1999 MERCURY Mountaineer

These recalls apply to the make, model, and year of your car – and should be fixed as soon as possible.

9 Recalls for 1999 MERCURY Mountaineer

Recall Date Component Summary
August 3, 2007 VEHICLE SPEED CONTROL

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Remedy:

DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

June 13, 2006 FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Remedy:

UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.

August 5, 2003 SEATS:FRONT ASSEMBLY:RECLINER

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER’S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.

Remedy:

DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

August 5, 2003 VEHICLE SPEED CONTROL:CABLES

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.

Remedy:

DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

March 7, 2000 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS “LOCK-UP” IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.

Remedy:

DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.

August 21, 2000 TIRES:TREAD/BELT

TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.

Remedy:

THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.

June 29, 1999 LATCHES/LOCKS/LINKAGES:HOOD:LATCH

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE SECONDARY HOOD LATCH MAY CORRODE AT THE LATCH PIVOT AND STICK IN THE OPEN POSITION.

Remedy:

DEALERS WILL INSTALL A SECONDARY HOOD LATCH WITH COMPONENTS THAT ARE COATED PRIOR TO ASSEMBLY FOR IMPROVED LATCH PIVOT CORROSION PROTECTION.

May 18, 1999 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT FRONT BRAKE LINE TO THE HYDRAULIC CONTROL UNIT (HCU) CONNECTION COULD SEPARATE CAUSING THE LINE TO LEAK WHEN THE BRAKE PEDAL IS APPLIED.

Remedy:

DEALERS WILL REPLACE THE FLARE NUT ON THE BRAKE LINE.

March 30, 1999 VEHICLE SPEED CONTROL

VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

Remedy:

DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.

These are complaints about vehicles like yours and some can only be found here. Do they sound familiar?

2 Complaints sent to the Center for Auto Safety for 1999 MERCURY Mountaineer

skip to NHTSA complaints

Date Component  
engine
accessories (cd/tape, radio, navigation system, etc)

156 Complaints submitted to NHTSA for 1999 MERCURY Mountaineer

skip to CAS complaints

Date Component  
SUSPENSION
ODI Number: 10218285
STEERING
ODI Number: 10073412
ELECTRICAL SYSTEM
ODI Number: 10040607
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 10101214
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
ODI Number: 8015321
TIRES:TREAD/BELT
ODI Number: 10928208
VEHICLE SPEED CONTROL
ODI Number: 11098222
AIR BAGS
ODI Number: 11061016
POWER TRAIN
ODI Number: 10617975
VISIBILITY/WIPER
ODI Number: 10512583
FUEL SYSTEM, GASOLINE
ODI Number: 10439981
ELECTRICAL SYSTEM
ODI Number: 10410359
ENGINE AND ENGINE COOLING
ODI Number: 10399883
VISIBILITY
ODI Number: 10286967
TIRES
ODI Number: 10249272
ENGINE AND ENGINE COOLING
ODI Number: 10226614
VEHICLE SPEED CONTROL
ODI Number: 10219550
STRUCTURE:BODY:HOOD
ODI Number: 10220689
SUSPENSION
ODI Number: 10218285
SEATS:FRONT ASSEMBLY:RECLINER
ODI Number: 10211509
VEHICLE SPEED CONTROL
ODI Number: 10212969
ELECTRICAL SYSTEM
ODI Number: 10186820
AIR BAGS:FRONTAL
ODI Number: 10175165
AIR BAGS:FRONTAL
ODI Number: 10156533
STRUCTURE:BODY:TAILGATE
ODI Number: 10153317
AIR BAGS | ENGINE AND ENGINE COOLING:ENGINE | POWER TRAIN:AUTOMATIC TRANSMISSION | TIRES | VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR | VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 10137734
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR | TIRES
ODI Number: 10129122
TIRES
ODI Number: 10120475
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
ODI Number: 10120444
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
ODI Number: 10116705
ENGINE AND ENGINE COOLING
ODI Number: 10109204
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
ODI Number: 10102429
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 10101214
AIR BAGS:FRONTAL | SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES | VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
ODI Number: 10101124
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
ODI Number: 10095411
TIRES
ODI Number: 10096395
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
ODI Number: 10088396
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
ODI Number: 10089443
STEERING:LINKAGES:TIE ROD ASSEMBLY
ODI Number: 10086125
STEERING
ODI Number: 10073412
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
ODI Number: 10071427
ENGINE AND ENGINE COOLING | EQUIPMENT:ELECTRICAL | TIRES
ODI Number: 10069447
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 10064976
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
ODI Number: 10063952
AIR BAGS:SIDE/WINDOW
ODI Number: 10064799
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
ODI Number: 10060089
VEHICLE SPEED CONTROL:CRUISE CONTROL
ODI Number: 10054587
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH | SERVICE BRAKES, AIR | SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT | SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR
ODI Number: 10053195
ELECTRICAL SYSTEM | ELECTRICAL SYSTEM:WIRING
ODI Number: 10049012
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE | VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 10050127
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
ODI Number: 10051109
SEATS:FRONT ASSEMBLY:RECLINER
ODI Number: 10043996
SEATS:FRONT ASSEMBLY:RECLINER
ODI Number: 10042091
AIR BAGS
ODI Number: 10041429
ELECTRICAL SYSTEM
ODI Number: 10040607
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
ODI Number: 10040369
VEHICLE SPEED CONTROL:CABLES | VEHICLE SPEED CONTROL:CRUISE CONTROL
ODI Number: 10038623
TIRES:TREAD/BELT
ODI Number: 10040028
STRUCTURE:FRAME AND MEMBERS
ODI Number: 10039685
TIRES
ODI Number: 10034449
AIR BAGS:FRONTAL
ODI Number: 10024268
AIR BAGS
ODI Number: 10020099
EQUIPMENT:MECHANICAL:ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT | TIRES:TREAD/BELT
ODI Number: 10021579
SEATS:FRONT ASSEMBLY:RECLINER
ODI Number: 10018544
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
ODI Number: 10008218
STEERING:COLUMN
ODI Number: 10001972
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER
ODI Number: 8024154
SUSPENSION:FRONT:CONTROL ARM
ODI Number: 8015888
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ODI Number: 8016789
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
ODI Number: 8015321
AIR BAGS:FRONTAL
ODI Number: 8017502
EQUIPMENT:MECHANICAL:CARRIER/RACK
ODI Number: 8017091
TIRES
ODI Number: 10439000
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ODI Number: 891151
TIRES:TREAD/BELT
ODI Number: 881995
TIRES
ODI Number: 883634
TIRES:TREAD/BELT
ODI Number: 878050
TIRES
ODI Number: 875766
TIRES:TREAD/BELT
ODI Number: 868969
TIRES
ODI Number: 871963
TIRES:TREAD/BELT
ODI Number: 870126
TIRES:TREAD/BELT
ODI Number: 868360
TIRES:TREAD/BELT
ODI Number: 870045
TIRES:TREAD/BELT
ODI Number: 869979
TIRES:TREAD/BELT
ODI Number: 869947
ELECTRICAL SYSTEM:12V/24V/48V BATTERY | ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | EXTERIOR LIGHTING:HEADLIGHTS
ODI Number: 861746
TIRES:TREAD/BELT
ODI Number: 866996
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 857307
ELECTRICAL SYSTEM:HORN
ODI Number: 857095
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 852210
AIR BAGS
ODI Number: 853232
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 844155
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 848858
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 843633
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 843619
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
ODI Number: 844008
EQUIPMENT:APPLIANCE:AIR CONDITIONER | VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 843191
SUSPENSION
ODI Number: 844743
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 844731
EXTERIOR LIGHTING:TURN SIGNAL:SWITCH | VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 848289
INTERIOR LIGHTING
ODI Number: 846291
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 845439
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 843397
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 847430
VEHICLE SPEED CONTROL:LINKAGES
ODI Number: 846603
POWER TRAIN:DRIVELINE
ODI Number: 769037
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ODI Number: 767790
AIR BAGS | ELECTRICAL SYSTEM:WIRING
ODI Number: 762438
VISIBILITY:WINDSHIELD
ODI Number: 760953
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
ODI Number: 760584
SUSPENSION
ODI Number: 753489
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
ODI Number: 751818
TIRES
ODI Number: 745686
VEHICLE SPEED CONTROL
ODI Number: 746151
POWER TRAIN:AXLE ASSEMBLY
ODI Number: 744323
TIRES
ODI Number: 739355
ENGINE AND ENGINE COOLING:ENGINE
ODI Number: 736779
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
ODI Number: 735965
TIRES
ODI Number: 734723
TIRES
ODI Number: 734603
SEAT BELTS:FRONT:BUCKLE ASSEMBLY | SEAT BELTS:FRONT:BUCKLE ASSEMBLY
ODI Number: 734262
TIRES
ODI Number: 732823
TIRES
ODI Number: 732589
TIRES
ODI Number: 731739
TIRES:TREAD/BELT
ODI Number: 731952
TIRES
ODI Number: 731410
TIRES
ODI Number: 731406
TIRES:SIDEWALL
ODI Number: 731266
TIRES
ODI Number: 731232
TIRES
ODI Number: 730618
TIRES
ODI Number: 728773
TIRES:BEAD
ODI Number: 729059
TIRES
ODI Number: 728541
STEERING: STEERING WHEEL/HANDLE BAR
ODI Number: 727168
TIRES:TREAD/BELT
ODI Number: 726891
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 725652
UNKNOWN OR OTHER
ODI Number: 722270
WHEELS:LUGS/NUTS/BOLTS
ODI Number: 721980
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 712395
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 712359
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 710315
VISIBILITY:WINDSHIELD WIPER/WASHER
ODI Number: 708613
TIRES:TREAD/BELT
ODI Number: 563919
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
ODI Number: 559870
TIRES:TREAD/BELT
ODI Number: 559105
TIRES:TREAD/BELT
ODI Number: 556944
TIRES
ODI Number: 556447
TIRES:TREAD/BELT
ODI Number: 557423
TIRES:SIDEWALL | TIRES:SIDEWALL
ODI Number: 555064
TIRES
ODI Number: 556238
TIRES
ODI Number: 554076
TIRES
ODI Number: 554309
SERVICE BRAKES, AIR | SERVICE BRAKES, HYDRAULIC | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
ODI Number: 549159
VEHICLE SPEED CONTROL
ODI Number: 546030
TIRES
ODI Number: 744000
TIRES:SIDEWALL | TIRES:SIDEWALL
ODI Number: 558200
Is the government investigating the safety of your vehicle? Find out here.

6 Investigations for 1999 MERCURY Mountaineer

Date Opened Date Closed Component  
ENGINE AND ENGINE COOLING
VISIBILITY
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
ENGINE AND ENGINE COOLING:ENGINE
SEATS:FRONT ASSEMBLY:RECLINER
POWER TRAIN
Manufacturers tell dealers about repairs for on your car. But they won’t tell you – unless you know to ask. Knowledge is power.

303 Service Alerts for 1999 MERCURY Mountaineer

Date Description
March 7, 2005 282100 BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT

FALSE PARKING AID WARNINGS. *TT UPDATE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 2, 2002 125100 EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

SOME VEHICLES MAY EXHIBIT A CD CHANGER WITH A CD MAGAZINE THAT JAMS / WILL NOT EJECT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 070000 FUEL SYSTEM, GASOLINE

SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK CONDITION DUE TO FUEL SYSTEM PRESSURE BLEED DOWN. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES EQUIPPED WITH 4R44E OR 5R55E TRANSMISSION MAY EXHIBIT SLIPPING SHIFTS, DELAYED OR NO ENGAGEMENTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 162000 STRUCTURE:BODY

USE KLEENEX BRAND JUNIORS OR LI’L TRAVELERS TO REFILL TISSUES FOR CERTAIN VEHICLES WITH THE HIGH SERIES CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 020000 SUSPENSION

SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE REAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK CONDITION AFTER SITTING FOR AN HOUR OR MORE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2001 137000 VISIBILITY:REAR WINDOW WIPER/WASHER

CONCERNS WITH REAR WIPERS THAT DO NOT SUFFICIENTLY CLEAN THE BACK GLASS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 3, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 22, 2001 036100 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODES B1994 AND / OR B1998 STORED IN MEMORY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 22, 2001 141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODES B1994 AND / OR B1998 STORED IN MEMORY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

INFORMATION ON VEHICLES EQUIPPED WITH AN OPTIONAL TRAVEL / NOTE DIGITAL VOICE MEMO RECORDER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 012200 STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE

SOME VEHICLES BUILT FROM 11/12/98 UNTIL 11/19/98 EQUIPPED WITH KEYLESS ENTRY AND PATS MAY EXHIBIT THE ALARM OPERATING PREMATURELY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 162000 STRUCTURE:BODY

SOME VEHICLES MAY EXHIBIT A WATER LEAK CONCERN FROM THE MOONROOF. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

INFORMATION ON VEHICLES EQUIPPED WITH AN OPTIONAL TRAVEL / NOTE DIGITAL VOICE MEMO RECORDER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 13, 2003 110000 ELECTRICAL SYSTEM

MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2003 100000 POWER TRAIN

AN UNCOMMANDED SHIFT TO 4X4 LOW. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 22, 2002 061000 ENGINE AND ENGINE COOLING:ENGINE

INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 26, 1998 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

EXPERIENCING A NOISE AND VIBRATION DURING IDLE.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 15, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 2, 2000 072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2000 355100 EQUIPMENT:OTHER:LABELS

SUBJECT PERTAINING TO SUPPLEMENTAL TIRE INFLATION LABEL. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

CONCERNS WITH OIL LEAK OF THE ENGINE BLOCK AT THE OIL PRESSURE SWITCH BOSS. TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 036400 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

VEHICLES MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1676. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

SOME 4X4 VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

EXPERIENCING FRONT WIPERS ACTIVATION WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 110000 ELECTRICAL SYSTEM

CONCERNS WITH MULTIPLE GENERIC ELECTRONIC MODULE (GEM) FUNCTIONAL CONCERNS (I.E., INOPERATIVE ONE TOUCH DOWN, CHIME, 4X4 SHIFT MOTOR, ETC.) *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 070000 FUEL SYSTEM, GASOLINE

CONDITIONS ON HARD START DUE TO FUEL SYSTEM PRESSURE BLEED DOWN. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 1999 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

A CONDITION WITH THE REAR WIPER BLADE ON VEHICLES BUILT THROUGH 1/22/1999 MAY FLIP OVER WHEN RUN THROUGH SOFT CLOTH STYLE CAR WASHES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

SOME VEHICLES MAY EXHIBIT A CD CHANGER WITH A CD MAGAZINE THAT JAMS / WILL NOT EJECT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

SOME VEHICLES MAY EXHIBIT A POP / CREAK NOISE FROM THE RIGHT A PILLAR / UPPER DOOR HINGE AREA WHILE DRIVING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

SERVICE TIP INFORMATION WHEN SERVICING THE 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

SOME VEHICLES MAY EXHIBIT A POP / CREAK NOISE FROM THE RIGHT A PILLAR / UPPER DOOR HINGE AREA WHILE DRIVING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

SERVICE TIPS INFORMATION PROVIDED TO ASSIST WHEN SERVICING VEHICLES WITH SHORT BLOCK ASSEMBLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

CONTINUED FROM 13251, UNCOMMANDED FRONT WIPER FUNCTION . *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

INFORMATION REGARDING UNCOMMANDED FRONT WIPER FUNCTION (CONTINUED ON 13252 AND 13253). *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 2001 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE. *YH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2001 110000 ELECTRICAL SYSTEM

INFORMATION ON REPLACING A GEM MODULE ON 4X4 VEHICLES EQUIPPED WITH 4.0L SOHC, OHV AND THE NEUTRAL TOW KIT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2001 106220 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2001 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / MOAN AT HIGHWAY SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 13, 2000 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2000 980000 UNKNOWN OR OTHER

SOME VEHICLES MAY COME IN FOR A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 IN SELF TEST. **MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2000 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT A HARD START / NO START CONDITION WHEN ATTEMPTING TO START THE VEHICLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

SOME VEHICLES EQUIPPED WITH A DUAL MEDIA (AM/FM/CASS/CD) RADIO MAY EXHIBIT AN AUDIO CONCERN OF NO DISPLAY OR GRAPHICS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 020000 SUSPENSION

SOME VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / PULSATION FELT FROM THE DRIVELINE IN THE STEERING WHEEL AND FLOORPAN ON ACCELERATION / LIGHT TIP-IN AT 25-35 MPH WHEN IN 4 AUTO MODE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 26, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SOME VEHICLES MAY EXHIBIT A BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE OCCURING WHEN THE BLOWER MOTOR IS RUNNING IF LEAVES OR FOREIGN MATERIAL ENTERS THE BLOWER CASE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 26, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 18, 2002 980000 UNKNOWN OR OTHER

SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES BUILT BEFORE APRIL 23, 2001 MAY EXHIBIT A HARD START/LONG CRANK AFTER SITTING FOR AN HOUR OR MORE DUE TO FUEL SYSTEM CONTAMINATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

CONCERNS WITH SPARK KNOCK NOISE OR CHAIN RATTLE NOISE BETWEEN 2000-3000 RPM, DURING COLD ENGINE OPERATION ONLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2000 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES BUILT THROUGH 01/1999, EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A COLD START OR HOT ENGINE DECELERATION NOISE COMING FROM THE #5 CYLINDER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2000 980000 UNKNOWN OR OTHER

SOME VEHICLES EQUIPPED WITH 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT (MIL) ON WITH POSSIBLE DIAGNOSTIC TROUBLE CODES (DTC) P0351, P0352, P0353 AND / OR P0354 IN SELF TEST WITH NO DRIVEABILITY CONCERNS PRESENT.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 12, 2003 090000 FUEL SYSTEM, OTHER

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 31, 2004 110000 ELECTRICAL SYSTEM

WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS. *MJ UPDATE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 23, 1998 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 12, 1998 221600 SEATS:FRONT ASSEMBLY:POWER ADJUST

CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2000 980000 UNKNOWN OR OTHER

INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 5, 2003 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

NEW SERVICE PART – NUMBER 5 NEEDLE BEARING AND RACE KIT – 4R70W TRANSMISSION – SERVICE TIP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 30, 2001 106000 POWER TRAIN:AXLE ASSEMBLY

ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 2, 2001 116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

INFORMATION ON REPLACING A FOUR WHEEL ANTI-LOCK BRAKES (4WABS) HYDRAULIC CONTROL UNIT (HUC). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

INFORMATION ON REPAIRING CLIMATE CONTROL SYSTEM INTERIOR ODOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

VEHICLES MAY EXHIBIT VARIOUS NOISES FROM THE POWER WINDOW REGULATOR DURING OPERATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

VEHICLE MAY EXHIBIT A SQUEAKING NOISE FROM THE DOOR(S) POWER WINDOW GLASS DURING OPERATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

INFORMATION REGARDING THE AUDIO SYSTEM SELECTIVE LIGHTING FEATURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 190000 TIRES

SUBJECT REGARDING REVOLUTIONS PER MILE TIRE SIZE DATA. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING HIGHER BASE IDLE STRATEGY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 183000 VEHICLE SPEED CONTROL:CABLES

VEHICLE EXHIBITING A VIBRATION OR BUZZ FELT THROUGH THE ACCELERATOR PEDAL OR FRONT FLOORBOARD AREA. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

COMPLAINTS THAT THE FRONT WIPERS ACTIVATE WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 020000 SUSPENSION

EXPERIENCING VIBRATION AT HIGHWAY SPEEDS DUE TO TIRE / WHEEL IMBALANCE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2004 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

INFORMATION REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

INFORMATION REGARDING REAR AXLE WHINE AT HIGHWAY SPEEDS. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

INFORMATION REGARDING SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

INFORMATION REGARDING 4.0L SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

INFORMATION REGARDING 4.0 L SOHC CAMSHAFT BOLT TORQUE. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SUBJECT ON MANUAL A/C SYSTEM-BLOWER WORKS IN HIGH SETTING ONLY. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 354600 EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES

INFORMATION REGARDING NEUTRAL TOW KIT AVAILABILITY. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 220000 SEATS

INFORMATION REGARDING SEAT THAT WILL NOT MOVE FORWARD. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 353000 EQUIPMENT:ELECTRICAL

INFORMATION REGARDING RADIO LIGHTS AND DISPLAY FLICKER/FLASH WITH HEADLIGHTS ON. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 022000 SUSPENSION:REAR

INFORMATION REGARDING REAR AXLE WHINE AT HIGHWAY SPEEDS. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 20, 1999 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 6, 1999 100000 POWER TRAIN

EXPERIENCING AN INOPERATIVE OR INACCURATE ODOMETER / SPEEDOMETER READINGS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 6, 1999 980000 UNKNOWN OR OTHER

SOME VEHICLES MAY EXHIBIT AN INTERMITTENT TRANSMISSION CONTROL INDICATOR LAMP OR MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 15, 2003 110000 ELECTRICAL SYSTEM

REMOTE KEYLESS ENTRY (RKE) – SERVICE TIPS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2002 020000 SUSPENSION

SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 020000 SUSPENSION

EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 022110 SUSPENSION:REAR:SPRINGS:COIL SPRINGS

EXHIBITING A SQUEAK TYPE NOISE FROM THE REAR STABILIZER BAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

EXHIBITING A LACK OF HEAT, EXHAUST SULPHUR SMELL AND / OR MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0125. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 354600 EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES

VEHICLES EQUIPPED THE NEUTRAL TOW FEATURE, BE AWARE THAT WHEN THE NEUTRAL TOW FEATURE IS ENABLED AND THE CUSTOMER PLACES THE VEHICLE INTO THE NEUTRAL MODE, THE NEUTRAL TOW INDICATOR WILL GO OUT WHEN THE GEM GOES TO SLEEP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

SOME VEHICLES MAY EXHIBIT NO / LOW A/C PERFORMANCE AT HIGH AMBIENT TEMPERATURES AND PROLONGED IDLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

SOME VEHICLES MAY EXHIBIT FRONT WINDSHIELD WIPER ACTIVATION WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

SOME VEHICLES MAY EXHIBIT AN AIR BAG LAMP ON WITH SIDE AIR BAG DIAGNOSTIC TROUBLE CODES B1994 AND / OR B1998 IN SELF TEST. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

A CONDITION MAY EXIST WHERE THE LEFT FRONT POWER WINDOW IS INOPERATIVE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2000 104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

SOME ALL WHEEL DRIVE VEHICLES MAY EXPERIENCE A LOW SPEED WHINING NOISE FROM THE TRANSFER CASE. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

INFORMATION ON REPLACING AND REMOVING THE GENERIC ELECTRONIC MODULE (GEM). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 031000 SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

CUSTOMERS MAY PERCEIVE A CONDITION IN WHICH THE BRAKE PEDAL IS SLOW TO RETURN AFTER IT IS APPLIED ON VEHICLES BUILT PRIOR TO 5/18/99. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

CONCERNS WITH 4.0L SOHC ENGINES EQUIPPED VEHICLES EXHIBITING AN OIL LEAK FROM THE OIL PRESSURE SWITCH BOSS OF THE ENGINE BLOCK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

INFORMATION REGARDING THE RIGHT REAR A/C COMPRESSOR MOUNTING BOLT THAT WAS DELETED FROM PRODUCTION FOR SOME MODELS *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2000 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

SOME VEHICLES BUILT THROUGH 11/22/99 AND EQUIPPED WITH 4.0L SOHC ENGINE MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS THAT LEAD TO IDLE AIR CONTROL (IAC) VALVE REPLACEMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 9, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

CONCERNS WITH SLIPPING TRANSMISSION SHIFTS AND / OR DELAYED OR NO TRANSMISSION ENGAGEMENTS MAY OCCUR ON SOME VEHICLES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

SOME VEHICLES MAY EXHIBIT MULTIPLE GENERIC ELECTRONIC MODULE (GEM) FUNCTIONAL CONCERNS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

CONCERNS WITH LACK OF HEAT AND / OR MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0125. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

SOME VEHICLES BUILT BEFORE 1/1/1999 EQUIPPED WITH 5.0L ENGINE MAY EXHIBIT A FRONT ACCESSORY DRIVE (FEAD) BELT NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 355100 EQUIPMENT:OTHER:LABELS

INFORMATION REGARDING VIN NUMBERS BEING ACTIVE 5/11/1999. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 350000 EQUIPMENT

SUBJECT REGARDING THE ABS MODULE ACTIVE COMMAND MODES FEATURE OF NGS SOFTWARE VERSION 16.1. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 104000 POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

VIBRATION ON LIGHT TO MODERATE ACCELERATION AT 0 – 45 MPH ON A4WD VEHICLES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

SOME VEHICLES MAY EXHIBIT FRONT WINDSHIELD WIPER ACTIVATION WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT REGARDING THE SBDS RELATIVE CAM TIMING TEST. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 110000 ELECTRICAL SYSTEM

SOME VEHICLES MAY EXHIBIT NO 2-STEP UNLOCK OR A FALSE DIAGNOSTIC TROUBLE CODE B1834 (DOOR UNLOCK DISARM OUTPUT – CIR) GENERATED BY THE GEM. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

SOME VEHICLES WITH AUTOMATIC 4 WHEEL DRIVE (A4WD) MAY EXHIBIT MULTIPLE GENERIC ELECTRONIC MODULE (GEM) FUNCTIONAL CONCERNS (I.E., INOPERATIVE ONE TOUCH DOWN, CHIME, 4X4 SHIFT MOTOR, ETC.). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 138120 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT

INFORMATION ON DAMAGED, SCRATCHED, SCUFFED MANUAL A/C CONTROL KNOBS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 036400 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

SOME VEHICLES MAY EXHIBIT AN ABS LAMP ON WITH DIAGNOSTIC TROUBLE CODE B1676 IN SELF TEST. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 14, 1999 980000 UNKNOWN OR OTHER

INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 17, 1999 020000 SUSPENSION

EXPERIENCING DRIFT / PULL TO THE RIGHT CONDITONS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 182000 VEHICLE SPEED CONTROL:LINKAGES

RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 1999 100000 POWER TRAIN

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 8, 1999 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 4, 2002 111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

INFORMATION REGARDING DISCHARGED BATTERY CHARGING SERVICE TIPS AND GUIDELINES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 4, 2002 106000 POWER TRAIN:AXLE ASSEMBLY

CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 15, 2002 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

INFORMATION ON DIAGNOSING ENGINE RATTLE NOISE FROM PRIMARY CHAIN DRIVE AREA BETWEEN 2000-3000 RPM ON COLD ENGINE OPERATION ONLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 10, 2003 102000 POWER TRAIN:MANUAL TRANSMISSION

LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2003 022000 SUSPENSION:REAR

VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 27, 1999 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING, HESITATION AFTER ACCELERATION FROM STOP AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP ON VEHICLES WITH 4.0L OR 5.0L ENGINES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOISE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

SUBJECT REGARDING ALL VEHICLES REQUIRES A PARAMETER RESET TO BE PERFORMED ON THE PASSIVE ANTI-THEFT SYSTEM MODULE (PATS / VIC / HEC) WHEN THE POWERTRAIN CONTROL MODULE (PCM) IS REPLACED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

SOME VEHICLES MAY EXHIBIT A CONCERN WITH THE POWER WINDOW(S) BECOMING INOPERATIVE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SERVICE TIPS WHEN SERVICING A 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

VEHICLES EQUIPPED WITH 4.0L SOHC ENGINE MAY EXHIBIT A SLIGHT HESITATION ON ACCELERATION DURING ENGINE WARM UP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 162300 STRUCTURE:BODY:DOOR

SOME VEHICLES MAY EXHIBIT A FUSE #18 OPEN / POWER DOOR LOCKS CYCLING UNCOMMANDED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

VEHICLES EQUIPPED WITH 5.0L ENGINES AND 3.73:1 RATIO / 8.8 INCH RING GEAR REAR AXLES MAY EXHIBIT A WHINE NOISE DURING VARIOUS DRIVE MODES AT SPEEDS BETWEEN 45 TO 65 MPH. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 13, 2004 138200 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR – TERMINAL TAB REPAIR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 2002 100000 POWER TRAIN

SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 9, 2004 138120 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT

REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR – TERMINAL TAB REPAIR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2002 072200 FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 21, 2002 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 17, 2001 103800 POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH

BRAKE SHIFT INTERLOCK.*JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 2001 126200 EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

INFORMATION REGARDING MULTIFUNCTION SWITCH PART NUMBER CLARIFICATION. *SLC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2000 020000 SUSPENSION

SUBJECT REGARDING POP / CREAK NOISE FROM THE REAR UNDERBODY WHILE DRIVING. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2000 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES BUILT THROUGH 01/1999 AND EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A COLD START OR HOT ENGINE DECELERATION NOISE COMING FROM THE #5 CYLINDER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2000 980000 UNKNOWN OR OTHER

SOME VEHICLES EQUIPPED WITH 5.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT (MIL) ON WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0351, P0352, P0353 AND / OR P0354 IN SELF TEST WITH NO DRIVEABILITY CONCERNS PRESENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 27, 2000 181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

ON SOME VEHICLES, THE ACCELERATOR PEDAL BRACKET MAY BECOME LOOSE OR SEPARATED FROM THE DASH PANEL. THIS MAY BE CAUSED BY REPEATED EXCESSIVE FORCE ON THE ACCELERATOR PEDAL, RESULTING IN CRACKING OF THE DASH PANEL SHEET METAL AT THE ACCELER

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

RIGHT REAR AIR CONDITIONER COMPRESSOR MOUNTNG BOLT WAS DELETED FROM PRODUCTION FOR THE 1999 3.OL EF1/4 RANGER & 4.0L EXPLORER/MOUNTAINEER VEHICLES. *TT OHV

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2000 980000 UNKNOWN OR OTHER

SOME VEHICLES EQUIPPED WITH 5.0L ENGINES AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2000 020000 SUSPENSION

ENGINEERING IS CURRENTLY INVESTIGATING CONCERNS WITH VEHICLES EXHIBITING A VIBRATION AT HIGHWAY SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2000 181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

SOME VEHICLES WITH 4.0L SOHC ENGINE AND BUILT PRIOR TO 9/21/99 MAY EXHIBIT A VIBRATION OR BUZZ FELT THROUGH THE ACCELERATOR PEDAL WHICH IS MOST NOTICEABLE DURING ACCELERATION UNDER 2000 RPMS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 7, 1998 110000 ELECTRICAL SYSTEM

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ – 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 162000 STRUCTURE:BODY

SOME VEHICLES MAY EXHIBIT A WATER LEAK CONCERN FROM THE MOONROOF. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 110000 ELECTRICAL SYSTEM

FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2000 106220 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2000 061000 ENGINE AND ENGINE COOLING:ENGINE

SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2000 106220 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2000 061000 ENGINE AND ENGINE COOLING:ENGINE

SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 2001 190000 TIRES

OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION – REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES WITH 4R44E / 5R55E TRANSMISSIONS MAY EXHIBIT SLIPPING SHIFTS, DELAYED OR NO ENGAGEMENTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 162000 STRUCTURE:BODY

INFORMATION ON REFILLING TISSUES FOR THE CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

EXHIBITING FRONT WINDSHIELD WIPER ACTIVATION WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

EXHIBITING A LACK OF HEAT AND / OR A MALFUNCTION INDICATOR LAMP (MIL) LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0125. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 110000 ELECTRICAL SYSTEM

CONCERNS WITH MULTIPLE GENERIC ELECTRONIC MODULE (GEM) (I.E., INOPERATIVE ONE TOUCH DOWN, CHIME, 4X4 SHIFT MOTOR, ETC). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS

VEHICLES MAY EXHIBIT A FRONT ACCESSORY DRIVE (FEAD) BELT NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 12, 1998 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

EXPERIENCING A ” BUZZING ” OR ” RATTLING ” NOISE FROM THE EXHAUST SYSTEM. *YC

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 6, 1999 980000 UNKNOWN OR OTHER

VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

CONCERNS WITH BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE WHILE BLOWER MOTOR IS ON. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 4, 1999 162200 STRUCTURE:BODY:BUMPERS

INFORMATION ON REPLACING THE FRONT BUMPER BRACKET. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 11, 2001 106000 POWER TRAIN:AXLE ASSEMBLY

SOME 4X4 VEHICLES MAY EXHIBIT A HIGH-PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT AXLE AREA OF THE VEHICLE AT SPEEDS FROM 16 TO 64 KM/H (10 TO 40 MPH). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 3, 1999 162300 STRUCTURE:BODY:DOOR

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT – SERVICE TIP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 3, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

CONCERNS OR ERRATIC OR INSUFFICIENT TEMPERATURE CONTROL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 3, 1999 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING; HESITATION AFTER ACCELERATION FROM STOP; AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 21, 2003 103600 POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES

NEW TRANSMISSION COOLER FLUSHER – SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 2000 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

SOME VEHICLES BUILT THROUGH 11/22/99 AND EQUIPPED WITH 4.0L SOHC ENGINE MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS THAT LEAD TO IDLE AIR CONTROL (IAC) VALVE REPLACEMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2000 350000 EQUIPMENT

INFORMATION ON 5R55E – 4R55E – 4R44E PUMP ALIGNMENT TOOLS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2000 354600 EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES

SUBJECT REGARDING NEUTRAL TOW INOPERATIVE AFTER GEM REPLACEMENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

February 1, 2000 330000 INTERIOR LIGHTING

SOME VEHICLES EQUIPPED WITH 5.0L ENGINE AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 1999 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

SOME VEHICLES WITH 4.0L OHV ENGINES BUILT AFTER 6/10/99 AT LOUISVILLE ASSEMBLY PLANT OR AFTER 6/14/99 AT ST. LOUIS ASSEMBLY PLANT MAY EXHIBIT A HIGHER THAN NORMAL BASE IDLE SPEED OF 1400-1600 RPM WHEN THE VEHICLE IS INITIALLY RECEIVED FROM

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 1999 181000 VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

EXPERIENCING A VIBRATION OR BUZZ FELT THROUGH THE ACCELERATOR PEDAL WHICH IS MOST NOTICEABLE DURING ACCELERATION UNDER 2000 RPMS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

SOME VEHICLES MAY EXHIBIT FRONT WINDSHIELD WIPER ACTIVATION WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT AN OIL LEAK FROM THE OIL PRESSURE SWITCH BOSS OF THE ENGINE BLOCK. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 1999 036400 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

SOME VEHICLES MAY EXHIBIT AN ABS LAMP ON WITH DIAGNOSTIC TROUBLE CODE B1676 IN SELF TEST. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 7, 2005 282100 BACK OVER PREVENTION:WARNINGS:EXTERNAL

FALSE PARKING AID WARNINGS. *TT UPDATE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES MAY EXHIBIT A WHINE NOISE FROM THE REAR AXLE DURING VARIOUS DRIVE MODES AT HIGHWAY SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES MAY EXHIBIT ENGINE NOISE(CAM CHAIN NOISE). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

INFORMATION REGARDING 4.0L SOHC CAMSHAFT BOLT TORQUE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 980000 UNKNOWN OR OTHER

SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODE PO420. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 020000 SUSPENSION

CONCERNS WITH SQUEAK -TYPE NOISE FROM THE REAR WHILE DRIVING OR GOING OVER BUMPS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 350000 EQUIPMENT

SUBJECT REGARDING THE ABS MODULE ACTIVE COMMAND MODES FEATURES OF THE NGS SOFTWARE VERSION 16.1 IS NOT FUNCTIONING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 110000 ELECTRICAL SYSTEM

INFORMATION ON REMOVING AND / OR REPLACING THE GENERIC ELECTRONIC MODULE (GEM). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 031000 SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES

A CONDITION IN WHICH THE BRAKE PEDAL IS SLOW TO RETURN AFTER IT IS APPLIED ON VEHICLES BUILT PRIOR TO 5/18/1999. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 29, 1999 126200 EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

ON SOME VEHICLES, THE FRONT WINDSHIELD WIPERS MAY OPERATE WHILE THE MULTIFUNCTION SWITCH IS IN THE OFF POSITION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 29, 2002 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

ON SOME VEHICLES, THE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) BLOWS COLD AIR FROM THE FLOOR DUCTS ON VEHICLES PRODUCED BEFORE 9/30/2000 ONLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 29, 2002 100000 POWER TRAIN

SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 29, 2002 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC (SINGLE OVER-HEAD CAM) ENGINE MAY EXHIBIT A PRIMARY TIMING CHAIN RATTLE NOISE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

VEHICLES WITH AUTOMATIC 4 WHEEL DRIVE MAY EXHIBIT MULTIPLE GENERIC ELECTRONIC MODULE (GEM) FUNCTIONAL CONCERNS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 020000 SUSPENSION

SOME VEHICLES WITH A4WD BUILT PRIOR TO 9/13/99 MAY EXHIBIT A VIBRATION / PULSATION AT 0 – 45 MPH. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 980000 UNKNOWN OR OTHER

EXHIBITING A MISS / ROUGH IDLE WITH THE MALFUNCTION INDICATOR LIGHT (MIL) ON AND DTC P0340 IN SELF TEST. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

SOME VEHICLES BUILT PRIOR TO 9/15/99 MAY EXHIBIT FRONT WINDSHIELD WIPER ACTIVATION WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 1, 1999 106220 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 1, 2002 010000 STEERING

EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 2002 140000 AIR BAGS

SOME VEHICLES MAY EXHIBIT REPEAT SERVICE FOR AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODE B1994 (DRIVER SIDE AIR BAG CIRCUIT RESISTANCE HIGH) AND / OR B1998 (PASSENGER SIDE AIR BAG CIRCUIT RESISTANCE HIGH). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 114400 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

SOME VEHICLES MAY EXHIBIT A CONDITION WITH FUSE #18 IN THE FUSE JUNCTION PANEL INTERMITTENTLY GOING OPEN. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 020000 SUSPENSION

SOME VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / MOAN AT HIGHWAY SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 014200 STEERING:RACK AND PINION:RACK

EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 980000 UNKNOWN OR OTHER

SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINE MAY EXHIBIT A CONDITION OF THE MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODE (DTC) P0161. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

SOME VEHICLES MAY EXHIBIT A HIGHER THAN NORMAL BASE IDLE SPEED OF 1400 – 1600 RPM WHEN THE VEHICLE IS INITIALLY RECEIVED FROM THE ASSEMBLY PLANT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

SOME VEHICLES MAY EXHIBIT FRONT WINDSHIELD WIPER ACTIVATION WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 020000 SUSPENSION

SOME VEHICLES MAY EXHIBIT A VIBRATION AT HIGHWAY SPEEDS DUE TO TIRE/WHEEL IMBALANCE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

VEHICLES WITH LIMITED SLIP / TRACTION-LOK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 102000 POWER TRAIN:MANUAL TRANSMISSION

BRIEF INFORMATION ON CHECKING TRANSMISSION FLUID LEVEL. *T

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES MAY EXHIBIT A HIGH PITCHED SQUEAL OR WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 12, 1999 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

INFORMATION ON USING THE SERVICE BAY TECHNICAL SYSTEM (SBTS) AND NEW GENERATION STAR (NGS) TESTER, AND TO UPDATE THE POWERTRAIN CONTROL MODULE (PCM) INFORMATION CHARTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 12, 1999 980000 UNKNOWN OR OTHER

VEHICLES WITH A4WD TRANSMISSION AND 4.0L ENGINE MAY HAVE THE 4X4 INDICATOR LAMPS FLASHING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 29, 2003 061000 ENGINE AND ENGINE COOLING:ENGINE

RATTLE/BUZZ SOUND FROM UNDER THE VEHICLE ON 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 2000 061000 ENGINE AND ENGINE COOLING:ENGINE

FORD MOTOR COMPANY IS PROVIDING ADDITIONAL COVERAGE FOR THE 4.0L SOHC CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 020000 SUSPENSION

INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 1998 012200 STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE

SOME VEHICLES BUILT FROM 11/12/98 UNTIL 11/19/98 EQUIPPED WITH KEYLESS ENTRY AND PASSIVE ANTI-THEFT SYSTEM (PATS) MAY EXHIBIT THE ALARM OPERATING PREMATURELY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 350000 EQUIPMENT

ON SOME VEHICLES BUILT BETWEEN 9/14/98 AND 10/28/98, THE REAR LIFTGATE APPLIQUE LETTERING MAY BE DIFFICULT TO READ. NEW APPLIQUES HAVE NOW BEEN RELEASED WHICH INCORPORATE CHROME LETTERING TO ENHANCE THE VISIBILITY OF THE BRAND NAME.

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 190000 TIRES

INFORMATION ON SETTING THE TIRE INFLATION PRESSURE FOR 1991 THROUGH 1999 MODEL YEAR VEHICLES IN THE PRE-DELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 061000 ENGINE AND ENGINE COOLING:ENGINE

SOME VEHICLES EQUIPPED WITH 5.0L ENGINES MAY EXHIBIT AN UPPER ENGINE TAPPING NOISE ON COLD START. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 2, 2002 032100 SERVICE BRAKES, HYDRAULIC:SWITCHES:BRAKE LIGHT

LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

INFORMATION REGARDING MANUAL A/C SYSTEM- BLOWER WORKS IN HIGH SETTING ONLY. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 354600 EQUIPMENT:MECHANICAL:WRECKER AND WHEEL LIFT DEVICES

INFORMATION REGARDING NEUTRAL TOW KIT AVAILABLE. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 220000 SEATS

INFORMATION REGARDING SEAT THAT WILLL NOT MOVE FORWARD. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 330000 INTERIOR LIGHTING

INFORMATION REGARDING RADIO LIGHTS AND DISPLAY FLICKER/FLASH WITH HEADLIGHTS ON. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 022000 SUSPENSION:REAR

INFORMATION REGARDING REAR AXLE WHINE AT HIGHWAY SPEEDS. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART (CONTINUED). *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 162000 STRUCTURE:BODY

EXPERIENCING WATER LEAK INTO THE VEHICLE THROUGH THE MOONROOF OPENING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 18, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

A NO START CONDITION WHEN VEHICLE IS PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL MAY OCCUR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2005 106000 POWER TRAIN:AXLE ASSEMBLY

FRONT AXLE LEAKS FLUID FROM VENT TUBE – VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2001 062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2001 103400 POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT

SOME 4.0L VEHICLES WITH A4WD BUILT PRIOR TO 9/13/99 MAY EXHIBIT A VIBRATION / PULSATION AT 0-45 MPH ON DRY PAVEMENT UNDER LIGHT TO MODERATE ACCELERATION IN 4 AUTO MODE WHICH MAY CHARACTERISTIC WITH THE CONTROL TRAC 4X4 SYSTEM. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2001 062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY

CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2001 061000 ENGINE AND ENGINE COOLING:ENGINE

VEHICLES MAY EXPERIENCE START UP TIMING CHAIN NOISE. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

January 1, 2001 980000 UNKNOWN OR OTHER

SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION MAY EXHIBIT THE TCIL ON WITH DIAGNOSTIC TROUBLE CODE P0741 (TORQUE CONVERTER CLUTCH SYSTEM PERFORMANCE OR STUCK OFF) IN CONTINUOUS MEMORY. *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 14, 1999 980000 UNKNOWN OR OTHER

FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 14, 1999 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES EQUIPPED WITH LIMITED SLIP / TRACTION-LOCK REAR AXLES MAY EXHIBIT A CHATTER NOISE WHILE TURNING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SERVICE TIPS FOR CHECKING TRANSMISSION FLUID LEVEL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

COMPLAINTS THAT THE REAR WIPER BLADE FLIPS OVER. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 185000 VEHICLE SPEED CONTROL:CRUISE CONTROL

SOME VEHICLES MAY EXHIBIT A MISS / ROUGH IDLE WITH THE MALFUNCTION INDICATOR LIGHT ON AND DIAGNOSTIC TROUBLE CODE P0340 IN SELF TEST. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 116200 ELECTRICAL SYSTEM:IGNITION:MODULE

VEHICLE EXHIBITING MULTIPLE GENERIC ELECTRONIC MODULE (GEM) RELATED SYMPTOMS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 1, 1999 106000 POWER TRAIN:AXLE ASSEMBLY

VEHICLE MAY EXHIBIT A HIGH PITCHED SQUEAL / WHISTLE TYPE NOISE FROM THE FRONT END AT SPEEDS FROM 10 MPH TO 40 MPH. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 10, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

September 1, 2001 034000 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS

CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

July 9, 2001 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES EQUIPPED WITH A 4R70W AUTOMATIC TRANSMISSION MAY EXHIBIT A CLUNK NOISE DURING THE 2-1 DOWNSHIFT EVENT. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2000 022000 SUSPENSION:REAR

SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 17, 2000 106000 POWER TRAIN:AXLE ASSEMBLY

SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 140000 AIR BAGS

SOME VEHICLES MAY EXHIBIT AN AIR BAG LAMP ON WITH SIDE AIR BAG DIAGNOSTIC TROUBLE CODES B1994 AND B1998 IN SELF TEST. ENGINEERING HAS RELEASED A ROBUST OVERLAY HARNESS TO INSTALL ON VEHICLES THAT COME IN FOR THIS ISSUE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 182000 VEHICLE SPEED CONTROL:LINKAGES

SOME VEHICLES EQUIPPED WITH 4.0L OHV OR 4.0L SOHC ENGINES MAY EXHIBIT VARIOUS DRIVEABILITY SYMPTOMS DUE TO INJECTOR(S) CONTAMINATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT AN OVERHEAT CONDITION THAT MAY BE ATTRIBUTED TO THE THERMOSTAT. ENGINEERING IS CURRENTLY INVESTIGATING THIS ISSUE AND IS LOOKING FOR THERMOSTATS AND COOLANTS SAMPLES FROM THESE

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 106220 POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL

CONCERNS WITH VEHICLES EXHIBITING AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. ENGINEERING IS CURRENTLY ADDRESSING THIS ISSUE THROUGH THE HIGH MILAGE / TIME-IN-SERVICE CONCERN RESOLUTION PROCESS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 021230 SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM

SOME VEHICLES EQUIPPED WITH REAR LOAD LEVELING SYSTEM MAY EXHIBIT AN AIR SUSPENSION LIGHT ON WITH DIAGNOSTIC TROUBLE CODE C1726 IN SELF TEST. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE-OFF DUE TO THE REAR TRANSMISSION MOUNT BEING TWISTED AND ALLOWING A GROUND OUT CONDITION TO OCCUR. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 015000 STEERING:HYDRAULIC POWER ASSIST SYSTEM

EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 162310 STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

EXPERIENCING A POPPING, SNAPPING OR TICKING NOISE FROM THE RIGHT A-PILLAR / UPPER DOOR HINGE AREA WHLE DRIVING. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

SOME VEHICLES MAY EXHIBIT THE LEFT FRONT POWER WINDOW INOPERATIVE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1999 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

March 17, 2003 106000 POWER TRAIN:AXLE ASSEMBLY

FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

VEHICLES MAY EXHIBIT AN OUTSIDE PASSENGER OR DRIVER SIDE MIRROR SLIGHT FLUTTER / SHAKE AT HIGHWAY SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 182000 VEHICLE SPEED CONTROL:LINKAGES

VEHICLES MAY EXPERIENCE A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 126200 EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

CONCERNS WITH UNCOMMANDED FRONT WIPER FUNCTION ACTIVATING WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

CONCERNS WITH UNCOMMANDED FRONT WIPER FUNCTION ACTIVATING WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

CUSTOMER MAY COMPLAIN THAT THE POWER WINDOW(S) MAY BECOME INOPERATIVE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 020000 SUSPENSION

SOME 4.0L VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / PULSATION AT 0-45 MPH ON DRY PAVEMENT UNDER LIGHT TO MODERATE ACCELERATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 102000 POWER TRAIN:MANUAL TRANSMISSION

SOME 4.0L VEHICLES WITH A4WD MAY EXHIBIT A VIBRATION / PULSATION AT 0-45 MPH ON DRY PAVEMENT UNDER LIGHT TO MODERATE ACCELERATION. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 061000 ENGINE AND ENGINE COOLING:ENGINE

SUBJECT PERTAINING TO THE SBDS RELATIVE CAM TIMING TEST WHICH HAS BEEN TEMPORARILY REMOVED FROM USE ON SOME VEHICLES DUE TO NOISE CONCERNS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 6, 1999 162300 STRUCTURE:BODY:DOOR

INFORMATION ON VEHICLES EXHIBITING A “NO 2-STEP UNLOCK” OR A FALSE DIAGNOSTIC TROUBLE CODE B1834 (DOOR UNLOCK DISARM OUTPUT – CIR) STORED IN MEMORY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)

SOME VEHICLES WITH AUTOMATIC 4 WHEEL DRIVE (A4WD) MAY EXHIBIT MULTIPLE GENERIC ELECTRONIC MODULE (GEM) FUNCTION CONCERNS SUCH AS INOPERATIVE ON TOUCH DOWN, CHIME, 4X4 SHIFT MOTOR, ETC. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

INFORMATION PERTAINING TO VEHICLES EQUIPPED WITH MANUAL A/C CONTROLS BUILT BETWEEN 7/26/99 THROUGH 8/5/99 MAY HAVE A/C CONTROL KNOBS THAT HAVE BEEN SCUFFED, SCRATCHED OR DAMAGED ON THE OUTER SURFACES DURING ASSEMBLY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 036400 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT

SUBJECT REGARDING VEHICLES EXHIBITING AN ABS LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1676 IN SELF TEST. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 135000 VISIBILITY:REARVIEW MIRRORS/DEVICES

CONCERNS WITH OUTSIDE PASSENGER OR DRIVER SIDE MIRROR SLIGHTLY FULTTERING / SHAKING AT HIGHWAY SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 114400 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

SOME VEHICLES MAY EXHIBIT A CONDITION WITH FUSE #18 IN THE FUSE JUNCTION PANEL INTERMITTENTLY GOING OPEN. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 020000 SUSPENSION

ENGINEERING IS CURRENTLY INVESTIGATING VEHICLES WITH A4WD EXHIBITING A VIBRATION / MOAN AT HIGHWAY SPEEDS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 015300 STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID

EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 980000 UNKNOWN OR OTHER

CONCERNS WITH VEHICLES EQUIPPED WITH 4.0L SOHC ENGINE EXHIBITING THE MALFUNCTION INDICATOR LAMP (MIL) ‘ON’ AND DIAGNOSTIC TROUBLE CODE (DTC) P0161 STORED. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 1999 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

CONCERNS WITH VEHICLES THAT EXHIBIT A HARD START / LONG CRANK CONDITION DUE TO A FUEL SYSTEM PRESSURE BLEED DOWN. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

October 14, 2002 357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

August 1, 2001 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

ON SOME VEHICLES THE REAR WIPER ARM FAILS TO CLEAN BACK GLASS. *ET

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2001 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2001 106000 POWER TRAIN:AXLE ASSEMBLY

CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

April 1, 2001 106000 POWER TRAIN:AXLE ASSEMBLY

SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 1, 1998 116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

December 1, 2000 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

SUBJECT REGARDING OWNER NOTIFICATION SUPPLLEMENTAL PROGRAM FOR VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES – CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET ADDITIONAL COVERAGE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 070000 FUEL SYSTEM, GASOLINE

SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

ADDRESSING CUSTOMERS CONCERN OF INOPERATIVE POWER WINDOWS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

INFORMATION ON RESETTING THE PASSIVE ANTI-THEFT SYSTEM (PATS). *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 103000 POWER TRAIN:AUTOMATIC TRANSMISSION

SOME VEHICLES MAY EXHIBIT SLIPPING SHIFTS, DELAYED OR NO ENGGEMENTS. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 140000 AIR BAGS

EXHIBITING AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1994 AND / OR B1998. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

EXHIBITING AIR BAG LAMP ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1994 AND / OR B1998. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

SOME VEHICLES EQUIPPED WITH TEVES FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT A YELLOW ANTI-LOCK BRAKE LAMP ILLUMINATED WITH NO DIAGNOSTIC TROUBLE CODES IN MEMORY. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

May 1, 1999 190000 TIRES

INFORMATION ON MAINTAINING TIRE PRESSURE. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

June 1, 1999 136000 VISIBILITY:WINDSHIELD WIPER/WASHER

CUSTOMERS MAY COMPLAIN OF FRONT WINDSHIELD WIPER ACTIVATION WITHOUT COMMAND. *TT

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

November 11, 2002 061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ

Click to view a copy of the full alert on NHTSA's website (select "Manufacturer Communication")

1999 MERCURY Mountaineer

search for another vehicle

Loading...