPEED CONTROL ODI Number: 11297729
2020-01-07			VEHICLE SPEED CONTROL ODI Number: 11297717
2019-12-10			VEHICLE SPEED CONTROL ODI Number: 11288227
2019-08-05			SERVICE BRAKES ODI Number: 11241696
2019-09-30			AIR BAGS \| FUEL/PROPULSION SYSTEM \| STRUCTURE:BODY ODI Number: 11265257
2019-09-23			AIR BAGS ODI Number: 11257309
2019-05-15			POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT ODI Number: 11207845
2019-04-02			SEAT BELTS ODI Number: 11194011
2019-06-13			STEERING ODI Number: 11219858
2018-12-11			POWER TRAIN ODI Number: 11160850
2018-08-25			ELECTRICAL SYSTEM ODI Number: 11122282
2018-08-27			VEHICLE SPEED CONTROL ODI Number: 11122739
2018-06-04			POWER TRAIN ODI Number: 11099545
2018-05-20			UNKNOWN OR OTHER ODI Number: 11096905
2018-05-16			SUSPENSION \| UNKNOWN OR OTHER ODI Number: 11096378
2018-04-10			POWER TRAIN ODI Number: 11084380
2018-03-30			STEERING ODI Number: 11082151
2018-02-12			SUSPENSION ODI Number: 11072241
2018-02-11			ENGINE \| FUEL/PROPULSION SYSTEM \| VEHICLE SPEED CONTROL ODI Number: 11072206
2018-08-02			ENGINE ODI Number: 11115390
2018-01-04			SUSPENSION ODI Number: 11058489
2017-12-14			POWER TRAIN ODI Number: 11054807
2017-11-29			SUSPENSION ODI Number: 11051182
2017-11-04			SUSPENSION ODI Number: 11043188
2016-07-28			SEATS \| UNKNOWN OR OTHER ODI Number: 10889275
2016-06-06			SEAT BELTS ODI Number: 10872780
2016-05-26			STEERING ODI Number: 10871112
2016-06-01			VEHICLE SPEED CONTROL ODI Number: 10871759
2016-04-05			VEHICLE SPEED CONTROL ODI Number: 10853547
2016-03-18			SUSPENSION ODI Number: 10850356
2016-02-19			SUSPENSION ODI Number: 10839448
2016-02-21			UNKNOWN OR OTHER ODI Number: 10837387
2016-02-05			VEHICLE SPEED CONTROL ODI Number: 10824550
2016-01-28			STEERING ODI Number: 10822958
2016-01-17			SERVICE BRAKES ODI Number: 10820673
2015-11-17			UNKNOWN OR OTHER ODI Number: 10794343
2015-09-18			ENGINE ODI Number: 10765130
2015-09-16			ELECTRICAL SYSTEM:WIRING ODI Number: 10764113
2015-08-20			STEERING ODI Number: 10750103
2015-08-07			SERVICE BRAKES \| SUSPENSION ODI Number: 10746969
2015-07-26			STRUCTURE:BODY ODI Number: 10743536
2015-07-21			SERVICE BRAKES ODI Number: 10735499
2015-07-12			ELECTRICAL SYSTEM ODI Number: 10733448
2015-07-01			ELECTRICAL SYSTEM \| ENGINE \| UNKNOWN OR OTHER ODI Number: 10731632
2015-06-01			POWER TRAIN ODI Number: 10722810
2015-04-29			POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT ODI Number: 10713529
2015-05-06			POWER TRAIN ODI Number: 10714989
2015-04-15			ELECTRICAL SYSTEM ODI Number: 10705929
2015-04-09			UNKNOWN OR OTHER ODI Number: 10705720
2015-03-31			AIR BAGS ODI Number: 10702774
2015-03-10			SUSPENSION ODI Number: 10693340
2015-03-02			POWER TRAIN ODI Number: 10691411
2015-01-31			AIR BAGS \| ENGINE \| STRUCTURE:BODY ODI Number: 10680189
2015-01-27			ENGINE ODI Number: 10679225
2015-01-12			POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT ODI Number: 10671973
2015-01-05			SUSPENSION ODI Number: 10670093
2015-01-03			STEERING ODI Number: 10669821
2014-11-24			VEHICLE SPEED CONTROL ODI Number: 10660670
2014-10-09			SUSPENSION ODI Number: 10643510
2014-10-03			SERVICE BRAKES \| SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER ODI Number: 10641261
2014-09-29			SUSPENSION ODI Number: 10639864
2014-09-08			ELECTRICAL SYSTEM \| ENGINE \| FUEL/PROPULSION SYSTEM \| POWER TRAIN ODI Number: 10631628
2014-09-17			VEHICLE SPEED CONTROL \| VISIBILITY ODI Number: 10632860
2014-09-04			POWER TRAIN ODI Number: 10630560
2014-08-29			SUSPENSION ODI Number: 10629289
2014-07-16			STEERING:LINKAGES:TIE ROD ASSEMBLY \| SUSPENSION ODI Number: 10611008
2014-07-02			SUSPENSION ODI Number: 10607854
2014-06-26			SUSPENSION ODI Number: 10606209
2014-06-20			SUSPENSION ODI Number: 10604773
2014-06-23			SUSPENSION ODI Number: 10605391
2014-06-09			SUSPENSION ODI Number: 10597127
2014-06-09			SUSPENSION ODI Number: 10597219
2014-06-06			SUSPENSION ODI Number: 10596740
2014-06-13			FUEL/PROPULSION SYSTEM \| STRUCTURE:BODY \| VEHICLE SPEED CONTROL ODI Number: 10598075
2014-06-13			WHEELS ODI Number: 10598066
2014-05-27			SUSPENSION ODI Number: 10594319
2014-06-04			SUSPENSION ODI Number: 10596192
2014-06-02			SUSPENSION ODI Number: 10595708
2014-05-28			SUSPENSION ODI Number: 10594555
2014-05-17			WHEELS ODI Number: 10592164
2014-05-16			SUSPENSION ODI Number: 10588840
2014-05-07			SUSPENSION ODI Number: 10586936
2014-04-22			CHILD SEAT ODI Number: 10584113
2014-04-18			ELECTRICAL SYSTEM \| STRUCTURE:BODY ODI Number: 10583445
2014-04-09			SUSPENSION ODI Number: 10578513
2014-04-18			SUSPENSION ODI Number: 10583510
2014-04-14			STEERING \| VEHICLE SPEED CONTROL ODI Number: 10579719
2014-04-02			SUSPENSION ODI Number: 10576745
2014-02-07			STEERING \| WHEELS ODI Number: 10563336
2014-02-12			ENGINE ODI Number: 10564052
2014-02-01			AIR BAGS \| ELECTRICAL SYSTEM ODI Number: 10562506
2014-01-31			SUSPENSION ODI Number: 10562322
2014-01-18			VEHICLE SPEED CONTROL ODI Number: 10560479
2014-01-06			VEHICLE SPEED CONTROL ODI Number: 10558629
2014-01-02			SUSPENSION ODI Number: 10558148
2013-10-31			POWER TRAIN ODI Number: 10550382
2013-10-04			TIRES ODI Number: 10546710
2013-08-08			SUSPENSION ODI Number: 10534253
2013-07-10			ENGINE ODI Number: 10524088
2013-05-30			VEHICLE SPEED CONTROL ODI Number: 10514343
2013-05-07			ENGINE ODI Number: 10510884
2013-05-16			VEHICLE SPEED CONTROL ODI Number: 10512331
2013-05-02			STEERING ODI Number: 10510352
2013-04-30			AIR BAGS \| SERVICE BRAKES ODI Number: 10510119
2013-04-02			ELECTRICAL SYSTEM \| ENGINE ODI Number: 10505370
2013-03-26			STEERING ODI Number: 10504587
2013-03-10			TIRES \| WHEELS ODI Number: 10502245
2013-02-26			AIR BAGS ODI Number: 10500123
2013-01-12			ENGINE \| POWER TRAIN ODI Number: 10492337
2013-01-28			STEERING ODI Number: 10494969
2013-01-24			SUSPENSION \| WHEELS ODI Number: 10494629
2013-01-22			STEERING ODI Number: 10493722
2012-12-14			STEERING ODI Number: 10488822
2012-12-26			ELECTRICAL SYSTEM ODI Number: 10490119
2012-10-31			STEERING ODI Number: 10482811
2012-10-24			UNKNOWN OR OTHER ODI Number: 10481941
2012-10-11			ENGINE ODI Number: 10479721
2012-09-05			POWER TRAIN ODI Number: 10474006
2012-09-07			STEERING \| SUSPENSION ODI Number: 10474250
2012-08-29			VEHICLE SPEED CONTROL ODI Number: 10472947
2012-08-08			STRUCTURE:BODY \| VEHICLE SPEED CONTROL ODI Number: 10469737
2012-08-07			VISIBILITY:SUN/MOON ROOF ASSEMBLY ODI Number: 10469558
2012-07-06			ENGINE ODI Number: 10464387
2012-05-25			AIR BAGS ODI Number: 10459633
2012-05-29			STRUCTURE:BODY ODI Number: 10459981
2012-04-14			STEERING ODI Number: 10455244
2012-03-14			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10451585
2012-03-05			SERVICE BRAKES \| VEHICLE SPEED CONTROL ODI Number: 10450353
2012-02-24			SERVICE BRAKES, HYDRAULIC \| STRUCTURE \| VEHICLE SPEED CONTROL ODI Number: 10449266
2011-12-21			TIRES ODI Number: 10440921
2011-11-10			SERVICE BRAKES, HYDRAULIC \| STEERING ODI Number: 10435196
2011-11-01			SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES ODI Number: 10433775
2011-10-27			VEHICLE SPEED CONTROL ODI Number: 10433028
2011-10-19			STEERING ODI Number: 10430776
2011-10-05			UNKNOWN OR OTHER ODI Number: 10429734
2011-09-24			ELECTRICAL SYSTEM \| SERVICE BRAKES, HYDRAULIC ODI Number: 10427030
2011-09-01			SERVICE BRAKES, HYDRAULIC ODI Number: 10422847
2011-08-15			VEHICLE SPEED CONTROL ODI Number: 10419523
2011-08-07			TIRES ODI Number: 10417861
2011-07-25			SUSPENSION:FRONT \| VEHICLE SPEED CONTROL ODI Number: 10415045
2011-07-16			ELECTRICAL SYSTEM ODI Number: 10413116
2011-07-18			VEHICLE SPEED CONTROL ODI Number: 10413398
2011-07-18			SERVICE BRAKES, HYDRAULIC \| STEERING \| VEHICLE SPEED CONTROL ODI Number: 10413368
2011-07-17			WHEELS ODI Number: 10413222
2011-06-17			VEHICLE SPEED CONTROL ODI Number: 10407298
2011-05-31			SERVICE BRAKES, HYDRAULIC ODI Number: 10403856
2011-05-08			VEHICLE SPEED CONTROL ODI Number: 10399472
2011-04-15			ELECTRICAL SYSTEM ODI Number: 10396031
2011-02-25			VEHICLE SPEED CONTROL ODI Number: 10384469
2011-03-14			VISIBILITY ODI Number: 10390127
2011-02-22			VEHICLE SPEED CONTROL ODI Number: 10383990
2011-02-15			SERVICE BRAKES, HYDRAULIC ODI Number: 10382314
2011-01-04			SEATS ODI Number: 10374628
2011-01-18			ENGINE AND ENGINE COOLING ODI Number: 10377728
2010-12-15			SUSPENSION \| TIRES \| TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS ODI Number: 10370161
2010-11-29			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10368166
2010-12-15			POWER TRAIN ODI Number: 10370808
2010-12-03			ELECTRICAL SYSTEM ODI Number: 10369078
2010-12-06			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10369352
2010-10-03			VEHICLE SPEED CONTROL ODI Number: 10358947
2010-10-08			VEHICLE SPEED CONTROL ODI Number: 10359661
2010-10-01			VEHICLE SPEED CONTROL ODI Number: 10358731
2010-09-28			VEHICLE SPEED CONTROL ODI Number: 10358163
2010-09-10			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10355337
2010-09-05			VEHICLE SPEED CONTROL ODI Number: 10353918
2010-08-24			ELECTRICAL SYSTEM ODI Number: 10351576
2010-08-05			EQUIPMENT:OTHER:LABELS ODI Number: 10347685
2010-08-06			SEATS ODI Number: 10347601
2010-08-06			VEHICLE SPEED CONTROL ODI Number: 10347780
2010-07-23			VEHICLE SPEED CONTROL ODI Number: 10344911
2010-07-19			VEHICLE SPEED CONTROL ODI Number: 10344016
2010-07-23			ENGINE AND ENGINE COOLING ODI Number: 10344851
2010-07-23			VEHICLE SPEED CONTROL ODI Number: 10344828
2010-06-21			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10337010
2010-06-24			VEHICLE SPEED CONTROL ODI Number: 10339902
2010-06-14			VISIBILITY ODI Number: 10336194
2010-06-13			VEHICLE SPEED CONTROL ODI Number: 10336025
2010-06-03			VEHICLE SPEED CONTROL ODI Number: 10334430
2010-06-04			ENGINE AND ENGINE COOLING:ENGINE ODI Number: 10334580
2010-05-31			ENGINE AND ENGINE COOLING \| VEHICLE SPEED CONTROL ODI Number: 10333955
2010-05-24			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10331968
2010-05-27			VEHICLE SPEED CONTROL ODI Number: 10332532
2010-05-19			VEHICLE SPEED CONTROL ODI Number: 10331222
2010-05-11			STRUCTURE:FRAME AND MEMBERS ODI Number: 10329993
2010-05-10			VEHICLE SPEED CONTROL ODI Number: 10329733
2010-05-03			VEHICLE SPEED CONTROL ODI Number: 10328642
2010-05-05			VEHICLE SPEED CONTROL ODI Number: 10328945
2010-04-28			VEHICLE SPEED CONTROL ODI Number: 10327873
2010-05-03			STEERING \| SUSPENSION ODI Number: 10328512
2010-04-22			VEHICLE SPEED CONTROL ODI Number: 10326973
2010-04-07			VEHICLE SPEED CONTROL ODI Number: 10324279
2010-04-08			AIR BAGS \| VEHICLE SPEED CONTROL ODI Number: 10324542
2010-04-13			FUEL SYSTEM, GASOLINE \| VEHICLE SPEED CONTROL ODI Number: 10325505
2010-04-19			VEHICLE SPEED CONTROL ODI Number: 10326439
2010-04-16			VEHICLE SPEED CONTROL ODI Number: 10325961
2010-04-07			VEHICLE SPEED CONTROL ODI Number: 10324155
2010-04-16			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10325940
2010-03-23			VEHICLE SPEED CONTROL ODI Number: 10321639
2010-03-26			UNKNOWN OR OTHER ODI Number: 10322392
2010-04-05			VEHICLE SPEED CONTROL ODI Number: 10323812
2010-03-25			VEHICLE SPEED CONTROL ODI Number: 10322101
2010-04-06			SERVICE BRAKES, HYDRAULIC ODI Number: 10323942
2010-03-17			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10320511
2010-03-18			VEHICLE SPEED CONTROL ODI Number: 10320788
2010-03-12			FUEL SYSTEM, GASOLINE \| STEERING ODI Number: 10319317
2010-03-18			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10320730
2010-03-08			VEHICLE SPEED CONTROL ODI Number: 10317782
2010-03-04			VEHICLE SPEED CONTROL ODI Number: 10316567
2010-03-10			VEHICLE SPEED CONTROL ODI Number: 10318489
2010-03-10			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10318479
2010-03-07			SERVICE BRAKES, HYDRAULIC ODI Number: 10317429
2010-03-04			VEHICLE SPEED CONTROL ODI Number: 10316803
2010-03-08			VEHICLE SPEED CONTROL ODI Number: 10317846
2010-03-10			SERVICE BRAKES, HYDRAULIC ODI Number: 10318740
2010-03-07			VEHICLE SPEED CONTROL ODI Number: 10317489
2010-03-08			SERVICE BRAKES, HYDRAULIC \| VEHICLE SPEED CONTROL ODI Number: 10317813
2010-03-04			VEHICLE SPEED CONTROL ODI Number: 10316580
2010-03-03			VEHICLE SPEED CONTROL ODI Number: 10316217
2010-03-01			VEHICLE SPEED CONTROL:ACCELERATOR PEDAL ODI Number: 10315105
2010-02-26			VEHICLE SPEED CONTROL ODI Number: 10314675
2010-02-24			SERVICE BRAKES, ELECTRIC \| VEHICLE SPEED CONTROL ODI Number: 10313702
2010-02-23			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10313415
2010-02-24			VEHICLE SPEED CONTROL ODI Number: 10313650
2010-02-23			ENGINE AND ENGINE COOLING ODI Number: 10313019
2010-02-23			ENGINE AND ENGINE COOLING:ENGINE \| SERVICE BRAKES, HYDRAULIC \| VEHICLE SPEED CONTROL ODI Number: 10313319
2010-02-20			VEHICLE SPEED CONTROL ODI Number: 10312394
2010-02-15			SERVICE BRAKES, HYDRAULIC ODI Number: 10310462
2010-02-17			VEHICLE SPEED CONTROL ODI Number: 10311341
2010-02-17			SERVICE BRAKES, HYDRAULIC ODI Number: 10311175
2010-02-17			STRUCTURE ODI Number: 10311318
2010-02-13			VEHICLE SPEED CONTROL ODI Number: 10310198
2010-02-09			ELECTRONIC STABILITY CONTROL \| STEERING ODI Number: 10307876
2010-02-05			SERVICE BRAKES, HYDRAULIC ODI Number: 10306456
2010-02-04			VEHICLE SPEED CONTROL ODI Number: 10305953
2010-02-04			POWER TRAIN ODI Number: 10305774
2010-02-05			VEHICLE SPEED CONTROL ODI Number: 10306856
2010-02-04			VEHICLE SPEED CONTROL ODI Number: 10305253
2010-02-04			FUEL SYSTEM, GASOLINE \| VEHICLE SPEED CONTROL ODI Number: 10305089
2010-02-04			VEHICLE SPEED CONTROL ODI Number: 10305072
2010-02-03			ENGINE AND ENGINE COOLING ODI Number: 10304202
2010-02-03			VEHICLE SPEED CONTROL ODI Number: 10304801
2010-02-03			VEHICLE SPEED CONTROL ODI Number: 10304501
2010-02-01			VEHICLE SPEED CONTROL ODI Number: 10303703
2010-01-26			EQUIPMENT ODI Number: 10302447
2009-12-23			ELECTRICAL SYSTEM ODI Number: 10296791
2010-01-08			VEHICLE SPEED CONTROL ODI Number: 10298754
2009-12-16			UNKNOWN OR OTHER ODI Number: 10296163
2009-11-30			VEHICLE SPEED CONTROL ODI Number: 10293991
2009-12-05			STRUCTURE:BODY \| TIRES ODI Number: 10294582
2009-11-13			UNKNOWN OR OTHER ODI Number: 10291751
2009-11-08			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10291419
2009-11-08			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10291418
2009-10-13			POWER TRAIN:AUTOMATIC TRANSMISSION ODI Number: 10287217
2009-09-30			AIR BAGS:FRONTAL ODI Number: 10285819
2009-10-01			ELECTRONIC STABILITY CONTROL \| TRACTION CONTROL SYSTEM ODI Number: 10285973
2009-09-17			WHEELS ODI Number: 10284249
2009-09-25			SERVICE BRAKES, HYDRAULIC ODI Number: 10285198
2009-10-05			VEHICLE SPEED CONTROL ODI Number: 10286348
2009-08-16			TIRES ODI Number: 10280567
2009-05-30			SEATS ODI Number: 10272422
2017-07-20			SUSPENSION ODI Number: 11006600
2015-01-12			ELECTRICAL SYSTEM ODI Number: 10671800
2010-03-02			SERVICE BRAKES, HYDRAULIC ODI Number: 10315500
2010-02-22			VEHICLE SPEED CONTROL ODI Number: 10312900
2009-05-28			ELECTRICAL SYSTEM ODI Number: 10270200
2010-02-04			ENGINE AND ENGINE COOLING:COOLING SYSTEM ODI Number: 10305200

Is the government investigating the safety of your vehicle? Find out here.

8 Investigations for 2009 TOYOTA RAV4

On february 16, 2010, nhtsa's office of defects investigation (odi) opened rq10-003 to determine whether the scope of prior toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, toyota recalls 07e-082, 09v-388, 10v-017, and 10v-023.nhtsa also requested information regarding potential electronic causes of unintended acceleration in toyota and lexus vehicles.i. pedal interference from floor mats, carpet covers and plastic pads in carpets.during the rq10-003 investigation, odi reviewed a large volume of documents to assess whether additional vehicles should be recalled.following the agency's analysis, nhtsa requested that toyota recall additional vehicles.toyota complied with the agency's request.the details of these recalls are set forth more fully in toyota's reports to nhtsa pursuant to 49 cfr part 573.these recalls are as follows:recall 11v-112: (1) model year (my) 2004-2006 toyota highlander and highlander hybrid; and, (2) my 2004-2007 lexus rx330,rx350, and rx400h (hybrid model). the total estimated population under this recall is 769,379 vehicles.this recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). recall 11v-113: (1) my 2003-2009 through 2009 toyota 4runner; (2) my 2006-2010 toyota rav4; and, (3) my 2008-2011 lexus lx570.the total estimated population under this recall is 1,381,000 vehicles.this recall supplements recall 09v-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.recall 11v-115: (1) my 2006-2007 lexus gs300 (all wheel drive vehicles); and, (2) my 2006-2007 lexus gs350 (all wheel drive vehicles). the total estimated population under this recall is 19,647 vehicles.this recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.ii. potential electronic causes of unintended acceleration.after nhtsa opened rq10-003, nhtsa launched a ten-month study of potential electronic causes of unintended acceleration in toyota vehicles.nhtsa launched the study in the spring of 2010 in light of concerns aired in congressional hearings.nhtsa enlisted engineers at the national aeronautics and space administration (nasa) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in toyota vehicles.that study has concluded.two reports are associated with the study and are available on nhtsa's website.nasa's report is entitled "technical support to the national highway traffic safety administration (nhtsa) on the reported toyota motor corporation (tmc) unintended acceleration (ua) investigation," nesc assessment no. ti-10-00618 (jan. 18, 2011).nhtsa's report is entitled "technical assessment of toyota electronic throttle control (etc) systems" (feb. 2011).both reports should be read in conjunction with each other. as stated in its report, nasa did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. nhtsa did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by toyota's recalls. this rq is closed.

Date Opened	Date Closed	Component
2012-06-14	2013-02-12	UNKNOWN OR OTHER
2012-02-06	2012-06-14	STRUCTURE:BODY
2012-02-06	2012-06-14	UNKNOWN OR OTHER
2012-06-14	2013-02-12	ELECTRICAL SYSTEM
2012-06-14	2013-02-12	STRUCTURE:BODY
2010-02-16	2011-03-01	VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
2012-02-06	2012-06-14	ELECTRICAL SYSTEM
2010-02-16	2011-03-01	ELECTRICAL SYSTEM:SOFTWARE

Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

314 Service Alerts for 2009 TOYOTA RAV4

Date	Description
2022-04-14	350000 EQUIPMENT Toyota Safety Recall and Service Campaign – Technician Certification Requirements 4.14.2022 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-17	030000 SERVICE BRAKES, HYDRAULIC TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-17	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-04-28	350000 EQUIPMENT CSP: Customer Support Program ZKG – Paint Repair Process Operation Flow Chart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-03-09	050000 PARKING BRAKE TSB: This Service Bulletin includes procedures to replace damaged or loose front carpet floor retainer(s) without replacing the carpet assembly. Follow the Repair Procedure in this bulletin to replace the loose or damaged carpet floor retai Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	190000 TIRES POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	200000 WHEELS POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2022-01-12	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-11-23	160000 STRUCTURE TSB: Some 2005 ? 2022 model year Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty smell is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The pur Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-10-28	160000 STRUCTURE DL: CUSTOMER SUPPORT PROGRAM ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1991-01-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-12-12	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1989-06-30	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1993-04-09	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
1991-01-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Product general information. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2001-05-04	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Replacement vin plates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-17	140000 AIR BAGS Toyota Safety Recall and Service Campaign – Technician Certification Requirements Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-12	030000 BRAKES (PWS) TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-12	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-03-08	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL OBSOLETE NOTICE March 08, 2021: This bulletin is now obsolete. Please see T-SB-0044-16. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2021-02-03	350000 EQUIPMENT TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the re Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	030000 BRAKES (PWS) TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	280000 BACK OVER PREVENTION TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-10-21	062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS TT: HVAC drain tube is found to be blocked/clogged. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-12-14	030000 SERVICE BRAKES, HYDRAULIC TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-03	063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but part Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL DL: Toyota plans to send Safety Recall Follow-Up Notices for the above referenced campaigns to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-14	350000 EQUIPMENT ZKG WEBSITE PROPER PHOTOGRAPH SUBMISSION Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-14	356000 EQUIPMENT ADAPTIVE/MOBILITY ZKG WEBSITE PROPER PHOTOGRAPH SUBMISSION Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-14	350000 EQUIPMENT TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-09-14	356000 EQUIPMENT ADAPTIVE/MOBILITY TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL DE: Safety Recall is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Follow-Up Notices to remind owners whose vehicles have not yet had Safety Recall repairs completed for the ca Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL RE: Toyota will be sending Safety Recall Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL DL: Safety Recall completion is an important part of our commitment to customer satisfaction of Toyota products. Toyota will be conducting follow-up notifications to remind owners whose vehicles have not yet had Safety Recall repairs comp Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL RL: Toyota plans to conduct Safety Recall follow-up notifications to owners whose vehicles have not yet had the following Safety Recall repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-06	162000 STRUCTURE:BODY DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-06	350000 EQUIPMENT DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-08-06	356000 EQUIPMENT ADAPTIVE/MOBILITY DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-23	020000 SUSPENSION TSB: OBSOLETE NOTICE June 23, 2020: This bulletin is now obsolete. Please see T-SB-0063-20. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-23	200000 WHEELS TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. ST005-01, SU001-08, and T-SB-0391-08. The aforementioned bulletins are obsolete, and any printed versions should be discarded. Be sure Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-15	162000 STRUCTURE:BODY TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-15	350000 EQUIPMENT TI: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Factory-Applied Paint Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-15	160000 STRUCTURE DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-05-15	350000 EQUIPMENT DL: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied during the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-07-30	062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM TT: HVAC drain tube is found to be blocked/clogged. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-06-03	063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR These SKUs are Exhaust Manifolds with Catalytic Converters. The customer communication requested return of unsold inventory due to a loss of CARB certification. These SKUs can no longer be sold as they do not meet CARB standards, but part Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-07	350000 EQUIPMENT TSB: OBSOLETE NOTICE April 07, 2020: This bulletin is now obsolete. Please see T-SB-0032-20. Replacement Certification Labels and VIN Plates Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-04-06	350000 EQUIPMENT TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, PG006-01, PG004-97, T-SB-0144-08, and T-SB-0304-17. The a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-12	350000 EQUIPMENT Technical Instructions: Customer Support Program ZKG ? Technical Instructions. December 12, 2019. This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-12	356000 EQUIPMENT ADAPTIVE/MOBILITY Technical Instructions: Customer Support Program ZKG ? Technical Instructions. December 12, 2019. This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-12	350000 EQUIPMENT Dealer Package: December 12, 2019 This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. However, after confirming that the pain Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-12	356000 EQUIPMENT ADAPTIVE/MOBILITY Dealer Package: December 12, 2019 This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. However, after confirming that the pain Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Dealer Package: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied du Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Dealer Email: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied duri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Dealer Daily Message: *Phase 2 ? Customer Renotification and Repair Phase* Repair is Now Available Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super White (040) Paint Color Coverage for Peeling of Fact Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE TSB: Some 2008 ? 2019 model year Toyota vehicles painted with either 070 Blizzard Pearl or 040 Super White may exhibit peeling paint on one or more metal body panels. The paint may peel between the primer and E-coat layer, exposing the gray Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Technical Instructions: TECHNICAL INSTRUCTIONS Customer Support Program ZKG Phase 2 ? Customer Renotification and Repair Phase Repair is Now Available Multiple Models and Model Years Vehicles Painted with Blizzard Pearl (070) or Super Whit Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Repair Process: Customer Support Program ZKG ? Paint Repair Process. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Region Letter: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied dur Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-04	160000 STRUCTURE Region Email: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied duri Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-02-06	350000 EQUIPMENT TSB: Some 2004 ? 2017 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-23	350000 EQUIPMENT Region Letter: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following infor Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-23	350000 EQUIPMENT Region Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-23	350000 EQUIPMENT Dealer Package: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following info Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-10-23	350000 EQUIPMENT Dealer Email: Toyota will be sending Safety Recall/Special Service Campaign Follow-Up Notices to owners whose vehicles have not yet had the following Safety Recall/Special Service Campaign repairs completed. Please note the following inform Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-12-19	356000 EQUIPMENT ADAPTIVE/MOBILITY Technical Instructions: December 12, 2019. This document has been updated to clarify that only authorized Toyota dealerships are authorized to confirm if the paint peeling condition is covered by this program. However, after confirming that Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-02-12	350000 EQUIPMENT OBSOLETE NOTICE February 12, 2020: This bulletin is now obsolete. Please see T-SB-0010-20. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2020-01-27	350000 EQUIPMENT TSB: Vehicles may display evidence of a fluid leak or fluid seep from powertrain components. This bulletin explains how to determine the differences between a fluid leak versus a fluid seep. Cases that are determined to be a ?leak? should b Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-09	356000 EQUIPMENT ADAPTIVE/MOBILITY TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin No. T-SB-0033-14. ? Applicability has been updated to include 2019 model year Toyota vehicles. Service Bulletin No. T-SB-0033-14 is obsolete and Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	100000 POWER TRAIN TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	110000 ELECTRICAL SYSTEM TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-07-01	060000 ENGINE (PWS) TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has be Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-09-26	030000 BRAKES (PWS) TSB: REVISION NOTICE September 26, 2019 Rev1: ? The Warranty Information, Parts Information, and Repair Procedure sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2018 model year RA Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-08	162000 STRUCTURE:BODY Region Letter: Phase 1 ? Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports ind Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-09	162000 STRUCTURE:BODY Dealer Email: Phase 1 – Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-09	162000 STRUCTURE:BODY Dealer Package: Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indicate that vehicles with these specific paint colors, applied du Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-09	162000 STRUCTURE:BODY Dealer Package: Phase 1 – Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports ind Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-08-08	162000 STRUCTURE:BODY Region Email: Phase 1 – Customer Notification Phase Repair Not Yet Available. Toyota has received reports of paint peeling on certain vehicles with the original factory-applied Blizzard Pearl or Super White paint colors. These reports indic Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-12	030000 SERVICE BRAKES, HYDRAULIC TSB: Some 2009 ? 2018 model year RAV4 and 2017 ? 2018 model year iM vehicles may exhibit a grind/groan noise from the front brake pads. An updated pad kit is now available as a service part. Follow the Repair Procedure in this bulletin to a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-03-12	034520 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS TSB: Some 2009 ? 2018 model year RAV4 and 2017 ? 2018 model year iM vehicles may exhibit a grind/groan noise from the front brake pads. An updated pad kit is now available as a service part. Follow the Repair Procedure in this bulletin to a Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-14	060000 ENGINE (PWS) TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Sma Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Sma Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Sma Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	110000 ELECTRICAL SYSTEM Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	350000 EQUIPMENT Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	353000 EQUIPMENT:ELECTRICAL Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2019-02-25	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TT: HVAC drain tube is found to be blocked/clogged. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-14	110000 ELECTRICAL SYSTEM TSB: Supersession Notice. Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Technical Instructions: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Sma Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Dealer Package: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Dealer Package email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Region Letter: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Stop T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-09-08	060000 ENGINE (PWS) Region Letter email: In our continuing effort to ensure the best in customer satisfaction, Toyota has converted Limited Service Campaign (LSC) BST into Special Service Campaign (SSC) BST with no expiration date. Toyota will install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-01-06	110000 ELECTRICAL SYSTEM TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0101-11. Applicability has been updated to include 2016 ? 2017 model year vehicles. Service Bulletin No. T-SB-0101-11 is Obsolete and any printed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	350000 EQUIPMENT TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	356000 EQUIPMENT ADAPTIVE/MOBILITY TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-02	021600 SUSPENSION:FRONT:WHEEL BEARING TSB: Some 2006 – 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this co Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-02	100000 POWER TRAIN TSB: Some 2006 – 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this co Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-12-12	100000 POWER TRAIN TSB: REVISION NOTICE December 12, 2017 Rev1: The Warranty and Parts Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2011 model year RAV4 vehicles equipped with the 2AR Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-21	350000 EQUIPMENT Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-07-21	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Update on Technician Certification Requirements. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-07-31	350000 EQUIPMENT TSB: REVISION NOTICE July 31, 2018 Rev2: ? The Supersession Notice has been updated. January 11, 2018 Rev1: ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	350000 EQUIPMENT Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	355100 EQUIPMENT:OTHER:LABELS Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	350000 EQUIPMENT Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-08-31	355100 EQUIPMENT:OTHER:LABELS Technical Service Bulletin: OBSOLETE NOTICE: July 31, 2018: This bulletin is now obsolete. Please see T-SB-0304-17. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-12-12	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) TSB: REVISION NOTICE December 12, 2017 Rev1: ? The Warranty and Parts Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2011 model year RAV4 vehicles equipped with the 2 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-12-12	060000 ENGINE (PWS) TSB: REVISION NOTICE December 12, 2017 Rev1: ? The Warranty and Parts Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2011 model year RAV4 vehicles equipped with the 2 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	110000 ELECTRICAL SYSTEM TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	350000 EQUIPMENT TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: The breather plug should be replaced during any differential/transfer case repairs to prevent possible repeat failures. The subsequent use of the original breather plug after a repair has been found to contribute to the failure of the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	100000 POWER TRAIN As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-26	110000 ELECTRICAL SYSTEM The vehicle will not start or ready0on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. If the operator attempts to ready-on or start the vehicle while there is tension on Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-08-31	118000 ELECTRICAL SYSTEM:SOFTWARE TechTip: Condition: Customers may experience connectivity issues when the following conditions are met: The customer?s iPhone is operating on iOS9 firmware The customer?s iPhone is connected to the vehicle via Bluetooth. If the veh Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-08-24	100000 POWER TRAIN TechTip: Condition – The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-14	180000 VEHICLE SPEED CONTROL The Federal Court in Orange County, CA today continued a Fairness Hearing regarding the proposed settlement of the consolidated Economic L:oss Class Actions relating to claims of unintended acceleration. The new (continued) date for Fairne Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-12	180000 VEHICLE SPEED CONTROL On June 14, 2013 the Federal Court in Orange County, California will conduct a Fairness Hearing regarding the proposed settlement of the consolidated Economic Loss Class Actions. Dealerships may notice media coverage of this Fairness Heari Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-12	181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL On June 14, 2013 the Federal Court in Orange County, California will conduct a Fairness Hearing regarding the proposed settlement of the consolidated Economic Loss Class Actions. Dealerships may notice media coverage of this Fairness Heari Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-14	105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT Some 2006 ? 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this condition Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	180000 VEHICLE SPEED CONTROL On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the third phase of a Limited Service Campaign to install Smar Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the third phase of a Limited Service Campaign to install Smar Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-25	130000 VISIBILITY Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	355100 EQUIPMENT:OTHER:LABELS This bulletin is now obsolete. Please see T-SB-0054-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-23	350000 EQUIPMENT California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guide Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-04	280000 BACK OVER PREVENTION If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-04-04	358100 EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-18	180000 VEHICLE SPEED CONTROL As communicated in mid-June 2013, the Federal Court in Orange County, California continued the Fairness Hearing regarding the proposed settlement of the consolidated Economic Loss Class Actions related to claims of unintended acceleration u Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-20	140000 AIR BAGS TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-07-20	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-01	100000 POWER TRAIN The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-19	130000 VISIBILITY/WIPER (PWS) This bulletin is now obsolete. Please see T-SB-0185-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-20	250000 ELECTRONIC STABILITY CONTROL Some 2006 ? 2012 model year RAV4 vehicles may exhibit a clunking noise coming from the rear of the vehicle. Upon inspection, one or both of the rear stabilizer links may be damaged. Follow the repair in this bulletin to address this conditi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-20	280000 BACK OVER PREVENTION Some 2006 ? 2012 model year RAV4 vehicles may exhibit a clunking noise coming from the rear of the vehicle. Upon inspection, one or both of the rear stabilizer links may be damaged. Follow the repair in this bulletin to address this conditi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-19	130000 VISIBILITY The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	060000 ENGINE (PWS) Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1AR-FE or 2AR-FE engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. Follow the repair proced Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-06	150000 SEAT BELTS The customer (individual requiring the extender) must visit a Toyota dealership to have the required measurements made and to complete the Seat Belt Extender Worksheet. The worksheet will allow the proper fitting and selection of a Seat Bel Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-23	132000 VISIBILITY:GLASS, SIDE/REAR The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	140000 AIR BAGS Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	220000 SEATS Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-11-04	350000 EQUIPMENT Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	110000 ELECTRICAL SYSTEM These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	353000 EQUIPMENT:ELECTRICAL These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone d Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-12	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	050000 PARKING BRAKE A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-09	350000 EQUIPMENT A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the B Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-11	118000 ELECTRICAL SYSTEM:SOFTWARE Tech Tip: Some customers may experience difficulty programming HomeLink. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	060000 ENGINE (PWS) TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bull Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-14	140000 AIR BAGS Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-01-23	190000 TIRES Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Toyota will be sending Safety Recall Follow Up Notices to remind owners whose vehicles have not yet had campaign repair completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-25	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Toyota will be sending Safety Recall Follow Up Notices to remind owners whose vehicles have not yet had campaign repair completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-28	350000 EQUIPMENT Customer complains of Bluetooth connectivity concerns such as: Difficulty to pair phone, Intermittent Bluetooth failure to connect to the vehicle when first turning on the vehicle. These concerns can be caused by changes made on the custom Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-05	030000 SERVICE BRAKES, HYDRAULIC A key part to maintain the proper function and safe operation of the vehicle’s braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-02-05	350000 EQUIPMENT A key part to maintain the proper function and safe operation of the vehicle’s braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This bulletin is now obsolete. Please see T-SB-0041-13 . Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	060000 ENGINE (PWS) Immediately following a cold soak startup, some 2009 ? 2013 model year vehicles equipped with 1AR-FE or 2AR-FE engines may exhibit a brief knock/rattle noise from the engine compartment for approximately one second. Follow the repair proced Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL On July 24, 2013, the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the third phase of a Limited Service Campaign to install Smar Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-25	011000 STEERING: STEERING WHEEL/HANDLE BAR The vehicle will not start or ready-on and the steering wheel lock is engaged so that the steering wheel may only be turned very little from side-to-side. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-20	100000 POWER TRAIN This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-11-22	110000 ELECTRICAL SYSTEM TSB: REVISION NOTICE November 22, 2017 Rev1: ? Applicability has been updated to include 2014 ? 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. In the event that a Toyota vehicle becomes submerg Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-19	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Some customers may inquire about the frequency and power output of the Smart Key/Smart Entry systems used on various models. The Smart Key/Smart Entry systems conform to all applicable FCC rules. This bulletin details the applicable specifi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-29	110000 ELECTRICAL SYSTEM Tech Tip: Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-29	130000 VISIBILITY Tech Tip: Tips for writing a DPR (Dealer Product Report) on manufacturing issues for windows and windshields. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-08	140000 AIR BAGS Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-08	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: REVISION NOTICE March 08, 2017 Rev1: ? Applicability has been updated to include 2015 – 2017 model year Toyota vehicles. ? The Parts Information section has been updated. Some vehicles in particular geographic areas may exhibit a c Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-03-08	140000 AIR BAGS Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-07	980000 UNKNOWN OR OTHER TSB: OBSOLETE NOTICE: July 7, 2014: This bulletin is now obsolete. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-07	353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Region Letter: Toyota will be sending Limited Service Campaign Notices to remind owners whose vehicles have not yet had Smart Stop Technology installed on their vehicle under LSC BST. Initial notification informing customers of the availabi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-25	353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-18	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL Dealer Letter: Toyota will be sending Limited Service Campaign Notices to remind owners whose vehicles have not yet had Smart Stop Technology installed on their vehicle under LSC BST. Initial notification informing customers of the availabi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-12	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-03-08	110000 ELECTRICAL SYSTEM TT: Some customers may encounter Bluetooth connectivity concerns such as: ? Difficulty pairing the phone. ? Intermittent Bluetooth failure to connect when first turning on the vehicle. ? Various Bluetooth Audio functions are no lon Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-27	110000 ELECTRICAL SYSTEM The customer is having difficulty changing the multi-display screen from Day Mode. If the multi-display screen is set to Day Mode when the headlights are on, the setting we be memorized when the engine is turned off. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-30	020000 SUSPENSION TSB: Safety Recall CSJ (?2006 ? 2011 RAV4; Rear Lower Suspension Arm No. 1?) involves inspection of the Rear Suspension Arm No. 1 for the presence of rust, replacement of the suspension arm if necessary, and application of an epoxy material Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-07	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SSTs are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-08	280000 BACK OVER PREVENTION Some vehicles may exhibit a MIL ?ON? Diagnostic Trouble Code (DTC) P0138 and/or P0158 (Oxygen Sensor Circuit High Voltage Bank 1 or 2). In some instances a P2195 or P2197 (A/F Sensor Signal Stuck Lean) DTC may also be present. This conditio Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-01	060000 ENGINE (PWS) Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-05-01	280000 BACK OVER PREVENTION Tech Tip: Low battery voltage can contribute to a MIL “ON” condition for P0335 (Crankshaft Position Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-11-10	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Some 2004 ? 2017 model year Toyota vehicles may exhibit odor Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-11	180000 VEHICLE SPEED CONTROL On July 24, 2013 the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the second phase of a Limited Service Campaign to install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-11	180000 VEHICLE SPEED CONTROL On July 24, 2013 the settlement of claims for Economic Loss arising from allegations of unintended acceleration was approved. As part of the settlement Toyota will be launching the second phase of a Limited Service Campaign to install Smart Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-11-29	118000 ELECTRICAL SYSTEM:SOFTWARE TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-15	060000 ENGINE (PWS) TT: The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-04	162000 STRUCTURE:BODY Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to se Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-22	190000 TIRES Please refer to the following recommendations for the best practices for vehicle tire rotations. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-02-12	190000 TIRES TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	110000 ELECTRICAL SYSTEM TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Customers may experience connectivity issues when the following conditions are met: The customer’s iPhone is operating on iOS9 firmware. The customer’s iPhone is connected to the vehicle via Bluetooth. The customer may complain of the f Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-02-12	190000 TIRES TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous print Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2018-01-11	350000 EQUIPMENT TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89 Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-01-11	350000 EQUIPMENT TECH TIP: SOME CUSTOMERS MAY EXPERIENCE DIFFICULTY PROGRAMMING HOMELINK. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	118000 ELECTRICAL SYSTEM:SOFTWARE Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-12-06	350000 EQUIPMENT A revised procedure has been developed to ensure proper removal and installation of the sun visor. Please use the following procedure for removal and installation of the sun visor. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-02	118000 ELECTRICAL SYSTEM:SOFTWARE Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin de Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This communication pertains to a current safety recall being conducted by the Southeast Toyota Distributors LLC (SET). TMS is sending this communication for informational purposes in the event you are contacted by a customer covered by th Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-10	111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY technicians should confirm the following key points to minimize the potential for future MIL “ON” concerns after HV Battery Replacement. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-03	140000 AIR BAGS Toyota vehicles are equipped with SRS, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pretensioner devi Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-01-29	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL This bulletin is now obsolete. Please see T-SB-0012-13. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	030000 SERVICE BRAKES, HYDRAULIC As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	180000 VEHICLE SPEED CONTROL As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-03-31	181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL As part of the settlement described above, Toyota will install Smart Stop Technology on the above listed model and model year vehicles. This feature will cut engine power in case of simultaneous application of both the accelerator and brake Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-10-30	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TSB: REVISION NOTICE October 30, 2017 Rev1: * Applicability has been updated to include 2018 model year vehicles. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Flash reprogramming allows the Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2017-10-27	162300 STRUCTURE:BODY:DOOR TSB: Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria lis Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-23	353000 EQUIPMENT:ELECTRICAL TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-04	021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM Dealer Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-04	021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-15	060000 ENGINE (PWS) TSB: FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DESCRIBED IN INDIVIDUAL SERVICE BULLETINS. THIS BUL Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	110000 ELECTRICAL SYSTEM TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	110000 ELECTRICAL SYSTEM TSB: THE BREATHER PLUG SHOULD BE REPLACED DURING ANY DIFFERENTIAL/TRANSFER CASE REPAIRS TO PREVENT POSSIBLE REPEAT FAILURES. THE SUBSEQUENT USE OF THE ORIGINAL BREATHER PLUG AFTER A REPAIR HAS BEEN FOUND TO CONTRIBUTE TO THE FAILURE OF THE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-25	100000 HYBRID POWERTRAIN: INVERTER TSB: THE BREATHER PLUG SHOULD BE REPLACED DURING ANY DIFFERENTIAL/TRANSFER CASE REPAIRS TO PREVENT POSSIBLE REPEAT FAILURES. THE SUBSEQUENT USE OF THE ORIGINAL BREATHER PLUG AFTER A REPAIR HAS BEEN FOUND TO CONTRIBUTE TO THE FAILURE OF THE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-06-13	181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL TOYOTA: ACCELERATOR PEDAL SENSOR ASSEMBLY INFORMATION REGARDING THE INSPECTION, REMOVAL, AND INSTALLATION, IF LUBRICATION OR OIL, IS APPLIED. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-05-08	117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL TOYOTA: MULTIPLE WARNING LIGHTS ILLUMINATED, VEHICLE NOT SHIFTING FROM PARK TO DRIVE, AND OTHER ACCESSORIES BECOMING INOPERATIVE AFTER VEHICLE HAS COLD SOAKED IN SUBFREEZING AMBIENT AIR TEMPERATURES. *PE UPDAT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-03	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL TOYOTA/LEXUS: INFORMATION REGARDING DEALER RE-NOTIFICATION, ON CERTAIN VEHICLES, OF REMEDY INSTRUCTIONS (DVD) VIA SEPARATE COVER. MODELS 2006-2011 RAV4, 2010 HS250TH. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-07	060000 ENGINE (PWS) TOYOTA: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN VEHICLES THE RUBBER OIL SUPPLY HOSE, FOR VVT-I ACTUATOR, IS DEGRADING OVER TIME AND CAUSING A LEAKAGE OF OIL, FROM OIL HOSE, PRODUCING AN ILLUMINATION OF OIL PRESSURE LIGHT Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353000 EQUIPMENT:ELECTRICAL TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-10	162000 STRUCTURE:BODY TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353000 EQUIPMENT:ELECTRICAL TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	060000 ENGINE AND ENGINE COOLING TT: Customer complaint of MIL (:Check Engine Light) ON Condition. Health Check retrieves DTC P2118 (Throttle Actuator Motor Current Range/Performance). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-13	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-13	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-13	118000 ELECTRICAL SYSTEM:SOFTWARE Tech Tip: Customer complains of carious Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	110000 ELECTRICAL SYSTEM TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-10	353000 EQUIPMENT:ELECTRICAL TSB: When servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. Many lubricants, cleaners, and automotive chemicals contain silicone or othe Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-04-09	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: Some 2004 – 2015 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bullet Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-05-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER TSB: The procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. Refer to the applicable Repair Manual for vehicle specific repair procedures and parts. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353000 EQUIPMENT:ELECTRICAL TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-02	118000 ELECTRICAL SYSTEM:SOFTWARE TT: Some customers may encounter various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing w Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-02-10	162000 STRUCTURE:BODY TSB: On some vehicles, when Rapgard is removed, the paint may have a stained appearance. These stains appear to be under the clear coat (repainting this area is not necessary). The stain patterns are usually under wrinkles in the Rapgard. T Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	100000 POWER TRAIN TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles r Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353000 EQUIPMENT:ELECTRICAL TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	118000 ELECTRICAL SYSTEM:SOFTWARE TT: Customers complain of various Bluetooth connectivity concerns after upgrading to iOS 8.0 and later. Conditions typically experienced include inability to pair the iPhone to the system, poor sound quality during phone calls placed throug Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-01-12	060000 ENGINE AND ENGINE COOLING TT: Customer complaint of MIL (:Check Engine Light) ON Condition. Health Check retrieves DTC P2118 (Throttle Actuator Motor Current Range/Performance). Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-16	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-07	060000 ENGINE AND ENGINE COOLING Dealer Letter: On certain vehicles equipped with a 2GR-FE (V6) engine, the rubber portion of the oil supply hose for the VVT-i actuator may degrade over time. This condition may cause oil to leak from the VVT-i oil hose producing abnormal e Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-08-07	060000 ENGINE AND ENGINE COOLING Region Letter: On certain vehicles equipped with a 2GR-FE (V6) engine, the rubber portion of the oil supply hose for the VVT-i actuator may degrade over time. This condition may cause oil to leak from the VVT-i oil hose producing abnormal e Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-06-30	022000 SUSPENSION:REAR SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-08	060000 ENGINE (PWS) TOYOTA: UPDATED INFORMATION REGARDING THE RESPONSE OF THE AIR FUEL RATIO SENSOR, THAT IS INCORRECT AND ALSO, AN INCORRECT OXYGEN SENSOR OPERATION MAY BE PRESENT, DUE TO ECM/PCM PROCESSOR P0606 DTC. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	060000 ENGINE (PWS) TOYOTA: ON CERTAIN VEHICLES, A KNOCK OR RATTLE NOISE, COMING FROM ENGINE COMPARTMENT, IS HEARD DURING A COLD SOAK STARTUP, AND THE CONDITION LASTS APPROXIMATELY ONE SECOND. MODEL YEARS 2009-2012 CAMRY, HIGHLANDER, SIENNA, VENZA, RAV4. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-12-20	022000 SUSPENSION:REAR TOYOTA: THERE IS A CLUNKING NOISE HEARD COMING FROM REAR OF VEHICLE AND ONE OR BOTH REAR STABILIZER LINKS ARE DAMAGED. MODEL 2006-2012 RAV4. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-07-23	353000 EQUIPMENT:ELECTRICAL TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased. Follow the procedures in this bulletin to Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 – 2014 model year automatic transmissions. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	100000 POWER TRAIN TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-09-30	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL “ON” shifting issues and/or transmission damage. Use the information in this bulletin when insta Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-08	020000 SUSPENSION TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Flat towing or towing where only the front or rear wheels are supported may damage the all-whee Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-10-08	200000 WHEELS TSB: The only acceptable towing method for vehicles equipped with an Active Torque Control 4WD system is to have all four wheels off the ground. Flat towing or towing where only the front or rear wheels are supported may damage the all-whee Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	110000 ELECTRICAL SYSTEM Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	162300 STRUCTURE:BODY:DOOR Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	350000 EQUIPMENT Region Letter: Safety Recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of Toyota products. Toyota will be sending Safety Recall Follow Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	021530 SUSPENSION:FRONT:CONTROL ARM:LOWER ARM Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	110000 ELECTRICAL SYSTEM Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	162300 STRUCTURE:BODY:DOOR Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-11-24	350000 EQUIPMENT Region Letter: Toyota will be sending Safety Recall Follow-Up Notices to remind owners whose vehicles have not yet had campaign repairs completed. Please note the following information for Regional and PD associates. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-04-08	071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY TOYOTA: 2009 RAV4. THE PAINT ON THE FUEL TANK ASSEMBLY MIGHT HAVE BEEN IMPROPERLY APPLIED AND START TO PEEL. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-02-14	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: THE MALFUNCTION LIGHT IS ON AND THERE IS A RATTLE NOISE FROM THE ENGINE. RM UPDATED 9/21/11. PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-08-03	355100 EQUIPMENT:OTHER:LABELS TOYOTA: UPDATE TO LOAD CARRYING CAPACITY MODIFICATION. ADDENDUM LABEL WAS INSTALLED AT VEHICLE PROCESSING CENTER WHEN ACCESSORIES WERE INSTALLED. THE ADDENDUM LABEL MUST BE INSTALLED WHEN ACCESSORIES ARE INSTALLED WHICH EXCEED 1.5% OF TH Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-10-24	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-27	353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM) SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-02-25	010000 STEERING SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-09-13	357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-09-06	140000 AIR BAGS TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-09-06	220000 SEATS TOYOTA: INFORMATION PROVIDED FOR REPLACING THE SEAT COVERS FOR VEHICLES EQUIPPED WITH SIDE AIRBAGS. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-02	100000 POWER TRAIN TSB: SOME 2006 – 2012 MODEL YEAR 4WD RAV4 VEHICLES MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. FOLLOW THE PROCEDURE IN THIS BULLETIN TO ADDRESS THIS CO Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2016-05-02	105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT TSB: SOME 2006 – 2012 MODEL YEAR 4WD RAV4 VEHICLES MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. FOLLOW THE PROCEDURE IN THIS BULLETIN TO ADDRESS THIS CO Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	060000 ENGINE (PWS) SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2014-07-18	350000 EQUIPMENT TOYOTA: ON SOME VEHICLES, INFORMATION BEING SENT OUT REGARDING INSTALLATION OF SMART STOP TECHNOLOGY. MODEL YEARS 2003-2010 COROLLA, COROLLA MATRIX, LAND CRUISER, HIGHLANDER RAV4, 4RUNNER, TUNDRA. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-03-15	060000 ENGINE (PWS) TOYOTA: THERE IS A KNOCKING OR RATTLING NOISE COMING FROM ENGINE COMPARTMENT, FOR A SHORT PERIOD OF TIME, AFTER A COLD SOAK STARTUP. MODEL 2010-2012 CAMRY, 2009-2013 HIGHLANDER, VENZA, 2009-2012 RAV4, 2011-2013 SIENNA. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	350000 EQUIPMENT TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-09-14	353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. TT: CUSTOMERS MAY EXPERIENCE CONNECTIVITY ISSUES WHEN THE FOLLOWING CONDITIONS ARE MET: THE CUSTOMER’S IPHONE IS OPERATING ON IOS9 FIRMWARE. THE CUSTOMER’S IPHONE IS CONNECTED TO THE VEHICLE VIA BLUETOOTH. THE CUSTOMER MAY COMPLAIN OF THE F Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-01-04	103000 POWER TRAIN:AUTOMATIC TRANSMISSION TOYOTA: 2009-2011 RAV4. THERE MAY BE A RATTLE NOISE FROM THE TRANSAXLE WHEN DRIVING AROUND 30MPH. *RM Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-03-19	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: SOME VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A TICKING/CLICKING TYPE NOISE FROM THE CYLINDER HEAD COVER AREA WHICH MAY BE ACCOMPANIED BY A MIL ON AND ONE OR MORE VVT-I RELATED DIAGNOSTIC TROUBLE CODES (DTCS). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-06-24	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2009-06-24	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) TOYOTA: VEHICLES WITH 2GR FE ENGINES MAY EXHIBIT A MIL ON CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505 STORED IN THE ENGINE CONTROL MODULE OR ECM (SAE TERM: POWERTRAIN CONTROL MODULE/PCM). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-07-25	358100 EQUIPMENT:EMERGENCY:ESCAPE/EGRESS/EXIT SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-08-01	355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2008-10-16	150000 SEAT BELTS SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-06-09	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: BRIEF ENGINE KNOCK/RATTLE NOISE COLD STARTUP. IMMEDIATELY FOLLOWING A COLD SOAK STARTUP, SOME MODEL VEHICLES EQUIPPED WITH THE 1AR-FE AND 2AR-FE ENGINES MAY EXHIBIT A BRIEF KNOCK/RATTLE NOISE FROM THE ENGINE COMPARTMENT FOR APPROX Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-05-22	190000 TIRES SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-02-22	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: ON CERTAIN MODEL VEHICLES,EQUIPPED WITH A 2GR-FE (VE) ENGINE, AN INITIATED PHASE 3 WILL REPLACE THE VVT-I OIL HOSE DUE TO THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR THE VVT-I ACTUATOR MAY DEGRADE OVER TIME. *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-02-22	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN MODEL VEHICLES EQUIPPED WITH A 2GR-FE (VE) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR THE VVT-I ACTUATOR MAY DEGRADE OVER TIME. THIS CONDITION MAY Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-03-01	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES EQUIPPED WITH A 2GR-FE (V6) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR VVT-I ACTUATOR MAY DEGRADE OVER TIME. THIS CONDITION MAY CAUSE OIL TO LEAK FR Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2011-03-01	103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM) TOYOTA SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. VEHICLES EQUIPPED WITH A 2GR-FE (V6) ENGINE, THE RUBBER PORTION OF THE OIL SUPPLY HOSE FOR VVT-I ACTUATOR MAY DEGRADE OVER TIME. THIS CONDITION MAY CAUSE OIL TO LEAK FR Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-14	021600 SUSPENSION:FRONT:WHEEL BEARING TOYOTA: THE REAR DIFFERENTIAL COUPLING, WHEN DRIVING SOME VEHICLES, MAY EXHIBIT A GROWL NOISE, DUE TO CONTAMINATION TO FRONT BEARING. MODEL 2006-2012 RAV4 (42WD). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2013-06-14	105500 POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT TOYOTA: THE REAR DIFFERENTIAL COUPLING, WHEN DRIVING SOME VEHICLES, MAY EXHIBIT A GROWL NOISE, DUE TO CONTAMINATION TO FRONT BEARING. MODEL 2006-2012 RAV4 (42WD). *PE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-12-03	100000 POWER TRAIN DD: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 4W Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2015-12-03	100000 POWER TRAIN DL: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 4WD Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2012-10-04	190000 TIRES SUMMARY TO BE PROVIDED ON A FUTURE DATE. Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")
2010-02-04	061000 ENGINE AND ENGINE COOLING:ENGINE TOYOTA: TECHSTREAM ECU FLASH REPROGRAMMING PROCEDURE. FLASH REPROGRAMMING ALLOWS THE ECU SOFTWARE TO BE UPDATED WITHOUT REPLACING THE ECU. FLASH CALIBRATION UPDATES FOR SPECIFIC VEHICLE MODELS/ECUS ARE RELEASED AS FIELD-FIX PROCEDURES DE Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

2009 TOYOTA RAV4

16 Recalls for 2009 TOYOTA RAV4

6 Complaints sent to the Center for Auto Safety for 2009 TOYOTA RAV4

312 Complaints submitted to NHTSA for 2009 TOYOTA RAV4

8 Investigations for 2009 TOYOTA RAV4

314 Service Alerts for 2009 TOYOTA RAV4

2009 TOYOTA RAV4

search for another vehicle

Related

Our Work

Press

About Us

Give Now

Address

Join our Email List

2009 TOYOTA RAV4

16 Recalls for 2009 TOYOTA RAV4

6 Complaints sent to the Center for Auto Safety for 2009 TOYOTA RAV4

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

312 Complaints submitted to NHTSA for 2009 TOYOTA RAV4

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details

Complaint Details