2004 CHEVROLET Cavalier

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

2 Recalls for 2004 CHEVROLET Cavalier

Recall Date Component Summary
October 17, 2008 STEERING

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN’S “OE SOLUTIONS” BRAND NAME), BALKAMP #’S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE “NAPA” BRAND NAME), AND PLATINUM PARTS #’S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

Remedy:

DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

June 23, 2004 SEAT BELTS:REAR/OTHER

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, ‘SEAT BELT ASSEMBLY ANCHORAGES.’ THE PASSENGER-SIDE REAR SAFETY BELT MAY HAVE BEEN INSTALLED WITH AN INCORRECT NUT AND BOLT.

Remedy:

DEALERS ARE TO INSPECT THE SAFETY BELT ANCHORAGE AND INSTALL A NEW NUT AND BOLT, IF NECESSARY. THE RECALL BEGAN ON AUGUST 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

8 Complaints sent to the Center for Auto Safety for 2004 CHEVROLET Cavalier

skip to NHTSA complaints

Date Component  
body & frame
paint
paint
paint
power options (window/door/seat/roof)
transmission
accelerator/throttle
fuel system

328 Complaints submitted to NHTSA for 2004 CHEVROLET Cavalier

skip to CAS complaints

Date Component  
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 10109182
SEAT BELTS | SEATS
ODI Number: 10918076
STEERING
ODI Number: 10985572
ELECTRICAL SYSTEM | ENGINE | UNKNOWN OR OTHER
ODI Number: 11012830
ELECTRICAL SYSTEM
ODI Number: 10907389
AIR BAGS
ODI Number: 10894003
AIR BAGS
ODI Number: 10893994
AIR BAGS
ODI Number: 10893984
ELECTRICAL SYSTEM | VEHICLE SPEED CONTROL
ODI Number: 10946542
POWER TRAIN
ODI Number: 11383222
ELECTRICAL SYSTEM
ODI Number: 10935344
SEAT BELTS
ODI Number: 11318646
VEHICLE SPEED CONTROL
ODI Number: 11281975
AIR BAGS
ODI Number: 11277967
STEERING
ODI Number: 11228454
STEERING | VEHICLE SPEED CONTROL
ODI Number: 11124077
VEHICLE SPEED CONTROL
ODI Number: 11180951
UNKNOWN OR OTHER | VISIBILITY/WIPER
ODI Number: 11080397
ELECTRICAL SYSTEM
ODI Number: 10861095
ELECTRICAL SYSTEM
ODI Number: 10853643
ELECTRICAL SYSTEM | SEAT BELTS
ODI Number: 10854186
UNKNOWN OR OTHER
ODI Number: 10811841
STEERING
ODI Number: 10818422
STEERING | SUSPENSION
ODI Number: 10811156
ELECTRICAL SYSTEM
ODI Number: 10809295
UNKNOWN OR OTHER
ODI Number: 10789816
STEERING
ODI Number: 10748651
STRUCTURE:BODY
ODI Number: 10733490
ELECTRICAL SYSTEM | STEERING
ODI Number: 10735069
ELECTRICAL SYSTEM
ODI Number: 10731076
STEERING
ODI Number: 10726245
EXTERIOR LIGHTING | SERVICE BRAKES | VEHICLE SPEED CONTROL
ODI Number: 10717248
ELECTRICAL SYSTEM:IGNITION:SWITCH | FUEL/PROPULSION SYSTEM
ODI Number: 10712311
POWER TRAIN
ODI Number: 10703449
STRUCTURE:BODY
ODI Number: 10694745
ELECTRICAL SYSTEM | VEHICLE SPEED CONTROL
ODI Number: 10691973
ELECTRICAL SYSTEM | ELECTRONIC STABILITY CONTROL | SERVICE BRAKES
ODI Number: 10680134
ELECTRICAL SYSTEM
ODI Number: 10669488
ELECTRICAL SYSTEM
ODI Number: 10671512
ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 10664660
VEHICLE SPEED CONTROL
ODI Number: 10644795
AIR BAGS
ODI Number: 10643707
ELECTRICAL SYSTEM
ODI Number: 10626856
AIR BAGS | ELECTRICAL SYSTEM | UNKNOWN OR OTHER
ODI Number: 10627972
ELECTRICAL SYSTEM | EXTERIOR LIGHTING | FUEL SYSTEM, GASOLINE
ODI Number: 10618412
VEHICLE SPEED CONTROL
ODI Number: 10615667
POWER TRAIN
ODI Number: 10608379
ELECTRICAL SYSTEM | ENGINE | UNKNOWN OR OTHER
ODI Number: 10608801
ELECTRICAL SYSTEM | ENGINE
ODI Number: 10604433
ELECTRICAL SYSTEM
ODI Number: 10606591
ELECTRICAL SYSTEM
ODI Number: 10595306
ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 10596032
ELECTRICAL SYSTEM | ENGINE | FUEL/PROPULSION SYSTEM
ODI Number: 10592115
ELECTRICAL SYSTEM
ODI Number: 10587091
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10586896
POWER TRAIN
ODI Number: 10584436
ELECTRICAL SYSTEM
ODI Number: 10577132
ELECTRICAL SYSTEM
ODI Number: 10576534
STRUCTURE:BODY
ODI Number: 10578453
ELECTRICAL SYSTEM
ODI Number: 10576075
ELECTRICAL SYSTEM
ODI Number: 10574473
ELECTRICAL SYSTEM
ODI Number: 10574009
ELECTRICAL SYSTEM
ODI Number: 10573191
AIR BAGS | ELECTRICAL SYSTEM
ODI Number: 10569185
ENGINE
ODI Number: 10572737
ELECTRICAL SYSTEM | EXTERIOR LIGHTING
ODI Number: 10569240
ELECTRICAL SYSTEM:IGNITION
ODI Number: 10568646
AIR BAGS | ELECTRICAL SYSTEM
ODI Number: 10566345
ELECTRICAL SYSTEM | ENGINE | STEERING
ODI Number: 10566028
ELECTRICAL SYSTEM
ODI Number: 10556982
ELECTRICAL SYSTEM
ODI Number: 10552663
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10543698
ELECTRICAL SYSTEM
ODI Number: 10543173
STRUCTURE:BODY | VISIBILITY/WIPER
ODI Number: 10534953
ELECTRICAL SYSTEM
ODI Number: 10520426
ELECTRICAL SYSTEM
ODI Number: 10512836
VEHICLE SPEED CONTROL
ODI Number: 10492289
ELECTRICAL SYSTEM
ODI Number: 10490067
ELECTRICAL SYSTEM
ODI Number: 10490027
ELECTRICAL SYSTEM | ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10490303
ELECTRICAL SYSTEM | ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10487609
STEERING
ODI Number: 10486035
UNKNOWN OR OTHER
ODI Number: 10486921
ELECTRICAL SYSTEM
ODI Number: 10478518
STRUCTURE:BODY
ODI Number: 10476603
ELECTRICAL SYSTEM | STEERING
ODI Number: 10461976
ENGINE
ODI Number: 10463074
FUEL/PROPULSION SYSTEM
ODI Number: 10463660
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10459199
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10456861
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10454434
ELECTRICAL SYSTEM
ODI Number: 10454555
ELECTRICAL SYSTEM | UNKNOWN OR OTHER
ODI Number: 10453435
ELECTRICAL SYSTEM | ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10450079
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10449490
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10451592
ELECTRICAL SYSTEM
ODI Number: 10446793
ENGINE AND ENGINE COOLING
ODI Number: 10443956
VISIBILITY
ODI Number: 10442249
ELECTRICAL SYSTEM
ODI Number: 10441771
ELECTRICAL SYSTEM | VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10435290
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10436212
ELECTRICAL SYSTEM
ODI Number: 10433525
VEHICLE SPEED CONTROL
ODI Number: 10433122
UNKNOWN OR OTHER | VEHICLE SPEED CONTROL
ODI Number: 10434410
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | FUEL SYSTEM, GASOLINE
ODI Number: 10428724
ELECTRICAL SYSTEM | ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | VEHICLE SPEED CONTROL
ODI Number: 10429608
ENGINE AND ENGINE COOLING | VEHICLE SPEED CONTROL
ODI Number: 10430395
POWER TRAIN | UNKNOWN OR OTHER
ODI Number: 10425840
ENGINE AND ENGINE COOLING | VEHICLE SPEED CONTROL
ODI Number: 10424030
ELECTRICAL SYSTEM | ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10419675
VEHICLE SPEED CONTROL
ODI Number: 10421204
ENGINE AND ENGINE COOLING
ODI Number: 10415586
ELECTRICAL SYSTEM
ODI Number: 10413088
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10410117
VEHICLE SPEED CONTROL
ODI Number: 10409381
ELECTRICAL SYSTEM
ODI Number: 10410711
ELECTRICAL SYSTEM
ODI Number: 10398513
FUEL SYSTEM, GASOLINE
ODI Number: 10397527
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10396038
ELECTRICAL SYSTEM
ODI Number: 10396022
ELECTRICAL SYSTEM
ODI Number: 10393861
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10384854
ELECTRICAL SYSTEM
ODI Number: 10386852
FUEL SYSTEM, OTHER
ODI Number: 10386620
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10384195
FUEL SYSTEM, GASOLINE
ODI Number: 10378619
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10379224
UNKNOWN OR OTHER
ODI Number: 10377618
ELECTRICAL SYSTEM
ODI Number: 10376981
EQUIPMENT
ODI Number: 10372222
UNKNOWN OR OTHER
ODI Number: 10374445
ELECTRICAL SYSTEM
ODI Number: 10372427
ELECTRICAL SYSTEM | ENGINE AND ENGINE COOLING:ENGINE | VEHICLE SPEED CONTROL
ODI Number: 10374119
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10370575
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10369941
ELECTRICAL SYSTEM
ODI Number: 10365140
ELECTRICAL SYSTEM | EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. | LATCHES/LOCKS/LINKAGES
ODI Number: 10367334
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10362572
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10364966
ELECTRICAL SYSTEM
ODI Number: 10356309
ELECTRICAL SYSTEM
ODI Number: 10353573
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10350843
ELECTRICAL SYSTEM
ODI Number: 10352898
EXTERIOR LIGHTING:HEADLIGHTS
ODI Number: 10348682
ELECTRICAL SYSTEM
ODI Number: 10347920
ELECTRICAL SYSTEM
ODI Number: 10348053
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10346199
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10345605
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10344259
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | ELECTRONIC STABILITY CONTROL
ODI Number: 10342906
LATCHES/LOCKS/LINKAGES | STRUCTURE
ODI Number: 10342885
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10341410
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10342456
ELECTRICAL SYSTEM
ODI Number: 10342886
ELECTRICAL SYSTEM
ODI Number: 10336856
VISIBILITY
ODI Number: 10339473
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10340007
ELECTRICAL SYSTEM
ODI Number: 10339090
ELECTRICAL SYSTEM
ODI Number: 10332550
ELECTRICAL SYSTEM
ODI Number: 10335148
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10335131
VISIBILITY
ODI Number: 10334948
ELECTRICAL SYSTEM
ODI Number: 10332142
ELECTRICAL SYSTEM
ODI Number: 10334225
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10332741
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10335043
STEERING:COLUMN
ODI Number: 10330483
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10330479
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10331802
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10319698
ELECTRICAL SYSTEM
ODI Number: 10317504
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10317325
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10315190
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10315647
STEERING
ODI Number: 10315775
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10312459
POWER TRAIN:MANUAL TRANSMISSION
ODI Number: 10312149
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10313363
ELECTRICAL SYSTEM
ODI Number: 10308860
AIR BAGS | SEATS
ODI Number: 10311397
AIR BAGS:FRONTAL | SEATS
ODI Number: 10311377
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10310213
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10310956
ELECTRICAL SYSTEM
ODI Number: 10304327
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10300295
ELECTRICAL SYSTEM
ODI Number: 10298483
AIR BAGS
ODI Number: 10294272
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10283108
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10283025
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10281315
POWER TRAIN:MANUAL TRANSMISSION
ODI Number: 10280611
ELECTRICAL SYSTEM
ODI Number: 10280228
EXTERIOR LIGHTING
ODI Number: 10280188
FUEL SYSTEM, GASOLINE
ODI Number: 10279773
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10274652
ELECTRICAL SYSTEM
ODI Number: 10274411
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10272508
EQUIPMENT:APPLIANCE:AIR CONDITIONER | EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. | FUEL SYSTEM, GASOLINE | VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10263642
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10265083
ELECTRICAL SYSTEM
ODI Number: 10258320
ELECTRICAL SYSTEM
ODI Number: 10258150
ELECTRICAL SYSTEM
ODI Number: 10258741
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10258665
POWER TRAIN | POWER TRAIN:MANUAL TRANSMISSION
ODI Number: 10255854
ELECTRICAL SYSTEM
ODI Number: 10254153
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10253913
ELECTRICAL SYSTEM
ODI Number: 10253892
POWER TRAIN:MANUAL TRANSMISSION
ODI Number: 10249893
ELECTRICAL SYSTEM
ODI Number: 10249637
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10249621
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10250935
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10251895
VISIBILITY:GLASS, SIDE/REAR
ODI Number: 10247215
POWER TRAIN:MANUAL TRANSMISSION
ODI Number: 10247640
ELECTRICAL SYSTEM
ODI Number: 10247750
ELECTRICAL SYSTEM
ODI Number: 10248312
FUEL SYSTEM, GASOLINE | VEHICLE SPEED CONTROL | VISIBILITY
ODI Number: 10249107
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10248279
ELECTRICAL SYSTEM
ODI Number: 10246305
ELECTRICAL SYSTEM
ODI Number: 10242903
ELECTRICAL SYSTEM
ODI Number: 10241595
ELECTRICAL SYSTEM
ODI Number: 10241739
ELECTRICAL SYSTEM
ODI Number: 10243107
TIRES
ODI Number: 10241938
ELECTRICAL SYSTEM | SERVICE BRAKES, HYDRAULIC
ODI Number: 10241382
POWER TRAIN:MANUAL TRANSMISSION
ODI Number: 10239176
SERVICE BRAKES, HYDRAULIC | SUSPENSION:REAR
ODI Number: 10240889
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10235679
POWER TRAIN:MANUAL TRANSMISSION
ODI Number: 10237572
SEATS
ODI Number: 10237196
VEHICLE SPEED CONTROL
ODI Number: 10230235
ELECTRICAL SYSTEM | ENGINE AND ENGINE COOLING:ENGINE | INTERIOR LIGHTING
ODI Number: 10230982
ELECTRICAL SYSTEM
ODI Number: 10232609
POWER TRAIN:MANUAL TRANSMISSION
ODI Number: 10232075
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10232178
ELECTRICAL SYSTEM
ODI Number: 10229180
SEATS
ODI Number: 10227761
ELECTRICAL SYSTEM
ODI Number: 10228725
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10224067
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
ODI Number: 10220909
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | ELECTRICAL SYSTEM:STARTER ASSEMBLY | ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10219878
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10217553
EXTERIOR LIGHTING:HEADLIGHTS | SEAT BELTS:FRONT
ODI Number: 10215510
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10211330
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10211076
ELECTRICAL SYSTEM:WIRING
ODI Number: 10208223
SEATS:FRONT ASSEMBLY:RECLINER | STRUCTURE
ODI Number: 10210240
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10209188
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10208312
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
ODI Number: 10208095
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10205531
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10201699
POWER TRAIN:CLUTCH ASSEMBLY | VEHICLE SPEED CONTROL:LINKAGES
ODI Number: 10199524
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
ODI Number: 10201764
UNKNOWN OR OTHER
ODI Number: 10196451
FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP
ODI Number: 10196231
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10187680
SEAT BELTS: REAR/OTHER:BUCKLE ASSEMBLY
ODI Number: 10175103
POWER TRAIN:CLUTCH ASSEMBLY
ODI Number: 10172741
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10171320
VEHICLE SPEED CONTROL
ODI Number: 10168681
STEERING:RACK AND PINION
ODI Number: 10168991
ELECTRICAL SYSTEM | ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH | EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. | FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM | LATCHES/LOCKS/LINKAGES:TRUNK LID:LOCK | POWER TRAIN:MANUAL TRANSMISSION | SEATS | UNKNOWN OR O
ODI Number: 10167018
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
ODI Number: 10165395
ELECTRICAL SYSTEM | ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10164658
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR
ODI Number: 10164074
EQUIPMENT | SERVICE BRAKES, HYDRAULIC | VISIBILITY
ODI Number: 10161471
SERVICE BRAKES, HYDRAULIC
ODI Number: 10158281
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH | SERVICE BRAKES, HYDRAULIC
ODI Number: 10158938
POWER TRAIN:CLUTCH ASSEMBLY
ODI Number: 10156537
AIR BAGS
ODI Number: 10157126
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10153494
SERVICE BRAKES, HYDRAULIC
ODI Number: 10152914
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH | SERVICE BRAKES, HYDRAULIC
ODI Number: 10151841
POWER TRAIN:AUTOMATIC TRANSMISSION | VEHICLE SPEED CONTROL:CRUISE CONTROL
ODI Number: 10149859
SUSPENSION:FRONT
ODI Number: 10151745
AIR BAGS:FRONTAL
ODI Number: 10151583
WHEELS:RIM
ODI Number: 10147881
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC
ODI Number: 10144376
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 10143575
ELECTRICAL SYSTEM | ENGINE AND ENGINE COOLING
ODI Number: 10142860
POWER TRAIN:MANUAL TRANSMISSION | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
ODI Number: 10143646
ELECTRICAL SYSTEM
ODI Number: 10139395
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 10141382
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 10141475
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM | STRUCTURE:BODY
ODI Number: 10137031
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
ODI Number: 10132274
STRUCTURE:BODY:TRUNK LID
ODI Number: 10132436
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 10132157
STRUCTURE:BODY
ODI Number: 10131631
ELECTRICAL SYSTEM
ODI Number: 10130252
ELECTRICAL SYSTEM | VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
ODI Number: 10127165
WHEELS:RIM
ODI Number: 10128916
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH | EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES | EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC. | WHEELS:HUB
ODI Number: 10126517
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 10125516
SEATS:MID/REAR ASSEMBLY
ODI Number: 10121605
VEHICLE SPEED CONTROL
ODI Number: 10117907
STRUCTURE:BODY:HOOD
ODI Number: 10114109
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:SHOES/LININGS
ODI Number: 10112661
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 10109182
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
ODI Number: 10108888
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10108873
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
ODI Number: 10109706
SUSPENSION
ODI Number: 10106955
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
ODI Number: 10104865
ELECTRICAL SYSTEM
ODI Number: 10104706
ELECTRICAL SYSTEM:IGNITION:MODULE
ODI Number: 10099059
VISIBILITY:REAR WINDOW WIPER/WASHER:MOTOR
ODI Number: 10099572
AIR BAGS:FRONTAL
ODI Number: 10094963
ENGINE AND ENGINE COOLING
ODI Number: 10089891
VEHICLE SPEED CONTROL
ODI Number: 10079607
POWER TRAIN:MANUAL TRANSMISSION
ODI Number: 10081039
ELECTRICAL SYSTEM:IGNITION:SWITCH
ODI Number: 10080753
ENGINE AND ENGINE COOLING | VEHICLE SPEED CONTROL
ODI Number: 10078371
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
ODI Number: 10073368
ELECTRICAL SYSTEM:IGNITION
ODI Number: 10073515
ELECTRICAL SYSTEM:IGNITION | ENGINE AND ENGINE COOLING | FUEL SYSTEM, GASOLINE | STRUCTURE
ODI Number: 10073471
SEAT BELTS:FRONT
ODI Number: 10066239
TIRES | VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
ODI Number: 10066807
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
ODI Number: 10063287
VISIBILITY:GLASS, SIDE/REAR
ODI Number: 10062531
WHEELS
ODI Number: 10062525
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
ODI Number: 10065047
STRUCTURE:BODY:TRUNK LID | VISIBILITY:GLASS, SIDE/REAR
ODI Number: 10063855
VISIBILITY:REAR WINDOW WIPER/WASHER
ODI Number: 10058199
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | VEHICLE SPEED CONTROL
ODI Number: 10416800
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
ODI Number: 10296500
Is the government investigating the safety of your vehicle? Find out here.

0 Investigations for 2004 CHEVROLET Cavalier

Date Opened Date Closed Component  
Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

477 Service Alerts for 2004 CHEVROLET Cavalier

Date Description
June 13, 2022 357400 EQUIPMENT:APPLIANCE:ELECTRIC WATER HEATER

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 15, 2022 060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 4, 2022 199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

This service bulletin provides information for accurate tire pressures that ensure the safe handling and appropriate ride characteristics of GM cars and trucks.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 31, 2022 160000 STRUCTURE

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 11, 2022 061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 16, 2022 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 2, 2022 353000 EQUIPMENT:ELECTRICAL

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 2, 2022 060000 ENGINE (PWS)

This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2022 190000 TIRES

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2022 200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 30, 2013 350000 EQUIPMENT

This informational bulletin provides information for Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TransFlow.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 23, 2013 350000 EQUIPMENT

This informational bulletin provides information for Engine Squealing Type Noise on Start-up or Vibration Condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 14, 2013 110000 ELECTRICAL SYSTEM

This informational bulletin provides a revision for 13-00-89-004A to include updated information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 16, 2013 131000 VISIBILITY:WINDSHIELD

This informational bulletin provides a revision for 05-08-48-001B to add 2010-2014 model years and update Labor Operation.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 25, 2014 060000 ENGINE AND ENGINE COOLING

This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 16, 2014 350000 EQUIPMENT

This informational bulletin provides information on what products GM has to aid in the eliminating unwanted odors in a vehicle.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 30, 2012 110000 ELECTRICAL SYSTEM

This informational bulletin provides information regarding the aftermarket device interference with onstar diagnostic service.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 31, 2022 060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 22, 2022 060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 3, 2022 190000 TIRES

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 3, 2022 200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 14, 2021 060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 – P0308 and/or P050D

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 5, 2021 356230 EQUIPMENT ADAPTIVE/MOBILITY:VEHICLE CONTROLS:STEERING

This service bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure, when diagnosing vibration concerns.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2015 100000 POWER TRAIN

OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2015 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2015 060000 ENGINE (PWS)

OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2015 353000 EQUIPMENT:ELECTRICAL

OnStar Voice Fallback Number Update

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2015 346000 COMMUNICATION:MANUFACTURER TELEMATICS

OnStar Voice Fallback Number Update

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 21, 2021 350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 21, 2021 356000 EQUIPMENT ADAPTIVE/MOBILITY

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 17, 2021 350000 EQUIPMENT

This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 21, 2021 120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 25, 2021 071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 25, 2021 110000 ELECTRICAL SYSTEM

This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2021 160000 STRUCTURE

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2021 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 12, 2021 200000 WHEELS

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 30, 2021 350000 EQUIPMENT

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2014 200000 WHEELS

Refinishing Aluminum Wheels This bulletin updates General Motor’s position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2014 350000 EQUIPMENT

Refinishing Aluminum Wheels This bulletin updates General Motor’s position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2014 356000 EQUIPMENT ADAPTIVE/MOBILITY

Refinishing Aluminum Wheels This bulletin updates General Motor’s position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2014 200000 WHEELS

Refinishing Aluminum Wheels This bulletin updates General Motor’s position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2014 350000 EQUIPMENT

Refinishing Aluminum Wheels This bulletin updates General Motor’s position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2014 356000 EQUIPMENT ADAPTIVE/MOBILITY

Refinishing Aluminum Wheels This bulletin updates General Motor’s position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the whe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2014 161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle’s underbody components are showing some fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2014 356000 EQUIPMENT ADAPTIVE/MOBILITY

Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle’s underbody components are showing some fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2014 161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS

Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle’s underbody components are showing some fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2014 356000 EQUIPMENT ADAPTIVE/MOBILITY

Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle’s underbody components are showing some fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 30, 2021 070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 22, 2021 061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2015 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

IPC Odometer Programming Method Quick Reference Guide Season Odometer Programming Methods in Use Today 1. IPC reprogramming and setup using the service programming system (SPS). 2. Odometer setup at the electronic service center (ESC)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2015 117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

IPC Odometer Programming Method Quick Reference Guide Season Odometer Programming Methods in Use Today 1. IPC reprogramming and setup using the service programming system (SPS). 2. Odometer setup at the electronic service center (ESC)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2017 021300 SUSPENSION:FRONT:SHOCK ABSORBER

Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2017 021400 SUSPENSION:FRONT:MACPHERSON STRUT

Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2017 022400 SUSPENSION:REAR:SHOCK ABSORBER

Information Regarding the Differences Between Fluid Leakage and Seepage This bulletin is intended to help identify the differences between what is considered a fluid leak and what is considered seepage. Improper diagnosis may lead to un

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2017 350000 EQUIPMENT

Essential Tools that Include Consumable Parts (U.S. Only)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2017 356000 EQUIPMENT ADAPTIVE/MOBILITY

Essential Tools that Include Consumable Parts (U.S. Only)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

IPC Odometer Programming Method Quick Reference Guide

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2017 117110 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER:SENSOR/SENDING UNIT

IPC Odometer Programming Method Quick Reference Guide

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 11, 2020 190000 TIRES

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 11, 2020 200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 5, 2020 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 27, 2020 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 27, 2020 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 27, 2020 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 22, 2020 355100 EQUIPMENT:OTHER:LABELS

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 22, 2020 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 5, 2020 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 20, 2020 110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 21, 2020 060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 – P0308 and/or P050D

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 8, 2020 060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 – P0308 and/or P050D

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 12, 2019 350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 12, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 12, 2019 120000 LIGHTING (PWS)

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 14, 2020 060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 12, 2019 046000 SERVICE BRAKES, AIR:ANTILOCK

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 12, 2019 200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 26, 2019 350000 EQUIPMENT

This informational bulletin provides information on key code security rules and information on GM keycode look-up applications.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 26, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information on key code security rules and information on GM keycode look-up applications.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 2020 073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 2020 350000 EQUIPMENT

This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 2, 2020 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 14, 2019 060000 ENGINE (PWS)

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 16, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information for dealers how to submit a product information report (PIR) (Canada Only).

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 10, 2019 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 18, 2019 350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 9, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information on key code security and information on GM key code look up applications.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 6, 2019 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 6, 2019 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 4, 2019 070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about a customer?s request to remove or disable the Bi-Fuel Compressed Natural Gas system. General Motors does not condone the removal of the original equippe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 7, 2019 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 26, 2019 110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 26, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 11, 2019 110000 ELECTRICAL SYSTEM

This bulletin explains the labor operation numbers used for submitting warranty claims for module reprogramming and not when replacing a module.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 11, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin explains the labor operation numbers used for submitting warranty claims for module reprogramming and not when replacing a module.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 21, 2019 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 15, 2019 110000 ELECTRICAL SYSTEM

This bulletin provides information for electrical ground repairs using new replacement fasteners with “conductive finish”.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 15, 2019 350000 EQUIPMENT

This bulletin provides information for electrical ground repairs using new replacement fasteners with “conductive finish”.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 15, 2019 356000 EQUIPMENT ADAPTIVE/MOBILITY

This bulletin provides information for electrical ground repairs using new replacement fasteners with “conductive finish”.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 22, 2019 353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 22, 2019 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 22, 2019 118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 2019 200000 WHEELS

This informational bulletin explains the wheel Road Force balancers and what they can do for customer concerns.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 13, 2018 120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 16, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This information bulletin provides the dealers on how to submit a product information report.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 19, 2019 060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 18, 2019 060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 – P0308 and/or P050D

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 21, 2018 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 20, 2017 070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 20, 2017 199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 20, 2017 350000 EQUIPMENT

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 20, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 11, 2017 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 11, 2017 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 11, 2017 356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 19, 2017 350000 EQUIPMENT

This Preliminary Information communication informs dealer technicians of a potential whining noise that can occur after servicing the water pump, water pump chain or cylinder head without use of the water pump sprocket holding tool. Dealers

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 19, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication informs dealer technicians of a potential whining noise that can occur after servicing the water pump, water pump chain or cylinder head without use of the water pump sprocket holding tool. Dealers

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 19, 2017 356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication informs dealer technicians of a potential whining noise that can occur after servicing the water pump, water pump chain or cylinder head without use of the water pump sprocket holding tool. Dealers

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 6, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technicians

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 8, 2018 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 20, 2018 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 15, 2018 060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. Technician will need to check the lower and oil pressure to t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 15, 2018 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. Technician will need to check the lower and oil pressure to t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 15, 2018 356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. Technician will need to check the lower and oil pressure to t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 15, 2018 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. Technician will need to check the lower and oil pressure to t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 10, 2018 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 11, 2014 350000 EQUIPMENT

This information bulletin provides the dealers on how to submit a product information report.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 16, 2014 350000 EQUIPMENT

This informational bulletin provides information on what products GM has to aid in the eliminating unwanted odors in a vehicle.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 25, 2014 350000 EQUIPMENT

This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 25, 2014 060000 ENGINE (PWS)

This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 16, 2014 350000 EQUIPMENT

This information bulletin provides the dealers on how to submit a product information report.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 23, 2014 350000 EQUIPMENT

This informational bulletin provides information on how to use floor mats.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 6, 2015 020000 SUSPENSION

This informational bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate Vibration Analysis-Road testing procedure, when diagnosing vibration concerns.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 2015 110000 ELECTRICAL SYSTEM

This informational bulletin provides information on control module diagnostics and configuration, programming using the TIS Service Programming System (SPS), set-up and warranty.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 23, 2013 350000 EQUIPMENT

This informational bulletin provides a revision for 11-00-89-005D to add additional Mandatory Minimum Tables and additional information concerning Policy decision making.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 16, 2015 060000 ENGINE AND ENGINE COOLING

This preliminary informational bulletin provides technicians an engine repair tip for installation of pistons.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 23, 2013 060000 ENGINE AND ENGINE COOLING

This informational bulletin provides information for Engine Squealing Type Noise on Start-up or Vibration Condition.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 30, 2013 100000 POWER TRAIN

This informational bulletin provides information for Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TransFlow.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 20, 2015 353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on a GM of Canada OnStar cellular communication upgrade.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 20, 2015 353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on a GM of Canada OnStar cellular communication upgrade.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 10, 2017 073200 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 10, 2017 350000 EQUIPMENT

This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 23, 2017 350000 EQUIPMENT

This informational bulletin explains the Road Force balancers and what they can do for customer concerns.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 17, 2017 060000 ENGINE (PWS)

This informational bulletin advises the possible issues that may occur using a scotch brite pad or highly abrasive disk on engine surfaces.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 11, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This information bulletin provides the dealers on how to submit a product information report.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 31, 2018 063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

This informational bulletin explains how the catalytic converters may need an inspection, cleaning or replacement if debris have entered the exhaust system.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 21, 2013 350000 EQUIPMENT

This informational bulletin provides a revision for 02-08-98-002C to add the 2010-2013 model years and revise the Approved Refinish Materials booklet information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 14, 2013 350000 EQUIPMENT

This informational bulletin provides a revision for 13-00-89-004A to include updated information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 20, 2013 350000 EQUIPMENT

This informational bulletin provides a revision for 09-00-89-008 to add model years, update the Labor Operation Information and Transaction Submissions Procedure and general content updates.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 16, 2013 350000 EQUIPMENT

This informational bulletin provides a revision for 05-08-48-001B to add 2010-2014 model years and update Labor Operation.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 21, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin explains how to update the older Onstar module software to new software over GSA.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 22, 2014 118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin advises the technician to update the Onstar from an analog system to a digital system if the customer wishes.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 19, 2014 350000 EQUIPMENT

This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 21, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin provides information for the GM of Canada OnStar Cellular Communication Upgrade to 3G/4G LTE for vehicles that may need an upgrade.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This information bulletin explains the labor operation numbers used for submitting warranty claims and how to setup, and reprogram modules.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 25, 2014 350000 EQUIPMENT

This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 9, 2014 070000 FUEL SYSTEM, GASOLINE

This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 16, 2014 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

This informational bulletin provides information on what products GM has to aid in the eliminating unwanted odors in a vehicle.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 16, 2014 350000 EQUIPMENT

This information bulletin provides the dealers on how to submit a product information report.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 16, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This information bulletin provides the dealers on how to submit a product information report.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 11, 2014 350000 EQUIPMENT

This information bulletin provides the dealers on how to submit a product information report.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 23, 2014 350000 EQUIPMENT

This informational bulletin provides information on how to use floor mats.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 23, 2014 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information on how to use floor mats.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 31, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This informational bulletin provides information to dealership personnel on upgrading certain OnStar Analog/Digital-Ready Systems to OnStar Generation 6 Digital-Capable System.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 31, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This informational bulletin provides information to dealership personnel on upgrading certain OnStar Analog/Digital-Ready Systems to OnStar Generation 6 Digital-Capable System.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 30, 2014 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 2015 110000 ELECTRICAL SYSTEM

This informational bulletin updates information on electrical ground repairs using new replacement fasteners with conductive finish.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 25, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This information bulletin provides the technician the information on how to properly clean a metal surface using the correct tool.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 21, 2017 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 16, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information on what products GM has to aid in the eliminating unwanted odors in a vehicle.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 15, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides policy information with the field action courtesy transportation policy.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 30, 2012 350000 EQUIPMENT

This informational bulletin provides information regarding the aftermarket device interference with onstar diagnostic service.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 13, 2012 350000 EQUIPMENT

This informational bulletin provides information and rules for GM keycode look up applicationa dn the key code security rules and regulations for Canada only.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 17, 2012 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information on the Clarification of Use for Dealer Empowerment Labor Operations and Customer Enthusiasm

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 20, 2012 350000 EQUIPMENT

This warranty administration bulletin provides information regarding customer concerns not duplicated and which labor operations to claim when the concern cannot be duplicated. Also provides information on how to submit claims within the gl

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 30, 2012 350000 EQUIPMENT

This informational bulletin provides information regarding the aftermarket device interference with onstar diagnostic service.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 17, 2014 350000 EQUIPMENT

This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 20, 2012 350000 EQUIPMENT

This warranty administration bulletin provides information regarding customer concerns not duplicated and which labor operations to claim when the concern cannot be duplicated. Also provides information on how to submit claims within the gl

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 13, 2012 353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

This informational bulletin provides information and rules for GM keycode look up applicationa dn the key code security rules and regulations for Canada only.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 17, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 9, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information on key code security and information on GM key code look up applications.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 8, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This technical bulletin provides a revision of 10-00-89-017Z to include updated information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 12, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information on key codes security rules and information on GM key code look up application.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 11, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This technical bulletin provides a revision of 99-04-20-002G to add 2013-2014 model years.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 11, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information on fix it right for first time issues.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 16, 2013 284300 BACK OVER PREVENTION: SENSING SYSTEM: RADAR

This informational bulletin provides directions on submitting different PIRs

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 4, 2013 200000 WHEELS

This informational bulletin provides information on the appearance of chromed aluminum wheels due to chemical staining, pitting corrosion and/or spotted.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 4, 2013 070000 FUEL SYSTEM, GASOLINE

This informational bulletin provides information on how to save fuel and proper maintenance without using fuel or oil additives.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 4, 2013 080000 FUEL SYSTEM, DIESEL

This informational bulletin provides information on how to save fuel and proper maintenance without using fuel or oil additives.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 4, 2013 090000 FUEL SYSTEM, OTHER

This informational bulletin provides information on how to save fuel and proper maintenance without using fuel or oil additives.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 13, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This preliminary information bulletin provides a revision of 13-00-89-004D to include updated information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 20, 2014 063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. It is recommended to inspe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 5, 2013 117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

This technical service bulletin provides a revision for 07-08-49-020G to add the 2014 model year and update model list.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 16, 2013 162000 STRUCTURE:BODY

This informational bulletin provides information pre-painting/cleaning process for TPO plastic fascias.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 25, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This technical bulletin provides Warranty Administration – New Labor Codes information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This technical bulletin provides a revision of 13-00-89-004 to update car issues information for reference information/bulletin PI0746C.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 24, 2017 350000 EQUIPMENT

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 26, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provide policy information on clarification of use-dealer empowerment labor operations and customer enthusiasm.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 22, 2014 120000 EXTERIOR LIGHTING

This informational bulletin explains condensation in exterior lights and replacment guidelines for warranty replacement.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 22, 2014 350000 EQUIPMENT

This informational bulletin is to assist with the identification of issues that are not considered warrantable.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 14, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This information bulletin provides the technician with additional information on fixing the vehicle right the first time by listing possible concerns to specific vehicles.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 10, 2014 063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. It is recommended to inspe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 10, 2014 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about vehicles that show an error message when a media disc is installed. Technician will need to check the Regular Production Option Code list to verify if t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 17, 2014 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 7, 2014 060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent engine misfire and a Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P030

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 7, 2014 070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent engine misfire and a Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P030

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 12, 2012 350000 EQUIPMENT

This informational bulletin provides a list of newly released PI and Bulletins in regards to recent released vehicles so that vehicles can be fixed right the first time in for service.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 30, 2012 118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin provides information regarding the aftermarket device interference with onstar diagnostic service.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 10, 2014 350000 EQUIPMENT

This information provides the proper way to install the floor mats .

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 31, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin explains the Road Force balancers and what they can do for customer concerns.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 13, 2012 350000 EQUIPMENT

This informational bulletin provides information and rules for GM keycode look up applicationa dn the key code security rules and regulations for Canada only.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 28, 2012 350000 EQUIPMENT

This informational bulletin provides a step by step procedure on how to properly use the GM chemicals to eliminate unwanted odors in vehicles and which products to use for each application.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 11, 2014 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This informational bulletin provide information for the technicians to repair the rear window defroster contact or tabs.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 12, 2012 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides a single point reference and strategy document to aid in reducing customer comebacks, and the possibility of buyback situations by outlining specific guidelines, strategy and forms that will assist with

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 19, 2017 060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication informs dealer technicians of a potential whining noise that can occur after servicing the water pump, water pump chain or cylinder head without use of the water pump sprocket holding tool. Dealers

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 29, 2015 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the incoming caller ID may no longer be available or displayed after the Canada OnStar upgrade. Dealer should communicate to the customer

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 28, 2015 070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician to help determine if the vehicle is equipped with factory or aftermarket Compressed Natural Gas, Liquefied Petroleum Gas, or Bi-Fuel Systems. Technician will

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 23, 2018 200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 25, 2018 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 18, 2018 060000 ENGINE (PWS)

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2014 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about vehicles that may not receiving all channels on the XM band. Technician will need to use a scan tool and verify current Digital Radio Receiver Status un

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2014 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about vehicles that may not receiving all channels on the XM band. Technician will need to use a scan tool and verify current Digital Radio Receiver Status un

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 4, 2018 350000 EQUIPMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2014 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system. For many 2008 and prior model year GM vehicles, the programming is performed using the Tech 2 and the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2014 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system. For many 2008 and prior model year GM vehicles, the programming is performed using the Tech 2 and the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 16, 2014 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This preliminary bulletin provides procedures on how to reset or refresh the XM radio receiver is the customers states that they only get a few channels.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 7, 2017 117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

This Preliminary Information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. Technician should obtain a hand-held GPS unit to test the odomete

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 20, 2015 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about connectivity concerns when connecting an Apple device via USB cord. Technician should insure the customer is using an original equipment manufacturer Ap

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 22, 2015 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about being unable to receive OnStar ?Over The Air? updates. Technician will need to press the OnStar button and verify they have an active account and that t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2015 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 8, 2015 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that may have the OnStar wireless fidelity inoperative. Technician will need to contact General Motors Technical Assistance Center with a scan

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 8, 2015 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that are unable to receive OnStar Hands Free Calling calls and or the OnStar center is unable to perform remote services. Technician will need

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 8, 2015 356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician about vehicles that are unable to receive OnStar Hands Free Calling calls and or the OnStar center is unable to perform remote services. Technician will need

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 16, 2015 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone cont

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 16, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone cont

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 7, 2016 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to contact General Motors T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 9, 2015 356000 EQUIPMENT ADAPTIVE/MOBILITY

This warranty administration bulletin provides information to clarify proper transaction administration of GM Dealer Empowerment Program and Goodwill Cases.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 14, 2015 020000 SUSPENSION

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 14, 2015 161000 STRUCTURE:FRAME AND MEMBERS

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assista

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 2016 356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assista

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 15, 2016 070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about engine block that have a possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leaka

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 15, 2016 356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician about engine block that have a possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leaka

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 15, 2016 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about engine block that have a possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leaka

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 4, 2014 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 24, 2014 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 23, 2016 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone cont

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 15, 2015 190000 TIRES

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 15, 2015 200000 WHEELS

This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 14, 2015 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the cu

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 17, 2014 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides a quick guide to updating which model vehicle after replacing the IPC.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 13, 2015 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 13, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicles that are travelling from Canada to the United States. While in the United States they are unable to receive Turn-by-Turn directions. Due to the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 21, 2014 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about vehicles that have a Malfunction Indicator Lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. Technician will need

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 14, 2015 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 14, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 28, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information for dealers how to submit a product information report.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 24, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin provides explanation on how to take snapshot data with a Tech 2 and upload it to a computer and where to email the info to.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 3, 2017 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 3, 2017 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 3, 2017 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 2, 2017 162800 STRUCTURE:BODY:HOOD

This Preliminary Information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. Technician will need to check the lower and oil pressure to t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 7, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides a revision for 04-06-04-047K to add the 2014 model year.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 6, 2017 110000 ELECTRICAL SYSTEM

This informational bulletin provides information for the IPC odometer programming method quick reference guide.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 7, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides a revision for 04-06-04-047 to add the 2014 model year.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational Bulletin provides a revision for 10-08-110-001 to add the 2012-2014 model years.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 19, 2013 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides an update for 13-00-89-004C to include updated information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 3, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 3, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty bulletin clarifies the use of dealer empowerment to satisfy the customer.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 12, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system. For many 2008 and prior model year GM vehicles, the programming is performed using the Tech 2 and the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This informational bulletin provides information on Clarification of Use – Dealer Empowerment Labor Operations and Customer Enthusiasm (U.S. Only)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2016 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information on Clarification of Use – Dealer Empowerment Labor Operations and Customer Enthusiasm (U.S. Only)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 8, 2016 121000 EXTERIOR LIGHTING:HEADLIGHTS

This informational bulletin provides information on exterior lamp condinsation and replacement guidelines

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2016 121000 EXTERIOR LIGHTING:HEADLIGHTS

This informational bulletin provides an out line on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage and what should be considered warranty replacement and not

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2016 124000 EXTERIOR LIGHTING:BACK UP LIGHTS

This informational bulletin provides an out line on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage and what should be considered warranty replacement and not

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2016 125000 EXTERIOR LIGHTING:BRAKE LIGHTS

This informational bulletin provides an out line on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage and what should be considered warranty replacement and not

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 2, 2017 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assista

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2016 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information on Behavior of Non-Upgraded OnStar Equipped Vehicles Operating in Canada after Decommissioning of 2G CDMA Cellular Networks

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 3, 2015 150000 SEAT BELTS

This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 3, 2015 151400 SEAT BELTS:FRONT:BUCKLE ASSEMBLY

This informational bulletin provides information to advise dealers about seat belt buckles not operating and/or seat belt warning light illumination, as well as difficulty latching and unlatching the buckle or the buckle release button stic

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 11, 2016 350000 EQUIPMENT

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. ONLY REPLACE THE ROLLER ROCKER THAT IS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 30, 2015 063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. It is recommended to inspe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 4, 2015 090000 FUEL SYSTEM, OTHER

This Preliminary Information communication provides information to the technician about a customer?s request to remove or disable the Bi-Fuel Compressed Natural Gas system. General Motors does not condone the removal of the original equippe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 23, 2015 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicle’s odometer appears to be inaccurate relative to a known distance traveled. Technician should obtain a hand-held GPS unit to test the odometer. I

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 27, 2015 090000 FUEL SYSTEM, OTHER

This informational bulletin provides dealership personnel with information on flexible fuel vehicles (FFVs) and the usage of E85 fuel in GM vehicles.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 27, 2015 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information to assist dealership personnel with the identification of vehicle headlamp, tail lamp, license lamp or fog/driving lamp damage that are not considered warrantable.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 18, 2015 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 18, 2015 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 18, 2015 356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availabilit

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 9, 2015 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P0442. Technician will need to review T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 9, 2015 070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P0442. Technician will need to review T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 9, 2015 091100 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P0442. Technician will need to review T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 10, 2012 356000 EQUIPMENT ADAPTIVE/MOBILITY

This warranty administrational bulletin provides information on Clarification of Use – Dealer Empowerment Labor Operations and Customer Enthusiasm

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 18, 2015 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about vehicles that when dialing certain numbers using OnStar Hands-free Calling, the audio is distorted or has poor quality after performing the OnStar Canad

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 5, 2012 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information on newly release bulletins used to fi the vehicles in the field the first time.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 30, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Warranty Admin bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 16, 2016 118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin explains the programming method quick reference guide for the IPC Odometer.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 2016 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication advises the technician after the OnStar Canada upgrade the OnStar Vehicle Diagnostic Email report is inoperative. Please communicate to the customer that we apologize for this inconvenience and tha

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 17, 2012 356000 EQUIPMENT ADAPTIVE/MOBILITY

This warranty administration bulletin provides information on the Clarification of Use for Dealer Empowerment Labor Operations and Customer Enthusiasm

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 4, 2016 063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

This Preliminary Information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. It is recommended to inspe

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 7, 2012 356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 31, 2015 110000 ELECTRICAL SYSTEM

This informational bulletin provides information to dealership personnel on upgrading certain OnStar Analog/Digital-Ready Systems to OnStar Generation 6 Digital-Capable System.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 5, 2013 190000 TIRES

This warranty administration bulletin provide policy information new tire warranty program and global warranty management submission information.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 9, 2012 030000 BRAKES (PWS)

This Preliminary Information communication provides information to the technician about brake rotors on new vehicles and replacement parts from General Motors Service Parts Operations. Technician should be advised the costing should not be

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 28, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 24, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communication provides information to help the dealership technicians perform a parasitic drain test for the OnStar module. When performing battery parasitic drain test, there may be some confusion as to what th

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 28, 2012 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 28, 2012 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 19, 2013 060000 ENGINE AND ENGINE COOLING

This informational bulletin provides information on close-coupled converter and engine replacement.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 19, 2013 354000 EQUIPMENT:MECHANICAL

This informational bulletin provides information on close-coupled converter and engine replacement.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2008 010000 STEERING

CONCERNS WITH CLUNK NOISE FROM FRONT OF VEHICLE TURNING MANEUVER / STEERING WHEEL ROTATION.*JB (LUBRICATE OR REPLACE INTERMEDIATE SHAFT AS APPROPRIATE). UPDATED 10/05/07. *NJ UPDATED 4/1/08. *NJ UPDATED 7/1/2008 *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 14, 2016 110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THAT ,WHEN TESTING ANY CIRCUIT FOR OPEN OR RESISTANCE, IT IS IMPERATIVE THAT ALL RELATED TERMINAL PIN FIT AND TENSION BE CHECKED WHEN THE TEST STEPS REQUIRE DISCONNECTION OF

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 20, 2004 110000 ELECTRICAL SYSTEM

SIR LIGHT ON, DIAGNOSTIC TROUBLE CODE B0036. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2003 162000 STRUCTURE:BODY

CARPET WET ON DRIVER’S SIDE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2012 161000 STRUCTURE:FRAME AND MEMBERS

GM: ON SOME TRUCK MODELS THERE IS SOME FRAME CORROSION. *RM UPDATED ON 5/2/2012. *KB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2005 030000 SERVICE BRAKES, HYDRAULIC

CAR ISSUES – FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2005 073200 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS

CAR ISSUES – FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2005 130000 VISIBILITY

CAR ISSUES – FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2005 138800 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR

CAR ISSUES – FIX IT RIGHT THE FIRST TIME (NEW ISSUES IN BOLD). TO INCLUDE 2006 AND 2007 MODELS. GM. TECH LINK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 19, 2003 160000 STRUCTURE

SCREW MISSING FROM THE A-PILLAR CEILING STRIP FRONT DOOR AUXILIARY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 10, 2003 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

THIS VME MESSAGE IS A WATER PUMP REPLACEMENT DUE TO A KNOWN CAM DRIVELINE. SOME CUSTOMERS MAY QUESTION ABOUT WHINE NOISE COMING FROM THE FRONT ENGINE AREA. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 16, 2003 162000 STRUCTURE:BODY

RATTLE OR BUZZ FROM THE RIGHT FRONT SPEAKER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2005 350000 EQUIPMENT

INFORMATION ON UPGRADING CERTAIN ONSTAR GENERATION 5 ANALOG/DIGITAL-READY SYSTEMS TO ONSTAR GENERATION 6 DUAL-MODE (ANALOG/DIGITAL). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2005 061000 ENGINE AND ENGINE COOLING:ENGINE

VEHICLE HESITATES, NO START, LACK OF POWER, LOW FUEL PRESSURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

ANTI-LOCK BRAKING SYSTEM (ABS) FRONT WHEEL SPEED CODES – JUMPER HARNESS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

061000 ENGINE AND ENGINE COOLING:ENGINE

LOW OIL PRESSURE – INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 13, 2012 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles may have a no power or no connect concern. Technician will find that the OnStar led is red and Diagnostic Trouble Code U1500 is set. Technician

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 30, 2014 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 30, 2014 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This Preliminary Information communication provides information to the technician about vehicle that may have an OnStar system that has progression tones when pressing the blue or red button. Technician will need to call General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 12, 2012 060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. Dealer should send the correc

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2016 113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY

This informational bulletin provides information on vehicles may rock or move slightly forward or rearward while in Park at start up after cold soak and that this is considered a normal conditon and no repairs are necessary

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 8, 2014 356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assista

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 26, 2014 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communication provides information to the technician about vehicles that have the OnStar system does not respond properly to some numbers and/or voice commands. Dealer should direct the customer to review the op

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 4, 2013 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. Technician will need to check the lower and oil pressure to t

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 16, 2014 350000 EQUIPMENT

This Preliminary Information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. Technician should look for Non – General Motors a

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 4, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 22, 2014 353000 EQUIPMENT:ELECTRICAL

This Preliminary Information communication provides information to the technician about vehicles that may have an issue when using Bluetooth voice recognition with an iPhone. Technician should work with the customer to insure the phone cont

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2014 030000 SERVICE BRAKES, HYDRAULIC

This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P0442. Technician will need to review T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2014 070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P0442. Technician will need to review T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 12, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have a Service Engine Soon Malfunction Indicator Lamp. Technician may find Diagnostic Trouble Code P0442. Technician will need to review T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 13, 2013 110000 ELECTRICAL SYSTEM

This Preliminary Information communication advises the technician that, when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 26, 2013 350000 EQUIPMENT

This Preliminary Information communication advises the technician that a noise or a vibration in the vehicle that seems to be abnormal may not have been there when the vehicle was purchased. Technician should look for Non – General Motors a

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 17, 2014 060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 12, 2016 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that have a Diagnostic Trouble Code B101D-37 history in the Vehicle Communication Interface Module or telematics communication interface contro

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2014 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assista

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2014 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assista

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 5, 2016 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provide policy information for GM dealer empowerment program and goodwill procedures.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 5, 2014 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician about vehicles that when a Canadian customer may comment that when they travel to the United States, they are unable to connect to OnStar or use hands free ca

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 4, 2014 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communication provides information to the technician about a customer?s request to install OnStar Bluetooth. Dealer should be advised at this time, there are no provisions to add this option to vehicles that wer

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 27, 2016 353000 EQUIPMENT:ELECTRICAL

This informational bulletin provides information on Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM) (GMNA Only)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 27, 2016 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

This informational bulletin provides information on Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM) (GMNA Only)

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 24, 2014 060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2012 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the OnStar

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 14, 2016 060000 ENGINE (PWS)

This informational bulletin provides information on close coupled converters and there affect on newly installed engines or engines during there break in period.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 2003 110000 ELECTRICAL SYSTEM

SIR LIGHT ON AND A DIAGNOSTIC TROUBLE CODE (DTC) B0036. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2005 020000 SUSPENSION

SQUEAKING NOISE IN FRONT END ON TURNS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2004 061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE IDLE FLAIR WHEN CLUTCH DEPRESSED OR DECEL STALL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

SUNROOF SUPPLEMENTAL INFORMATION TO 03-08-67-009.*MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 100000 POWER TRAIN

4T40E, 4T45E CHANGE IN APPEARANCE OF FORWARD, SECOND AND REVERSE CLUTCH WAVE PLATE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 20, 2013 110000 ELECTRICAL SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the OnStar system will not connect. Technician should record module info per the latest version of PIC4310 and contact General Motors Tech

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 18, 2012 356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts. Technician can check Service Information for some accessories. Technician can also contact Partech for assist

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 2, 2013 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician that after replacing the Instrument Panel Cluster the exchange center is unable to program the actual mileage on the odometer or the actual mileage is unknown

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 2, 2013 117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

This Preliminary Information communication provides information to the technician that after replacing the Instrument Panel Cluster the exchange center is unable to program the actual mileage on the odometer or the actual mileage is unknown

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2013 060000 ENGINE AND ENGINE COOLING

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 3, 2013 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partech for assista

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 29, 2016 060000 ENGINE (PWS)

THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 13, 2017 350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 17, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system. For many 2008 and prior model year GM vehicles, the programming is performed using the Tech 2 and the

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 20, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have an OnStar Turn-By-Turn Navigation the system that is inoperative. Technician verifies there are no Diagno

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 13, 2017 060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about vehicles that have a Malfunction Indicator Lamp on or engine misfire, rough idle, extended crank, or crank no start in some cases. Technician will need

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 20, 2017 010000 STEERING

This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the cu

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 20, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communication provides information to the technician the steps needed to diagnose and repair the vehicles that may have unwanted or phantom phone calls. Technician will need to determine what type of call the cu

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 22, 2017 118000 ELECTRICAL SYSTEM:SOFTWARE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 27, 2016 110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 27, 2016 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 21, 2016 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN. THE VEHICLE’S XM RADIO ONLY HAS XM PREVEIW CHANNELS.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

121000 EXTERIOR LIGHTING:HEADLIGHTS

IPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER. *AK FB2

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

330000 INTERIOR LIGHTING

IPC, INTERIOR LIGHTS AND/OR HEADLAMPS FLICKER. *AK FB2

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

VEHICLE WILL NOT MOVE IN EITHER DIRECTION. TRANSMISSION MAY SHOW OVER FULL. P90 4T40E 4T45E NO MOVEMENT DRIVE OR REVERSE. CONVERTER MAY BE EMPTY OF FLUID. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

100000 POWER TRAIN

4T40E OR 4T45E WILL NOT SHIFT NO DIAGNOSTIC TROUBLE CODES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 021000 SUSPENSION:FRONT

FRONT SUSPENSION STEER NOISE SMOOTH ROAD TURNS. *MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2016 353000 EQUIPMENT:ELECTRICAL

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE’S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CA

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

CLUTCH PEDAL STAYS TO FLOOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2006 010000 STEERING

CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING TURNING MANEUVER AND/OR STEERING WHEEL ROTATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE MISFIRE DUE TO INJECTOR FRETTING CORROSION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2004 060000 ENGINE AND ENGINE COOLING

NEW CYLINDER BORE LINER REPLACEMENT PROCEDURE. THIS SERVICE BULLETIN REPLACES 030601018A. *EH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2004 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

CLUNK NOISE FROM FRONT END DURING LOW SPEED TURNS OR MANEUVERS. THIS SERVICE BULLETIN REPLACES 030729005A. *EH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2004 162000 STRUCTURE:BODY

BOWTIE EMBLEM DISCOLORATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2004 010000 STEERING

MOMENTARY REDUCTION OF POWER STEERING PS ASSIST ON INITIAL START UP WITH LOW AMBIENT TEMPERATURES. THIS SERVICE BULLETIN REPLACES 030232001A. *EH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 2003 100000 POWER TRAIN

TRANSMISSION SLIPS IN 4TH GEAR, STUCK IN 2ND GEAR OR SES/TCS LIGHT ILLUMINATED, DIAGNOSTIC TROUBLE CODES (DTCS) P0753, P0758, P1860, C1223, C1224 OR C1275 MAY BE SET. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

XM RADIO WAS WORKING PRIOR TO JULY 26, 2004 AND IT IS INOPERATIVE NOW. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

ONSTAR CENTER UNABLE TO PERFORM REMOTE DIAGNOSTIC. (2004-2005 CHEVROLET YUKON, 2005 CHEVROLET TRAILBLAZER, 2002, 2003, 2005 BUICK RAINIER, 2005 CHEVROLET EXPRESS VAN, AND 2005 CADILLAC SEVILLE) *SC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

XM RAPID ACTIVATION UTILIZATION. *MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 2003 101000 POWER TRAIN:CLUTCH ASSEMBLY

GRINDING/RATTLE NOISE WITH CLUTCH FULLY DISENGAGED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 2003 110000 ELECTRICAL SYSTEM

DIAGNOSTIC TROUBLE CODES (DTCS) P0716, P0717. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 2003 110000 ELECTRICAL SYSTEM

FALSE CODE B3785. SERVICE VME. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2004 138600 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE

BINDING MODE VALVE-HVAC. *SC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2004 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

BINDING MODE VALVE-HVAC. *SC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2003 160000 STRUCTURE

RIGHT FRONT SPEAKER RATTLE. *SC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

TECH 2 DISPLAYS ASTERISK FOR THE LEFT FRONT WHEEL SPEED SENSOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2005 010000 STEERING

CLUNK NOISE FROM FRONT OF VEHICLE DURING TURNING MANEUVER/STEERING WHEEL ROTATION. *TT *NM

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2008 110000 ELECTRICAL SYSTEM

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2008 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2008 118000 ELECTRICAL SYSTEM:SOFTWARE

GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2016 110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2016 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 2, 2016 061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL

THIS INFORMATIONAL BULLETIN EXPLAINS THE USE OF DIESEL FUEL ADDITIVES IN AN ENGINE, ARE NOT REQUIRED UNLESS THE CUSTOMER DESIRES ADDITIVES TO PREVENT FUEL CONCERNS DEPENDING ON FUEL OR TEMPERATURE RELATED CONDITIONS.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXCESSIVE OIL CONSUMPTION AND/OR BLACK/BLUE SMOKE FROM THE EXHAUST. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 061000 ENGINE AND ENGINE COOLING:ENGINE

STALL, HESITATION, STUMBLE WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2005 980000 UNKNOWN OR OTHER

SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE STALL HESITATION STUMBLE WITH NO DIAGNOSTIC TROUBLE CODES (DTCS). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)

CLUTCH PEDAL STAYS TO FLOOR REPEAT SLAVE CYLINDER FAIL. SIT BULLETIN 1405756. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2003 162000 STRUCTURE:BODY

RIGHT FRONT SPEAKER RATTLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2003 061000 ENGINE AND ENGINE COOLING:ENGINE

SERVICE ENGINE SOON/CHECK ENGINE LIGHT ILLUMINATED, MISFIRE OR ROUGHNESS, DIAGNOSTIC TROUBLE CODE (DTC) P0300 SET. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 15, 2003 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM

COOLANT LOSE, EVIDENCE FLUID ON THE GARAGE FLOOR, ETC., OR COOLANT WARNING LIGHT COMING ON. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

090000 FUEL SYSTEM, OTHER

CRANK NO START, LOW OR NO FUEL PRESSURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2004 134000 VISIBILITY:SUN/MOON ROOF ASSEMBLY

SUNROOF WILL NOT OPEN OR CLOSE COMPLETELY DUE TO THE SUNROOF MOTOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2012 150000 SEAT BELTS

GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2012 151600 SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

114100 ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

HESITATION ON ACCELERATION AFTER INTERNAL ENGINE REPAIRS – CHECK INJECTOR HARNESS ORIENTATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 8, 2016 350000 EQUIPMENT

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THAT AFTER REPLACING THE INSTRUMENT PANEL CLUSTER THE EXCHANGE CENTER IS UNABLE TO PROGRAM THE ACTUAL MILEAGE ON THE ODOMETER OR THE ACTUAL MILEAGE IS UNKNOWN

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 8, 2016 117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THAT AFTER REPLACING THE INSTRUMENT PANEL CLUSTER THE EXCHANGE CENTER IS UNABLE TO PROGRAM THE ACTUAL MILEAGE ON THE ODOMETER OR THE ACTUAL MILEAGE IS UNKNOWN

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2005 060000 ENGINE AND ENGINE COOLING

ENGINE FAILURE DUE TO WATER INGESTION HYDRO LOCK. *EH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 046300 SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR

ABS FRONT WHEEL SPEED CODES – JUMPER HARNESS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2007 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. *NJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

073100 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL

INFORMATION ON TRANSFERRING ORIGINAL FUEL RAIL TO GOODWRENCH ENGINE. *AK

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

M86/M94 TRANSMISSION INFORMATION TO DISASSEMBLE THIRD FOURTH AND FIFTH GEAR. *AK

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

061000 ENGINE AND ENGINE COOLING:ENGINE

INFORMATION ON TRANSFERRING ORIGINAL FUEL RAIL TO GOODWRENCH ENGINE. *AK

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

020000 SUSPENSION

FRONT SUSPENSION NOISE ON TURNS. *EH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2003 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

AUTOMATIC TRANSMISSION POOR ACCELERATION, PERFORMANCE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2003 980000 UNKNOWN OR OTHER

XM DEALER ASSISTANCE LINE INFORMATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 2004 036400 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

ANTI-LOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON, TRACTION OFF WARNING LIGHT ON, DIAGNOSTIC TROUBLE CODES (DTCS) C1223 AND C1225 SET. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 15, 2015 350000 EQUIPMENT

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT CHANGING THE TIRE AND WHEEL SIZE ON VEHICLES. GENERAL MOTORS WILL ONLY SUPPORT A TIRE CALIBRATION FOR TIRES THAT HAVE BEEN SIZED, TESTED AND DESIGNED FO

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 14, 2015 110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. TECHNICIAN WILL NEED TO DETERMINE WHAT TYPE OF CALL THE CU

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 14, 2015 353000 EQUIPMENT:ELECTRICAL

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN THE STEPS NEEDED TO DIAGNOSE AND REPAIR THE VEHICLES THAT MAY HAVE UNWANTED OR PHANTOM PHONE CALLS. TECHNICIAN WILL NEED TO DETERMINE WHAT TYPE OF CALL THE CU

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2003 102000 POWER TRAIN:MANUAL TRANSMISSION

GRIND NOISE FROM MANUAL TRANSMISSION WHEN CLUTCH IS RELEASED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2003 100000 POWER TRAIN

CLUNK NOISE FROM FRONT END DURING LOW SPEED TURNS OR MANEUVERS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 2005 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

TRANSAXLE OR TRANSMISSION SLIPS, WON’T SHIFT, NO REVERSE, 2ND, 3RD OR OVERDRIVE, ERRATIC SHIFTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

350000 EQUIPMENT

GENERATION 5 ONSTAR STEERING WHEEL CONTROL FUNCTION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 061000 ENGINE AND ENGINE COOLING:ENGINE

EXCESSIVE OIL CONSUMPTION ON THE 2.2L L61 ECOTEC ENGINE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2003 010000 STEERING

SOME CUSTOMERS MAY COMMENT ON A CLUNK TYPE NOISE COMING FROM THE FRONT OF THE VEHICLE DURING A TURNING MANEUVER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2003 980000 UNKNOWN OR OTHER

SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND. THIS BULLETIN PROVIDES INFORMATION REGARDING RECREATIONAL (DINGHY) TOWING FOR CERTAIN VEHICLES INCLUDING 1988-2004 CHEVROLET AND GMC LI

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

CRUISE CONTROL SHUTS OFF WHEN THE HAZARDS ARE SWITCHED ON. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

180000 VEHICLE SPEED CONTROL

SUPPLEMENT TO 05-06-01-003A – WRONG THROTTLE GASKET PART NUMBER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2007 061000 ENGINE AND ENGINE COOLING:ENGINE

MULTIPLE DRIVEABILITY SYMPTOMS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 20, 2004 061000 ENGINE AND ENGINE COOLING:ENGINE

INTERMITTENT IDLE CONCERNS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 8, 2004 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

GM SERVICE TECHNICAL COLLEGE. *EH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2016 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 2003 100000 POWER TRAIN

2004 MODEL YEAR CHANGES FOR 4T40E AND 4T45E TRANSMISSIONS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 2008 353000 EQUIPMENT:ELECTRICAL

BUICK\CADILLAC\CHEVROLET\GMC\HUMMER\OLDSMOBILE\PONTIAC\SAAB\SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. FCC RULED IN 2002 WIRELESS CARRIERS WOULD NO LONGER R

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 350000 EQUIPMENT

02-05 ONSTAR EQUIPPED VEHICLES EMITTING BEEPING NOISE BEFORE CONNECTING TO ONSTAR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 19, 2016 110000 ELECTRICAL SYSTEM

THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT TH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

XM ERROR ON A RADIO DISPLAY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2004 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

HVAC MODE CONTROL HARD TO CHANGE SETTINGS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 26, 2016 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 18, 2003